Mini Cooper seat belt problems

SEAT BELTS

The seatbelt and air bag warning light for the passenger front seat stays on.

NHTSA complaint #11698274 — an unverified report by a vehicle owner.

SEAT BELTS

Passenger Airbag sensor is off even when passenger is in the seat and airbag should be on.

NHTSA complaint #11662967 — an unverified report by a vehicle owner.

SEAT BELTS

As per NHTSA there was a recall the replace OC3 SEAT OCCUPANCY MAT but I never received recall notice and just passed 10 years with 40K millage and started getting air bag light, dealer is not replacing it under warranty, if they was a recall they should have replaced my seat earlier so that I would not have this issue today. is there a way to extend warranty to longer time or recall all the cars and replace them so that we do not have to spend 2k to replace it? "01 11 16_OC3 SEAT OCCUPANCY MAT: LIMITED WARRANTY EXTENSION TO 10 YEARS/120,000 MILES"

NHTSA complaint #11617003 — an unverified report by a vehicle owner.

SEAT BELTS

My passenger seat airbag warning is illuminated, with associated chime. I am also getting a orange warning light indicating the passenger airbag is inop. This is intermittent with a passenger occupying the passenger seat. lights go on and off with movement of the passenger. There is a current recall for the convertible model of the R56 Mini Cooper.

NHTSA complaint #11582702 — an unverified report by a vehicle owner.

SEAT BELTS

The passenger occupancy seat sensor is defective (as reported by many other owners of this vehicle model). The sensor is very costly to replace in terms of parts ($1,500) and labor ($1,500) and MINI does not sell the sensor separately as it is embedded in the seat foam. The defective sensor does not recognize a passenger sitting in the passenger seat and deactivates the passenger airbag which is an essential, lifesaving device fitted to a small vehicle. When involved in a major vehicle collision, without a working airbag, the risk of fatality drastically increases. The sensor is also responsible for NOT deploying the airbag if a passenger under 100lbs is sitting in the seat ie. a child. Again, this is a massive safety concern especially due to other owners resorting to a cheap aftermarket bypass module which will always deploy the airbag. This solution could seriously injure or cause fatalities for passengers under 100lbs. Other MINI models with the same electronic occupancy sensor problems have had recalls issued by the NHTSA and has not issued recalls for vehicles with the same issue consistently. It is the NHTSA's responsibility to hold the manufacturer accountable for ALL vehicle models with similar defects impacting the safe and consistent operation of life preservation devices such as airbags especially when repair costs for these defective devices are cost prohibitive for vehicle owners to replace.

NHTSA complaint #11577181 — an unverified report by a vehicle owner.

SEAT BELTS

Seat belt warning for passenger seat stays on despite buckling the seat belt. I suspect the air bag deployment is therefore not functioning.

NHTSA complaint #11564726 — an unverified report by a vehicle owner.

SEAT BELTS

The footwell module that controls the lights, brake lights windows and dashboard is faulty on all mini cooper of this module. Every time I change my battery or disconnect it the module brakes and the dealership knows this problem and still want to charge 1300 dollars to fix it it is a safety and hazard issue.

NHTSA complaint #11562296 — an unverified report by a vehicle owner.

SEAT BELTS

What component or system failed or malfunctioned, and is it available for inspection upon request? THE AIRBAG LIGHT KEEPS COMING ON AND OFF, AS WELL AS THE SEATBELT LIGHTS. IT CAN BE INSPECTED IF REQUESTED. How was your safety or the safety of others put at risk? IF THE AIRBAGS OR SEAT BELTS ARE NOT FUNCTIONING PROPERLY THIS COULD RESULT IN INJURY UP TO AND INCLUDING DEATH. Has the problem been reproduced or confirmed by a dealer or independent service center? IT KEEPS HAPPENING, NOT BEEN TO A DEALER YET THOUGH. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NO INPSECTION HAS BEEN DONE. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? IT APPEARS THAT THE SUNROOF HAS BEEN LEAKING DOWN THE DASH ON THE PASSENEGER SIDE. THAT LEAKS RIGHT ONTO THE FUSE BOX WHICH COULD BE CAUSING SOME OF THE ISSUES. IF THE FUSE BOX IS BEING LEAKED ONTO THIS COULD BE A POTENTIAL FIRE HAZARD.

NHTSA complaint #11555327 — an unverified report by a vehicle owner.

SEAT BELTS

Restraint System Malfunction Fault in passenger-restraint system effecting airbag, belt tensioner or belt-force limiter. Having to replace passenger seat or sensor to indicate I have a passenger so the airbag will deploy. It looks like there may have been a recall for this in the past according to an article I found, but my VIN does not come up as needing this item replaced. Cost is approximately $800.

NHTSA complaint #11547285 — an unverified report by a vehicle owner.

SEAT BELTS

Passenger seat occupancy sensor failure. This is a very common fault in the R56 series Mini Cooper. The manufacture has not initiated a recall. There are vendors selling "bypass" kits which will cause unsafe air bag deployment in an infant is in the seat.

NHTSA complaint #11530391 — an unverified report by a vehicle owner.

SEAT BELTS

Lights come on & off for airbags and or seat belts - randomly - unknown as to why - or if they are working - sometimes stay on - for 2 weeks - then go off and not on for quite awhile (weeks) brought up as to -why? with no resolution except may need repair? Does not seem to make sense - no accidents or even close to an accident ever occurring- local driving - car maintained.

NHTSA complaint #11521218 — an unverified report by a vehicle owner.

SEAT BELTS

There have been at least 7 write-ups about air bag failure on this model reported to you. When a passenger sits in the seat of my car, with the seat belt on, 01 the airbag light and seat belt light come on. If I have an accident the airbag on the passenger side will not deploy, leading to death or injury to the passenger. This has been reported to a MINI dealership. They will inspect it at my cost to see if it rates as a safety item. It is available for inspection as I can't drive it with a passenger and I can't leave my disabled wife alone at home. The car has 92323 miles on it. [XXX]--- [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11505013 — an unverified report by a vehicle owner.

SEAT BELTS

When passenger is seated with safety belt on the seat belt light comes on along with a message that the passenger seat air bag will not deploy.

NHTSA complaint #11494448 — an unverified report by a vehicle owner.

SEAT BELTS

The lighting and small system computer or FRM module. This module controls any features including safety features on the car. My turn signals, hazard lights, dash lights, courtesy lights, tail lights, windows, horn, high beam headlights and possibly airbags don’t work. Mini will fix the problem if the car is ten years old or less, but any car that is older doesn’t qualify. My car is a 2011 but I bought it new in 2012. They refuse to fix it and the repair cost is around $2000. I have had so many other problems with my car that have cost me several thousands of dollars and I feel like Mini should fix this problem considering these are safety features that could result in injury or death.

NHTSA complaint #11429910 — an unverified report by a vehicle owner.

SEAT BELTS

2007 mini cooper s airbag light with warning on navigation screen saying seat belt tensioner or belt force limiter has a problem and passenger airbag is off. Odometer is 76,000 when problem started.

NHTSA complaint #11427021 — an unverified report by a vehicle owner.

SEAT BELTS

TL* THE CONTACT OWNS A 2009 MINI COOPER. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE AIR BAG AND THE SEAT BELT WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR INDEPENDENT MECHANIC TO BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 156,000.

NHTSA complaint #11407243 — an unverified report by a vehicle owner.

SEAT BELTS

MINI COOPER BASE MODEL WITH 90K MILES HAS SEAT BELT AND AIR BAG WARNING LIGHTS ILLUMINATED. WARNING LIGHTS STARTED INTERMITTENTLY GOING ON AND OFF AND NOW STAY ILLUMINATED CONTINOUSLY WHEN IGNITION IS ON. NO VEHICLE ACCIDENTS OR INCIDENTS TO CAUSE THIS PROBLEM.

NHTSA complaint #11377428 — an unverified report by a vehicle owner.

SEAT BELTS

RECENTLY PURCHASED A USED 2008 MINI COOPER. PASSENGER SIDE AIRBAG SENSOR WARNING LIGHT IS ON AND ALWAYS STAYS ON. THIS IS A KNOWN DEFECT THAT MINI HAS COVERED UNDER WARRANTY/RECALL. I TOOK VEHICLE TO BMW/MINI DEALER IN BIRMINGHAM, AL AND WAS INFORMED THAT THIS PARTICULAR RECALL EXPIRED IN 2018, OR WITH VEHICLES WITH MORE THAN 120,000 MILES. MINE HAS 123,000 MI. ALSO CALLED MINI CUSTOMER SERVICE AND RECEIVED THE SAME INFORMATION. MANY VIDEOS EXIST ON INTERNET/YOUTUBE ABOUT THIS PARTICULAR DEFECT AND HOW TO BYPASS PROBLEM BY INSTALLING A PART THAT BYPASSES THE SENSOR OR BY USING A SCAN TOOL TO ERASE THE CODE TO REMOVE THE WARNING LIGHT. NEITHER OF THESE SOLUTIONS SEEM SAFE. I AM CONCERNED THAT THE CAR'S PASSENGER AIRBAG WOULD FAIL TO DEPLOY IN THE EVENT OF A COLLISION. HERE IS A VIDEO THAT EXPLAINS THE PROBLEM AND A POSSIBLE UNSAFE FIX: HTTPS://WWW.YOUTUBE.COM/WATCH?V=GDLMTYGUIPM&T=615S

NHTSA complaint #11341850 — an unverified report by a vehicle owner.