2014 Honda Cr-V engine problems

ENGINE

This make and model Honda with a 2.4L engine have several known defects which brings potential harm and high operational and repair costs to its owners. Honda is well aware of the engine problems but refuses to issue recalls to correct the problem. Two of the major problems are: 1. due to a design error, the engine burns excessive amounts of oil, and 2. Honda installed a defective VTC Actuator in this engine. Either problem can cause the engine to suddenly sieze/fail which could lead to serious injury or loss of life. I purchased a used 2014 Honda CR-V from a Honda dealer in 2022 with about 50,000 mi. After a short time owning the vehicle I realized that the engine was burning excessive oil (about 2 quarts every 2 to 3 weeks). When I discussed this issue with my local Honda dealer, they told me that according to a Honda Service Bulliten, my car was not losing oil at a rate that warranted repair. I've owned around 10 Hondas in my life and I've never had a car burn oil where I had to add ANY oil between oil changes. So, burning multiple quarts of oil a month is EXTREMELY UNUSUAL and should have been repaired by Honda! The 2nd problem, defective VTC Actuators, actually may be related to the 1st problem due to a constant fluctuation of the oil level, and lack of oil. The defective VTC Actuators lead to a stretched/worn Timing Chain which can cause engine failure at any time and any place. After experiencing a loud rattling coming from my engine on start-up for some time, I just had several dashboard lights come on. Running a scan on the vehicle it showed a P0341 code. I took my car to my local Honda Dealer where they informed my that I had to replace the stretched Timing Chain and failed/defective VTC Actuator at a cost of over $2600. I believe that fraud was committed by Honda from the day I purchased the vehicle as Honda was aware of both significant engine problems and did not inform us a unexpecting Buyers.

NHTSA complaint #11741874 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

See attached document for complaint.

NHTSA complaint #11718746 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

See attached document for complaint.

NHTSA complaint #11718746 — an unverified report by a vehicle owner.

ENGINE

My 2014 CRV has 83,131 miles and I am a careful driver and like to keep my vehicle in top shape. The service done was replaced outer tie rod ends that were cracked and I could have lost control , replaced front lower control arms, replaced front struts, replaced rear sway bar bushings, reseal coolant passage housing , head gaskets, my vehicle could have quit in traffic. The top of my CRV has paint faded and gone to a white powder look. There are things that a car with low miles driven carefully and taken very good car of should not be happening. There should be recalls because there are issues with timing chains and fuel system. I am scared to drive it anymore. I won't stay loyal to Honda now and I am very disappointed that they know these issues and haven't attempted to fix them.

NHTSA complaint #11674672 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2014 Honda CR-V. The contact stated that upon starting the vehicle, there was an abnormal rattling sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the VTC actuator, resulting in damages to the engine. The contact was informed that a partial rebuild of the engine was required. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin: 16-012. The manufacturer was not notified of the failure. The failure mileage was 58,000.

NHTSA complaint #11656861 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2014 Honda CR-V. The contact stated while starting the vehicle there was an abnormal sound that was coming from the front of the vehicle. The vehicle was not taken to a dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 38,000.

NHTSA complaint #11620142 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2014 Honda CR-V. The contact stated when the vehicle was started, there was a loud rattling sound coming from the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The vehicle was scheduled for an upcoming diagnostic test. The contact stated that the failure had been occurring intermittently since 2014, however in 2020 the failure occurred, and the variable timing actuator (VTC)was replaced. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 52,032.

NHTSA complaint #11615283 — an unverified report by a vehicle owner.

ENGINE

Engine code p1009 VTC valve replacement no know place will replace due to zero tolerant engine and timing not in tune due too much damage by the pistons and valves

NHTSA complaint #11608379 — an unverified report by a vehicle owner.

ENGINE

Rattles and shakes between 25 and 40 mph, bad actuator will cause timing failure. It only has 71,000 miles. Honda is well aware of this defect in this vehicle. When will they be held accountable to fix this issue? At 33k I was definitely taken for a ride! No engine warning light either!

NHTSA complaint #11602310 — an unverified report by a vehicle owner.

ENGINE

Purchased our 2014 CR-V [XXX], used one owner, 55301 mileage. Very little driving the next three years due to the pandemic. Summer of 2023 we were driving from Buffalo to [XXX] , first 30 miles, severe hesitation, amber lights on, until reaching 70mph. Hesitation stopped but lights stayed on. By August the TPMS indicator, malfunction indicator lamp and other lights came on, again. We reset according to the manual, but this was just the beginning of this process happening over and over again. During dealer testing Code PO 341 came up. Had it tested at another place before taking it to West Herr Honda and was told needed Timing chain replacement with VTC. This was done at a cost of $2232.06 with car mileage of 63159. We were sad and disappointed. Research shows that Honda is very much aware of over 500 plus recorded problems with the 2014 CR-V not to mention unreported problems. The model should be recalled before lives are lost. Car still hesitates but evidently due to a different problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11590814 — an unverified report by a vehicle owner.

ENGINE

On 2/21/24 as we were exiting a Hospital Parking Garage and I slowed down to stop at exit where road is, the engine suddenly had an uncontrolled acceleration. Difficult to stop but I pressed hard on brakes (which alone did not stop vehicle)and immediately put gearbox in Neutral, stopping vehicle before it made it on the street. After that, no more incidents on 2/21 or 2/22.. Should be noted I had total of 3 such incidents in past 4-5 months, this was the third. One occurred as getting out a store parking lot, slowing down at street interface and suddenly engine acceleration, used same technique as above. Another was at end of our street coming to a stop at interface to another street, same occurrence. In each of the occurrences I can verify that it was neither a car mat issue (it is anchored in car) not an accidental stepping o accelerator. . Have not contacted dealer or Honda as I note neither has ever found an answer to similar occurrences with others. For now drive carefully and one hand on shift lever most of the time when coming to a stop as occurrences appear to be far apart.

NHTSA complaint #11573388 — an unverified report by a vehicle owner.

ENGINE

A VTC actuator rattles and is damaging the timing chain that will fail and cause catastrophic engine failure on road that can cause life threatening event

NHTSA complaint #11573395 — an unverified report by a vehicle owner.

ENGINE

VTC failed July 2018. Honda stated I must pay for the repair costing $662. According to Honda receipt the R5A new VTC was installed. Now it's January 2024 and car VTC failing again. Note: When I changed the valve cover gasket I looked at the VTC and noticed that it says R44. Basically they lied about the repair and put another of the defective VTC. Obviously a much more expensive repair this time due to Honda negligence and dishonesty.

NHTSA complaint #11565185 — an unverified report by a vehicle owner.

ENGINE

For over a year now, my Honda CRV 2014 has been producing a rattling noise from the engine on every cold startup. This happens regardless of the temperature outside. When I initially heard it, it was sporadic, again, on cold startup - so the rattling didn't occur every time. Over time though, it will occur every morning, or after the car has been sittinwith the engine off for at least a few hours. I asked a mechanic to look at it after a few months after I had first heard it, because it continued to happen, even periodically. As it only happened on cold startup, I could not reproduce it for the mechanic - he could not find any obvious issue. After a few more months, I recorded the issue on video (and audio). The same mechanic said it may be the VTC actuator. I had another mechanic look at the same video, and he said it was almost certainly the VTC actuator. He said Honda had recalled the vehicle because of the VTC actuator issue and sent me a link to a webpage with the information. It turns out it was only a technical bulletin rather than a recall. I called a Honda dealership and provided them information about the issue. They asked for my VIN and told me there was no recall after searching my VIN. After some discussion with them, wherein I referenced the technical bulletin and inquired if Honda would provide a replacement for the known issue, the representative said since it wasn't recalled, they could only diagnose and repair at full cost. After I continued to press the issue, she asked if I wanted the telephone number for Honda corporate, so I could send them my complaint. I have no yet taken my car in for repair, as the cost will be very expensive. I don't understand why Honda has not recalled the vehicles over this issue, given the fact that it is an issue they have admitted to, and it apparently is a potentially dangerous and life-threatening issue.

NHTSA complaint #11561307 — an unverified report by a vehicle owner.

ENGINE

Loud grinding noise when starting a cold engine. Honda dealer replicated noise and stated that it was the VTC Actuator-which needed to be replaced along with the Cam Chain for a total of $1,392.23 before the Florida 7% sales tax of $97.46 totaling$1,489.69. Other manufacturing years for Honda received a recall notice. I believe that my 2014 Honda CR-V should be included in that recall so that the dealer may reimburse me for this acknowledged defect in the Honda engine.

NHTSA complaint #11535841 — an unverified report by a vehicle owner.

ENGINE

The car makes a very loud grinding sound when starting. A metal on metal sound. This was fixed in October 2021 when vehicle had 77,500 miles for about $800. Dealership stated not covered by any recall or warranty. Service agreement states replaced VTC actuator with VCG set. Now, June 2023, the car is making the exact same noise. Many honda owners are writing about this issue. Honda corporation not taking any ownership for this issue. The "fix" is NOT a fix. Honda is being complacent. Owners are paying for this every 18-24 months. This needs to be addresssed by the company and not having owners pay over and over again to TEMPORARILY fix this issue.

NHTSA complaint #11532372 — an unverified report by a vehicle owner.

ENGINE

Oil Dilution (gas mixing with oil) caused engine to overheat, making my car abruptly breakdown on a busy interstate and we were nearly rear ended because of it. Now I need a full engine replacement. Car is low mileage.

NHTSA complaint #11528579 — an unverified report by a vehicle owner.

ENGINE

Upon cold start, the VTC actuator makes a grinding noise. It also makes the noise when car not driven for 5 hours or more. It lasts about 1 to 2 seconds upon releasing ignition key at start. No Check Engine light or dash warning lights come on. Concerned about timing chain damage. The car only has 33,385 miles on it. Research on web, indicates multiple reports of same issue.

NHTSA complaint #11515635 — an unverified report by a vehicle owner.

ENGINE

VTC actuator makes grinding sound upon cold start and reduces engine power. Has been doing it since the car had 22200 miles and had it repair and the same thing started 4 months after repair. Seems to be an ongoing problem with 2013 and 2014 CRVs

NHTSA complaint #11508176 — an unverified report by a vehicle owner.

ENGINE

The engine has rattled noises when starting, I look online and a lot of people have the same problem, they said the VTC actuator’s problem, even after they changed it, the noise is back 1-2 years. Honda needs to recall and replace this part for Honda’s customers.

NHTSA complaint #11507903 — an unverified report by a vehicle owner.

ENGINE

There is a rattling noise coming from the engine area at extreme cold startups since I had the car at 24,000 miles on it. When having the car parked with the emergency brake on at an incline and after leaving it ther for a few days, after I press the release on the brake after starting the car, the emergency brake sticks and the car won't move forward when accelerating or backward when releasing the brakes or accelerating. I have to repeatedly press and release the emergency brake to allow the car to release the brake from the wheel for the car to move forward. There is repeatedly a build up of rust on the rear wheels when the car is exposed to humid and wet conditions due to some flaw in the design, and it causes the car the have a loud thumping noise when applying the breaks . I have had to get the rear brakes refinished or shaved down to smooth them out repeatedly.

NHTSA complaint #11506316 — an unverified report by a vehicle owner.

ENGINE

The VTC (Variable Timing Chain) Actuator is faulty. It cause premature wear on the vehicle’s engine. I had mine replaced at 148,648 miles and it is now needing a replacement again at 162,560 miles. When performing a cold start on the vehicle, user will hear a 2-3 second grinding noise coming from the engine. When I had to replace the actuator the first time, the wear was so bad on my engine, it also meant I had to get a new timing chain as too much stress had been put on mine and the chain began to stretch.

NHTSA complaint #11503319 — an unverified report by a vehicle owner.

ENGINE

Yo compre este carr9 desde el principle salio con problems ellos no quieren arreglarlo ni devolverme los 5 mil dollars que di de deposito. Translation-I bought this car from the beginning, it came out with problems, they don't want to fix it or give me back the 5 thousand dollars I gave as a deposit.

NHTSA complaint #11485523 — an unverified report by a vehicle owner.

ENGINE

VTC Actuator making grinding noise on cold start up and after sitting for long periods of time even after running. Timing chain is stretched making warning lights come on and go off.

NHTSA complaint #11484752 — an unverified report by a vehicle owner.

ENGINE

When starting the engine, it makes a grinding noise each time. No check engine or safety lights have come on and when the engine is cold it will shake very badly upon take off.

NHTSA complaint #11478370 — an unverified report by a vehicle owner.

ENGINE

Between every oil change I have to add oil, there are no visible leaks but it always uses oil and the low oil light will come on.

NHTSA complaint #11478371 — an unverified report by a vehicle owner.

ENGINE

VTC Actuator making rattling noise during start up in the morning and every five hours of sitting

NHTSA complaint #11478129 — an unverified report by a vehicle owner.

ENGINE

My 2014 Honda CR-V EX does not initially start-up following the 3-step starting the engine process as outlined on page 239 of the CR-V owner's manual.It sometimes takes up to 6 to 12 times for the engine to engage.The starter appears to be defective as it was made.

NHTSA complaint #11473956 — an unverified report by a vehicle owner.