AC not working, recall SA512 is needed, Kia wont cover the cost of replacing electrical components. Thermal Runaway / Fire Risk: The broken compressor prevents the battery thermal management system from cooling the main high-voltage lithium-ion battery package, creating an overheating hazard during driving or DC fast-charging. Sudden Loss of Power (Motive Power): Battery overheating can trigger a sudden "safe mode" or turtle mode, dropping your speed to zero unexpectedly on the highway.Impaired Driver Visibility: The lack of functional cabin heating prevents windshield defrosting, severely impairing the driver's ability to see the road safely.
NHTSA complaint #11755319 — an unverified report by a vehicle owner.
My 2017 Kia Niro exhibits a dangerous low-speed engine surging hazard matching Safety Recall SC276. An authorized Kia dealership technician inspected the vehicle under RO #6115244 and formally documented 'seeping fluid residue' inside the clutch actuator housing. However, the dealership and Kia Corporate are refusing to honor the recall remedy and have released the car at a $0.00 balance while explicitly stating in writing that the vehicle is 'not safe to drive.' I am requesting federal intervention for safety campaign non-compliance.
NHTSA complaint #11753205 — an unverified report by a vehicle owner.
My 2023 Kia Niro Hybrid EX has experienced multiple warning messages and unresolved concerns after previous repairs. After the first recall repair, I began receiving intermittent warning messages while driving. The messages appeared briefly and disappeared before I could safely document them. After a second repair, the transmission was replaced. Shortly afterward, the vehicle displayed an overheating warning. I returned to the dealership, but they stated they could not find a problem. While traveling out of state, on July 6, 2026, the vehicle displayed warnings indicating that the 12V battery needed to be charged. On July 8, 2026, the vehicle would turn on, but the engine would not start or operate. Multiple attempts to jump-start the vehicle failed, including using a portable jump pack, another vehicle, and assistance from a tow truck driver. The vehicle displayed warnings stating that the 12V battery needed charging, the battery was draining, and that the hybrid system needed to be checked. Because the vehicle could not be operated and I was stranded away from home, I am concerned about the reliability and safety of the vehicle. The vehicle has undergone multiple repairs, including a transmission replacement, but I continue to experience warning messages and a loss of confidence in the vehicle's ability to operate reliably. I am requesting that this issue be reviewed for possible safety concerns.
NHTSA complaint #11752872 — an unverified report by a vehicle owner.
Finally got car back from previous repairs and it was making a loud groaning noise all the time. Took it back to dealership and they said they had to repair the rack and pinion system and the gears were shredded. Employee says they now have another niro with the same problem as my original symptoms when transmission was replaced twice. Car has consistently had problems with the RPMs being incredibly high at low speeds but the dealership can’t seem to replicate the problem. Car randomly switched over to manual mode after a long drive. Video of problems given to employee and just said he’s going to give them to his field technician. Car has now been at the dealer for over 4 months and was finally returned because they can’t reproduce the problem.
NHTSA complaint #11752437 — an unverified report by a vehicle owner.
Kia Dealership (DCH Kia of Temecula) Repair order 237695 shows Recall SC276 was 'passed' via inspection on October 16, 2025. However, the Hydraulic Clutch Actuator has now suffered the exact fluid leak the recall warned about, destroying the slave cylinder. The dealership is refusing to honor the safety recall, leaving an active fire hazard unaddressed.
NHTSA complaint #11745143 — an unverified report by a vehicle owner.
Transmission was replaced but then completely shut down as I was making a right turn. Multiple indicators on dash went off and safety errors kept scrolling across dash. Vehicle then wouldn’t shift at all. TCM was replaced but vehicle has high RPMs at low speeds. Has been at the dealership now for over 90 days.
NHTSA complaint #11744906 — an unverified report by a vehicle owner.
On or around March 20, 2026, my 2017 Kia Niro Hybrid experienced a complete failure of the high-voltage hybrid battery system, rendering the vehicle undriveable. The vehicle was towed to Kia of South Austin. As of the date of this complaint (74 days later), no diagnosis has been provided, no parts have been ordered with trackable confirmation, and no repair timeline has been given. Kia Techline corporate engineers are reportedly involved but have provided no resolution. A sudden high-voltage battery failure in a hybrid vehicle raises potential safety concerns I believe warrant NHTSA's attention, particularly given the extended inability to diagnose or repair the system.
NHTSA complaint #11741447 — an unverified report by a vehicle owner.
Problem 1, Check Engine Light: I purchased the used car on Jan 9 2025, around 23,400 miles from Kia Dealership, capitol Expy in San Jose. Today 05/27/2026, the odometer reads 26, 407 miles. My car is used only twice a week - 20 miles on Fridays, 12 miles on Wednesdays. My car has less than minimum wear and tear and is barely used. I completed my 25K service after Thanksgiving in Nov 2025. I have not even driven 1500 miles and the car is back in for service. Prior to this, within a month of purchasing my car Kia replaced the battery in my car. Around Mar 15, 2026, the Check Engine Light displayed. I called the Kia Dealership on Capitol Expy in San Jose 3-4 times, but they Kia dealership don't call back. On 05/15/2026, for the first time I drove about 50 miles return trip. While driving North on I-280 from [XXX] to [XXX] , over rolling hills that had some incline, the Check Engine Light came on.I scheduled service. I experienced that the vehicle struggle to climb the incline of rolling hills, after the battery charge was exhausted and the engine was running only on gas. The gas was 3/4 full. This is a safety hazard for me to be interrupted by Check Engine Light twice while driving and that too when my car has not even completed 30K miles. My car is sin Service on 05/26/2026 and in the shop for 3 days diagnosis. The Kia Dealership has yet to determine the problem. I have had to rent my own rental car even though I purchased Extended Warranty on the car. Problem 2, Blind Spot Warning Light on right side mirror: On 05/13/2026 and on 05/22/2026, the Blind Spot warning light on right side mirror does not display oncoming traffic when my car is parallel to the lane markings. On 05/13/2026, I was driving at 30mph and on 05/22/2026 I was stationary in the center divider. In both instances, the passing driver had to honk at me really loud -- to avert an accident. Both problems are severe safety hazards. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11740374 — an unverified report by a vehicle owner.
On April 21, 2026, Go Kia Renton performed an oil change on my 2018 Kia Niro Touring (VIN). The car was in perfect condition just two weeks earlier — North Seattle Transmission did a full service on April 6, 2026 at 283,649 miles with no issues noted. Later that night while driving, the red oil light flashed. I pulled over immediately and called AAA. AAA towed the vehicle from Belltown [XXX] ) at 12:11 AM on April 23 to my house then at 9:14 AM towed it straight to Go Kia Renton. The AAA driver found oil leaking all over his tow truck. The car now has a dead battery and is showing Hybrid Control System / Low Voltage DC/DC Converter and Engine Control System codes. This appears to be a sudden engine seizure caused by oil loss shortly after dealer service. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11735577 — an unverified report by a vehicle owner.
The Hydraulic Clutch Actuator (HCA) and the Under Hood Wiring Harness have failed due to internal fluid contamination and corrosion. Yes available for inspection. The vehicle experienced a sudden loss of motive power while driving. Per Safety Recall SC276, this component failure creates an electrical short and internal corrosion that poses a significant fire risk and potential for a sudden stall at high speeds, endangering the driver and other motorists. YES. Rusty Wallace Kia of alcoa confirmed the failure on 04/27/2026. They diagnosed the vehicle with DTCs P17EE and U1010. They provided a repair quote (RO XXX) for $9,431.48 to replace the corroded HCA and harness. YES. The vehicle was inspected by an authorized Kia dealer (Rusty Wallace Kia of alcoa ). They are refusing to perform the Recall SC276 mandated repair, claiming it was "already completed" with a fuse swap in Jan 2024, even though the safety defect has now manifested as a full component failure. Yes. The HEV warning light and Check Engine light appeared. Symptoms include "Check Hybrid System" messages and the vehicle failing to engage the engine clutch. These symptoms appeared recently at approximately 107,000 miles. Then when i checked the car it vanished, no error on dashboard ,so i took the car back and was driving error showed up at 109k miles again They asked to repair the vehicle and the repair is not in my budget and i told them that its the recall related issue and they are denying and saying recall was done and they dont open recall again and I found in the document they provided they just did the fuse replacement not HCA unit and The fuse swap did help with the hca corrosion and its not in drivable state and it becae a fire hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11734200 — an unverified report by a vehicle owner.
I had my oil changed in Dec. 2025. I drove 1000+ miles w/no issue. Engine suddenly seized w/no engine light warning. Oil dumped all at once. Kia refuses to cover under warranty. THIS HAPPENED TO MY CAR: NTSA announced it had launched an investigation into Hyundai Motor Company and Kia Motor Company for problems with their oil pans and oil drain plugs... consumers have filed complaints their engine’s oil drain plug falls out, causing all the oil to drain out of their engine while driving. In multiple tests the oil drain plug was tightened according to factory torque specifications and the tightening was well documented. Yet, testing shows in multiple cases that while driving, the oil drain plug falls within a few thousand miles after the service. In those cases, the crankcase drained completely. The Hyundai and Kia drain plug falls out due to inferior oil pan material and the drain plug gasket. The testing and investigations appear to show that the oil drain plans are made with THIN METAL AND THE DRAIN PLUG MOUNTING IS POORLY REINFORCED. In addition, the oil pan is coated with a thick paint coating the bonds the gasket to the pan, so the gasket does not come off when the drain plug is removed. That gasket issue alone is not why the oil drain plug falls out, but it is a factor in the chain of events. The oil pan is the biggest problem Apparently, the thin metal, along with engine vibrations and expansion/contraction tend to loosen the drain plug without any other intervention. NHTSA is investigating this as a factory defect ... The problem is two-fold. First, even if the repair shop properly torques the drain plug, the oil drain plug falls out on its own. The customer then blames the shop for shoddy workmanship. Second, Hyundai and Kia dealers are telling customers that servicing their vehicle at an aftermarket shop automatically voids their factory warranty. This is totally false & actually illegal under the terms of the Magnuson-Moss Warranty Act.
NHTSA complaint #11733521 — an unverified report by a vehicle owner.
The contact owns a 2017 Kia Niro. The contact stated that while driving approximately 60 MPH, there was smoke coming from the rear of the vehicle. The message, "Turn Off the Vehicle and Stop" was displayed, and the transmission failure warning light was illuminated. The contact pulled over and turned off the vehicle. Once the vehicle was turned off, the smoke dissipated. The vehicle was towed to the dealer, who diagnosed that there were holes in the engine, power steering, and there was an engine oil leak. The engine, transmission, and battery were replaced. However, 2 months later, the contact attempted to start the vehicle; however, the vehicle failed to start. The vehicle was scheduled to be towed to another dealer, Buster Miles Kia (1401 S Quintard Ave, Anniston, AL 36201). The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure, and it was determined that the repair was not covered under warranty or recall. The failure mileage was approximately 50,500.
NHTSA complaint #11731378 — an unverified report by a vehicle owner.
The contact owns a 2017 Kia Niro. The contact stated that while driving 60 MPH on the highway, the vehicle jolted and shook abnormally. The electrical system warning light illuminated, and the vehicle lost partial power. The engine and hybrid warning lights were illuminated. The vehicle was coasted off the roadway to a gas station. The vehicle was towed to the local dealer, where it was diagnosed with a blown high-voltage fuse. The vehicle was repaired with a higher voltage fuse. The manufacturer was contacted and opened a case. The approximate failure mileage was 101,000. The VIN was not available.
NHTSA complaint #11729706 — an unverified report by a vehicle owner.
The vehicle has a recurring P0420 code (“Catalyst System Efficiency Below Threshold Bank 1”). A boroscope inspection at Ricardo Caballero Kia Santa Isabel (invoice #[XXX] dated December 5, 2025) confirmed internal disintegration of the catalytic converter, with physical pieces of the catalyst falling out when the exhaust pipe was removed. This failure appears related to Recall 23V534 (SC276) and TSB PS709 (overheating / coolant boiling issues in 2017-2022 Niro Hybrid models). Motorambar, Inc. (official Kia distributor in Puerto Rico) has ignored my warranty claim since December 2 and December 22, 2025 (more than four months). Motorambar is now refusing to authorize a courtesy loaner vehicle at the dealer Ricardo Caballero Kia Santa Isabel, claiming the tests will take less than 5 days. This leaves me without transportation. The catalytic converter is fully covered under the Federal Emissions Warranty (8 years / 80,000 miles). I request that NHTSA investigate this as a potential safety and emissions defect and require Kia / Motorambar to: 1. Immediately repair or replace the catalytic converter under warranty at no cost. 2. Provide a courtesy loaner vehicle during the repair. 3. Reimburse previous diagnostic costs of $449.17. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11728234 — an unverified report by a vehicle owner.
The contact owns a 2019 Kia Niro. The contact stated that while driving at an undisclosed speed, the vehicle stalled in the middle of the road. The vehicle was successfully restarted and moved over to the side of the road. The vehicle was towed to an independent mechanic, where it was diagnosed with a blown head gasket, a misfire in the engine, and coolant mixing with the engine oil; however, the vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 118,000.
NHTSA complaint #11727300 — an unverified report by a vehicle owner.
Engine Seized at 79,000 miles on Kia Niro Hybrid on 3/8/2025. Oil was changed at 78,225 miles on 12/16/2025. No issues with vehicle until approx. 1,000 miles later and just a month and a half later when car suddenly lost power on a highway forcing me to try to safely and quickly navigate off the road. This could have caused risk to my life and other lives. The car could not be restarted. Kia said the drain plug was not screwed on and is refusing to honor warranty despite no issues with the oil change. Notably, in October 2022, the National Highway Traffic Safety Administration (NHTSA) announced it had launched an investigation into Hyundai Motor Company and Kia Motor Company for problems with their oil pans and oil drain plugs. Specifically, consumers and aftermarket service facilities have filed complaints their engine’s oil drain plug falls out, causing all the oil to drain out of their engine while driving. In multiple tests the oil drain plug was tightened according to factory torque specifications and the tightening was well documented. Yet, testing shows in multiple cases that while driving, the oil drain plug falls within a few thousand miles after the service. In those cases, the crankcase drained completely. [XXX] This issue should be investigated for potential recall to keep drivers, passengers safe on our highways. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11726377 — an unverified report by a vehicle owner.
EV motor and drive train have a clattering noise, much like a playing card attached to a bicycle clattering against the wheel spokes. it speeds up and slows down with the acceleration of the motor.
NHTSA complaint #11725753 — an unverified report by a vehicle owner.
-Car was leaking or burning coolant causing engine to overheat. -Car was diagnosed with: Exhaust heat exchanger is leaking coolant and needs to be replaced. After costly repair, car continued to leak coolant and overheated. -Car was taken back to the dealership and diagnosed with: Engine Assembly - Long Block - Replace | Engine long block needs replacement due to coolant in the oil. This was at a certified Kia Dealership. No insurance reps or police were involved. An engine light has come on a couple of times over the years that was interpreted to mean replacing the gas cap. After replacing the gas cap, the engine light didn't come back on. My safety was impacted as a person living in a cold, rural state to have a sudden mechanical failure where I couldn't run the heat and had to stop the car immediately.
NHTSA complaint #11725337 — an unverified report by a vehicle owner.
While traveling from upstate New York, the vehicle displayed an engine overheating warning shortly after startup while the engine was still cold. Because I was away from home, I stayed overnight and the next morning took the vehicle to a Kia dealership for inspection. The dealership inspected the vehicle and diagnosed a problem with the exhaust heat recovery system pipe. According to the service department, coolant is leaking internally through this component and is being burned in the exhaust system. The cooling system was pressure tested and held pressure externally, indicating the coolant loss is occurring internally through the exhaust heat recovery system rather than from an external leak. This condition can cause coolant loss and overheating while driving. If the engine overheats while the vehicle is in operation, it could create a safety risk due to sudden loss of power or engine damage. The dealership confirmed the diagnosis after inspection and testing and provided a repair estimate to replace the affected exhaust heat recovery system component. The overheating warning message was the first symptom observed prior to diagnosis. The problem was confirmed by the dealership after inspection and testing. This issue may indicate a defect in the exhaust heat recovery or thermal management system used in this hybrid vehicle, as coolant is entering the exhaust stream internally rather than leaking externally. If this type of failure occurs in other vehicles, it could lead to overheating while driving and potential engine damage.
NHTSA complaint #11724340 — an unverified report by a vehicle owner.
The contact owns a 2019 Kia Niro. The contact stated while driving at an undisclosed speed, the vehicle jerked. The check engine warning light and the hybrid battery warning light were illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the clutch actuator was leaking, and the dual clutch and slave cylinder needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but denied assistance in covering the cost of the repair. The contact stated that the engine and dual clutch were replaced two years ago. The contact related the failure to NHTSA Campaign Number: 23V534000 (POWER TRAIN); however, the VIN was not included. The failure mileage was approximately 100,000.
NHTSA complaint #11722353 — an unverified report by a vehicle owner.