The contact owns a 2018 Kia Niro. The contact stated that while driving at an undisclosed speed, the temperature gauge became elevated, and the vehicle stalled. The message "Check Hybrid System - Turn Engine Off" was displayed. The contact associated the failure with NHTSA Campaign Number: 23V534000 (Power Train). The dealer was contacted and stated that the vehicle was serviced under the recall; however, the vehicle was still inoperable, and additional diagnostic tests were needed. The vehicle was towed to an independent mechanic, and the mechanic discovered that there was no coolant inside the coolant reservoir. The contact attempted to contact the dealer but had not received a reply from the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 158,000.
NHTSA complaint #11757679 — an unverified report by a vehicle owner.
2017 Kia Niro Hybrid subject to Safety Recall SC276 (NHTSA Campaign 23V534) for the Hydraulic Clutch Actuator (HCA). Fluid contamination of the HCA PCB can cause an electrical short and engine compartment fire risk. Official remedy is HCA inspection/replacement as necessary plus a new fuse. Three dealer visits: Shortly after purchase for SC276 recall and routine service. Dealer performed HCA Inspect/Replace, reported no problem codes, and replaced the fuse. After sudden complete loss of propulsion on the freeway at 60-65 mph with a passenger. Engine RPM rose sharply as if in neutral. No accelerator response. Brake system warning lights illuminated. Had to pull over to the shoulder, shut off and restart before it would move. Took to dealer same day. They kept it several days, found no codes, could not duplicate, and released as "good to go." Vehicle later would not move and entered limp mode. Towed to dealer. That morning I replaced spark plugs myself with new NGK Laser Iridium Premium and informed the dealer. HCA fluid reservoir was empty. Dealer diagnosed internal leak in the HCA causing clutch contamination. Photos showed green fluid on undercarriage. Repair estimate exceeds $6900. Same Multi-Point Inspection that diagnosed the internal leak marked fluid leaks and fluids as Passed. Report still recommended spark plug replacement despite being told they were just replaced. Sudden loss of propulsion on public freeway with a passenger present, followed by complete loss of driveability due to internal leak of the same recalled HCA component, created a clear safety risk. Vehicle became undriveable and required towing. Prior "good to go" release left the vehicle on the road with an unresolved issue involving the recalled component.
NHTSA complaint #11754127 — an unverified report by a vehicle owner.
My 2017 Kia Niro exhibits a dangerous low-speed engine surging hazard matching Safety Recall SC276. An authorized Kia dealership technician inspected the vehicle under RO #6115244 and formally documented 'seeping fluid residue' inside the clutch actuator housing. However, the dealership and Kia Corporate are refusing to honor the recall remedy and have released the car at a $0.00 balance while explicitly stating in writing that the vehicle is 'not safe to drive.' I am requesting federal intervention for safety campaign non-compliance.
NHTSA complaint #11753205 — an unverified report by a vehicle owner.
My 2023 Kia Niro Hybrid EX has experienced multiple warning messages and unresolved concerns after previous repairs. After the first recall repair, I began receiving intermittent warning messages while driving. The messages appeared briefly and disappeared before I could safely document them. After a second repair, the transmission was replaced. Shortly afterward, the vehicle displayed an overheating warning. I returned to the dealership, but they stated they could not find a problem. While traveling out of state, on July 6, 2026, the vehicle displayed warnings indicating that the 12V battery needed to be charged. On July 8, 2026, the vehicle would turn on, but the engine would not start or operate. Multiple attempts to jump-start the vehicle failed, including using a portable jump pack, another vehicle, and assistance from a tow truck driver. The vehicle displayed warnings stating that the 12V battery needed charging, the battery was draining, and that the hybrid system needed to be checked. Because the vehicle could not be operated and I was stranded away from home, I am concerned about the reliability and safety of the vehicle. The vehicle has undergone multiple repairs, including a transmission replacement, but I continue to experience warning messages and a loss of confidence in the vehicle's ability to operate reliably. I am requesting that this issue be reviewed for possible safety concerns.
NHTSA complaint #11752872 — an unverified report by a vehicle owner.
The vehicle experienced a sudden powertrain failure while driving. A certified Kia dealership diagnostic scan confirmed active Diagnostic Trouble Code (DTC) P17ED (Engine Clutch System) and a physical hydraulic clutch fluid leak around the transmission housing area. These symptoms match the exact criteria of NHTSA Safety Recall 23V534 (Kia Campaign SC276) for the Hydraulic Clutch Actuator (HCA). The manufacturer's defective component leaked fluid, causing direct consequential failure of the internal clutch and transmission assembly. Kia is refusing to remedy this safety campaign failure at 100% zero cost to the consumer, violating federal safety recall mandates by attempting to charge 50% of the repair cost ($3,708.29) under the guise of 'goodwill assistance'.
NHTSA complaint #11748846 — an unverified report by a vehicle owner.
What's malfunctioning: coolant monitoring system shows low coolant warning when coolant level is observably fine. Problem has been ongoing for over a year. Available for inspection: yes. Safety problem: coolant monitoring is inaccurate, causing alarm when coolant levels are fine and possibly causing no alarm when coolant levels are too low. Problem reproduced: yes, by both dealer and independent service center. Vehicle inspected by manufacturer: yes. They attempted service but their repair only lasted a few months. Symptoms prior to failure: no. The problem is that the warning lights are turning on when they should not be. This matches the symptoms of Kia Technical Service Bulletin SA512, but the manufacturer's fix did not work.
NHTSA complaint #11746979 — an unverified report by a vehicle owner.
Transmission was replaced but then completely shut down as I was making a right turn. Multiple indicators on dash went off and safety errors kept scrolling across dash. Vehicle then wouldn’t shift at all. TCM was replaced but vehicle has high RPMs at low speeds. Has been at the dealership now for over 90 days.
NHTSA complaint #11744906 — an unverified report by a vehicle owner.
The vehicle experienced a dangerous driving failure due to a hydraulic clutch actuator system issue and was towed to Kia Delray. The authorized dealership has officially diagnosed the issue as a "brake/clutch fluid leak" (attached diagnostic estimate), which is exactly the hazardous condition outlined under Safety Recall 23V534 (SC276). However, the dealer refuses to perform the free recall repair remedy, claiming that the recall campaign was technically marked as completed after a previous interim fuse replacement. They are demanding $5,642.21 out-of-pocket and threatening to charge $75/day storage fees starting Monday morning. I am seeking immediate federal regulatory intervention as this vehicle has a well-documented fire and safety hazard that the manufacturer refuses to cure.
NHTSA complaint #11741038 — an unverified report by a vehicle owner.
A major drivetrain service and repair was completed by an authorized manufacturer dealership. After picking up the vehicle, an unusual front-end/steering noise was immediately reported to the staff. Over just 390 miles of driving, the symptom worsened. A subsequent formal inspection by a separate, independent authorized service center confirmed the root cause of the safety failure: the primary axle nut had been left completely unstaked during the initial drivetrain assembly, rendering the vehicle entirely unsafe to operate. The vehicle was grounded to prevent an accident. Because the mandatory safety protocol of staking the axle nut was omitted, the critical fastening hardware was allowed to back off under normal driving conditions. This component failure directly compromised the structural integrity of the front drivetrain, steering knuckle, and wheel hub assembly. Had the vehicle continued to be driven, the omission presented an imminent risk of complete mechanical separation, which could cause a wheel assembly to detach or lock up while in motion at high speeds, putting the safety of the occupants and other motorists at extreme risk. The vehicle remains grounded and is available for inspection. The safety-critical assembly failure has been fully documented by the inspecting service center via technical video (available upon request) and photographic evidence. The manufacturer has been notified of the dealer workmanship defect but has failed to authorize corrective action or safe transport of the vehicle to a certified facility for remediation.
NHTSA complaint #11739644 — an unverified report by a vehicle owner.
2024 KIA Niro
at 140,000 milesCartersville, GACrash2 injured
POWER TRAIN
The contact owns a 2024 Hyundai Niro Hybrid. The contact stated that while at a stop light the warning message "transmission overheating" had displayed and the vehicle did not drive forward. The contact attempted to push the vehicle offer the road when suddenly the vehicle accelerated forward and drove on the opposite side of the over a curb and drove into oncoming traffic and crashed head on into a second vehicle. The vehicle the drover over a curb and down an embankment and crashed. The failure mileage was 140,000.
NHTSA complaint #11738543 — an unverified report by a vehicle owner.
The Hydraulic Clutch Actuator (HCA) and the Under Hood Wiring Harness have failed due to internal fluid contamination and corrosion. Yes available for inspection. The vehicle experienced a sudden loss of motive power while driving. Per Safety Recall SC276, this component failure creates an electrical short and internal corrosion that poses a significant fire risk and potential for a sudden stall at high speeds, endangering the driver and other motorists. YES. Rusty Wallace Kia of alcoa confirmed the failure on 04/27/2026. They diagnosed the vehicle with DTCs P17EE and U1010. They provided a repair quote (RO XXX) for $9,431.48 to replace the corroded HCA and harness. YES. The vehicle was inspected by an authorized Kia dealer (Rusty Wallace Kia of alcoa ). They are refusing to perform the Recall SC276 mandated repair, claiming it was "already completed" with a fuse swap in Jan 2024, even though the safety defect has now manifested as a full component failure. Yes. The HEV warning light and Check Engine light appeared. Symptoms include "Check Hybrid System" messages and the vehicle failing to engage the engine clutch. These symptoms appeared recently at approximately 107,000 miles. Then when i checked the car it vanished, no error on dashboard ,so i took the car back and was driving error showed up at 109k miles again They asked to repair the vehicle and the repair is not in my budget and i told them that its the recall related issue and they are denying and saying recall was done and they dont open recall again and I found in the document they provided they just did the fuse replacement not HCA unit and The fuse swap did help with the hca corrosion and its not in drivable state and it becae a fire hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11734200 — an unverified report by a vehicle owner.
The contact owns a 2017 Kia Niro. The contact stated that while driving approximately 60 MPH, there was smoke coming from the rear of the vehicle. The message, "Turn Off the Vehicle and Stop" was displayed, and the transmission failure warning light was illuminated. The contact pulled over and turned off the vehicle. Once the vehicle was turned off, the smoke dissipated. The vehicle was towed to the dealer, who diagnosed that there were holes in the engine, power steering, and there was an engine oil leak. The engine, transmission, and battery were replaced. However, 2 months later, the contact attempted to start the vehicle; however, the vehicle failed to start. The vehicle was scheduled to be towed to another dealer, Buster Miles Kia (1401 S Quintard Ave, Anniston, AL 36201). The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure, and it was determined that the repair was not covered under warranty or recall. The failure mileage was approximately 50,500.
NHTSA complaint #11731378 — an unverified report by a vehicle owner.
I am reporting a safety issue involving my 2018 Kia Niro hybrid related to the Hydraulic Clutch Actuator (HCA), which is currently subject to a recall addressing fire risk. My vehicle has already had the recall remedy performed, which consisted of inspection and installation of a lower-amperage fuse. The dealer confirmed that the actuator is leaking fluid but did not replace it because there was no evidence of PCB contamination, which is the condition required under the recall. However, the vehicle is now experiencing significant drivability issues that create a safety hazard: Intermittent hesitation when accelerating from a stop Failure to properly engage the transmission, especially on inclines Engine revving without corresponding vehicle movement Delayed or inconsistent clutch engagement In one recent instance, the vehicle would not properly engage while attempting to move from a stopped position on an uphill incline, creating a hazardous situation where the vehicle could not reliably move when needed. This condition appears to be caused by loss of hydraulic pressure due to the leaking actuator, even though it has not yet reached the stage of PCB contamination described in the recall. The current recall remedy does not address this failure mode. Instead, it allows a known defective component to remain in service until it reaches a condition that presents a fire risk. In the meantime, the vehicle can experience loss of propulsion under normal driving conditions. I believe this represents a separate safety defect or an incomplete remedy, as loss of propulsion, especially during acceleration from a stop or on an incline, can significantly increase the risk of a crash. I am requesting that NHTSA investigate whether the current recall adequately addresses all safety risks associated with the defective Hydraulic Clutch Actuator, including drivability and loss-of-propulsion conditions that occur prior to PCB contamination.
NHTSA complaint #11731040 — an unverified report by a vehicle owner.
This is a hybrid vehicle. It has Dual clutch transmission. Since I have owned it, intermittently the clutch does not disengage completely. This causes the vehicle to try to pull ahead but my foot is on the brake. The vehicle does not stall. Somehow it figures out it can't pull ahead and somehow fully releases. I have brought it to kia at least 3 times. In each case they tell me they cNt get the car to fail and since there are no codes produced they can't fix it. They even held onto the car several days. I asked them to please replace SOMETHING but the say Kia policy will not allow them to do that. So I am stuck with a car that keeps misbehaving. It is embarrassing because problems occur while a passenger is in the car and it seems to them that I am not driving correctly. I don't know what to do.
NHTSA complaint #11730504 — an unverified report by a vehicle owner.
The contact owns a 2018 Kia Niro. The contact stated that when the vehicle was shifted into reverse(R), the vehicle failed to respond. The vehicle was turned off and restarted to reset the transmission, but the vehicle failed to respond while in reverse(R). The vehicle was shifted to drive(D) but failed to respond. The vehicle was shifted into park(P). The vehicle was towed to a local dealer. The dealer diagnosed the vehicle and determined that the transmission fuse and the hydraulic clutch actuator had failed and that the transmission needed to be replaced. The contact researched online and related the failure to NHTSA Campaign Number: 23V534000 (Power Train). The manufacturer was contacted and the contact was informed that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 175,000.
NHTSA complaint #11728259 — an unverified report by a vehicle owner.
EV motor and drive train have a clattering noise, much like a playing card attached to a bicycle clattering against the wheel spokes. it speeds up and slows down with the acceleration of the motor.
NHTSA complaint #11725753 — an unverified report by a vehicle owner.
I previously had major issues and recall 23V534000 fixed on my 2017 Kia Niro. I had issues again and took it to the local Kia dealership in Wichita, KS. They found a leak in a seal causing fluid to leak on to the clutch actuator. The service tech indicated it is related to the recall. I have spoken with Kia customer service escalations on multiple occasions. Originally they stated it was related to the recall. When I spoke when them today, on the phone they said all the parts that are affected are what were changed out previously. When they called back, they changed the story and said it is not related and they would not pay for it to be fixed, even though they previously said it was the exact thing related to the recall. When I emailed and asked for it in writing as to why it was denied, she changed the reasoning. It was nothing the same that she had told me on the phone. This is a safety issue that should be fixed by the manufacturer and they are refusing to fix it and telling me I have to pay over $5000 to fix it. Completely unacceptable.
NHTSA complaint #11722316 — an unverified report by a vehicle owner.
The contact owns a 2019 Kia Niro. The contact stated while driving at an undisclosed speed, the vehicle jerked. The check engine warning light and the hybrid battery warning light were illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the clutch actuator was leaking, and the dual clutch and slave cylinder needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but denied assistance in covering the cost of the repair. The contact stated that the engine and dual clutch were replaced two years ago. The contact related the failure to NHTSA Campaign Number: 23V534000 (POWER TRAIN); however, the VIN was not included. The failure mileage was approximately 100,000.
NHTSA complaint #11722353 — an unverified report by a vehicle owner.
Ever since the purchase of the car I been bringing this attention to the dealership but they always turn down and avoiding the situation at first electrical issues like turning signals goes in and out window stop rolling up sometimes had to try for hours just rolls up fog light check light headlight and turn signal all together went out in the beginning started to work in and out and now window turn signal front both and one fog light now won't come back and front Air Flap won't operate that's from the few months into the car check light and also in the beginning car transmission always felt rough not gears smoothly change I brought this attention but they always ask change the transmission fluid but it's was a new car felt that but never bothered looking into but over time got worst now it hit you when picking up like gear just stuck and your whole body gets that shock like someone hit you from the back every time and when comes to slow stopping making crying sound. It's like I made the biggest mistake why I decided to buy the new car because I know old cars have problems but this is Brand New I bought shouldn't have problems, and from it's was new always heard the click sound when move from complete stop like go from on red light or from any stop position click hear it from front never worried but was not feeling good why but now all of sudden it's unbearable sound when turning or making u turn loud like anything when acceleration but not in straight drive asked dealership about all the problems I been getting since was a brand new car the answered I got it's now not in the warrenty will cost to check wow what a rip off and when I use to say those problems when was in the warrenty they would say it's not the major issue and yes one time one of the tech specialists I mentioned he you know what he said made me sick we would try something but warrenty is BS it's a piece of *** we never get money easily so this is why they always refuse to take this seriously wow
NHTSA complaint #11712850 — an unverified report by a vehicle owner.
When I was driving, a propulsion system warning went off. Then a malfunction in the vehicle’s powertrain/propulsion system lit up on the GPS screen. Shortly afterward, the engine began smoking, and a loud popping sound occurred simultaneously. The vehicle then experienced a sudden loss of propulsion, requiring me to pull over immediately to avoid a hazardous situation. An authorized Kia dealer subsequently diagnosed a blown head gasket with internal coolant intrusion, confirming an internal powertrain failure consistent with propulsion system malfunction, and the vehicle became inoperable. The vehicle was inspected in October and the loss-of-propulsion failure occurred in December.
NHTSA complaint #11709453 — an unverified report by a vehicle owner.