Owners have filed 1,430 complaints
about the 2010 Mercury Milan with NHTSA between 2010 and 2026.
The largest single group is the steering.
Across this model's run it ranks 1 of 6 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the Mercury Milan. 50 means typical for this
model; 100 means roughly double.
Severity — 30
5.8% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 31
18% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
724.1%
Instrument Cluster/Panel
413.8%
Brake Lights
413.8%
Automatic Transmission
413.8%
Tail Lights
310.3%
Door
310.3%
Adaptive Cruise Control
26.9%
Electric Power Assist System
26.9%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
121.0%
1,000 – 9,999 miles
181.5%
10,000 – 24,999 miles
786.5%
25,000 – 49,999 miles
38031.9%
50,000 – 74,999 miles
32126.9%
75,000 – 99,999 miles
18315.3%
100,000 – 149,999 miles
14312.0%
150,000+ miles
584.9%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Apr 2010peak 96May 2026
NHTSA investigations into the 2010 Mercury Milan
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
PE13003Opened 21 Feb 2013Closed 28 Feb 2014ENGINE
Electronic Throttle Body Malfunction
On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. During this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting...
EA12009Opened 12 Dec 2012Closed 12 Jun 2014VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Floor mat interference with accelerator
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated c...
EA11009Opened 26 Jul 2011Closed 20 Jan 2012WHEELS:LUGS/NUTS/BOLTS/STUDS
Wheel Mounting Stud Fracture
To date, the agency is aware of 84 consumer complaints and 361 warranty claims related to the alleged defect in the subject vehicles.In total, 382 subject vehicles reportedly experienced one or more wheel stud fractures, resulting in 7 alleged wheel separation incidents.Most of the reported wheel stud fractures occurred on subject vehicles originally equipped with 17 inch diameter steel wheels (368 of 382) as did all 7 alleged wheel separation incidents.Of the 7 alleged wheel separation incidents, 5 reportedly involved a wheel becoming detached from the subject vehicle's rear axle.The subject...
PE11003Opened 21 Jan 2011Closed 26 Jul 2011WHEELS:LUGS/NUTS/BOLTS/STUDS
Wheel Stud Fracture
On January 21, 2011, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE11-003) to investigate alleged wheel stud fractures in certain model year (MY) 2010 Ford Fusion vehicles.ODI sent the manufacturer an information request letter dated February 8, 2011 and Ford responded by letter dated March 25, 2011.Ford provided a supplemental response by letter dated July 15, 2011.To date, ODI is aware of 29 complaints related to the alleged defect in the subject vehicles, which now include certain MY2010 Mercury Milan vehicles that are the same or substantially similar to the...
AQ10001Opened 18 Nov 2010Closed 28 Dec 2015UNKNOWN OR OTHER
Fleet Vehicle Recall Completion Audit
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this...
PE10019Opened 28 May 2010Closed 11 Jan 2013VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Accel Pedal Interference - Acc Floormat
Unsecured mats may interfere with accelerator pedal return to idle. A heel blocker in the floor pan provides a platform that may lift an unsecured mat into contact with the pedal. Ford introduced new pedals as a running change early in model year (MY) 2010 vehicles. Analysis of complaints received by ODI and Ford show elevated rates of pedal entrapment incidents in MY 2008 through early 2010 production vehicles. Incidents typically occur following hard pedal applications to pass slower traffic or when merging into faster traffic. Drivers allege continued high engine power after releasing the a...
Recalls on the 2010 Mercury Milan
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
21V158000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
21E013000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain air bag inflator and/or module replacement service parts that may have been used as part of a collision repair. The parts include certain driver-side air bag inflators and/or modules, designed to fit 2005-2014 Ford Mustang and Mustang GT500. It also includes certain passenger-side air bag inflators and/or modules designed to fit 2005-2014 Ford Mustang, 2010-2012 Lincoln MKZ, 2010-2012 Ford Fusion, 2010-2011 Mercury Milan, 2007-2011 Ford Ranger, and 2007-2010 Lincoln MKX vehicles. Please see Ford's recall report for the specific part numbers. These parts may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Risk: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
21V081000
AIR BAGS:FRONTAL
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Risk: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
19V904000
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.
Risk: If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.
19V001000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain 2014 Ford Mustang vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Ford is recalling certain 2011 Ford Ranger and Mercury Milan vehicles, 2011-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles and 2011-2014 Ford Mustang vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Ford is also recalling certain 2010 Ford Edge and Lincoln MKX vehicles, 2010-2011 Ford Ranger and Mercury Milan vehicles, 2010-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles, and 2010-2014 Ford Mustang vehicles sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with air bag inflators a
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
18V775000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain 2010 Ford Fusion, Mercury Milan and 2010-2012 Lincoln MKZ vehicles that previously received a replacement passenger air bag under recall 16V-384, 17V-024 or 18V-046. In the event of a crash requiring deployment of the passenger air bag, the bracket that secures the air bag inflator to the module housing may deform, allowing the gas that inflates the air bag to leak out.
Risk: If the air bag does not inflate as intended, there is an increased risk of injury in the event of a crash.
18V046000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain 2013 Ford Mustang vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Ford is recalling certain 2010 Ford Edge, Fusion, Mustang and Ranger, Lincoln MKX and Zephyr/MKZ, and Mercury Milan vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Ford is also recalling certain 2009 Ford Edge, Fusion, Mustang and Ranger, Lincoln MKX and Zephyr/MKZ, and Mercury Milan vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with air bag inflators assembl
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
16V384000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with
Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2021029274,737 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the driver-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Action: Ford will notify owners by mail. The corrective actions for this recall are under development. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected.
Recall 201966554,292 units in Canada
Brakes
Issue: On certain cars, a problem with the hydraulic control unit for the anti-lock brake system (ABS) could cause increased brake pedal travel. Safety Risk: Increased brake pedal travel could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct you to take your vehicle to a Ford or Lincoln dealer to inspect the ABS module assembly. The system will be flushed with DOT 4 brake fluid, and if necessary, the hydraulic control unit will be replaced. Dealers will also replace the DOT 3 reservoir cap with a new DOT 4 cap.
Recall 2019005300,898 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the passenger-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Actions: Owners will be notified by mail and instructed to take their vehicle to a dealer to have the passenger-front airbag inflator replaced. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected. Additional note: This recall supersedes recalls 2016-347 (Ford Safety Improvement Program 16S26), 2017-024 (Ford Recall 17S01) and 2018-035 (Ford Recall 18S01). Vehicles repaired under the previous recalls do not require repair under this recall.
Recall 20163475,867 units in Canada
Airbag
Ford Canada is conducting a voluntary Safety Improvement Program involving passenger airbag inflators in certain vehicles that were originally sold or ever registered in certain high humidity areas of the United States equipped with Takata airbags. Ford will replace the driver or passenger inflator on affected vehicles, depending on the vehicle involved. Owners who believe their vehicles may have been originally purchased or registered in the states of New Jersey, Delaware, District of Columbia, Maryland, Pennsylvania, Ohio, Indiana, Illinois, Virginia, West Virginia, Kentucky, Missouri, Nebraska, Kansas, Oklahoma, Arkansas, Tennessee, North Carolina, Nevada, Arizona, New Mexico, California, Texas, Louisiana, Mississippi, Alabama, Georgia, South Carolina, Florida, Hawaii, Puerto Rico or the U.S. Virgin Islands should contact a Ford dealer. This action is not being conducted under the requirements of the Motor Vehicle Safety Act. Note: This Safety Improvement Program is superseded by recall 2019005 (Ford Recall 19S01). Please see <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2019005">recall 2019005</a> for more information.
Reports where the owner recorded a crash, a fire, an injury or a death.
Ontario, CACrash1 injured
AIR BAGS
I collided with three parked vehicles and my airbags did not deploy causing me to hit my head
NHTSA complaint #11678528 — an unverified report by a vehicle owner.
Ontario, CACrash1 injured
FUEL/PROPULSION SYSTEM
I collided with three parked vehicles and my airbags did not deploy causing me to hit my head
NHTSA complaint #11678528 — an unverified report by a vehicle owner.
Kings Park, NYCrash
SERVICE BRAKES
My name is [XXX] and I own a 2010 Mercury Milan. I bought it on [XXX] from an 84 year old woman who take good care of it. It had 91,000 miles which were mostly hwy miles. She kept records of all her oil changes. After having it for almost 3 years and keeping up with it myself, on February 27,2024 in the morning I put brake fluid in the car. I had brake pads and rotors done on the car in August 2023. On the evening of [XXX], my son and I took a ride to the local 7/11 which is 5 minutes away. While driving home and coming to the traffic light at the beginning of my neighborhood the light turned red. As I proceeded to stop my foot went all the way to the ground and I had no brakes. I had to go through the light because i could not stop. The car was flying down the road because it is a very steep hill. I tried to pull the emergency brake and nothing happened. I was nearing the end of the road going 40 MPH due to the hill. I thought I was going to hit my neighbors house at the bottom of the hill. My son grabbed the steering wheel to turn it and I went up on my curb, across my lawn and crashed into a storage tent on my driveway. My car was wedged inside the tent which was filled with furniture and other belongings. I called Ford Corporation in reference to this recall from December 2019 for 2010 Mercury Milans. Then I spoke with a Ford dealership in Smithtown where they were rude and said the car was 14 years old and I may have to pay if they didn't find my car was part of the recall. I tried calling several other numbers in Washington and was finally told to upload the horrible situation that had occurred due to my brakes not working on this website. Someone needs to look at my car to make sure this will not happen to others. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11600649 — an unverified report by a vehicle owner.
Fergus Falls, MNCrash
AIR BAGS
I was driving home from Fargo ND to Fergus falls MN on Christmas Eve when a gust of wind blew me out of the tracks into the slush. My car slid of the road on the left side where I hit a guard rail with the front driver’s side hitting first. I bounced of the rail and drove it back on the road. The airbag never did deploy. I have a doctor appointment for my left hip on the 8th because it's hard for me to put on a sock. I have a police report and pictures but it will not let me upload them.
NHTSA complaint #11563114 — an unverified report by a vehicle owner.
Jesup, GACrash
EXTERIOR LIGHTING
My head lights are NOT sufficient. It does not have the option for 2 bulbs. I have changed out the bulbs 3 times while owning this vehicle and from the first night I drove it after owning it, I noticed the lights where very off. I drive around town and on dark roads where there is NO Road LIGHTS at night with my head lights on Bright and I DO NOT get brighted back. I have hit an animal due to the lights not being bright. I fear driving the car at night or where it's to dark because the light assembly is not proper. No warning lights.
NHTSA complaint #11488511 — an unverified report by a vehicle owner.
Alexandria, LACrash1 injured
STEERING
I backed out of a parking space in a parking lot and turned the steering wheel left then as I put vehicle into "drive" my steering seemed to lock up and became extremely hard to turn. I kept attempting to turn wheel and suddenly it was easily turned again as normal. While I was driving home the power steering stopped working causing steering wheel to feel as if locked again and almost impossible to turn in any direction. I almost wrecked my vehicle and hit another vehicle on the road way but hit my brakes and continued to aggressively turn the wheel to missed the vehicle in front of me. I heard and felt a pop and then steering wheel was easily turned again. I barely missed the vehicle in front of me but I did hit the curb and a bicycle a pedestrian was holding next to him on sidewalk. He was able to jump out of the way and was fortunately unharmed. I stopped my vehicle and parked immediately. I called my husband and he came to get the vehicle and I drove his home. He had no problems driving vehicle home and power steering was working as normal but once he was close to pulling into the driveway, a warning message on dash read "service power steering now".... there were no warning of this problem what so ever and just suddenly happened. Very dangerous and I have read many many others have had same issue with exact make and model of 2010 mercury milan. Please add this issue with power steering to recall list so others don't get hurt. I hurt my neck & wrist when I hit that curb and bicycle. I also had to pay for bicycle I hit.. A code reader was put onto car the next day and gave codes C-1963 and C-1277 if that helps with the recall. Thank you for your time and concern in this matter and I apologize for any inconvenience.
NHTSA complaint #11442954 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Stamford, CT
STEERING
While driving at low speed performing a turn in a residential area, the vehicle suddenly displayed a “Steering Assist Fault” warning message and the steering wheel became completely locked with essentially no movement possible. I attempted to turn the wheel with extreme force but it would barely move, creating a serious safety hazard. I was fortunately driving slowly at the time. If this had occurred at higher speed or in traffic, it could have caused a crash, serious injury, or even death. Prior to the incident, there had occasionally been a slight amount of unusual tension/resistance felt while turning the steering wheel, although it was minor and inconsistent before the complete failure occurred. The failure happened suddenly while driving normally. The issue appears related to the electronic power steering (EPAS) / steering assist system. Similar steering assist failure complaints and recalls/investigations have existed on related Ford Fusion/Mercury Milan vehicles involving sudden loss of steering assist and steering control concerns. The vehicle is also currently affected by brake recall 19S54/19V904 involving braking performance concerns, increasing overall safety concerns regarding the vehicle. At the time of filing this complaint, the steering issue has not yet received a complete repair or confirmed diagnosis because the manufacturer and dealer stated the VIN is not currently included under steering recall coverage.
NHTSA complaint #11738608 — an unverified report by a vehicle owner.
Grove City, OH
STEERING
I was driving on the freeway and the steering began to stiffen. I got to my destination and decided to check the tires for any ice or snow, thinking that might be why it was difficult to drive but there was no buildup. I made it home and parked the car. The next day, I can't even turn the steering and a warning comes up that says service power steering and advancetrac.
NHTSA complaint #11717622 — an unverified report by a vehicle owner.
Grove City, OH
ELECTRICAL SYSTEM
I was driving on the freeway and the steering began to stiffen. I got to my destination and decided to check the tires for any ice or snow, thinking that might be why it was difficult to drive but there was no buildup. I made it home and parked the car. The next day, I can't even turn the steering and a warning comes up that says service power steering and advancetrac.
NHTSA complaint #11717622 — an unverified report by a vehicle owner.
Ontario, NY
STEERING
Bought this car less then a year ago with 38k miles and just last week after coming back from vacation my power steering system went while on the expressway. The advancetrac warning light came on and then the service power steering now. The steering wheel was impossible to turn and to make matters worse it was snowing out.
NHTSA complaint #11704889 — an unverified report by a vehicle owner.
Independence, MO
STEERING
The electric power steering has failed again this will make it twice in 18 months the last time it cost 1800 dollars to fix it know that only some of the 2010 Mercury Milans are on a recall list unfortunately mine is not on that list why because it is absurd that I should I have to make this repair for 1800 dollars again you cant safely drive this car it takes everything I have to turn the steering wheel
NHTSA complaint #11689597 — an unverified report by a vehicle owner.
Independence, MO
ELECTRICAL SYSTEM
The electric power steering has failed again this will make it twice in 18 months the last time it cost 1800 dollars to fix it know that only some of the 2010 Mercury Milans are on a recall list unfortunately mine is not on that list why because it is absurd that I should I have to make this repair for 1800 dollars again you cant safely drive this car it takes everything I have to turn the steering wheel
NHTSA complaint #11689597 — an unverified report by a vehicle owner.
Renton, WA
SERVICE BRAKES
The safety recall 19S54 is affecting my vehicle. It was made at the same plant at the approved date range as the other vehicles on the recall list but it seems my vehicle wasnt added to the list because it is a hybrid but it has the same exact issue as the non hybrid models
NHTSA complaint #11689311 — an unverified report by a vehicle owner.
at 60,562 milesLebanon, TN
STEERING
The contact owns a 2010 Mercury Milan. The contact stated that while driving approximately 30 MPH, the "Service Traction Control" and “Power Steering Sensor” warning lights illuminated. The contact stated that the steering wheel became difficult to turn to the left or the right. The contact was able to drive the vehicle back to the residence. The local dealer was contacted and sent an agent to the residence to drive the vehicle to the dealer. The vehicle was diagnosed, and it was determined that the power steering assist had failed, and the steering gears and rack, and pinion needed to be replaced. The vehicle was repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 60,562.
NHTSA complaint #11679284 — an unverified report by a vehicle owner.
Ontario, CACrash1 injured
AIR BAGS
I collided with three parked vehicles and my airbags did not deploy causing me to hit my head
NHTSA complaint #11678528 — an unverified report by a vehicle owner.
Ontario, CACrash1 injured
FUEL/PROPULSION SYSTEM
I collided with three parked vehicles and my airbags did not deploy causing me to hit my head
NHTSA complaint #11678528 — an unverified report by a vehicle owner.
at 140,000 milesBell Buckle, TN
SERVICE BRAKES, HYDRAULIC
The contact owns a 2010 Mercury Milan. The contact stated that while depressing the brake pedal to the floorboard, the vehicle failed to immediately stop. The vehicle was taken to the local brake service center, but the cause of the failure was not yet determined, and the vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 19V904000 (SERVICE BRAKES, HYDRAULIC). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was approximately 140,000.
NHTSA complaint #11671729 — an unverified report by a vehicle owner.
Streator, IL
STEERING
Check engine light is on mechanic says it's a fuel tank issue
NHTSA complaint #11655144 — an unverified report by a vehicle owner.
Streator, IL
SUSPENSION
Check engine light is on mechanic says it's a fuel tank issue
NHTSA complaint #11655144 — an unverified report by a vehicle owner.
Streator, IL
FUEL/PROPULSION SYSTEM
Check engine light is on mechanic says it's a fuel tank issue
NHTSA complaint #11655144 — an unverified report by a vehicle owner.
Mount joy, PA
STEERING
I experienced a loss of power steering while driving and a dash display "Service Power Steering Now" and "Service Advancetrac". The messages started just before the failure. The lack of power steering was a risk to everyone as the car could only be turned with significant effort and not respond to quick movement. The dash messages are still on after a restart and the car cannot be driven because of safety. My independent mechanic confirmed the issue and fix to be a bad rack. He noted the rack part number is the same as the 2011 Milan, currently under recall for this issue. However, the 2010 is not included.
NHTSA complaint #11640467 — an unverified report by a vehicle owner.
Livonia, MI
SERVICE BRAKES
Whenever the car engine isn't warm and I slam on the brakes, they barely respond. I have replaced the master cylinder, abs hydraulic module, brake booster, calipers, pads, and rotors, and it still has about 20% normal braking power when the engine is cold. Just got it back from the dealership again. Dealer said no vacuum leak found, no leaks found, abs module checks out fine, and said the check valve passed diagnostics. The problem remains. This has been ongoing for several years now. May have contributed to an accident in 2023. Not sure as my wife was driving. When the engine is warm, the brakes work perfectly.
NHTSA complaint #11639152 — an unverified report by a vehicle owner.
Cincinnati, OH
STEERING
The contact owns a 2010 Mercury Milan. The contact stated while driving at various speeds, the steering wheel was difficult to turn. Additionally, the contact stated while driving 30-35 MPH, the steering wheel seized inadvertently. There were no warning lights illuminated. The contacted depressed the brake pedal and pulled over to the side of the road and parked the vehicle. The contact stated that upon returning to the vehicle, the vehicle was restarted, and the steering wheel was no longer seized, but the steering wheel was difficult to turn. The contact was able to drive the vehicle; however, the failure recurred while driving. The dealer was notified of the failure and informed the contact that the failure was related to NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA complaint #11625230 — an unverified report by a vehicle owner.
at 126,000 milesBrownstown Twp, MI
STEERING
The contact owns a 2010 Mercury Milan. The contact stated while driving at approximately 45 MPH while turning the steering wheel to the right, the steering warning illuminated, and the steering wheel became difficult to turn. The contact stopped and turned off the vehicle and the power steering function returned. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 15V340000 (Steering). The manufacturer was informed of the failure. The failure mileage was approximately 126,000.
NHTSA complaint #11623168 — an unverified report by a vehicle owner.
at 240,000 milesFindlay, OH
SERVICE BRAKES, HYDRAULIC
The contact owns a 2010 Mercury Milan. The contact stated that while operating the vehicle, the "Check Brake System" and "Service Advance Track" messages remained displayed. The cause of the failure was not yet determined. The contact indicated that the failure had occurred days after the vehicle was repaired under NHTSA Campaign Number: 19V904000 (SERVICE BRAKES, HYDRAULIC). The manufacturer and local dealer were notified of the failure. The failure mileage was 240,000.
NHTSA complaint #11622282 — an unverified report by a vehicle owner.
Woodbridge, VA
STEERING
started vehicle, "power steering assist fault" message appeared on dash message center, unable to turn steering wheel. Turn car off, waited, turn back on, message appeared again. tried an additional 3 times, same results. Had to leave the car where i was visiting.
NHTSA complaint #11617343 — an unverified report by a vehicle owner.
Indianapolis, IN
STEERING
My power steering light came on and then immediately the wheel got tight. I was unable to turn the wheel and then eventually the car is un drivable. There is a lot of complaints about this happening to thousands of cars and it is still under investigation. Imagin someone jumps out in front of you and you are stopping and unable to maneuver your car out of the way. By the grace of God I was able to do so. Please advise me when this recall is open.
NHTSA complaint #11614194 — an unverified report by a vehicle owner.
at 38,000 milesAlcoa, TN
STEERING
The contact owns a 2010 Mercury Milan. The contact stated that the power steering assist became inoperable. The driver was unable to turn the steering wheel. The contact stated that the steering wheel had seized. The vehicle was restarted, and the steering wheel operated as designed. The power steering assist fault and service power steering soon messages were displayed. The contact stated that the failure was related to NHTSA Campaign Number: 15V340000 (Steering). The local dealer was contacted, and the contact was referred to the Ford Warranty Department for assistance. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 38,000.
NHTSA complaint #11610808 — an unverified report by a vehicle owner.
at 153,000 milesPhoenix, AZ
ENGINE
The contact owns a 2010 Mercury Milan. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the electronic throttle body and the throttle body injectors failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 153,000.
NHTSA complaint #11609523 — an unverified report by a vehicle owner.
Gary, IN
STEERING
See attached document for complaint
NHTSA complaint #11608152 — an unverified report by a vehicle owner.
Kings Park, NYCrash
SERVICE BRAKES
My name is [XXX] and I own a 2010 Mercury Milan. I bought it on [XXX] from an 84 year old woman who take good care of it. It had 91,000 miles which were mostly hwy miles. She kept records of all her oil changes. After having it for almost 3 years and keeping up with it myself, on February 27,2024 in the morning I put brake fluid in the car. I had brake pads and rotors done on the car in August 2023. On the evening of [XXX], my son and I took a ride to the local 7/11 which is 5 minutes away. While driving home and coming to the traffic light at the beginning of my neighborhood the light turned red. As I proceeded to stop my foot went all the way to the ground and I had no brakes. I had to go through the light because i could not stop. The car was flying down the road because it is a very steep hill. I tried to pull the emergency brake and nothing happened. I was nearing the end of the road going 40 MPH due to the hill. I thought I was going to hit my neighbors house at the bottom of the hill. My son grabbed the steering wheel to turn it and I went up on my curb, across my lawn and crashed into a storage tent on my driveway. My car was wedged inside the tent which was filled with furniture and other belongings. I called Ford Corporation in reference to this recall from December 2019 for 2010 Mercury Milans. Then I spoke with a Ford dealership in Smithtown where they were rude and said the car was 14 years old and I may have to pay if they didn't find my car was part of the recall. I tried calling several other numbers in Washington and was finally told to upload the horrible situation that had occurred due to my brakes not working on this website. Someone needs to look at my car to make sure this will not happen to others. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11600649 — an unverified report by a vehicle owner.