2014 Ford Fusion engine problems

ENGINE

coolant leaking into engine * sudden engine failure risk * overheating * loss of power * expensive engine replacement from known defect 2014 Ford Fusion EcoBoost is losing coolant internally into the engine. Ford dealership diagnosed coolant intrusion requiring full engine replacement costing approximately $14,000. This appears to be a known defect affecting many Ford EcoBoost vehicles. Vehicle experiences coolant loss and risk of engine failure.

NHTSA complaint #11737935 — an unverified report by a vehicle owner.

ENGINE

Transmission randomly stopped driving at highway speeds rpm spiked and no movement was in fast lane at 75 mph. Transmission is toast now in for 4-6 thousand dollars to replace also ford did the recall on the emissions reprogram a few months before this issue then tells me it needs a catalytic converter another costly repair car is unsafe. I’m thankful I was driving and not a family with kids.

NHTSA complaint #11721943 — an unverified report by a vehicle owner.

ENGINE

The transmission failed completely. The vehicle will not engage or shift properly and cannot be driven. The failed transmission is still installed in the vehicle and available for inspection upon request.

NHTSA complaint #11690102 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2014 Ford Fusion. The contact stated that while his son was driving approximately 70 MPH, the check engine warning illuminated. The contact stated that the vehicle went into LIMP Mode, and his son was able to coast to the side of the highway. The contact drove out to his son's location and was able to clear the codes using a handheld scanner and the vehicle was able to be driven back to the residence. The contact stated that the failure was intermittent, and the vehicle was showing other symptoms. The contact stated that the vehicle was idling rough after a cold start and occasionally was blowing white smoke from the exhaust pipe. The contact stated that 2 years prior the vehicle exhibited the same symptoms, and the vehicle was taken to a dealer who diagnosed that there was coolant intrusion into the engine block, and the engine was replaced. The contact stated that the vehicle was under warranty at the time of the failure. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and confirmed that there was coolant intrusion into the engine, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was 86,825.

NHTSA complaint #11680205 — an unverified report by a vehicle owner.

ENGINE

Coolant is leaking into the head gasket of the 2014 Ford Fusion Hybrid similar to the other 2014 Ford Fusion cars (they have a recall on them for this issue). Upon calling the nearest Ford dealership, I was told that the recall did not apply to my vehicle, even though the same recall has been made for other 2014 Ford Fusions (just not the hybrid specifically). The safety of the driver and passengers in the car is at risk due to the coolant fluid mixing into the engine oil, eventually causing a blown head gasket and potentially engine failure. This problem was identified within minutes of getting a routine oil change, as coolant was found in the cap of the head gasket. The vehicle has not been inspected by the manufacturer, police, or insurance representatives. There were no warning signs. The car notified me when I needed to change my oil, but otherwise, no dash lights came on and no notifications were sent to the dash.

NHTSA complaint #11679270 — an unverified report by a vehicle owner.

ENGINE

On cold startup, a significant amount of white exhaust is sometimes observed coming out of the tailpipes. The exhaust has a sweet aroma and after checking the coolant levels, it appears that the coolant levels have dropped and the exhaust smoke is being caused by a coolant intrusion into the engine block. No warning lights have been observed and it only happens about half of the time.

NHTSA complaint #11676918 — an unverified report by a vehicle owner.

ENGINE

I had multiple coolant leaks in the pass and I have to constantly replace the hose about every 2000-3000 miles Also my screen went out in my dashboard causing me to not be able to make any audio changes or station adjustments in my car Lastly whenever I get ready to increase my speed my car jerks back

NHTSA complaint #11665681 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2014 Ford Fusion. The contact stated that while starting the vehicle, the vehicle idled and then stalled. There was no warning light illuminated. The contact used a code reader to diagnose the vehicle. The contact filled the coolant reservoir and noticed that the coolant was leaking out. There was coolant intrusion into the cylinder, causing engine failure. The vehicle was towed to the dealer, and confirmed that there was coolant intrusion into the block head. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Technical Service Bulletin: 23-2223. The manufacturer was notified of the failure and the manufacturer referred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 154,135.

NHTSA complaint #11653643 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2014 Ford Fusion. The contact stated while driving 10 MPH, the vehicle was shaking with a rattling sound coming from the engine compartment. A code was displayed on the instrument panel; however, the contact was unsure what the code referenced. The contact stated that the vehicle was not safe to drive. The contact stated that an independent mechanic inspected the vehicle and diagnosed that there was a coolant leak, causing the coolant and oil to mix that caused engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The mechanic informed the contact of NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling); which was related to the failure experienced. The manufacturer was informed of the failure and confirmed that the VIN was not included in NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling) and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 188,000.

NHTSA complaint #11650064 — an unverified report by a vehicle owner.

ENGINE

I was having issues with this vehicle sputtering a bit and the antifreeze was seeming to be disappearing. There were no visible leaks. I took it to the shop to have it looked at. The engine light was on and there was a code for a cylinder 3 misfire. Th mechanic diagnosed the vehicle and, upon removing the spark plugs, noticed they were fouled with what he said was antifreeze in the cylinder (because of the white substance on the electrode end). I saw where there is a recall for the particular engine block that is in this vehicle from 2014 to 2020. When I notified Ford and the NHTSA I was told that my VIN number was not included in the recall. I am confused because I would think that the recall would be for vehicles with this particular block not specific VIN numbers. Please help! I just got this car hoping for a reliable vehicle. I am a grad student and I do not have the funds for such a big repair.

NHTSA complaint #11646858 — an unverified report by a vehicle owner.

ENGINE

Vehicle flexplate broke causing loss of power in rush hour traffic. Luckily was able to get to the side of the road without major incident or causing an accident. Broken flexplate also caused damage to transmission and ptu. Was informed this is a common issue wiith this yeat make and model but ford refuses to do anything about it. They would rather wait for some peopke to lose their life befor takiing responsibility. But who cares about peoples lives when you have stockholders to pay and ceo bonuses to hand out. Feel its worth mentioning i had the car at the dealership a couple times for other issues and had asked them about problems i suspected were precursors to this happening. They denied there was even an issue. They they told me the noises were normal and refused to even document my concerns let alone actually physically check the vehicle. I believe they were intentionally trying to hide the fact they knew exactly what was going on. Ford needs to take responsibility but since they wont you guys need to make them.

NHTSA complaint #11644336 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2014 Ford Fusion. The contact stated that while driving at various speeds, the vehicle lost automotive power and stalled. The vehicle was towed to the local mechanic who diagnosed that the engine had failed due to coolant intrusion into the cylinders. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 17V209000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 112,000.

NHTSA complaint #11642858 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, the engine overheated. The contact stated that several unknown warning lights were illuminated. The contact pulled over to the side of the road and the check engine warning light illuminated. The vehicle was towed to an independent mechanic where it was diagnosed with an unknown pump failure. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The contact stated that after the first failure, the vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that the failure persisted. The contact stated that while depressing the accelerator pedal, the engine made revving sounds with ticking sounds coming from the vehicle. The manufacturer was made aware of the failure and filed a claim and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 65,000.

NHTSA complaint #11638824 — an unverified report by a vehicle owner.

ENGINE

A third party hacked my CPU/Transmission Control System causing malfunction with the engine. The engine randomly would cut off during traffic, and I would need to press gas directly after starting the vehicle to go. My vehicle was fairly new and transmission module should not be ineffective after purchasing my vehicle last July 2023 with less than 80K miles. The notification that makes the vehicle stay in the lane would malfunction randomly notifying me of failure to sensor active crash alert. I also have inability to connect to Ford vehicle app with no reason provided to cut off WiFi connectivity. Please review external IP as I can hear communication of third party observing my way of driving and communication while attempting to drive causing distraction affecting safety of myself, my location placement, and health of the car. Possible CPU/transmission/AC connectivity from July 2023 to Malfunction of vehicle starting 10/2024.

NHTSA complaint #11637520 — an unverified report by a vehicle owner.

ENGINE

Experiencing repeated coolant leaks. Heating/coolant was repaired last winter. Failed again this winter. Car keeps needing additional coolant added. Will be taking it in on Monday to find out which parts failed this time.

NHTSA complaint #11635325 — an unverified report by a vehicle owner.

ENGINE

I bought the 2014 Fusion in 2019 used. It had roughly 60 some thousand miles. I had to replace the motor at 94 thousand miles. Now at 131 thousand miles, I am faced with the same issue and need to replace the motor again after only 37 thousand miles. From what the dealer said (Copper Country Ford in Houghton Michigan) both issues have been coolant leaking into the cylinders and killing the motor. The first motor was around $4500.00 and now it is roughly the same $4500.00. So $9000.00 in 4 years!!!!! I called Fo Mo Co and they will do nothing to help. They say there is no recall and or order from NHTSA about this issue. Nor do they have any other programs to help resolve this issue or help pay for the repair. First Motor Replaced August 2020 at 94,000 Second Motor Died December 2024 at 131,000

NHTSA complaint #11634542 — an unverified report by a vehicle owner.

ENGINE

Car stalls then dies out well starting but engine is still on.

NHTSA complaint #11633677 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2014 Ford Fusion. The contact stated that while parked, it was discovered that the vehicle was slowly losing coolant. The failure became a reoccurring failure. The vehicle was taken to a local dealer however, a diagnostic test was pending. The vehicle was not repaired. The manufacturer was notified of the failure and referred to the NHTSA Hotline for assistance. The contact referenced an unknown manufacturer’s recall that was related to the failure; however, the manufacturer confirmed that the VIN was not associated. The approximate failure mileage was 47,000.

NHTSA complaint #11631779 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2014 Ford Fusion. The contact stated that while driving at various speeds the vehicle would not properly accelerate, the engine experienced misfiring and the check engine light remained illuminated. The vehicle was taken to the local dealer who diagnosed that coolant was present inside the engine cylinders and the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 80,000.

NHTSA complaint #11625516 — an unverified report by a vehicle owner.

ENGINE

When accelerating from a stopped position, the throttle is staying stuck wide open. Without my foot on the accelerator, the engine still accelerates wide open. Stepping on the brake, doesn't do anything or make it stop. It has now happened 3 times in the last 2 weeks. I was not taking off at a fast speed. I was accelerating at a normal rate.

NHTSA complaint #11621795 — an unverified report by a vehicle owner.

ENGINE

I've had my Ford Fusion SE ecoboost 1.5, 2014 in for service on 2 separate occasions a day apart for the same reoccurring problems. The first service there was the actions done related to recalls which are consistent with 20S15 A-C and recall 23E03 B. The reasons for my Ford Fusion 1.5 to have been brought to the Premier Ford, Waveland, Ms was as follows: The temperature overheat lamp light was jared, there was 3 leaks from the overheat, there was a Shutter and sounds that came from the engine, (LIMP*)and there was no fuel power through acceleration. There had been moisture located on exhaust before brakedown without having been driven for approximately 10hrs before brakedown. 2ed service was as follows: temperature overheat lamp light jared, no power through fuel to accelerate, and issues starting. LIMP* I had not on this brakedown paid attention to if my Fusion needed water, the engines performance in regards to shakes or sounds nor did I look to notice nor did I look for leaks. I called directly to Premier Ford, Waveland and had my Ford towed in. The service was as follows: 1) 3U2Z*14S411*HYB WPT988 WIRE ASY 2) DS7Z*8501*E PW556 PUMPASP-WATER 3) BE8Z*8507*A GASKET-WATER PUMP 4)VC*13*G 3801132 ANTI-FREEZE 5) 6 BM5Z*6K2543*S437 SCREW 6) BM5Z*6K254*A TENSIONER - TIMING BELT With the parts 261.44 Labor 1748.99 misc charges 50.00 for a total of after taxes 2204.66 I picked up my Ford Fusion on October 4, 2024 and on October 9, 2024 I went beck to the Premier Ford and spoke with the service department because I had to stop and let my Fusion cool every 20 to 30 minutes, I stated that there was some loss of water and it was overheating, the power train light warning notify me of an issue, and that my Fusion would not go over 80miles per hr. The service department associate seemed frustrated with me and argued the fact that it had ran hot and said that the reason for the speed issue was that the lamp was Identifying the keylock complete on pdf

NHTSA complaint #11619482 — an unverified report by a vehicle owner.

ENGINE

Attachment to last complaint

NHTSA complaint #11619485 — an unverified report by a vehicle owner.

ENGINE

another attachment!

NHTSA complaint #11619497 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, an unknown warning light illuminated, and the contact noticed a ticking sound coming from the vehicle. The contact stated that the check engine warning light later became illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with engine failure. The contact was advised to take the vehicle to the dealer for assistance. The vehicle was towed to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 32,000.

NHTSA complaint #11618160 — an unverified report by a vehicle owner.

ENGINE

This is a attachment to my last Inquiry.

NHTSA complaint #11617112 — an unverified report by a vehicle owner.

ENGINE

On [XXX] ford premier out of waveland evaluated my car after I had to have it towed in due to overheating. The high temperature warning notification was lock and wouldn't change to normal after it cooled. I was not fully aware of my car overheating due to no warning other the the temperature overheat warning. A couple of days prior without driving it for 10hrs I noticed a moist to the exhaust pipe. When it broke down the engine had a misfire, a shake, and had not power to the engine to accelerate. There was 3 different puddles of fluids underneath the car. When I had spoke to the service department on this breakdown I made them aware of everything with one of the Mechanics witnessing the shake within the engine. There was a confusion on my part due to the sticker showing a 1.5l and my Insurance showing through carfax a 2.5l with also Descripting a 1.5l that showed for my car to be compatible to a 2.0l, 1.6l Installation of coolant system, that of which lead me to request recalls through Vin# on [XXX] through Verified and it was shown to be compatible for recall. Premier Ford service department Assured me that nothing was wrong with the coolant system that the power train control module reprogramming took care of the breakdown. He assured me when I picked up my car That nothing was wrong with my car. Except for me needing to go, change the brakes so that he could change the brake hoses that are part of the recall associated with the brakes. This was on [XXX]. On [XXX] I broke down again with the same issue with this time before the breakdown there was a stall when I started my car And when they had my car on [XXX] I asked them the check the Fuel Injections and he stated there was nothing wrong with the fuel injections. My car has shown every sign that shows through the coolant system of a fire hazard. I am requesting that the Department to assign the safety recall 17s09 to my vin# [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11617127 — an unverified report by a vehicle owner.

ENGINE

Complaints 11617112 and 11617127 Thank you for your patience with me!

NHTSA complaint #11617131 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2014 Ford Fusion. The contact stated while driving at various speeds, there was a misfire coming from the engine. The vehicle lost motive power with white smoke coming from the exhaust system. Upon inspection, it was discovered that there was no coolant in the coolant reservoir. The vehicle was examined by an independent mechanic who determined that the engine short block was faulty due to coolant intrusion. The contact was informed that the engine short block needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 164,000.

NHTSA complaint #11616166 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2014 Ford Fusion. The contact stated that while adding coolant, the coolant was leaking out. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate properly. The vehicle was turned off and restarted and there was smoke detected. The contact opened the hood and noticed that the coolant level was low. The check engine warning light was illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling). The vehicle was towed to the local dealer but was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 60,000.

NHTSA complaint #11616205 — an unverified report by a vehicle owner.