KIA Sorento other reported problems

UNKNOWN OR OTHER

My 2026 Sorento developed a fault after just two weeks of use. It had to be towed three times because the engine shuts down and won't restart. I tried to resolve the issue with the dealership, but they claim there is nothing wrong with the car. I reported the situation to Kia America; after a 19-day wait, they replied that there is nothing they can do and that I must pick up the vehicle from the Kia East Orlando dealership, or else I will have to pay parking fees. During this time—while the car was being towed three times by Kia’s own partners and transported to the dealership—it sustained damage to the trunk. They claim the car arrived at the dealership in that condition but refuse to provide me with photos or the tow truck inspection checklists.

NHTSA complaint #11761556 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I went in a few months ago for a routine oil change. My car has had zero operating issues since I had the engine replaced around 5 years ago. They told me that I need to have a voluntary emissions update performed, so I gave consent. (The letter I received a few days later referred to it as "Voluntary Emissions Service Campaign.")On the way home, it seemed to drive rougher. I figured it was relearning some of the basic operating values. The following morning, it idled rough and then when I began driving, it would lurch forward irradically for the first one or two minutes of driving. I called the dealership and they insisted that it was coincidence. They said they will look at it, but there would be a charge. I have noticed a pattern since then. During normal driving, it is now smooth. It only happens on cold starts. Allowing it to idle elimiates the issue. However, it continues to idle rough on cold starts. If I drive it after it warms up, however, it does lurch forward. After this, it drives normal. Today I went in to the dealership for another oil change and asked about it. They continued to insist that it was impossible, but that I could leave it overnight and pay to have it looked at with the understanding that the two cannot be related. The safety issue is that it will literally make the car lurch forward when barely touching the gas. If this continues to worsen, it will cause a wreck. It has not been formally inspected, but I can provide dash cam footage.

NHTSA complaint #11759097 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

On multiple occasions, my 2023 Kia Sorento has experienced an intermittent failure where numerous dashboard warning lights and alerts illuminate and the engine will not start. During the failure, the brake pedal becomes very stiff and the vehicle cannot be shifted out of Park. The problem is unpredictable and has left the vehicle disabled. The vehicle was taken to a Kia dealership for diagnosis. The dealer initially stated that the battery was not properly secured and was moving around, possibly contacting nearby electrical components. They told me the issue had been repaired. However, when I returned to pick up the vehicle, the exact same failure occurred again in the dealership parking lot before I was able to leave. The warning lights came on and, after the vehicle was turned off, it would not restart. The dealer has therefore been able to directly observe the repeated failure. The exact component causing the malfunction is still unknown. I am concerned that this may be an electrical or grounding issue and that the vehicle could become disabled unexpectedly while in use.

NHTSA complaint #11759161 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Engine burning oil Failed oil consumption test done by dealership - had to get engine replaced Still noticing stuttering and fluctuating power at times. Failure of Snow White Pearl paint delamination issue causing the top-coat to lift off of underlying primer. Rust has started in some of the spots

NHTSA complaint #11758613 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

During highway trips the info cluster starts chiming and a coffee cup light comes on the dash saying I should consider taking a break! This happens frequently and is distracting as I need to look down from the road to access what the warning is. I'm being told now that it is not able to be disabled. It's distracting and there's no way I would have bought the car with such a distraction during highway driving.

NHTSA complaint #11758296 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The dashboard has a screen display. I couldn’t see my fuel tank information. Every time I would use my turn signal a large green circle would take over the screen. Followed by loss of the screen, meaning no speedometer, rpm, etc. As the problem continued the speedometer started displaying incorrect numbers. Saying I was going 70 miles an hour when I was actually going about 55. Gage for fuel and heat (notifying if car is overheating, was lost for the entirety of my drive).

NHTSA complaint #11757326 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I believe my car should be in the ac recall for faulty ac motor/wire harness due to my ac is only cooling on passenger side. Blowing hot on driver. I’m afraid it may catch fire as I read this can happen.

NHTSA complaint #11756282 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

While driving, the dashboard lit up with warnings about forward collision, lane departure, lane keeping assistance, breaks, speed etc. that keep cycling through with alarm sounds on the dashboard. I have brought my car to the dealership few times and they reprogram the car but the issue keeps coming back randomly. Seems like a loose connection somewhere. I am afraid of driving when it happens.

NHTSA complaint #11756297 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I was driving up a hill and my car stalled. Contacted Kia of Bowie for assistance had a diagnostic asked for a goodwill repair because of this being a safety issue with my car stalling while driving up a hill life threating situation and they have denied the goodwill repair the service tech is saying because I didnt get my car serviced there and they have no records I informed them that I have and had been taking care of the maintenance at the Kia dealership in Temple hills md. They are just overlooking the severity of the situation of a safety issue.

NHTSA complaint #11755593 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The paint is peeling in sheets, especially above the windshield, leaving the vehicle unprotected and vulnerable to rust. There were no chips or damage in this area prior to the paint beginning to peel away and once it started it's been progressing very quickly. Other owners have reported similar issues with this paint color (I believe it's pearl white) in Kia other forums online

NHTSA complaint #11755415 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I am writing to escalate an unresolved issue regarding a Voluntary Emissions Service Campaign performed on my vehicle at Bulldog Kia on July 14, 2026. Shortly after leaving the dealership, my Check Engine Light illuminated. An independent mechanic scanned the vehicle and confirmed that the active fault code directly relates to the components/logic altered during the corporate emissions campaign. I have called the dealership multiple times over the last few weeks and left voicemails for two different service representatives, but my calls are being ignored. I also contacted Kia corporate customer service who responded saying that they could not do anything and that I needed to continue contacting the local dealership (Bulldog Kia). From what I understand this could be a safety issue because it prevents me from being alerted to other safety issues that would trigger the check engine light, and there are also ways in which this could potentially cause the vehicle to slow way down or stop running while driving. As noted above the dealer has been unresponsive to my repeated contact attempts and the check engine light remains illuminated.

NHTSA complaint #11755257 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I am submitting this complaint regarding what I believe is a premature paint defect on my Kia vehicle that has resulted in exposed bare metal and the development of rust on my vehicle. The factory paint has begun peeling and chipping away without any collision, misuse, or abnormal wear. As the paint has separated from the metal surface, it has exposed multiple areas of bare metal that are now actively rusting. I have attached photographs documenting the condition. While paint deterioration may initially appear cosmetic, I believe this issue presents potential safety concerns because the failed paint no longer protects the vehicle's metal body from corrosion. Continued exposure to moisture and environmental elements can allow rust to spread, which may: Accelerate corrosion of the vehicle's body panels. Weaken the structural integrity of affected components over time. Increase the likelihood of water intrusion into the vehicle, potentially damaging electrical components. Reduce the effectiveness of corrosion protection designed into the vehicle. Negatively impact the vehicle's resale value and long-term reliability. This condition appears to be the result of a failure in the factory paint system rather than normal wear and tear. The paint is peeling prematurely, exposing metal that should remain protected throughout the expected life of the vehicle. I am requesting that NHTSA review whether this paint failure represents a broader manufacturing defect affecting other Kia vehicles and determine whether an investigation is warranted if similar complaints exist. Additionally, I respectfully request that Kia acknowledge this premature paint failure as a manufacturing defect and cover the cost of restoring the affected panels, including proper rust remediation, surface preparation, priming, and repainting. Simply touching up the exposed areas would not adequately address the underlying defect or prevent continued corrosion. Owners should not be responsible for r

NHTSA complaint #11753358 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

This is a follow up of NHTSA case# 1840444. Complaint Description: Vehicle exhibited active CAN-bus communication timeout code DTC C1642 targeting the Hydraulic Electronic Control Unit (HECU). Following the official technical safety guidelines established under NHTSA Campaign 20V519000 (Kia SC197), an isolated parasitic current draw test was performed between the engine junction box positive power post and the ABS2 circuit terminal. Testing across three independent iterations utilizing a digital multimeter confirmed a continuous localized parasitic draw of 218.6 uA. This dramatically exceeds the manufacturer's maximum safety engineering threshold of 70.0 uA by over 312%. This quantified excessive amperage draw conclusively isolates an internal circuit board short-circuit condition caused by a failure of the internal HECU brake fluid seals. The vehicle presents an immediate network communication failure, brake malfunction, and thermal/fire risk. Kia Corporate must be compelled to immediately authorize an expedited, zero-cost component replacement under the active safety recall mandate.

NHTSA complaint #11752517 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The panoramic sunroof on my 2023 Kia Sorento intermittently fails to close. When commanded to close, the glass travels most of the way, then stops or reverses before reaching the fully closed position. It frequently takes many repeated attempts. In some cases the panel will not seat at all until the vehicle is driven over rough pavement, and the resulting vibration allows it to complete closure. The malfunction is accompanied by a loud grinding or scraping noise from the roof assembly during travel. This condition has been present since I purchased the vehicle new. The sunroof has seen very limited use. Safety risk: the glass panel cannot be reliably secured. An open or unseated panoramic panel at highway speed presents a risk of water intrusion, wind loading on an unsecured glass panel, and loss of roof structure integrity. Repeatedly operating the switch and monitoring the panel while driving is a significant distraction from the driving task, and driving specifically to induce vibration in order to force closure is itself an unsafe workaround. Dealer history: I have reported this to a Kia dealership on multiple occasions. I was told there is no defect and that the cause is debris, which is inconsistent with a vehicle purchased new with minimal sunroof use. On one visit the dealer cleaned the assembly as a goodwill gesture. This did not correct the noise or the closure failure. The vehicle was returned to me as repaired while the noise and the failure to close were both still present. Kia issued Technical Service Bulletin BOD125 (Rev 1, 02/27/2017) describing a slow-to-close condition and abnormal closing noise on the prior-generation Sorento (UMa), remedied by cleaning and lubricating the rear guide rails and replacing the rear tilt levers. My vehicle exhibits the same failure mode described in that bulletin. The component is available for inspection on request. No warning lamps or messages preceded or accompanied the failure.

NHTSA complaint #11751824 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

My rear backup camera stopped working this year it's either a black screen or blinking screen no video will play. When I first started the video was foggy like moisture was in the camera and now it shows nothing. Other Kia sorento's my same model year have had a recall for the backup camera but mine is not on the recall list for some reason.

NHTSA complaint #11751075 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I have a 2019 Sorento my car was loud when I start it so I took it into my KIA dealership. They found that my muffler had come apart at the seam, but that it is not under warrenty. My concern is that if anyone is sitting in a parked car with the windows up they could be overcome by the exhault fumes.

NHTSA complaint #11750965 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Vehicle Component Affected: Electrical System / HVAC / Blower Motor Resistor Incident Description: While operating my 2023 Kia Sorento, the HVAC system suddenly suffered a complete failure, causing all airflow to cease instantly. A subsequent professional diagnostic inspection by an authorized Kia dealership revealed that the contacts at the blower motor resistor were severely burnt, causing the blower motor relay to burn out. This failure presents two critical safety and fire hazards: Fire Risk: The physical burning and overheating of electrical components and wiring within the dashboard assembly create an active fire hazard in the passenger cabin. Loss of Visibility: The sudden, complete loss of the climate control system severely compromises passenger safety by preventing the vehicle from defogging or defrosting the windshield during inclement weather, presenting an immediate crash hazard. This exact failure mechanism matches the description of Kia Safety Recall SC351 (NHTSA Campaign 25V649) word-for-word. However, Kia has stated that my specific VIN is excluded from the current recall population. Because this identical safety defect is actively manifesting outside of Kia's restricted recall range, I am requesting that the NHTSA investigate an expansion of SC351 to include all affected 2023 Kia Sorento vehicles to mitigate the risk of electrical fires and sudden visibility loss. 06/29/26 Experienced symptoms Inspected and diagnosed on 07/01/26 at JT Kia (Killian Road) Columbia, South Carolina

NHTSA complaint #11749974 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

My Kia Sorrento 2019 model has dashboard cracks on the driver as well as the passenger side. I tried calling the KIA dealership that sold me the car to help me with the goodwill repair and they refused to do so. Its very expensive to replace or repair but most importantly it poses a grave risk to me and my family. Airbag Danger: Cracks near the passenger airbag can become shrapnel during deployment.Electronics: Dust and moisture can fall into the cracks and ruin hidden wires causing extensive damage to the car. KIA needs to take responsibility for this and either change the material used to make this for the future and repair the existing customers cars.

NHTSA complaint #11749499 — an unverified report by a vehicle owner.