41 of the
682 complaints filed about the Honda Insight
are about the fuel system —
6% of everything owners reported.
The worst model year for it is 2019.
Went in for a typical servicing. They noted that the downstream O2 sensor was damaged by rodents. The vehicle, with around 14k has always been stored in a weather tight garage, never stored outside. There has been no rodents in the building since I owned it from 1999. This is a presumptuous statement I refuted, but they wouldn’t take off, and I felt this is a warranty or recall item. There are lots of speed bumps in the North Portland neighborhood, which may have caused the problem by cable scraping. I believe they documented it as rodents to escape their extended warranty contract requirements. I purchased an O2 sensor, which my independent said I don’t need to use it after taping the scrape as there’s no electronic issues being reported in the system. I would like this investigated and them pay for the sensor I apparently don’t need to install.
NHTSA complaint #11712835 — an unverified report by a vehicle owner.
This issue actually started in November of 2022. Driving down from the mountains the car started losing power. I took the car to the dealership on Monday. I was then advised that there was not an issue they could they could find. A few months later the car would not start. They replaced the battery and the issue was resolved (I don’t recall the exact month the battery was replaced). November 29,2025, I started my car and when I accelerated to about 30+ miles the car started to hesitate and it felt as if the car was going to stop. The check engine light came on and stayed on. I had over a half a tank of gas and temperature was around 28-30 degrees. I drove the car for about 2 miles to fill up to make the drive to my house. The distance is about 170 miles. Once the tank was full, I started up with no issues of shaking/hesitation/loss of power. Monday December 1,2025, Two days later. Started the car. Check engine light came on/car was vibrating/hesitation when giving gas. Drove to the dealership for them to check what the issue is. I noticed there are two other reported issues with the same/similar issue. At this moment, I’m waiting for the dealership to advise what the issue is/how to resolve the issue. It would be beneficial if service bulletins were added in the recall section. That could help fix problems faster and help make recalls faster.
NHTSA complaint #11702271 — an unverified report by a vehicle owner.
The car was serviced due to a recall about fuel pump defect and after the service, the car was halted in the middle of the trip. This incident is not acceptable and especially the recall service was supposed to fix that problem. The sudden stop of malfunctioning fuel pump could cause collision, injury and possible lives!
NHTSA complaint #11640438 — an unverified report by a vehicle owner.
The contact owns a 2019 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11630288 — an unverified report by a vehicle owner.
The contact owns a 2019 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11629202 — an unverified report by a vehicle owner.
The contact owns a 2019 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11624923 — an unverified report by a vehicle owner.
The contact owns a 2019 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000(Fuel System, gasoline); however, the part to do the recall repair was not yet available. The contact stated that the vehicle was experiencing engine hesitation while driving. There was no warning light illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000. Parts distribution disconnect.
NHTSA complaint #11623803 — an unverified report by a vehicle owner.
Engine will start shaking and making a helicopter sound while idling or driving under 45. Check engine light will begin to blink. While on the interstate, engine began to shake loudly making helicopter sound. Then it began to decelerate from 75 to 40 ON THE INTERSTATE before stalling out completely. I had to coast it into the pull off lane to avoid being hit. Spark plugs were replaced, but issue continues. Mechanic said it sounds like a fuel pump issue when I recorded it on video. When we restarted the car, engine light was not on so error codes could not be read.
NHTSA complaint #11619595 — an unverified report by a vehicle owner.
The contact owns a 2019 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact called another local dealer, Sloane Honda Service (9903 Bustleton Ave., Philadelphia, PA 19115); but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11616374 — an unverified report by a vehicle owner.
The contact owns a 2019 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11614074 — an unverified report by a vehicle owner.
If the manufacturer has failed or is unable to remedy this safety recall for your vehicle in a timely manner, please contact the NHTSA Vehicle Safety Hotline at: 1-888-327-4236 or TTY: 1-800-424-9153 or file an online complaint with NHTSA.
NHTSA complaint #11614092 — an unverified report by a vehicle owner.
The contact owns a 2019 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline). The contact stated that while driving on several occasions at various speeds, the vehicle failed to accelerate as intended and lost motive power. The contact stated that the failure was mostly noticeable while making left returns and the vehicle did not accelerate as needed. On one occasion, the vehicle was taken to a dealer where it was diagnosed and determined that an unknown part needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.
NHTSA complaint #11606848 — an unverified report by a vehicle owner.
The contact owns a 2019 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while driving approximately 60 MPH, the vehicle was losing motive power. The contact stated that the message “Engine Overheating” had flashed on the instrument panel. The contact pulled over and then stopped the vehicle and waited 15 minutes before restarting the vehicle. The contact stated that the failure had become a recurring failure with the check engine warning light illuminated. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and determined that the water pump needed to be replaced. The vehicle was repaired. The contact stated that the check engine warning illuminated and the vehicle almost stalled. Additionally, the contact stated that the check brakes message was displayed and the stabili-trak warning light was illuminated. The contact had not taken the vehicle to a dealer or independent mechanic. The vehicle was not diagnosed or repaired. The failure mileage was approximately 133,000. VIN tool confirms parts not available.
NHTSA complaint #11606578 — an unverified report by a vehicle owner.
I am writing to report a potentially serious safety issue with my vehicle. My car recently had its fuel pump replaced/repaired as part of a recall. However, only about 2 years after this recall repair, my car stopped accelerating while I was driving. This left me and my toddler stranded in the middle of the road in 110 degrees, creating a dangerous situation for us and other drivers. I took the vehicle to the dealership, where they diagnosed that the fuel pump needs to be replaced again. This is concerning as fuel pumps are typically expected to last up to 100,000 miles, and mine was just recently replaced/repaired due to the recall. This incident has caused significant hardship: It put my child and me in a potentially dangerous roadside situation. I lost a day's wages due to being unable to get to work. I am now faced with paying for over a thousand dollars of repairs, as I have no other option. I need my vehicle to get to work and transport my child. I am concerned that there may be a persistent issue with the fuel pumps in this vehicle model, or that the recall repair was not performed adequately. My Honda Service Consultant mentioned that there was a Honda bulletin letting them know of this sort of problem in cars that my make/model/year falls under and beckoned to another car with seemingly the same issue. This leaves me wondering why a, to all intents and purposes, common issue is a bulletin for instead of a recall. I request that the NHTSA investigate this matter to ensure the safety of other drivers who may have had the same recall repair. Thank you for your attention to this matter.
NHTSA complaint #11604279 — an unverified report by a vehicle owner.
The contact owns a 2019 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11600513 — an unverified report by a vehicle owner.
The contact owns a 2019 Honda Insight. The contact stated that after opening the fuel cap, the contact became aware that there was smoke coming from the fuel filler neck. Additionally, the contact heard boiling gasoline coming from the fuel tank. Later, while refueling the vehicle, the fuel nozzle was inserted into the fuel filler neck and fuel streamed out from the fuel filler neck. The cause of the failure was not yet determined. The manufacturer and local dealer were not notified of the failure. The contact stated that the outdoor temperature was 118-degrees during the failure. The failure mileage was 125,000. The VIN was not available.
NHTSA complaint #11600093 — an unverified report by a vehicle owner.
The contact owns a 2019 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000(Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts Distribution disconnect
NHTSA complaint #11590432 — an unverified report by a vehicle owner.
The contact owns a 2020 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated the vehicle had stalled on several occasions. Additionally, the vehicle occasionally failed to start-up. The local dealer was contacted, but the vehicle was not diagnosed or repaired due to the cost. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 49,000. Parts distribution disconnect.
NHTSA complaint #11590427 — an unverified report by a vehicle owner.
I received a letter from Honda indicating a recall for the fuel pump impeller. The only thing Honda failed to say was for me to go to a dealership to get this fixed. Instead they sent a letter saying that they know the recall is needed but they didn’t know when they would have the piece available. I believe the letter was received in January 2024. Still to this date I haven’t received a letter from Honda indicating to take my vehicle in for repair. I am not sure how Honda is not prioritizing this as according to their letter our cars can stall while driving causing an accident. I would like my vehicle fixed as I don’t want to drive everyday and worry that my car will stall and possibly kill me. I have felt my gas pedals to feel weird as there’s times that I push the gas and my car accelerates too fast and there are times when I take my foot off the gas pedal it like shakes a little. My car has been feeling very different with regards to the gas pedal. I am concerned that it has to do with the recall.
NHTSA complaint #11583135 — an unverified report by a vehicle owner.