Owners have filed 202 complaints
about the 2016 KIA Forte with NHTSA between 2016 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 8 of 15 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 42
Against the median year of the KIA Forte. 50 means typical for this
model; 100 means roughly double.
Severity — 100
21.3% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 81
47% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
44.4%
1,000 – 9,999 miles
1415.4%
10,000 – 24,999 miles
1415.4%
25,000 – 49,999 miles
2325.3%
50,000 – 74,999 miles
1819.8%
75,000 – 99,999 miles
55.5%
100,000 – 149,999 miles
1213.2%
150,000+ miles
11.1%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jun 2016peak 6Aug 2026
Recalls on the 2016 KIA Forte
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
21V622000
LATCHES/LOCKS/LINKAGES:TRUNK LID:LATCH
Kia Motors America (Kia) is recalling certain 2016-2018 Forte 4-door, Forte Koup 2-door, and 2018-2019 Rio 4-door vehicles. The trunk latch may become damaged, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."
Risk: A person inside the trunk compartment may become trapped, increasing their risk of injury.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202416342,571 units in Canada
Brakes
Issue: On certain vehicles, the inspection completed by a Kia dealer during service campaign SC044 (Transport Canada recall number 2022-222) may not have been done correctly. As a result, a second inspection is required. Over time, the brake lines under the vehicle could corrode. If this happens, a brake line could fail and leak. A brake fluid leak can result in reduced braking. Note: This service campaign replaces service campaign SC044 (Transport Canada recall number 2022-222). Vehicles that had brake lines replaced under that service campaign don't require this inspection. Safety Risk: Reduced braking can cause extended stopping distances and increase the risk of a crash. Corrective Actions: Kia will notify owners by mail and advise you to take your vehicle to a dealership to inspect the brake lines. The dealer will apply an anti-corrosion treatment and replace the brake lines, if required.
Recall 202222242,571 units in Canada
Brakes
Issue: Over time, the brake lines under the vehicle could corrode. If this happens, a brake line could fail and leak. A brake fluid leak can result in reduced braking. Safety Risk: Reduced braking can cause extended stopping distances and increase the risk of a crash. Corrective Actions: Kia will notify owners by mail and advise you to take your vehicle to a dealership to inspect the brake lines. The dealer will apply an anti-corrosion treatment and replace the brake lines, if required.
Recall 202150432,274 units in Canada
Structure
Issue: On certain vehicles, a part in the trunk release latch could fail. If this happens, the emergency trunk release located inside the trunk compartment may not work properly. This could prevent a person that is trapped inside the trunk from opening it. Safety Risk: If a person is closed inside the trunk compartment, they may not be able to get out. This could create a risk of injury. Corrective Actions: Kia will notify owners by mail and instruct you to take your vehicle to a dealer to replace the trunk latch assembly.
Recall 202103930,938 units in Canada
Engine
Issue: Kia Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. An engine failure could cause a sudden loss of power with an inability to restart. Note: This only affects vehicles equipped with a 2.0 L Nu GDI engine. Safety Risk: A sudden loss of engine power could increase the risk of an accident. An engine failure could also create the risk of a fire. Corrective Actions: Kia will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to update the software for the engine control module. Note: Kia recommends that you should always follow the correct vehicle maintenance schedule, which is printed in the Owner's Manual. If you experience unusual engine noise, reduced power, or a check engine/oil warning light, Kia advises you to immediately visit a Kia dealership to have your vehicle diagnosed.
Reports where the owner recorded a crash, a fire, an injury or a death.
Fullerton, CACrash1 injured
AIR BAGS
The contact owned a 2016 Kia Forte. The contact stated that while decelerating due to traffic, the vehicle was struck in the rear end and pushed approximately a few feet, causing the vehicle's front end to crash into the rear of the vehicle in front. No warning lights illuminated. No air bags deployed. The contact stated that due to the impact of the crash, she had fallen unconscious. A police report was filed. The contact sought medical attention for bruises and head damage. The vehicle was towed to the local tow lot, where it remains, and was declared a total loss by the insurance provider. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 22V031000 (Airbags) however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was unknown.
NHTSA complaint #11682452 — an unverified report by a vehicle owner.
Elpaso, TXCrash2 injured
ENGINE
We used to have a 2016 Kia Forte5 LX hatchback we been having problems with this vehicle the car would stall and it was having electrical problems like my turn signals not working even when the bulbs were replaced and same thing to the brake lights prior after I noticed the problem with the car was going to take it in to get ot looked at and serviced when exiting my home with the car and turning left the vehicle stalled while in drive I did have my emergency flash on but the other cars didn’t seem to notice the vehicle got t boned and we got in to a accident when trying to get this issue resolved
NHTSA complaint #11619374 — an unverified report by a vehicle owner.
Kansas City, MOCrash
ENGINE
I was attempting to park in a parking spot that I use regularly at Dollar General. As it was coming to a stop, the brakes failed. I was pushing the brake pedal down. The car started to rev up and speed forward on it's own. It lunged forward jumping the curb and into the pillar. It wouldn't stop going forward. So I had to put it in reverse. As I did that, I put the brakes on as well as the ebrake. It was wanting to speed in reverse for a second. So I threw it into park and turned it off. My family and I went into the store to let the car settle down. Then we was able to drive it home and park it. So it's currently sittling in our driveway here at home.
NHTSA complaint #11584848 — an unverified report by a vehicle owner.
Kansas City, MOCrash
SERVICE BRAKES
I was attempting to park in a parking spot that I use regularly at Dollar General. As it was coming to a stop, the brakes failed. I was pushing the brake pedal down. The car started to rev up and speed forward on it's own. It lunged forward jumping the curb and into the pillar. It wouldn't stop going forward. So I had to put it in reverse. As I did that, I put the brakes on as well as the ebrake. It was wanting to speed in reverse for a second. So I threw it into park and turned it off. My family and I went into the store to let the car settle down. Then we was able to drive it home and park it. So it's currently sittling in our driveway here at home.
NHTSA complaint #11584848 — an unverified report by a vehicle owner.
at 118,000 milesSouth River, NJCrash
AIR BAGS
The contact owned a 2016 Kia Forte. The contact stated that while her grandson was driving at an undisclosed speed, he was involved in a hit-and-run accident and after the impact, the vehicle crashed into a tree. The contact stated that all of the air bags failed to deploy. No warning lights were illuminated. The contact's grandson did not require medical attention. A police report was filed. The insurance company towed the vehicle to one of their tow yards and at that time the vehicle was deemed totaled. The manufacturer was made aware of the failure and advised to file a complaint with the NHTSA Hotline. The approximate failure mileage was 118,000.
NHTSA complaint #11492108 — an unverified report by a vehicle owner.
at 60,000 milesMogadore, OHFire1 injured
ENGINE AND ENGINE COOLING
The contact owned a 2016 Kia Forte. The contact stated that while driving, the vehicle caught fire. The vehicle was burning an excessive amount of oil and fuel. There were no warning indicator lights illuminated. While his wife was driving, the vehicle was making abnormal engine noises. The contact stated he sustained emotional distress and medical attention was provided. The vehicle was towed to an independent towing lot. A police report was filed. The fire department extinguished the fire. The vehicle was taken to an unknown local dealer where it was diagnosed that the pulley needed to be replaced. The vehicle was repaired. The manufacturer was notified but no additional assistance was provided. The failure mileage was approximately 60,000.
NHTSA complaint #11465876 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Greensboro, NC
Insert, Padding
When I have the windows down, I can see the headrest flapping in the wind. I took the cover off and discovered that the styrofoam had broken in half. I used foam adhesive to bind it together. Once again, windows down and the headrest is still flapping in the wind. Look underneath the cover and this time the Styrofoam is broken into multiple pieces.
NHTSA complaint #11758465 — an unverified report by a vehicle owner.
Burlington, NC
ENGINE
My 2016 Kia Forte had a recall that was never performed and I was never told anything about the car fax or any recalls from where I got the car from, it needs a engine repair.
NHTSA complaint #11755914 — an unverified report by a vehicle owner.
Monterey, TN
ENGINE
Car runs fine at lower speeds. When traveling over 50 mph for ten minutes or more, then decelerating or stopping in traffic or at a stop light it stalls. It cranks right back up after you put it neutral and turn the key. We’ve almost been rear ended twice since this started. The car has only been driven about 3000 miles a year over the past 7 years and only about 45 mph. It has been to two shops and hasn’t been driven since May 15th.
NHTSA complaint #11751429 — an unverified report by a vehicle owner.
Columbus, GA
FUEL/PROPULSION SYSTEM
Vehicle won't intake gas. Cod P0451, P0456
NHTSA complaint #11750139 — an unverified report by a vehicle owner.
Muskogee, OK
UNKNOWN OR OTHER
Unknown it makes a ticking noise check engine light came on and oil isn't low. Recently bought it.
NHTSA complaint #11747849 — an unverified report by a vehicle owner.
Muskogee, OK
ELECTRICAL SYSTEM
Unknown it makes a ticking noise check engine light came on and oil isn't low. Recently bought it.
NHTSA complaint #11747849 — an unverified report by a vehicle owner.
Muskogee, OK
ENGINE
Unknown it makes a ticking noise check engine light came on and oil isn't low. Recently bought it.
NHTSA complaint #11747849 — an unverified report by a vehicle owner.
Walnut Ridge, AR
ENGINE
This Forte was not neglected and it was not abused. Nearly 90% of its miles came from highway commuting and interstate travel. It was completely stock, never modified, never driven hard. More importantly, it received fully synthetic oil changes every 3k-4k miles since new, well ahead of what Kia or the oil manufacturer even recommends, because I intended to keep this car long term. All of that is verifiable through Carfax. The engine failure came without meaningful warning. While driving, I noticed an unusual noise and pulled over as quickly as safely possible. I checked the dash expecting some kind of indicator and found nothing. No check engine light, no oil pressure warning. A nearby mechanic found the engine more than 2.5 quarts low on oil despite the vehicle being only about 3,300 miles into a fresh synthetic oil change. There were no external leaks. No oil spots at home, none at work. Nothing to explain where that oil went. After topping it off, the noise briefly stopped. With no warning lights on and the noise stopped, I thought we had caught it in time. I even felt confident enough to also have the mechanic change the transmission fluid as it was about due again. However, a few miles later, the engine suffered complete failure. Violent shaking, severe knock, then the check engine light came on. I shut it down immediately and pushed it home. Once home, I checked the oil again and found it had unusually darkened in an extremely short period of time. The vehicle has not been driven since and is currently inoperable. What troubles me most, beyond the financial loss, is that this vehicle gave me no real opportunity to save it. The oil pressure warning light never illuminated. More than two quarts of oil vanished within a single service interval with no external source and no indication whatsoever, even with checking the level periodically. I went above and beyond in maintaining this vehicle and still lost the engine. This could have been a catastrophe on the road
NHTSA complaint #11740160 — an unverified report by a vehicle owner.
Zolfo Springs, FL
UNKNOWN OR OTHER
This is a paint issue.
NHTSA complaint #11737302 — an unverified report by a vehicle owner.
Austin, TX
ELECTRICAL SYSTEM
Instrument panel lighting and radio lighting flicker constantly while driving. When the headlights are on, the headlights will also turn and off on their own, constantly. Because of this, I can not drive this car at night, in the early morning, in the rain, or whenever my headlights are needed. From what I've surmised, the issue seems to be the multifunction switch, which, coincidentally, Kia has an active recall on for one of their other models.
NHTSA complaint #11731694 — an unverified report by a vehicle owner.
Oakland Park, FL
UNKNOWN OR OTHER
While driving on I-95 at 60mph the car began to jump as it attempted to shift gears and the speed stalled to where it slowed down to 20mph and would not go any faster. The car slowed while I was in the fast lanes of the highway and I had to work my way to the right to the slower lanes to avoid abusing traffic congestion or any accidents. It was scary. Separately, my engine light has been on for the last year. I recently had the MAPs replaced and the light went off for two days and came back. It’s a steady continuous light, no flashing. The analysis check gives some other reason for the light but when checked it doesn’t fix the issue.
NHTSA complaint #11721142 — an unverified report by a vehicle owner.
Oakland Park, FL
ENGINE
While driving on I-95 at 60mph the car began to jump as it attempted to shift gears and the speed stalled to where it slowed down to 20mph and would not go any faster. The car slowed while I was in the fast lanes of the highway and I had to work my way to the right to the slower lanes to avoid abusing traffic congestion or any accidents. It was scary. Separately, my engine light has been on for the last year. I recently had the MAPs replaced and the light went off for two days and came back. It’s a steady continuous light, no flashing. The analysis check gives some other reason for the light but when checked it doesn’t fix the issue.
NHTSA complaint #11721142 — an unverified report by a vehicle owner.
Lebanon, PA
ENGINE
Point 1)CVVT pin was sheared off. Not available for inspection, was replaced and discarded by KIA. Point 2)The vehicle had a rough start and stalled out while stopping. Had to have the car towed to the dealership. Point 3) UNKNOWN Point 4) No Point 5) The Check Engine Light would come on and off randomly. Code P0017 & P0016 would come up as pending when the engine light was on.
NHTSA complaint #11712704 — an unverified report by a vehicle owner.
Holland, OH
AIR BAGS
I am filing a formal complaint regarding serious safety and mechanical problems with my vehicle. The brakes do not function properly and I have to add brake fluid every few days, which indicates a possible leak or brake system failure. This creates an extremely dangerous driving condition. The vehicle also has electrical problems, including malfunctioning lights. The engine has lost power, making it unsafe to drive, especially in traffic or on highways. In addition, the airbag warning light is on, which means the airbag system may not deploy in a crash, putting me at risk of serious injury or death. These problems have made the vehicle unreliable and unsafe to operate. I am requesting that these issues be inspected and repaired immediately at no cost to me, or that the vehicle be replaced or refunded under warranty or consumer protection laws. I am concerned for my safety and the safety of others, and I expect this matter to be handled urgently.
NHTSA complaint #11710115 — an unverified report by a vehicle owner.
Holland, OH
VEHICLE SPEED CONTROL
I am filing a formal complaint regarding serious safety and mechanical problems with my vehicle. The brakes do not function properly and I have to add brake fluid every few days, which indicates a possible leak or brake system failure. This creates an extremely dangerous driving condition. The vehicle also has electrical problems, including malfunctioning lights. The engine has lost power, making it unsafe to drive, especially in traffic or on highways. In addition, the airbag warning light is on, which means the airbag system may not deploy in a crash, putting me at risk of serious injury or death. These problems have made the vehicle unreliable and unsafe to operate. I am requesting that these issues be inspected and repaired immediately at no cost to me, or that the vehicle be replaced or refunded under warranty or consumer protection laws. I am concerned for my safety and the safety of others, and I expect this matter to be handled urgently.
NHTSA complaint #11710115 — an unverified report by a vehicle owner.
Holland, OH
SERVICE BRAKES
I am filing a formal complaint regarding serious safety and mechanical problems with my vehicle. The brakes do not function properly and I have to add brake fluid every few days, which indicates a possible leak or brake system failure. This creates an extremely dangerous driving condition. The vehicle also has electrical problems, including malfunctioning lights. The engine has lost power, making it unsafe to drive, especially in traffic or on highways. In addition, the airbag warning light is on, which means the airbag system may not deploy in a crash, putting me at risk of serious injury or death. These problems have made the vehicle unreliable and unsafe to operate. I am requesting that these issues be inspected and repaired immediately at no cost to me, or that the vehicle be replaced or refunded under warranty or consumer protection laws. I am concerned for my safety and the safety of others, and I expect this matter to be handled urgently.
NHTSA complaint #11710115 — an unverified report by a vehicle owner.
Merced, CA
EXTERIOR LIGHTING
Headlights shut off entirely multiple times when switching to high beams on dark road, almost causing an accident. Multi-function switch failing the exact way the Sorento switches are failing, confirmed by mechanic. This is a severe hazard when driving at night. There was no warning whatsoever.
NHTSA complaint #11694440 — an unverified report by a vehicle owner.
at 85,000 milesMorris Plains, NJ
ENGINE
The contact owns a 2016 Kia Forte. The contact stated that while driving approximately 45 MPH, the vehicle started to lose motive power. The accelerator pedal was depressed; however, the vehicle failed to respond as needed and then stalled. The contact stated that the "Battery" symbol was illuminated on the instrument cluster. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the engine connecting rod bearings had failed, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 85,000.
NHTSA complaint #11690736 — an unverified report by a vehicle owner.
Rocky Mount, NC
FUEL/PROPULSION SYSTEM
The fuel input is not working properly. Will not allow fuel to go into fuel tank. Risk of fuel spilling and fire hazard.
NHTSA complaint #11685206 — an unverified report by a vehicle owner.
Surprise, AZ
EXTERIOR LIGHTING
I own a 2016 Kia Forte LX and have been experiencing repeated and dangerous electrical failures with the headlight and lighting system. When I turn on the headlights, they sometimes do not come on at all, or they shut off unexpectedly while driving. In some cases, using the turn signal causes the headlights to cut out completely. The interior dash lights flicker between dim and bright, and the tail lights are also affected. This is a serious safety hazard because it results in sudden and complete loss of exterior lighting (headlights and tail lights) while the vehicle is in motion at night. It significantly increases the risk of an accident. Online owner forums and repair shops confirm this issue is widespread in Kia vehicles, often traced to a failing multifunction headlight/turn signal switch. Despite the frequency of these failures, there has been no recall issued by Kia. I am requesting that NHTSA investigate this defect in the 2016 Kia Forte and related models, as it directly compromises driver and passenger safety.
NHTSA complaint #11684559 — an unverified report by a vehicle owner.
Surprise, AZ
ELECTRICAL SYSTEM
I own a 2016 Kia Forte LX and have been experiencing repeated and dangerous electrical failures with the headlight and lighting system. When I turn on the headlights, they sometimes do not come on at all, or they shut off unexpectedly while driving. In some cases, using the turn signal causes the headlights to cut out completely. The interior dash lights flicker between dim and bright, and the tail lights are also affected. This is a serious safety hazard because it results in sudden and complete loss of exterior lighting (headlights and tail lights) while the vehicle is in motion at night. It significantly increases the risk of an accident. Online owner forums and repair shops confirm this issue is widespread in Kia vehicles, often traced to a failing multifunction headlight/turn signal switch. Despite the frequency of these failures, there has been no recall issued by Kia. I am requesting that NHTSA investigate this defect in the 2016 Kia Forte and related models, as it directly compromises driver and passenger safety.
NHTSA complaint #11684559 — an unverified report by a vehicle owner.
Fullerton, CACrash1 injured
AIR BAGS
The contact owned a 2016 Kia Forte. The contact stated that while decelerating due to traffic, the vehicle was struck in the rear end and pushed approximately a few feet, causing the vehicle's front end to crash into the rear of the vehicle in front. No warning lights illuminated. No air bags deployed. The contact stated that due to the impact of the crash, she had fallen unconscious. A police report was filed. The contact sought medical attention for bruises and head damage. The vehicle was towed to the local tow lot, where it remains, and was declared a total loss by the insurance provider. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 22V031000 (Airbags) however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was unknown.
NHTSA complaint #11682452 — an unverified report by a vehicle owner.
Danielson, CT
ENGINE
I purchased the 2016 Kia Forte on [XXX] from Bald Hill Kia in Warwick, RI. Within the first 30 days, there was a knocking noise which turned out to be the knocking sensor. I took the car to be checked on 11/1/2022 and paid to replace the knock sensor. On [XXX], the knock sensor acted up again so the knock sensor had to be replaced again. They also found a small evap leak and the charcoal canister was cracked and replaced. On 12/9/2022, the engine assembly was replaced. On [XXX], the check engine light came on and the O2 sensor was replaced. On 1/5/2023, the catalytic converter had to be replaced. On 1/16/2023, the canister purge valved was replaced. On 8/29/2023, the catalytic converter had to be replaced again. On 6/11/2024, the catalytic converter had to be replaced a third time! Over a year passed and on Saturday afternoon on [XXX] the check engine light turned on again and Kia was closed on Sunday so I took the car to Firestone for a diagnostic test and it turned out that it was the catalytic converter for the 4th time. I dropped off the car in 8/4/2025 and I'm waiting to see if the car can get looked at this week to confirm the problem for a 4th time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11678419 — an unverified report by a vehicle owner.
at 84,000 milesOrlando, FL
ENGINE
The contact owns a 2016 Kia Forte. The contact stated while driving approximately 40 MPH and depressing the accelerator pedal to merge onto the highway, the check engine warning light illuminated, and the vehicle went into LIMP Mode. The contact stated that the vehicle failed to exceed 15 MPH. The vehicle was taken to an auto parts store, where it was scanned, and DTC: P1326; was retrieved. The contact stated that the code indicated a Knock Sensor Detection system failure. The vehicle was towed to a dealer, where the contact was informed that the manufacturer had advised the dealer not to diagnose the vehicle due to an incomplete oil change history. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 84,000.
NHTSA complaint #11677520 — an unverified report by a vehicle owner.
Belleville, IL
POWER TRAIN
1. NHTSA Safety Complaint Draft Vehicle Info: Make: Kia Model: Forte5 SX Year: 2016 VIN: [XXX] Engine: 1.6L GDI (G4FJ Nu engine) Issue: This vehicle uses the 1.6L GDI Nu engine (engine code G4FJ), which is the same engine involved in Kia’s engine defect recalls and class action settlements related to connecting rod bearing failure and engine seizure risks. However, Kia is refusing to provide the Knock Sensor Detection System (KSDS) update, and no internal campaigns or recalls are listed for my VIN despite the identical mechanical risk. I purchased the vehicle in 2017 and was unaware of the extended warranty and safety campaigns until now. I am experiencing symptoms of rough idle and pre-knock concerns, and yet Kia and my local dealership are unwilling to escalate my case or even verify warranty eligibility. This defect poses a risk of sudden engine failure and should be addressed under expanded recall coverage. I am requesting NHTSA investigate inclusion of later-production 2016 vehicles like mine, which clearly share the same defective power train. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11675975 — an unverified report by a vehicle owner.