138 of the 1,430 complaints about the 2010 Mercury Milan are about the fuel system — 10% of everything reported for this model year. Half of the failures with a mileage on record happened before 49,604 miles.
138
Complaints
3
Crashes
0
Fires
1
Injuries
Filed with NHTSA, in their own words.
FUEL/PROPULSION SYSTEM
I collided with three parked vehicles and my airbags did not deploy causing me to hit my head
NHTSA complaint #11678528 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Check engine light is on mechanic says it's a fuel tank issue
NHTSA complaint #11655144 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact's father-in-law owns a 2010 Mercury Milan. The contact stated that upon refueling the vehicle, her father-in-law noticed that fuel was leaking on the rear passenger side tire. The contact's husband then verified that fuel was leaking from the fuel tank. The vehicle was taken to the dealer, where it was diagnosed that the fuel tank was fractured and needed to be replaced. The dealer diagnosed and determined that the failure was related to NHTSA Campaign Number: 15V793000 (Fuel System, Gasoline); however, the VIN was not included. The vehicle was taken for State Inspection, where it was diagnosed with evaporated emission system leak related to the canister purge valve. The contact's husband replaced the canister purge valve; however, the failure persisted. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a recall. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 95,000
NHTSA complaint #11513625 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
STARTED MY CAR UP AND IT SAID POWER STEERING FAILED..I CUT THE CAR OFF AND WAITED THEN IT WENT OFF...AS I WAS HEADED TO WORK THE AIRBAG LIGHT CAME ON FOR THE PASSENGER SIDE..I PULLED INTO THE STORE TURNED THE CAR OFF A WHILE AND STARTED IT BACK UP THE LIGHT WENT OFF BEFORE LEAVING WORK THE POWER STEERING MESSAGE POPPED BACK UP I ONCE AGAIN TURNED OFF THE CAR FOR A WHILE...I MANAGE TO MAKE IT HOME BUT A MILE FROM MY HOUSE THE AIRBAG LIGHT ONCE AGAIN CAME ON.. PLEASE CHECK INTO THIS..I LOVE MY LIFE AND THE LIFE OF MY LOVED ONES DRIVING LIKE THIS IS VERY DANGEROUS AND THIS IS MY ONLY MEANS OF TRANSPORTATION.
NHTSA complaint #11404365 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2010 MERCURY MILAN. THE CONTACT STATED THAT THE FUEL TANK FRACTURED AND LEAKED FUEL. THE CONTACT STATED THAT THE VEHICLE HAD BEEN AT AN INDEPENDENT MECHANIC FOR FOUR WEEKS NOW. THE VEHICLE WAS TAKEN TO LEGACY FORD (413 INDUSTRIAL BLVD, MCDONOUGH, GA 30253, (770) 914-2800) ONE YEAR AGO TO BE REPAIRED PER AN UNKNOWN RECALL. THE DEALER STATED THAT THERE WAS NO FAILURE WITH THE VEHICLE AND DIAGNOSTIC TESTING DID NOT REVEAL A CODE REGARDING A VAPOR LOCK FAILURE THAT MAY HAVE DAMAGED THE FUEL TANK. THE CONTACT BEGAN TO SMELL A FUEL ODOR ON SEPTEMBER 25, 2019 AND SHE NOTICED A HUGE PUDDLE OF FUEL ON THE DRIVEWAY. SHE TOOK THE VEHICLE BACK TO THE DEALER AND WAS SHOWN THE STRESS CRACK ON THE FUEL TANK. THE DEALER ACKNOWLEDGED THAT THE FAILURE WAS FROM THE RECALL REPAIR A YEAR EARLIER; HOWEVER, THEY WOULD HAVE TO CHARGE THE CONTACT FOR THE REPAIRS. THE MANUFACTURER WAS CONTACTED, BUT THE DEALER AND CONTACT HAD NOT HEARD BACK. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11270993 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
MY CHECK ENGINE LIGHT CAME ON AND WAS CHECKED AND THE FUEL VAPOR CANISTER PURGE VALVE IS NOT OPERATING PROPERLY
NHTSA complaint #11269595 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2010 MERCURY MILAN. THE CONTACT STATED THAT THE VEHICLE LEAKED FUEL AND THERE WAS AN ABNORMAL FUEL ODOR INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO OXMOOR FORD LINCOLN (100 OXMOOR LN, LOUISVILLE, KY 40222, (502) 426-2500) WHERE IT WAS DIAGNOSED THAT A NEW FUEL TANK WAS NEEDED. THE VEHICLE WAS NOT REPAIRED. THE DEALER ALSO FOUND THAT THE REAR BRAKES NEEDED TO BE REPLACED. NEW BRAKES WERE INSTALLED; HOWEVER, FRONT BRAKES WERE INSTALLED INSTEAD OF REAR BRAKES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 70,000.
NHTSA complaint #11208969 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2010 MERCURY MILAN. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 15V793000 (FUEL SYSTEM GASOLINE) AND STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO REPAIR THE VEHICLE. THE DEALER (STEVENS JERSEY CITY FORD, 740 NJ-440, JERSEY CITY, NJ 07304) CONFIRMED THAT PARTS WERE NOT AVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA complaint #11204393 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2010 MERCURY MILAN. THE CONTACT STATED THAT THE FUEL INLET AND CHECK ENGINE WARNING INDICATORS ILLUMINATED INTERMITTENTLY. THE CONTACT STATED THAT THE VEHICLE EXHIBITED THE SAME SYMPTOMS AS LISTED IN NHTSA CAMPAIGN NUMBER: 15V793000 (FUEL SYSTEM, GASOLINE), WHICH SHE RECEIVED. THE VEHICLE WAS SERVICED BY HOLMAN FORD (3641 NJ-42, TURNERSVILLE, NJ 08012, 888-449-0296), BUT THE FAILURES RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND STATED THAT NOTHING COULD BE DONE SINCE THE VEHICLE HAD ALREADY BEEN SERVICED. THE FAILURE MILEAGE WAS APPROXIMATELY 71,000.
NHTSA complaint #11128672 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WELL FOR STARTERS ITS THROWING A CODE SAYING THAT I HAVE A SMALL FUEL LEAK SOME WHERE AND THE 2 IS ONE DAY I HAD A FLAT AND AFTER I CHANGED THE TIRE THE POWER STEERING WENT OUT AND NOT ONLY THAT BUT THE CAR HAS A HEAVY VIBRATION IN IT AND WHILE DRIVING IT WANT TO TAKE OFF EITHER LEFT OR RIGHT WHICH ENDED UP WITH ME RUNNING OFF THE ROAD TWICE ALREADY
NHTSA complaint #11099386 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
MY STEERING WHEEL COMPLETELY WENT OFF IN THE FREEWAY I GOT A SIGN ON THE DASHBOARD TO SERVICE STEERING WHEEL NOW AND THEN MY STEERING WHEEL STOPPED WORKING AS I WAS DRIVING IN THE FREEWAY. AFTER GETTING THIS FIXED LESS THEN A YEAR LATER THE SAME ISSUE HAPPENED AS I WAS DRIVING MY STEERING WHEEL JUST LOCKED AND IT WAS VERY DIFFICULT FOR ME TO STEER MY CAR TO A SAFE PLACE. THIS IS THE SECOND TIME THIS HAPPENED THE FIRST TIME BEING ON THE FREEWAY AND THIS SECOND TIME DRIVING IN THE STREETS BOTH TIMES IT HAPPENED WHILE I WAS DRIVING FROM ONE SECOND TO THE NEXT I GOT A MESSAGE TO SERVICE STEERING WHEEL NOW AND THEN MY STEERING WHEEL AUTOMATICLY LOCKED AND IT MADE IT EXTREMELY DIFFICULT TO MANUEVER THE CAR TO A SAFE PLACE. BOTH TIMES MY CHILDREN WERE IN THE CAR AND IT WAS A VERY SCARY THING TO GO THROUGH.
NHTSA complaint #11092724 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TAKATA RECALL . WE WERE NOTIFIED YEARS AGO, STILL PASSENGER SIDE AIR BAG NOT REPLACED. NOW FORD IS TELLING US NOT LET ANYONE SIT IN THE PASSENGER SEAT. FORD HAD IGNORED ALL OUR CORRESPONDENCE. IT'S REDICULOUS, WILL NEVER PURCHASE ANOTHER FORD PRODUCT.
NHTSA complaint #11084054 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I RECEIVED A RECALL NOTICE FOR MY VEHICLE AND I LOOKED IT UP WITH MY VIN NUMBER AND IT SAID I HAD A RECALL ON MY VEHICLE. I'M UPLOADING THE NOTICE
NHTSA complaint #11067402 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
REAR PASSENGER SIDE TAIL LIGHT STAYS ILLUMINATED EVEN WHILE BRAKE PADDLE IS ENGAGED... BASICALLY I HAVE NO BRAKE LIGHTS... ALSO FUEL RECALLS STILL HASNT BEEN DONE ON MY VEHICLE.
NHTSA complaint #11034470 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2010 MERCURY MILAN. WHILE STATIONARY, THE VEHICLE LEAKED FUEL ONTO THE GROUND. THE VEHICLE WAS TOWED TO KAISER MILLER FORD IN COLLEGEVILLE, PENNSYLVANIA. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND STATED THAT THE PART FOR THE REPAIR WAS ON BACKORDER FOR NHTSA CAMPAIGN NUMBER: 15V793000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 170,000.
NHTSA complaint #11024884 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FUEL TANK & CANISTER PURGE VALVE RECALL - 15S34 RECALL - VEHICLE WAS INSPECTED FOR RECALL IN AUGUST 2016 AND PASSED THE RECALL AND THE RECALL WAS CLOSED BY FORD. IN JULY 2017, THE VEHICLE HAD A CHECK ENGINE LIGHT AND MESSAGE TO CHECK FUEL TANK INLET THAT WOULD COME ON AND GO OFF IN. THE CHECK ENGINE LIGHT CODE WAS RELATED TO THE EVAP SYSTEM. VEHICLE WAS TAKEN TO THE SAME FORD DEALERSHIP THAT PERFORMED THE RECALL IN 2016. THE CANISTER PURGE VALVE FAILED AND THE FUEL FILLER PIPE HAD LEAKS AND NEEDED REPLACEMENT. THE FORD DEALERSHIP SUBMITTED A 360 CLAIM FOR THE PARTS AND LABOR. THE 360 CLAIM WAS DENIED BECAUSE THE CAR WAS OUTSIDE THE 7 YEARS OF SERVICE AND THE DEALERSHIP WOULD NOT WARRANTY THE CLAIM BECAUSE THE RECALL HAD ALREADY BEEN CLOSED.
NHTSA complaint #11010355 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
ENGINE LIGHT WAS ON AND INTERMITTENTLY SMELLED GAS OR GOT FUEL FILL CHECK INDICATOR. UPON DIAGNOSTIC MIL P0455 AND P0457. CANISTER PURGE VALVE HAD TO BE REPLACED PAID $300. GOING THROUGH MY RECORDS I FOUND THAT ON APRIL 5,2016, I HAD A RECALL 15S34 FUEL TANK AND CANISTER PURGE VALVE INSPECTION COMPLETED. THERE WAS NO EVIDENCE OF CRACKS OR LEAKS SO ONLY RECALIBRATION WAS COMPLETED. NOW LESS THAN 10,000 MILES LATER A REPLACEMENT WAS NEEDED. AWAITING REVIEW FOR A REFUND FROM FORD DEALERSHIP
NHTSA complaint #11003755 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2010 MERCURY MILAN. THE CONTACT STATED THAT THE CHECK FUEL WARNING INDICATOR ILLUMINATED AND THERE WAS AN ABNORMAL FUEL ODOR. THE VEHICLE WAS TAKEN TO AUTO ZONE WERE IT WAS DIAGNOSED THAT THE CANISTER PURGE VALVE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS ALSO TAKEN TO THE QUIRK FORD DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL FILLER NECK WOULD NEED TO BE REPLACED. A YEAR PRIOR TO THE FAILURES, THE VEHICLE WAS TAKEN TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 15V793000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS INSPECTED AND FOUND TO HAVE NO LEAKS. THE SOFTWARE WAS UPDATED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 125,000.
NHTSA complaint #11003631 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2010 MERCURY MILAN. WHILE OPERATING THE VEHICLE, THE SERVICE LIGHT WOULD ILLUMINATE. AFTER REFUELING, THE VEHICLE WOULD NOT START. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PURGE VALVE WAS FAULTY AND WOULD ERRONEOUSLY REMAIN OPEN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS INSPECTED PER NHTSA CAMPAIGN NUMBER: 15V793000 (FUEL SYSTEM) IN APRIL OF 2016, BUT WAS NO LONGER ELIGIBLE FOR THE REPAIR. THE CONTACT INDICATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 108,000.
NHTSA complaint #10958348 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TROTTLE ACUTATOR STUCK IN CLOSED POSITION AS THE CAR WAS MOVING ABOUT 25 MPH, PRESSED THE ACCELARATOR BUT NOTHING WAS HAPPENING,ENGINE WAS AT IDDLE, AND WAS ABLE TO MOVE TO THE SIDE OF THE ROAD. STARTED THE CAR AGAIN AND EVERYTHING WORKED FOR ABOT A MINUTE AND THEN IT HAPPENED AGAIN. WHEN I GOT HOME AFTER A FEW RESTARTS I HOOKED UP MY COMUPTER TO READ THE OBD CODE THAT CAME ON !! IT WAS CODE P2112 , WITCH IS THE TROTTLE ACUTATOR MODULE !! AFTER RESETING THE OBD CODE IT WAS WORKING FINE ON THE DRIVEWAY. I'LL TAKE IT FOR A TEST DRIVE LATER. IT SEEMS CLEAR THAT A PROBLEM EXISTS WITH THE TROTTLE ACUTATOR ON THE TROTTLE BODY !!! A DESIGN FLAW IS VERY POSSIBLE, AND IT PRESENTS A DANGER WHEN DRIVING ON THE ROAD WITH A SUDDEN LOSS OF POWER AND SPEED. A RECAL SHOULD BE IN THE WORKS FOR FORD !!! I HAVE READ TOO MANY COMPLAINTS ABOUT THE SAME PROBLEM. MY CAR HAS 32,000 MILES AND IS A 2010 YEAR.
NHTSA complaint #10904812 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2010 MERCURY MILAN. WHILE DRIVING 20 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE DEALER DIAGNOSED THAT THE CODE FOR THE FUEL SYSTEM INDICATED TO INSPECT THE FUEL TANK AND VMV VALVE. AN EVAPORATION TEST WAS ALSO PERFORMED. THE TECHNICIAN REPROGRAMMED THE COMPUTER; HOWEVER, THE FAILURE RECURRED. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED A SECOND TIME. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V793000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 53,006.
NHTSA complaint #10903148 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
STALLS (APPROX 10 MPH) THEN SUDDEN SURGES. THE VEHICLE KEEPS MOVING, BUT AT DRASTICALLY REDUCED SPEEDS. AFTER SITTING FOR SOME TIME THE CHECK ENGINE LIGHT OR WRENCH SYMBOL GOES AWAY. AFTERWARDS DRIVING BACK TO STALLING (APPROX 10 MPH) THEN SUDDEN SURGES.
NHTSA complaint #10882011 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
STALLS (APPROX 10 MPH) THEN SUDDEN SURGES. THE VEHICLE KEEPS MOVING, BUT AT DRASTICALLY REDUCED SPEEDS. AFTER SITTING FOR SOME TIME THE CHECK ENGINE LIGHT OR WRENCH SYMBOL GOES AWAY. AFTERWARDS DRIVING BACK TO STALLING (APPROX 10 MPH) THEN SUDDEN SURGES.
NHTSA complaint #10882007 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
I RECEIVED A RECALL NOTICE (15V-793) FROM FORD IN JANUARY 2016 ABOUT THE CANISTER PURGE VALVE, VAPOR CANISTER, GAS TANK, AND POWER CONTROL MODULE ON MY 2010 MERCURY MILAN. I TOOK IT TO THE FORD DEALER AND THEY DID AN ELECTRONIC TEST AND SAID IT WAS OK. ONE MONTH LATER THE CHECK ENGINE LIGHT CAME ON AND THE CODE SAID THE PROBLEM WAS THE PRIOR RECALLED CANISTER PURGE VALVE. TOOK IT BACK TO THE DEALER AND THEY DID THEIR ELECTRONIC TEST AGAIN AND SAID IT WAS THE GAS TANK FILL TUBE VALVE. FOUR DAYS LATER THE CHECK ENGINE LIGHT CAME ON AGAIN AND THE CODES AGAIN SAID IT WAS THE CANISTER PURGE VALVE. THIS TIME THE DEALER DID AS I ASKED THEM AND MECHANICALLY CHECKED THE VALVE, AND DISCOVERED THAT IT AND THE VAPOR CANISTER HAD FAILED. HOWEVER, FORD WILL NOT COVER THE REPAIR. IS THIS ALLOWED? I WILL MAIL A LETTER WITH MORE DETAIL. AFTER RESEARCHING THE ISSUE, THIS PARTICULAR VALVE COMMONLY FAILED BY STICKING OPEN OR CLOSED AND THE ONLY WAY TO DETECT IT, WAS TO DO A MECHANICAL TEST BY TAKING THE HOSES OFF AND CHECKING FOR PRESSURE OR VACUUM. THE DEALER DID NOT PERFORM THE TEST PROPERLY. UPDATED 05/31/16.
NHTSA complaint #10861514 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2010 MERCURY MILAN. THE CONTACT STATED THAT WHEN FUEL WAS PUMPED INTO THE FUEL TANK, THE FUEL SPEWED BACK OUT OF THE TANK AND THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHERE IT WAS DIAGNOSED THAT THE PURGE VALVE CRACKED, CAUSING THE FUEL TANK TO LEAK. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000.
NHTSA complaint #10808849 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WHILE PASSING THREE SEMI TRUCKS IN THE THIRD LANE OF A HIGHWAY AT 70 MPH, THE ENGINE POWER CUT OUT. NAVIGATING ACROSS THREE LANES OF HIGHWAY THROUGH MULTIPLE VEHICLES WAS TERRIFYING. MY LIFE WAS PLACED WITH IN JEOPARDY, YET THE FORD MOTOR COMPANY REFUSES TO RECOGNIZE ITS THROTTLE BODY CONTROL PROBLEM AS A SAFETY ISSUE.
NHTSA complaint #10806508 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
(1) MAY 5, 2015: IN TRAFFIC 65MPH ON MA RT3S, ENGINE "BLUBBERED" THEN DIED IN LEFT LANE. SUCCEEDED NOT BEING HIT BY VEHICLES, PARKED ON SHOULDER. WRENCH LIGHT LIT. ENGINE FINALLY STARTED AND RAN OK AFTER 15 MINUTES; (2) JUNE 6, 2015: PULLING INTO 99 RESTAURANT, QUINCY, MA, CAR SUDDENLY DIED, WRENCH LIGHT LIT. CAR WAS NOT COMPLETELY WITHIN THE LOT. CAR PUSHED INTO LOT WITH THE HELP OF THREE MALES. CAR STARTED AFTER C. 12 MINUTES.; (3) JUNE 24, 2015: EXITING BETSY'S DINER, FALMOUTH, MA ON RT28 IN TRAFFIC, CAR BLUBBERED THEN DIED, WRENCH LIGHT LIT. BLACK DODGE RAM NARROWLY MISSED US! CAR STARTED WITH 3-5 MINUTES; (4) OCTOBER 2, 2015: ON MA TPK, I-90W IN FAST TRAFFIC, CAR LOST POWER, BLUBBERED, THEN DIED IN FRONT OF THE CHARLTON STATE POLICE STATION. ENGINE RE-STARTED WITHIN 12 MINUTES, RAN ROUGHLY FOR A FEW MINUTES, THEN CLEARED, RAN OK; (5) OCTOBER 7, 2015: 1315, ENGINE SHOOK THEN DIED TWO BLOCKS AFTER LEAVING CAR WASH ON CENTRE STREET, QUINCY, MA, WRENCH LIT. NARROW STREET. LIT THE HAZARD FLASHERS, EXITED CAR. AFTER 15 MINUTES RE-ENTERED CAR WHICH STARTED AFTER 3 ATTEMPTS; (6) OCTOBER 7, 2015: 1405: WITHIN A BLOCK AFTER LEAVING OUR HOUSE, THE CAR ENGINE AGAIN BLUBBERED THEN DIED, WRENCH LIT. PULLED TO THE CURB, SAT FOR FIVE MINUTES. CAR WAS RESTARTED. THREE TIMES I HAVE BROUGHT MY MILAN TO OUR LOCAL AUTOMOTIVE GURU WHO ATTACHED HIS SCANNER AND CONFORMED 2111 CODE AND 2112 CODES (2). I PURCHASED THE CAR FROM ENTERPRISE SALES RENTALS AT 24,000 MILES, NOW 58,000 MILES. NEVER HAVE RECEIVED A RECALL NOTICE OF ANY TYPE. RESEARCH INDICATES A NUMBER OF TSBS RELATED TO THROTTLE BODY ISSUES BUT NO NOTICE FROM FOMOC OR LOCAL DEALER. THERE IS POTENTIAL FOR BEING KILLED IN THIS CAR. HOW TO GET THE CAR PROPERLY REPAIRED?
NHTSA complaint #10781307 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FIRST OF ALL THIS HAS HAPPENED ON SEVERAL OCCASIONS. DRIVING DOWN THE INTERSTATE THE CAR WILL STALL AND BEGIN TO SHAKE AND PUTS A WRENCH ICON ON THE DASH, THE VEHICLE HAS NO RESPONSE TO THE ACCELERATION PEDAL. I HAVE TO PULL OVER AND SH U THINK THE CAR OFF A FEW MINUTES AND THEN GO AGAIN. IT HAS ALSO HAPPENED SEVERAL TIMES WHILE PULLING ACROSS TRAFFIC FROM A STOP, ONE TIME NEARLY GETTING ME HIT FROM ONCOMING TRAFFIC. IT IS IMPOSSIBLE TO TELL WHEN OR WHERE THIS WILL HAPPEN. I HAVE CALLED FORD AND WAS DENIED A REPAIR BECAUSE MY VIN WAS NOT ON THE RECALL LIST FOR THE THROTTLE BODY EVEN THOUGH IT HAS THE SAME PROBLEM AS THE ONES COVERED. I HAVE HAD THE DIAGNOSTIC TEST AND RECEIVED CODES THAT MATCH AS WELL.
NHTSA complaint #10764139 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
DRIVING DOWN THE CAR STALLED AND SPUTTERED PULLED OVER AND IT RESTARTED FINE DRINK HALF MILE AND DID IT AGAIN ALMOST GO HIT BY A CAR THIS TIM I HAPPEN 5 MONTHS AGO AND I WAS ALMOST REAR ENDED WAS TOLD MY FORD DEALERSHIP THAT IS THE THROTTLE BODY FORD ISSUED A EXTENDED WARRANTY BUT WILL NOT REPLACE IT UNLESS THE CAR FAILS WHICH I THINK IS BS IF MY FAMILY IS HURT I'LL BE FILING SUIT AGAINST FORD AND THE DEALERSHIP.
NHTSA complaint #10745558 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WHILE DRIVING MY CAR ON THE INTERSTATE IN A CONSTRUCTION ZONE THE ENGINE LOST ALL POWER AND DROPPED TO AROUND 1000 RPM NO MATTER IF I PRESSED ON THE ACCELERATOR OR NOT. I WAS NEARLY REAR-ENDED BY A SEMI AND THERE WAS NO EMERGENCY LANE FOR ME TO PULL THE CAR OVER TO. IT COSTED FOR ABOUT 3/4 OF A MILE UNTIL I COULD PULL BEHIND SOME ORANGE BARRIERS. AFTER SHUTTING IT OFF AND CALLING ROADSIDE ASSISTANCE I RESTARTED THE CAR AND IT WAS FINE. I TOOK BACK ROADS HOME WITHOUT INCIDENT. THE NEXT DAY WHILE GOING 65 ON THE INTERSTATE IT HAPPENED AGAIN BUT I WAS PREPARED FOR A PROBLEM AND WAS ABLE TO GET TO AN EMERGENCY LANE TO TURN THE CAR OFF. IT RESTARTED FINE AND DROVE FINE AGAIN UNTIL THE NEXT DAY WHEN IT HAPPENED AT 20MPH ON A CITY STREET. THE DEALER HAS HAD IT FOR 3 DAYS NOW AND HAVE NOT IDENTIFIED THE ISSUE.
NHTSA complaint #10735819 — an unverified report by a vehicle owner.