2010 Mercury Milan electrical problems

ELECTRICAL SYSTEM

I was driving on the freeway and the steering began to stiffen. I got to my destination and decided to check the tires for any ice or snow, thinking that might be why it was difficult to drive but there was no buildup. I made it home and parked the car. The next day, I can't even turn the steering and a warning comes up that says service power steering and advancetrac.

NHTSA complaint #11717622 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The electric power steering has failed again this will make it twice in 18 months the last time it cost 1800 dollars to fix it know that only some of the 2010 Mercury Milans are on a recall list unfortunately mine is not on that list why because it is absurd that I should I have to make this repair for 1800 dollars again you cant safely drive this car it takes everything I have to turn the steering wheel

NHTSA complaint #11689597 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

UNKNOWN When air temperature drops below 50 degrees radio console does not function. Display is locked with only the words "Mercury Milan". Now the electrical system is not functioning. I know it isn't the battery- I had it replaced within the past 4 months.

NHTSA complaint #11556794 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I have a 2010 mercury milan premier thats power steering went out I found out the part has been recalled on the 2011 model but not the 2010 model and it's the same exact part so now the 2011 has been recalled but not the 2010 and I'm out over 600 dollars + to fix it

NHTSA complaint #11556019 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Power steering fault. Steering wheel locks up.

NHTSA complaint #11525235 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Oct 2019 I went to My dealer to have a tire pressure sensor replaced due to a warning message. The sensor was replaced but the warning message remained. The mechanic did further checking and said I needed a smart junction box which can affect many things such as lights turn signals heat seat belts etc. Ford said they could not repair my car because they could not get this part. I recently inquired if it was available and there is still no ETA for this part. I had to pay them up front even though none are available. Is there a way that you can get this part expedited at Ford or issue a recall as it affects warnings and safety components. This part has to be programmed by the dealer so I do not think a salvage yard part is feasible not really sure.

NHTSA complaint #11474118 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Driving and steering fault showed on dash. Steering failed became dangerous to control vehicle.

NHTSA complaint #11437964 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The passenger rear tail light has gone out on my 2010 Mercury Milan Hybrid. Just had the left one replaced 5 months ago to the tune of $900 and the dealership is asking for the same for this one. Seriously, a $900 tail light?

NHTSA complaint #11435540 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

For years I have sporadically gotten a "Power Steering Sensor Fault" displayed when I would start the car. You could barely turn the steering wheel. In searching the Owner's Manual, owners are advised to turn off the ignition, wait briefly then restart the car (how this issue got into the Owner's Manual and could not be addressed and eliminated, I don't understand). This would correct the fault and the power steering would function normally. Fortunately it never happened while driving. In the last week this display was occurring more frequently until on 5/16/21 it would not go away and I could not drive the car. Today, 5/20/21 I got it towed to the local Ford dealer. The situation will probably not be diagnosed until next week. From reading everything on the internet, this is a routine safety concern, and a recall for the control module has been issued on the 2011-2015 Milan models. Unfortunately my car is 2010 and is not included in the recall. Aren't we talking about an identical control module as to those that have been recalled?? Then why wouldn't the NHTSA not be concerned about this very similar safety issue??!! I'm thankful this didn't happed to me while driving!

NHTSA complaint #11417924 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I WAS DRIVING THE SHORT DISTANCE HOME WHEN MY VEHICLE BEGAN TO SHAKE BACK AND FORTH. THE ERROR LIGHT CAME ON STATING THAT THE POWER STEERING NEEDED TO BE CHECKED. WHEN I TURNED OFF THE CAR AND TURNED IT BACK ON, THE CAR NO LONGER ALLOWED THE POWER STEERING TO DRIVE. THE ELECTRIC RACK AND PINION FOR MY 2010 MERCURY MILAN NEEDS TO BE REPLACED. THERE HAVE BEEN SEVERAL RECALLS FOR THE SAME PROBLEM WITH OTHER MERCURY MILANS BUT MY PARTICULAR CAR DOES NOT HAVE THE SAME RECALL EVEN WITH THE SAME OCCURANCE.

NHTSA complaint #11353827 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

DRIVING ON PARKWAY IN HUNTSVILLE ALABAMA WHEN THE POWER STEERING DEFAULT LIGHT COME ON AND COULDN'T STEER IT AT ALL AND MEMORIAL PARKWAY IS ALWAYS VERY BUSY. COULDN'T EVEN GET IN A TURNING LANE TO GET OFF OF THE PARKWAY. TOOK ME TWO HRS TO DRIVE 10 MILES AND FINALLY GOT IT INTO THE PARKING LOT AT THE MAINTENANCE SHOP. LIKE TO HAVE NEVER GOT IT TO A SHOP. IMAGINE A 72 YR OLD ELDERLY LADY TRYING TO ENTER THE PARKING LOT OF A MAINTENANCE SHOP. I REALLY NEED SOME HELP TO REPLACE A POWER STEERING.

NHTSA complaint #11348470 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

LEFT REAR BRAKE LIGHT. IT WORKS PART OF THE TIME AND THEN IT DOES NOT WORK. STOPPED SEVERAL TIMES FOR IT NOT WORKING, THEN IT WOULD START. NOT THE ENTIRE BRAKE LIGHT IS OUT. PART OF IT STILL LIGHTS UP. THIS HAS BEEN HAPPENING SINCE I BOUGHT THE CAR USED ABOUT 4 YEARS AGO.

NHTSA complaint #11265830 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I WAS PUTTING MY CAR IN PARK AND THE LIGHTS FLICKERED A FEW TIMES THE CAR LOCK AND UNLOCKED A SEVERAL TIMES. I CUT THE CAR OFF AND WHEN I TIRED TO OPEN THE DOOR I COUNT OPEN IT OR LET THE WINDOWS DOWN. NO WINDOWS OR DOORS WOULD OPEN. I WAITED 5 TO 10 MINUTES. I TURNED THE CAR OWN AND ALL THE DOORS AND WINDOWS WORKED EXCEPT DRIVERS DOOR. UNABLE TO OPEN DRIVERS DOOR FROM INSIDE. I HAVE TO RULE DOWN WINDOW TO OPEN DRIVER DOOR.

NHTSA complaint #11165938 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I WAS IN MOTION MERGING ONTO A TWO LANE HIGHWAY. I RAN OVER TWO CONSECUTIVE MANHOLE COVERS WHILE LIGHTLY BRAKING TO SEE IF IT WAS CLEAR. BUT WHEN I WENT TO BRAKE BECAUSE IT WASN'T CLEAR TO MERGE ONTO THE HIGHWAY I HAD BARELY ANY BRAKE! THANKFULLY THE CAR IN FRONT OF ME WAS ABLE TO MERGE OR I WOULD HAVE HIT HIM. AFTER THAT I HAD A VERY SOFT BRAKE PEDAL. LEFT IT IN A PARKING LOT UNTIL AFTER WORK. SO HOURS LATER, THE BRAKES SEEMED FINE. BUT I DIDN'T TRUST IT. HAD IT TOWED AND FORD TOLD ME IT WAS THE ABS HCU AND ECU AND THAT THEY ARE KNOWN FOR THIS PROBLEM. ESPECIALLY AFTER TRAVELING ON A ROUGH ROADWAY. I HAD TO GO BACK TO THE ROAD THE NEXT DAY BECAUSE I COULDN'T REMEMBER IT BEING A ROUGH ROAD. THEN I SAW THE TWO CONSECUTIVE MANHOLE COVERS. I RAN THEM OVER IN MY HUSBANDS TRUCK AND SURE ENOUGH, EVEN HIS TRUCK JOLTED FROM THEM, ENOUGH FOR THE ABS TO ENGAGE. THIS IS A HORRIBLE ISSUE AND I'M AMAZED THAT FORD HAS NOT MADE IT A RECALL YET! WHAT WILL IT TAKE!? THE REPAIR WAS QUITE EXPENSIVE. AND I WAS OUT OF A CAR FOR TWO WHOLE WEEKS! IT TOOK ALMOST A WEEK FOR THE PART TO COME IN. NOT SURE IF THAT WAS THE DEALERS BS OR FORD NOT HAVING THE PARTS READILY AVAILABLE FOR AN ISSUE THEY ALREADY KNOW EXISTS. THIS HAS NOT BEEN MY FIRST FORD PRODUCT BUT IT SURE MAY BE MY LAST!

NHTSA complaint #11128259 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TAKATA PLUS NUMEROUS OTHER RECALLS: POWERTRAIN CONTROL MODULE, "CONTAMINATION ON INTERNAL MOTOR CONTACTS OF THE THROTTLE BODY" REAR TAIL LIGHTS REPLACED, ARM REST REPLACED AS IT BECAME DETACHED, BATTERY REPLACED AT 23K MILES AND DOES NOT HOLD A CHARGE AND CONSISTENTLY NEEDS TO BE RECHARGED. THIS HAPPENED AT A LIGHT IN A MAJOR AND VERY BUSY INTERSECTION. I WENT AND THE CAR DID NOT MOVE AND ALMOST GOT REAR-ENDED. IT ADDITIONALLY OVER EXCELERATED ON ITS OWN. I HAD TO GET MY CAR TOWED TO DEALER AS THE CAR DIED DUE TO FAILED THROTTLE.

NHTSA complaint #11110102 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 MERCURY MILAN. THE CONTACT STATED THAT THE TRANSMISSION WRENCH ICON REMAINED ILLUMINATED FOR MONTHS. THE DEALER (NATCHEZ FORD LINCOLN, 14 SGT PRENTISS DR, NATCHEZ, MS 39120, (601) 445-0076) REFUSED TO PROVIDE A SOLUTION AND SUGGESTED THAT THE VEHICLE BE DIAGNOSED AND REPAIRED. THE CONTACT STATED THAT THERE WAS A REMEDY FOR AN UNKNOWN TRANSMISSION RECALL THAT WAS NOT PERFORMED ON THE VEHICLE; HOWEVER, THE DEALER AND THE MANUFACTURER INDICATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED PER THE RECALL. IN ADDITION, THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS). THE DEALER STATED THAT PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA complaint #11082453 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

REAR PASSENGER SIDE TAIL LIGHT STAYS ILLUMINATED EVEN WHILE BRAKE PADDLE IS ENGAGED... BASICALLY I HAVE NO BRAKE LIGHTS... ALSO FUEL RECALLS STILL HASNT BEEN DONE ON MY VEHICLE.

NHTSA complaint #11034470 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2010 MERCURY MILAN. THE CONTACT STATED THAT THERE WAS A SUDDEN LOSS OF POWER WHILE DRIVING HIGHWAY SPEEDS. THE ENGINE STALLED AND THE CONTACT WAS ABLE TO COAST THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS SCHEDULED FOR AN APPOINTMENT WITH THE DEALER. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS INCLUDED IN A CUSTOMER SERVICE PROGRAM CONCERNING THE ELECTRIC THROTTLE BODY REPLACEMENT. THE CONTACT WAS UNCERTAIN IF THE VOLUNTARY SERVICE CAMPAIGN FROM THE MANUFACTURER WOULD PROVIDE A SOLUTION. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.

NHTSA complaint #10959047 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

A FEW WEEKS AGO, I HAD A HARD TIME STEERING MY CAR AT AN INTERSECTION. WHEN I TRIED STEERING, THE CAR WOULD SHAKE AS I TURNED. ALTHOUGH THE ROADS WERE WET, MY TIRES ARE RELATIVELY NEW, SO I NEW IT WASN'T THE TRACTION. I TURNED OFF THE ELECTRONIC STEERING ASSISTANCE AND IT STARTED TURNING AGAIN. A FEW DAYS AGO, I WAS TURNING, THE ROADS WERE DAMP, BUT NOT WET AND I HAD MY STEERING ASSIST ON (IT GOES ON BY DEFAULT). WHEN I TUNED, THE CAR WENT THE OPPOSITE WAY OF THE DIRECTION I WAS TURNING. I HAD TO TURN OFF MY STEERING ASSIST IN ORDER TO REGAIN CONTROL OF MY CAR. THERE WERE NO ALARMS, NOTICE OR ALERTS ON MY CONTROL PANEL. ALSO, WHEN IT'S BEEN A HOT DAY OR A COLD DAY, THE CAR WON'T START.

NHTSA complaint #10936065 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

ELECTRONIC THROTTLE BODY (ETB) INDICATOR IS ILLUMINATED. I HAVE A SUDDEN LOSS OF POWER WHILE DRIVING, MY ACCELERATOR STOPS WORKING OR HAS EXTREMELY LIMITED POWER, AND MY ENGINE IDLES ROUGHLY.

NHTSA complaint #10898379 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

JANUARY 15 2016 I WAS DRIVING MY 2010 MILIAN, WENT TO MAKE A LEFT TURN AND MY STEERING WENT OUT, THEN MY DASHBOARD LIT UP SAYING SERVICE POWER STEERING AND ADVANCE TRAC SYSTEM NEEDS ATTENTION, THEN MY PASSENGER FRONT TIRE BLEW. IVE SEEN WHERE THE 2011 MILIAN HAS HAD A RECALL ON THIS SAME ISSUE THAT MY 2010 MILIAN IS NOW HAVING, I HAVENT BEEN ABLE TO DRIVE MY CAR SINCE JANUARY AND I STILL HAVE 3 YEARS OF PAYMENTS ON A CAR I CAN'T DRIVE. SO PLEASE SEND OUT A RECALL NOTICE FOR THE 2010 MILIAN SO I CAN START DRIVING MY CAR AGAIN.

NHTSA complaint #10872823 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TOOK CAR IN TO FORD DEALER FOR SERVICING PER RECALL 15S34 ON 4/27/16. DEALER NOTIFIED ME THAT BRAKE LIGHTS ARE; "....STUCK ON WHEN PARKING LIGHTS OR HEADLIGHTS ARE ON -- THEY WORK IF HEADLIGHTS ARE OFF ....". (SEE NOUGHTON FORD AURORA, CO INVOICE # FOCS418452). THIS IS A HAZARD!!!!!

NHTSA complaint #10862631 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

JERSEY CITY FORD SERVICE DEPART REPORTS THE HYBRID HARNESS BURNT OUT AND KILLED MY BATTERY. $900 FOR THE HARNESS, $185 FOR THE 84 MONTH BATTERY. THE CAR IS 5 YEARS OLD AND I'M REPLACING THE HARNESS? THE VEHICLE WAS STATIONARY IN A CAR PORT. WHEN I TRIED STARTING THE CAR THE PATS SYSTEM ACTIVATED, THE CAR WOULD NOT START. IT WAS TOWED TO THE DEALERSHIP AND THEY CALLED TODAY, THE HYBRID HARNESS AS TO BE SHIPPED FROM DETROIT. THIS PART SHOULD NOT HAVE FAILED UNDER ANY NORMAL USE....EVER. IF I HAD BEEN DRIVING WHEN IT FAILED I WOULD HAVE LOST ALL POWER, STEERING, BRAKES, AND ABILITY TO CONTROL THE CAR.

NHTSA complaint #10787439 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

DRIVER SIDE REAR BRAKE LIGHT IS FULLY ILLUMINATED AT ALL TIMES WHEN THE HEADLIGHTS ARE ON. THIS IS A SAFETY ISSUE AND REPLACEMENT OF THE DRIVER SIDE TAILLIGHT IS $400+.

NHTSA complaint #10702309 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

THE TAIL LIGHT ASSEMBLY BURNED OUT AFTER AN UNUSUALLY SHORT PERIOD OF TIME, THEY ARE LED TYPE AND LASTED ONLY 5 YEARS. LED'S WITH THIS SHORT LIFE SPAN SHOULD BE CONSIDERED DEFECTIVE AS THERE ARE NUMEROUS INCIDENTS BEING REPORTED ABOUT THIS PROBLEM.

NHTSA complaint #10695198 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I PURCHASED MY 2010 MERCURY MILAN USED ON AUGUST 30, 2012 WITH 987 MILES. APPROXIMATELY IN JUNE, 2013 THE CAR'S RIGHT REAR TAIL LAMP WENT COMPLETELY OUT AND I HAD A NEW TAIL LAMP INSTALLED FOR $408 + LABOR. IN NOVEMBER, 2013 THE CAR'S LEFT REAR TAIL LAMP WENT COMPLETELY AND I HAD A NEW TAIL LAMP INSTALLED FOR $408 + LABOR. NOW, MARCH 6, 2015 THE RIGHT REAR TAIL LAMP HAS GONE OUT AND I CANNOT AFFORD TO KEEP ON PAYING THESE EXPENSES WHEN I NOW KNOW THAT THIS IS A FORD PROBLEM AND DUE TO POOR ENGINEERING OF THE LIGHT ASSEMBLY AND BECAUSE IT HAS NOT BEEN RE-ENGINEERED TO CORRECT THE PROBLEM, THIS WILL BE A RECURRING PROBLEM FOR THE LIFE OF THE CAR. I RUN THE CHANCE OF BEING STOPPED BY THE POLICE FOR AN UNSAFE VEHICLE.

NHTSA complaint #10692427 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

THE DRIVER'S SIDE BREAK LIGHT IS HYDERACTIVE WHEN MY HEADLIGHTS ARE ON. WHEN THE HEADLIGHTS ARE OFF THE BREAK LIGHT WORKS FINE. THIS SEEMS TO BE A POPULAR ISSUE WITH MANY MERCURY MILIANS. THE PART WAS 377.00 TO REPLACE IT AND I HAVE NO HAD THE CAR A FULL YEAR. ALSO MY DRIVER'S SIDE ACTUATOR IN MY HEADLIGHT WENT AS WELL. MY FIRST CAR PURCHASED EVER AND IT WAS FORD AND I HAVE HAD NOTHING BUT ISSUE WITH THE CAR. DISAPPOINTING.

NHTSA complaint #10690468 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

DRIVER SIDE TAIL LAMP ASSEMBLY IS NOT FUNCTIONAL SEEMS THE LED PORTION OF THE TAILLIGHT ASSEMBLY NEEDS TO BE REPLACED AT A COST OF $400-500 FROM THE DEALER. THIS IS THE SECOND TAILLIGHT IN THE 2 YEARS OF OWNERSHIP THAT IT HAS HAD TO BE REPLACED. VERY POOR DESIGN AND SAFETY CONCERN OF MINE SINCE THIS IS NO LONGER A $2.00 BULB REPLACEMENT BUT AN ENTIRE TAILLIGHT ASSEMBLY.

NHTSA complaint #10669725 — an unverified report by a vehicle owner.