2013 KIA Sportage problems

ENGINE

Claim #25921274 To Whom It May Concern, I am writing to formally dispute Kia’s denial of warranty coverage for the engine failure in my 2013 Kia Sportage. Per communication with customer care, Kia denied my claim on the basis of “excessive mileage between oil changes.” However, this conclusion is not supported by sufficient evidence and does not meet the legal standard required under the Magnuson-Moss Warranty Act. My vehicle received regular oil changes at intervals ranging from approximately 5,000 to 13,000 miles using full synthetic oil designed for extended service intervals. While these intervals may exceed conservative manufacturer recommendations, they do not constitute neglect, nor do they establish that maintenance caused the engine failure. The engine failure occurred suddenly while driving at highway speed, resulting in a complete seizure and requiring an emergency stop. This type of abrupt failure is consistent with known defects in Kia’s engines, particularly rod bearing failure, and not indicative of progressive oil starvation or maintenance-related damage. Under federal warranty law, Kia bears the burden of demonstrating a causal connection between the alleged maintenance deficiency and the specific mechanical failure. A general assertion regarding oil change intervals is insufficient. To date, Kia has not provided evidence establishing that my maintenance practices caused or contributed to the engine seizure. Accordingly, I request the following: 1.All documentation supporting the denial of my claim, including: •Photographs of engine teardown •Inspection reports •Evidence of sludge, oil starvation, or restricted oil flow 2.A written explanation detailing how the oil change intervals directly caused the engine failure, rather than a known defect associated with this engine. Absent such evidence, the denial of coverage constitutes a breach of warranty under KIA’s engine settlement program and the Magnuson-Moss Warranty Act.

NHTSA complaint #11733886 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Driver side door will not open from the outside. Handle no longer operates.

NHTSA complaint #11728871 — an unverified report by a vehicle owner.

ENGINE

My engine failed due to the knock sensor recall a known issue on my 2013 Kia Sportage the recall is supposed to provide a lifetime warranty but I was denied coverage because the failure happened before I was able to perform the update as I was a new owner to the car and was unaware of the recall at the time I have been going back and forth with the kia dealership for almost 8 months now 4 of those the car was at the dealership because they said I had to pay a $170 the fee for them to inspect the car to see if kia would repair it or not it which I was told I would get a full report when I finally was able to pick my car up I was told the claim was denied "due to recall not being performed" and that's literally all the paper said no report no details nothing I do t understand why I had to pay $170 for something they could have just told me because they knew the recall hadn't been completed at the time of entry and why did it take 4months of my car being there just to tell me that just for them to tell me that furthermore the recall applies to the car not just the original owner and covers all known defects and considering the engine failure was because of the defect and not normal wear and tear I'm requesting that KIA replace the engine in my vehicle in a timely manner as this failure was of no fault of my own but something that came directly from the manufacturer at time of purchase and had there vehicle not had a recall that effects the engine and the notification of a possible problem with the engine then my vehicle would not require a engine at this time.

NHTSA complaint #11704971 — an unverified report by a vehicle owner.

POWER TRAIN

KIA America has rejected my appeal for an Engine replacement through the Recall , I had the KSDS, Knock Sensor Installed by North Town KIA 3900 Sheridan Drive Amherst NY , May 7 2021. The warranty I received mentioned to keep oil and filter changed every 7500 miles with 5 w 20 oil . The oil was changed by Myself and I have receipts every 5k miles or less. I was turned down for what KIA tech line said Insufficient maintenance . As in they are calling me a liar . I bought 5w 20 full Synthetic oil and filters on 12 occasions from Walmart that Fit my 2013 KIA Motor The weight was recommended by KIA and the Filters rated at 10K miles . Have worked on My cars since I was [XXX] old have thousands of dollars in tools. I do what ever maintenance that is still possible to do on newer cars . Brakes , Filters Fluid changes tire rotations Ect . If KIA would have mentioned in the Warrenty you need to take Videos I would have . Why are not receipts enough? Also the way the oil looks rite now ?? Clean on the dipstick. Have talked to 3 different car service technicians. And they said the same thing. If that motor was not maintained the oil would not look that good. I asked the dealer for the video that the technician does when they told me what I already knew. I paid 230 dollars for the diagnostic, They sent the video to KIA tech line. KIA told me I have to get a subpoena . To get a copy.. Does that tell you they may be hiding something?? So I have brought this to the attention of 3 different KIA dealers. They said hands are tied to to KIA tech line . My 2013 KIA Sportage looks as good if not better then some cars 3 years old .Everything works except The 2.4 liter motor with bad rod bearings. The car died while my Wife was driving it while at a stop light at a busy intersection. No light on dash no warning. What if it quit when she was at a high speed. No power steering, no power brakes??That is dangerous . This happened on September 4 2025, towed straight to the KIA Dealer . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF I

NHTSA complaint #11700819 — an unverified report by a vehicle owner.

ENGINE

While driving in the carpool lane, the engine briefly cut-out and than a rattling sound was heard. We decided to immediately exist the free way at a left-side car pool exit as a precaution. Immediately after exiting, the car went into a complete stall. Had we remained on the freeway, we would have been stranded in the fastest lane with no shoulder and with traffic approaching from the rear at 70mph. Thus we likely avoided catastrophe. There was no warning light. The problems was later determined to be caused by a manufacturer defect resulting in a connecting rod bearing failure. Pursuant to a class action settlement the engine was replaced. I'm writing to let others know that this is a potentially life-threatening danger and that the knock sensor recall does not adequately address this. Also, the dealer mischaracterized the symptoms on the engine warranty invoice, misstating the narrative above, wrongly stating "customer states CEL started flashing when driving after light appeared vehicle would not accelerate properly or start." This quote is untrue. There was no warning, and the car stalled.

NHTSA complaint #11692682 — an unverified report by a vehicle owner.

ENGINE

Have been denied replacement of 2013 Kia Engine due to insufficient records. The KSDS had been installed May 7, 2021. Was told because I did my own maintenance and I have receipts and dates when the maintenance was done reason for being denied. I used 5W 20 full synthetic motor oil which was over and above what the car called for and a new oil filter every time which shows on my receipts. Obvious by looking at the vehicle that it was in good shape and maintained well for being a 2013. When I presented this to Kia, they said that they have in writing that you can’t do this. All it says is that they recommend service being done by a Kia dealer . this is when I found out about the Magnus and Moss warranty act of 1975. I kept a log of service done in my car from 5, 16 2019 until present. The car just stopped in the middle of the city street. It gave no warning sensor did not work. It did not slow the car down.. my wife called AAA and had it towed to the closest dealer . Again, I have receipts of all my purchases of oil and oil filters from 2019. I appealed the decision with Kia in which they came back and gave me the decision they weren’t going to replace it. We have been without a car for close to a month. I don’t know where to turn. I will continue to work on this as much as I can do what I think is right. I will also contact a Better Business Bureau . I know of people that had zero maintenance records and not the KSDS and had their car repaired. Talking with the mechanics they said at first they were fixing everything now they’re trying not to fix everything we bought the car in 2018 with 70,000 miles right now. The car has 103,600 miles. We bought the car from a Kia used car dealer.

NHTSA complaint #11691810 — an unverified report by a vehicle owner.

ENGINE

my vehicle, 2013/ SL Sportage recently suffered catastrophic engine failure. I received a renotification from Kia regarding the software updates. Barely a week, [XXX], my engine seized in traffic due to rod failure which the software update could have prevented according to Metro Kia of Madison. I was also told by the same Kia authorized dealer that the repair would cost me $11,000 out of pocket in addition to the diagnostic fees of $210.87. I also contacted Kia Consumer Affairs at 1-800-333-4542 regarding this issue, but the representative told me that the defect is my responsibility as the owner of the vehicle. I think this is absurd and unacceptable. I’m a student who relies on this vehicle to commute to school. With the semester beginning and winter approaching, I can’t imagine being left without safe transportation which places me in a severely disadvantaged position. I cannot and should not bear financial responsibility for a defect Kia has already acknowledged. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11681448 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2013 Kia Sportage. The contact stated that while coming to a gas station rest stop, making a left turn to the fuel pump, the vehicle lost power and coasted to the fuel pump. There were no warning lights illuminated. The VIN was included in NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic), which had a warranty extension for the engine to be repaired or replaced. The vehicle was towed to the dealer, who diagnosed the vehicle and determined that the engine had failed and needed to be replaced. The dealer was unable to replace the engine and referred the contact to another mechanic to repair the vehicle. The vehicle was not repaired. The dealer referred the contact to the manufacturer for assistance. The manufacturer was informed of the failure. The manufacturer informed the contact that the timeframe for the engine coverage extension had been exceeded, and the HECU not been replaced under NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic). The manufacturer opened a case regarding the failure. The failure mileage was approximately 50,000.

NHTSA complaint #11680633 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2013 Kia Sportage. The contact stated that while coming to a gas station rest stop, making a left turn to the fuel pump, the vehicle lost power and coasted to the fuel pump. There were no warning lights illuminated. The VIN was included in NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic), which had a warranty extension for the engine to be repaired or replaced. The vehicle was towed to the dealer, who diagnosed the vehicle and determined that the engine had failed and needed to be replaced. The dealer was unable to replace the engine and referred the contact to another mechanic to repair the vehicle. The vehicle was not repaired. The dealer referred the contact to the manufacturer for assistance. The manufacturer was informed of the failure. The manufacturer informed the contact that the timeframe for the engine coverage extension had been exceeded, and the HECU not been replaced under NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic). The manufacturer opened a case regarding the failure. The failure mileage was approximately 50,000.

NHTSA complaint #11680633 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I bought my car and then I received a letter stating that it had 1 recall. I called KIA to schedule the recall and they said there are 4 in total. I told them to get them all done because the closes KIA is about 45 min from my house. I took it in KIA called me said everything was done that I could go pick up my car. Then on 7/19/25 I am driving in the highway and my car stops accelerating I pull over turn off my car let it cool off and turn it back on. It moves and the moment I try to accelerate it the car stops again. Thank God I was able to arrive to a gas satiation at an exit and not have someone crash into me. I tried jump starting it and nothing. I tried turning it on again and smoke stated coming out from the engine. I had to tow the car to my house. I called my mechanic to check it and 3 codes showed up (C1611, C1612, C1613). I called KIA to let them know the codes and that I needed them to tow my car to their dealership. They proceed to inform me that 1 of the recalls were not fixed (the fuse) had to ordered and was not done. No one had informed me that when I picked up my car. They are not wanting to give me a solution and I have called 3 days straight.

NHTSA complaint #11675552 — an unverified report by a vehicle owner.

TIRES

See attached document for complaint.

NHTSA complaint #11675522 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I bought my car and then I received a letter stating that it had 1 recall. I called KIA to schedule the recall and they said there are 4 in total. I told them to get them all done because the closes KIA is about 45 min from my house. I took it in KIA called me said everything was done that I could go pick up my car. Then on 7/19/25 I am driving in the highway and my car stops accelerating I pull over turn off my car let it cool off and turn it back on. It moves and the moment I try to accelerate it the car stops again. Thank God I was able to arrive to a gas satiation at an exit and not have someone crash into me. I tried jump starting it and nothing. I tried turning it on again and smoke stated coming out from the engine. I had to tow the car to my house. I called my mechanic to check it and 3 codes showed up (C1611, C1612, C1613). I called KIA to let them know the codes and that I needed them to tow my car to their dealership. They proceed to inform me that 1 of the recalls were not fixed (the fuse) had to ordered and was not done. No one had informed me that when I picked up my car. They are not wanting to give me a solution and I have called 3 days straight.

NHTSA complaint #11675552 — an unverified report by a vehicle owner.

ENGINE

Engine failure

NHTSA complaint #11669177 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2013 Kia Sportage. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 120,000.

NHTSA complaint #11668744 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I received a recall notification last year, I live about an hr and a half away from the nearest Kia dealer, so I wasn’t able to get my car in to be inspected until last spring at the Kia in Medford. Then I got another notice in the mail stating my vehicle was amongst the ones that needed the HECU recall service done. I called the Kia dealer in Eugene and the earliest they could get me in was August 2024. A day or two before my long awaited appointment, they called to inform me that the part was on back order and that they would call me once it became available again. I haven’t received any communication from them as of yet. My car has been mostly parked since then and I’ve been borrowing a friends vehicle because I don’t want to risk my daughter and i’s safety. I received another notice from the corporate of Kia, stating I haven’t gotten it done and they strongly urge me to get it taken care of, I’ve tried booking another appointment online twice and there’s no availability and I’ve called 3 times with no return call. On the last notice I received, I see it says to submit a complaint to safercar.gov

NHTSA complaint #11634848 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Problem with the BCM, my signal lights, headlights and beeper is not working. My power lock doesn't work nor my beeper

NHTSA complaint #11630558 — an unverified report by a vehicle owner.

ENGINE

MY WIFE WAS DRIVING AND WENT AROUND A SEMI AND ALL OFTHE SUDDEN THE ENGINE STALLED AND SHE ALMOST GOT HIT BY THESEMI SHE HAD JUST PASSED. NEXT DAY TOWED IT TO KIA AND THE SAID THE ENGINE HAD SEIZED UP BUT THATTHE ENGINEWAS NOT WARRENTY BECAUSE IT HAD NOT THROWN A KNOCK SENSEOR CODE. WE HAVE MAINAINED THIS VEHICLE AND GOTTEN THE UPDATE FOR THE KNOCK SENSOR AND WERE ABOUT TO GIVE IT TO OUR SON AND GET OURSELVES ANOTHER KIA. DONT THINK THATS GOING TO HAPPEN NOW THATI KNOW KIA DOES NOT STAND BEHINDE THEIR PRODUCT OR CARE ABOUT THEIR CUSTOMERS.

NHTSA complaint #11628946 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2013 Kia Sportage. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The contact stated that the infotainment system was intermittently inoperable. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 68,000. Parts distribution disconnect.

NHTSA complaint #11623681 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2013 Kia Sportage. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The contact stated that the infotainment system was intermittently inoperable. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 68,000. Parts distribution disconnect.

NHTSA complaint #11623681 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2013 Kia Sportage. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was unable to pull over to the shoulder of the roadway and the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the engine, informing the contact that the engine had seized. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 131,000.

NHTSA complaint #11623732 — an unverified report by a vehicle owner.

ENGINE

My car has a recall on the engine due to the chance it could catch fire. I brought my car to the dealership to have them replace the recalled part and they returned the car to me without performing the work. They didn't tell me that they didn't fix the recalled part, but I happened to notice on the receipt a day later that it said "can't perform bulletin parts on backorder freeze".

NHTSA complaint #11613064 — an unverified report by a vehicle owner.