298 of the
2,646 complaints filed about the Mercury Mountaineer
are about the body and structure —
11% of everything owners reported.
The worst model year for it is 2004.
STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS:SUPPORT DEVICE/STRUT
The contact's daughter owns a 2000 Mercury Mountaineer. The contact stated that while her husband and her daughter were inspecting the engine compartment of the vehicle, the hinges of the hood failed, causing the hood to drop inadvertently. The contact's husband sustained a laceration on the arm but did not seek medical assistance. The vehicle was taken to an independent mechanic, where the hood hinges were replaced. Additionally, the contact purchased a stick to hold the hood open. The vehicle was repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was unknown. The VIN was not available.
NHTSA complaint #11651158 — an unverified report by a vehicle owner.
Body : to much rust, corrosion, on rear of truck other failure or detachment of exterior body like rear gate frame components, and other structural components that may present a safety hazard. Electrical : electrical systems and items such asa wiring and cable on or inside the door, ignition switch cover detach ,instrument panel and gauges blinking that causes motors and actuators that power mechanical devices like (windows, sunroofs, seats, etc.) Generate some kind of electrical problem that may present a safety hazard. Power train :transmissions, transfer cases fluid hard to check ,electronic control units and shift lever inacurated, drive axles, hubs, shafts, differentials, CV joints star vibration that may present a safety hazard.
NHTSA complaint #11469915 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE REAR LIFT GATE FAILED TO LATCH SECURELY ON SEVERAL OCCASIONS. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE CONTACT STATED ON ONE OCCASION WHILE DRIVING THE VEHICLE, THE LIFT GATE AJAR WARNING LIGHT ILLUMINATED. THE CONTACT'S SON WENT TO CLOSE THE LIFT GATE AND GLASS SHATTERED. THE CONTACT HIRED A GLASS REPAIRMEN TO FIX THE WINDOW FOR $250.00. THE DEALER NOR THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE. UPON INVESTIGATION, THE CONTACT ASSOCIATED NHTSA CAMPAIGN NUMBER: 01I010000 (VISIBILITY) WITH THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11307302 — an unverified report by a vehicle owner.
2006 MERCURY MOUNTAINEER, 123,000 MILES. NOTICE (BOTTOM) OF BOX SUBFRAME, LOCATED REAR DRIVER SIDE ONLY. FOWARD OF REAR AXLE, HAS EXCESSIVE CORROSION IN A LENGTH OF 8 TO 10 INCHES. CORROSION HAS ROTTED THROUGH THIS AREA. VEHICLE HAS 123000 MILES ON IT. ALSO VEHICLE HAS SURFACE CORROSION ALL OVER BOTTOM OF SUBFRAME. FORD DID NOT APPLY CORROSION COATINGS ON THIS SUB FRAME PROPERLY. THIS COULD BE A HAZARD FOR OTHER VEHICLES AS WELL AS TIME GOES ON. NOTICE OTHER FORD VEHICLES HAVE NUMEROUS PROBLEMS AND RECALLS WITH SUB FRAME CORROSION, RANGING FROM 2001 THROUGH 2014. FORD'S VENDORS THAT FABRICATE THESE PARTS SHOULD BE UPDATED WITH MODERN PROCEDURES TO APPLY CORROSION PREVENTED COATINGS ON THESE PARTS PROPERLY. SHOULD BE A RECALL ON THESE SECTIONS FOR REPAIR... NO ACCIDENTS, NO ISSUES, AS TIME GOES ON THERE MAYBE PROBLEMS IN THE FUTURE WITH FORD PRODUCTS SUB FRAME CORROSION RESULTING IN ACCIDENTS ON ROADS.
NHTSA complaint #11269593 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2005 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE REAR HATCHBACK PANEL WAS CRACKED IN SEVERAL LOCATIONS. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED THE LOCAL DEALER (FIVE STAR FORD, 6618 NE LOOP 820 AT RUFE SNOW, NORTH RICHLAND HILLS, TX 76180-7844, 817-500-0097) AND WAS INFORMED THAT THEY COULD NOT REPAIR THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND REFERRED THE CONTACT TO THE LOCAL DEALER. THE FAILURE MILEAGE WAS 100,000.
NHTSA complaint #11164258 — an unverified report by a vehicle owner.
THE MOUNTAINEER IS A 2005. I LOVE THE VEHICLE BUT, THE PAINT IS ALMOST GONE ON THE HOOD AND IS STARTING TO BUBBLE IN OTHER AREA. THIS IS MY DAILY CAR, HAS BEEN GARAGE KEPT UNTIL MAY 2018. I CANNOT THINK OF ANYTHING WHICH WOULD HAVE CAUSED THIS.
NHTSA complaint #11120237 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2005 MERCURY MOUNTAINEER. UPON INSPECTION, THE CONTACT NOTICED THAT THE REAR PANEL WAS CRACKED. THE CONTACT WAS CONCERNED THAT THE INTEGRITY OF THE REAR WINDOW WAS COMPROMISED DUE TO THE CRACKS. THE VEHICLE WAS TAKEN TO DICK SMITH FORD (9505 E STATE RTE 350, RAYTOWN, MO) WHERE THE CRACKS WERE CONFIRMED. THE DEALER DIAGNOSED THAT ADHESIVE MATERIAL NEEDED TO BE ADDED TO THE CRACKS TO REINFORCE THE PANEL. THE MANUFACTURER STATED THAT IF THE CONTACT WERE TO REPAIR THE FAILURE INDEPENDENTLY, SHE MAY BE REIMBURSED IF A RECALL WERE ISSUED. THE FAILURE MILEAGE WAS APPROXIMATELY 116,354. *TT
NHTSA complaint #11100229 — an unverified report by a vehicle owner.
AT THIS POINT ALL 4 DOOR LOCKS/LATCHES ARE MESSED UP. BOTH DRIVER &PASSENGER BACK DOORS WON'T OPEN FROM OUTSIDE OR INSIDE. DRIVER &PASSENGER FRONT DOORS WON'T OPEN FROM OUTSIDE UNLESS OPEN FROM INSIDE FIRST. KEY WON'T UNLOCK DOORS. BACK GLASS ON HATCH DOOR WON'T OPEN. BACK WIPER BROKEN. BACK HATCH WOULDN'T OPEN UNTILL I PAID TO HAVE IT FIXED. I CONTACTED THE MANUFACTURER THEY SAID MY TRUCK NOT ON RECALL LIST & WANTED ME TO PAY TO FIX IT. MY TRUCK HAS SAME ISSUES AS THE ONES BEING RECALLED. HOW DO THEY DETERMINE WHICH ONES TO RECALL?
NHTSA complaint #11062659 — an unverified report by a vehicle owner.
1. PAINT COMING OFF OF ROOF AND DRIVER'S DOOR. 2. REAR PASSENGER SIDE AND DRIVER SIDE POWER WINDOWS NOT WORKING. 3. CRACKS IN PLASTIC AREA OF REAR LIFT GATE AROUND WIPER ARM. 4. ALMOST LOST CONTROL AND POTENTIAL ACCIDENT ON INTERSTATE WHEN RIGHT REAR WHEEL CAME LOOSE.
NHTSA complaint #11053938 — an unverified report by a vehicle owner.
MY 2007 MERCURY MOUNTAINEER NEVER HAD ANY PROBLEMS UNTIL RECENTLY, THOUGHT IT WAS THE TRANSMISSION BECAUSE OF THE WAY IT DROVE. TOOK IT TO THE MECHANIC AND GOT TRANSMISSION FLUID PUT IN BUT THE PROBLEMS REMAINED THE SAME AND WAS TOLD THE TRANSMISSION WAS FINE. MY THERMOSTAT HOUSING UNIT WAS LEAKING (THIS IS VERY COMMON WITH THESE CARS AND VERY DANGEROUS, NEEDS IMMEDIATE ATTENTION!) AND HAD CAUSED VERY EXPENSIVE WIRING ISSUES. ALMOST ACTS EXACTLY LIKE THE TRANSMISSION IS GOING OUT - RPM'S ARE WAY TOO HIGH, THE VEHICLE WOULD NOT ACCELERATE IN THE MIDDLE OF CITY TRAFFIC, THE CAR JUMPED AT A STOPLIGHT AND CAUSED ME TO HIT THE CAR IN FRONT OF ME, AND IT DOESN'T SHIFT PROPERLY. PROBLEMS OCCURRED OUT OF NOWHERE AND ARE TOO DANGEROUS TO BE IGNORED BUT VERY EXPENSIVE TO BE FIXED. ITS VERY COMMON AND SHOULD BE RECALLED BEFORE SOMEONE GETS SERIOUSLY INJURED!!!!
NHTSA complaint #11043298 — an unverified report by a vehicle owner.
I HAVE A MERCURY MOUNTAINEER 2003 AND IT WAS STATIONED THERE WAS A CRACK IN THE BACK MIDDLE OF THE HATCH NOW THERE A HUGE CRACK AND MY WINDOW OF THE TRUNK CAME UNHINGED AND FELL OFF I SEE THIS PROBLEM IN ALL MOUNTAINEERS THEY ALL HAVE THE CRACK IN THE HATCH HOPE THEIRS DON'T FALL OFF I SEE IT IN ALMOST EVERYONE'S. THIS SHOULD BE RECALLED BECAUSE WHAT WOULD OF HAPPENED IF I WAS DRIVING AND IT FELL OFF THIS IS NOT SAFE. PLEASE HAVE THIS INVESTIGATED. THANK YOU!
NHTSA complaint #11030250 — an unverified report by a vehicle owner.
1) FRONT WHEEL BEARING HUB ASSEMBLY FAILURE RESULTING IN UNSAFE​ UNDRIVEABLE (THIS HAS BEEN REPEATEDLY​ REPORTED BY VEHICLE OWNERS REGARDLESS OF VEHICLES MILAGE) FAILURE ACCURED WHILE SLOWING DOWN FOR A STOPLIGHT AFTER EXITING A PARKING LOT OF A RESTAURANT 2) LIFT HATCH CRACKED CENTER OF HATCH ABOVE THE EMBLEM POTENTIALLY ALLOWING WATER INTO THE INTERIOR WORKING OF HATCH AND CAUSING UNTOLD AND UNSEEN WATER RELATED DAMAGES​(THIS IS AN ADMITTED FORD MANUFACTURING DEFECT ACROSS THE ENTIRE VEHICLE​ LINE SPENDING MULTIPLE YEARS PRODUCTION)
NHTSA complaint #10969975 — an unverified report by a vehicle owner.
JUST LIKE EVERY OTHER MOUNTAINEER OR EXPLORER OF THIS ERA THE LIFT GATE HAS CRACKED AROUND THE VEHICLE LOGO. THIS HAS CAUSED PROBLEMS INCLUDING CORROSION, RUST, AND LOCKING MECHANISM FAILURE ON THE LIFTGATE. THIS PROBLEM CAN BE SEEN ON EVERY SINGLE MOUNTAINEER OR EXPLORER OF THIS ERA. IT'S PRETTY RIDICULOUS THAT FORD HAS NOT BEEN FORCED TO REMEDY THE ISSUE OR DONE IT VOLUNTARILY. IT IS CLEARLY AN ENGINEERING FAILURE.
NHTSA complaint #10863138 — an unverified report by a vehicle owner.
REAR TAILGATE WINDOW HINGE BROKE WHILE HAVING THE WINDOW ONLY OPEN AND PUTTING AWAY GROCERIES. UPON CLOSING THE WINDOW, THE RIGHT HINGE BROKE CAUSING THE WINDOW TO ALMOST FALL OFF OF THE CAR. I ATTEMPTED, WITH ASSISTANCE FROM OTHERS IN THE PARKING LOT, TO PUSH THE WINDOW BACK INTO THE FRAME AND HAVE IT LOCK AT THE CENTER LATCH. THE LATCH IS NO LONGER ENGAGED AND I HAVE ATTEMPTED TO PUSH ON THE WINDOW TO CONNECT WITH THE LATCH. I AM NOT STRONG ENOUGH TO DO SO. THE WINDOW IS AT A POINT WHERE IT COULD FALL OFF OF MY CAR. THERE WAS A RECALL ON THIS PART FOR 2000-2003 VEHICLES OF THIS MAKE AND MODEL. FORD IS NOT CARRYING OVER THE RECALL TO 2004 STATING THE DEFECT IS NOT THE SAME (WITH THE DETAILS) AS THE RECALL ITSELF. IT IS STILL THE SAME DEFECTIVE PART! I AM OF SHORT STATURE AND DO NOT HAVE THE STRENGTH TO PUSH THE WINDOW THE 1" OR SO TO GET IT INTO THE FRAME TO LOCK SUCCESSFULLY. I HAVE CONTACTED MY LOCAL FORD DEALERSHIP FOR ADVICE BUT HAVE BEEN TOLD I WOULD NEED TO PAY OUT OF POCKET. I AM AT RISK OF HAVING THE WINDOW FALL OFF THE BACK OF MY CAR AND DO NOT CURRENTLY HAVE THE MONEY TO PAY FOR THIS REPAIR AT THIS TIME. THERE HAVE BEEN SEVERAL COMPLAINTS NOTED FOR THIS EQUIPMENT FAILURE ON THIS SITE FOR THE 2004 MOUNTAINEER. JUST NOT SURE WHAT TO DO NEXT. MY VEHICLE IS MY BREAD AND BUTTER IN ORDER TO WORK.
NHTSA complaint #10862164 — an unverified report by a vehicle owner.
MY HUSBAND WAS DRIVING OUR 2005 MERCURY MOUNTAINEER AND HE WAS GOING LESS THAN 20 MILES PER HOUR ON A MAIN STREET AND GOT IN A ACCIDENT THE WOMAN STOPPED SHORT AND HE REAR ENDED HER. THE CAR TOTALLED UP BUCKLED UP AIR BAGS NEVER INFLATED THEY CAME OUT COMPLETELY DEFLATED. ISSUE WITH THIS CAR ALSO IS THE ELECTRIC DRIVER WINDOW DIES OUT MECHANIC COULD NOT FIGURE OUT BOUGHT NEW MOTORS STILL WOULDNT OPEN ELECTRIC SWITCHES THEY THOUGHT IT WAS FULLY ELECTRONIC THEY WHERE GOING TO RE WIRE VERY EXPENSIBE BUT CAR WAS TOTALLED. CAR HORRIBLE ON GAS ALSO. HAVE PICTURES OF DELATED AIR BAGS BOTH DRIVER AND PASSANGER
NHTSA complaint #10860958 — an unverified report by a vehicle owner.
STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS
TL* THE CONTACT OWNS A 2005 MERCURY MOUNTAINEER. AFTER PARKING THE VEHICLE, THE CONTACT NOTICED THE LIFTGATE WINDOW HANGING OFF THE HINGES. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000. UPDATED 06/15/16*LJ
NHTSA complaint #10860019 — an unverified report by a vehicle owner.