Owners have filed 193 complaints
about the 2009 Mini Cooper with NHTSA between 2010 and 2026.
The largest single group is the airbags.
Across this model's run it ranks 7 of 19 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 65
Against the median year of the Mini Cooper. 50 means typical for this
model; 100 means roughly double.
Severity — 67
13% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 31
18% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
10.7%
1,000 – 9,999 miles
32.0%
10,000 – 24,999 miles
106.8%
25,000 – 49,999 miles
2819.0%
50,000 – 74,999 miles
4832.7%
75,000 – 99,999 miles
2315.6%
100,000 – 149,999 miles
2617.7%
150,000+ miles
85.4%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Feb 2010peak 9Aug 2026
Recalls on the 2009 Mini Cooper
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202328121,319 units in Canada
Electrical
Issue: On certain vehicles, the footwell module (FRM) may become contaminated by a mixture of salt and moisture inside the vehicle. Over time, this can lead to corrosion that could cause a short circuit. Safety Risk: A short circuit can create a fire risk, even while the vehicle is parked and turned off. Corrective actions: BMW will notify owners by mail. The corrective actions for this recall are under development. BMW advises that you should park your vehicle outdoors and away from other vehicles or structures until the recall repairs have been completed.
Recall 201854418,468 units in Canada
Electrical
On certain vehicles, the footwell module (FRM3) may become contaminated by a mixture of salt and moisture which could lead to corrosion over time. This could cause a short circuit, resulting in overheating of the module that could lead to a fire causing injury and/or damage to property. Correction: Dealers will inspect the footwell module, and replace if necessary. A protective film will be also installed over the module. Note: Owners are advised to park the vehicle outdoors until the recall repairs have been completed.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 140,000 milesBullhead City, AZFire3 injured
ELECTRICAL SYSTEM
The contact owned a 2009 Mini Cooper. The contact stated that after the vehicle was unoccupied and parked in the residential garage, she was putting her children down for a nap and 2 minutes later, the contact and her husband smelled smoke within the residence, shortly afterward it was discovered that the garage was engulfed in flames. The contact called 911 and evacuated her family of 2 dogs, and 2 minor children. The contact sustained injuries to both arms, both legs and her rear end up to her back. The husband sustained bruises right leg and back. The contact's toddler son sustained a bruise from running into the wall in the residence. No medical attention was sought. The contact mentioned that 1 of the dogs sustained abnormal breathing injuries. The police and fire departments arrived on the scene, and the firefighters extinguished the fire. The fire consumed the vehicle in the garage and resulted in damage to the residence. Police and fire department reports were filed. The contact does not have the fire report, yet, and was currently being worked by the chief of the fire department. The vehicle currently remained on the scene. The insurance company deemed the vehicle and her home totaled. The manufacturer was not made aware of the failure. The failure mileage was 125,000.
NHTSA complaint #11638081 — an unverified report by a vehicle owner.
Ada, MIFire
ELECTRICAL SYSTEM
MINI was totally destroyed by fire after driving for 15 minutes. It was parked in a parking lot and was in flames 5 minutes after my wife entered the store. This is comparable with problem requiring recall (with no remedy). No warnings
NHTSA complaint #11533682 — an unverified report by a vehicle owner.
Ada, MIFire
ENGINE
MINI was totally destroyed by fire after driving for 15 minutes. It was parked in a parking lot and was in flames 5 minutes after my wife entered the store. This is comparable with problem requiring recall (with no remedy). No warnings
NHTSA complaint #11533682 — an unverified report by a vehicle owner.
at 120,000 milesSeattle, WAFire
STEERING
HELLO, YESTERDAY AFTERNOON I STARTED MY 2009 MINI COOPER AND NOTED THAT MY GAUGES SUDDENLY FAILED. THE TACH DROPPED TO ZERO. SUDDENLY I RECEIVED A TIRE PRESSURE WARNING LIGHT. I DECIDED I WOULD MOVE THE CAR TO A MORE FAVORABLE LOCATION TO LOOK UNDER THE HOOD. AS I PLACED THE CAR IN REVERSE I NOTED THAT MY POWER STEERING HAD FAILED. I STOPPED THE CAR IMMEDIATELY AND POPPED THE HOOD. I IMMEDIATELY NOTICED THE SMELL OF BURNING ELECTRICAL EQUIPMENT. I RAN DOWN TO THE BASEMENT TO GRAB A WRENCH TO DISCONNECT THE BATTERY. WHEN I RETURNED I COULD HEAR POPS AND CRACKS AND NOTED CHAR ON THE HOOD INTERIOR. THOUGH THE KEYS WERE OUT I CONTINUED TO HEAR POPS AND CRACKS AND FELT HEAT ACCUMULATING . I FINALLY GOT THE BATTERY DISCONNECTED AND THE POPPING STOPPED. AFTER SOME INVESTIGATION I FOUND THAT THE WIRING NEAR THE POWER STEERING MODULE WAS COMPLETELY BURNT OUT. THE CAR DROVE FINE THE DAY PRIOR. MY WIFE IS 38 WEEKS PREGNANT AND I AM SHAKEN BY THE IDEA THAT THIS COULD HAVE HAPPENED WHILE SHE WAS DRIVING THE DAY BEFORE.
NHTSA complaint #11269786 — an unverified report by a vehicle owner.
at 120,000 milesSeattle, WAFire
ELECTRICAL SYSTEM
HELLO, YESTERDAY AFTERNOON I STARTED MY 2009 MINI COOPER AND NOTED THAT MY GAUGES SUDDENLY FAILED. THE TACH DROPPED TO ZERO. SUDDENLY I RECEIVED A TIRE PRESSURE WARNING LIGHT. I DECIDED I WOULD MOVE THE CAR TO A MORE FAVORABLE LOCATION TO LOOK UNDER THE HOOD. AS I PLACED THE CAR IN REVERSE I NOTED THAT MY POWER STEERING HAD FAILED. I STOPPED THE CAR IMMEDIATELY AND POPPED THE HOOD. I IMMEDIATELY NOTICED THE SMELL OF BURNING ELECTRICAL EQUIPMENT. I RAN DOWN TO THE BASEMENT TO GRAB A WRENCH TO DISCONNECT THE BATTERY. WHEN I RETURNED I COULD HEAR POPS AND CRACKS AND NOTED CHAR ON THE HOOD INTERIOR. THOUGH THE KEYS WERE OUT I CONTINUED TO HEAR POPS AND CRACKS AND FELT HEAT ACCUMULATING . I FINALLY GOT THE BATTERY DISCONNECTED AND THE POPPING STOPPED. AFTER SOME INVESTIGATION I FOUND THAT THE WIRING NEAR THE POWER STEERING MODULE WAS COMPLETELY BURNT OUT. THE CAR DROVE FINE THE DAY PRIOR. MY WIFE IS 38 WEEKS PREGNANT AND I AM SHAKEN BY THE IDEA THAT THIS COULD HAVE HAPPENED WHILE SHE WAS DRIVING THE DAY BEFORE.
NHTSA complaint #11269786 — an unverified report by a vehicle owner.
at 120,000 milesSeattle, WAFire
ENGINE
HELLO, YESTERDAY AFTERNOON I STARTED MY 2009 MINI COOPER AND NOTED THAT MY GAUGES SUDDENLY FAILED. THE TACH DROPPED TO ZERO. SUDDENLY I RECEIVED A TIRE PRESSURE WARNING LIGHT. I DECIDED I WOULD MOVE THE CAR TO A MORE FAVORABLE LOCATION TO LOOK UNDER THE HOOD. AS I PLACED THE CAR IN REVERSE I NOTED THAT MY POWER STEERING HAD FAILED. I STOPPED THE CAR IMMEDIATELY AND POPPED THE HOOD. I IMMEDIATELY NOTICED THE SMELL OF BURNING ELECTRICAL EQUIPMENT. I RAN DOWN TO THE BASEMENT TO GRAB A WRENCH TO DISCONNECT THE BATTERY. WHEN I RETURNED I COULD HEAR POPS AND CRACKS AND NOTED CHAR ON THE HOOD INTERIOR. THOUGH THE KEYS WERE OUT I CONTINUED TO HEAR POPS AND CRACKS AND FELT HEAT ACCUMULATING . I FINALLY GOT THE BATTERY DISCONNECTED AND THE POPPING STOPPED. AFTER SOME INVESTIGATION I FOUND THAT THE WIRING NEAR THE POWER STEERING MODULE WAS COMPLETELY BURNT OUT. THE CAR DROVE FINE THE DAY PRIOR. MY WIFE IS 38 WEEKS PREGNANT AND I AM SHAKEN BY THE IDEA THAT THIS COULD HAVE HAPPENED WHILE SHE WAS DRIVING THE DAY BEFORE.
NHTSA complaint #11269786 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 90,000 milesDaytona Beach, FL
ELECTRICAL SYSTEM
The contact owns a 2009 Mini Cooper. The contact stated that while driving approximately 65 MPH at night, the exterior lights started flickering and started to become inoperable. The contact pulled over to the side of the road, turned off the vehicle, removed the battery terminals, and performed a master reset. After the master reset, there was an abnormal clicking sound inside the vehicle. The contact restarted the vehicle and drove to the residence. After arriving to the residence, the failure reoccurred. The vehicle was parked and turned. The vehicle was then taken to a certified mechanic to be diagnosed, and it was determined that the relays inside the junction box used to control several of the electronic features had become inoperable. The mechanic suggested that the vehicle not be driven. The vehicle was not repaired. The manufacturer was informed of the failure and confirmed that the vehicle was not under recall. The failure mileage was approximately 90,000.
NHTSA complaint #11754946 — an unverified report by a vehicle owner.
Columbia, SC
SEATS
The seatbelt and air bag warning light for the passenger front seat stays on.
NHTSA complaint #11698274 — an unverified report by a vehicle owner.
Columbia, SC
SEAT BELTS
The seatbelt and air bag warning light for the passenger front seat stays on.
NHTSA complaint #11698274 — an unverified report by a vehicle owner.
Columbia, SC
AIR BAGS
The seatbelt and air bag warning light for the passenger front seat stays on.
NHTSA complaint #11698274 — an unverified report by a vehicle owner.
at 92,000 milesKaty, TX
AIR BAGS
The contact owns a 2009 Mini Cooper. The contact stated that while driving at an undisclosed speed, the seat belt warning light illuminated even though there was no passenger seated in the passenger’s seat. The contact stated that the warning light remained illuminated with the passenger’s seat occupied and the seat belt properly fastened. The vehicle was taken to an independent mechanic, but was not diagnosed or repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The failure mileage was approximately 92,000.
NHTSA complaint #11684570 — an unverified report by a vehicle owner.
Montgomery, AL
ELECTRICAL SYSTEM
When it rains, my car seems to have a short circuit and all the electrical components start going crazy, mainly the windows, locks and indoor lights/dash. There is an active recall for the same problem and car model but mine doesn't seem to fit the recall I am not sure why.
NHTSA complaint #11677585 — an unverified report by a vehicle owner.
Brown Deer, WI
EXTERIOR LIGHTING
My car has had an exterior lighting problem related to a bad FRM. This is causing my lights not to work. After seeking help, I saw that there was an actual recall on the FRM and I decided to take my car to International Mini dealership in Wisconsin. Once there, they proceeded to only fix the leak on sunroof. I then went back and explained that the leak had caused actual damage to the FRM and connectors and they told me to leave the car for another night. Next day I went to pick it up and they gave me the paperwork stating that they had replaced and reprogrammed the FRM but the problem persist. The connector on the FRM are also water corroded and they just refuse to do anything else to the car. I can’t drive my car due to the safety hazard of not having any exterior lights working.
NHTSA complaint #11654250 — an unverified report by a vehicle owner.
Brown Deer, WI
ELECTRICAL SYSTEM
My car has had an exterior lighting problem related to a bad FRM. This is causing my lights not to work. After seeking help, I saw that there was an actual recall on the FRM and I decided to take my car to International Mini dealership in Wisconsin. Once there, they proceeded to only fix the leak on sunroof. I then went back and explained that the leak had caused actual damage to the FRM and connectors and they told me to leave the car for another night. Next day I went to pick it up and they gave me the paperwork stating that they had replaced and reprogrammed the FRM but the problem persist. The connector on the FRM are also water corroded and they just refuse to do anything else to the car. I can’t drive my car due to the safety hazard of not having any exterior lights working.
NHTSA complaint #11654250 — an unverified report by a vehicle owner.
at 150,000 milesBrown Deer, WI
ELECTRICAL SYSTEM
The contact owns a 2009 Mini Cooper. The contact stated that the headlights, taillights, and the turn signal lights were inoperable. The vehicle was repaired under NHTSA Campaign Number: 23V337000 (ELECTRICAL SYSTEM); but the repair failed to fix the vehicle. The contact stated that several unknown warning lights had remained illuminated after the recall repair. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 150,000.
NHTSA complaint #11648826 — an unverified report by a vehicle owner.
at 140,000 milesBullhead City, AZFire3 injured
ELECTRICAL SYSTEM
The contact owned a 2009 Mini Cooper. The contact stated that after the vehicle was unoccupied and parked in the residential garage, she was putting her children down for a nap and 2 minutes later, the contact and her husband smelled smoke within the residence, shortly afterward it was discovered that the garage was engulfed in flames. The contact called 911 and evacuated her family of 2 dogs, and 2 minor children. The contact sustained injuries to both arms, both legs and her rear end up to her back. The husband sustained bruises right leg and back. The contact's toddler son sustained a bruise from running into the wall in the residence. No medical attention was sought. The contact mentioned that 1 of the dogs sustained abnormal breathing injuries. The police and fire departments arrived on the scene, and the firefighters extinguished the fire. The fire consumed the vehicle in the garage and resulted in damage to the residence. Police and fire department reports were filed. The contact does not have the fire report, yet, and was currently being worked by the chief of the fire department. The vehicle currently remained on the scene. The insurance company deemed the vehicle and her home totaled. The manufacturer was not made aware of the failure. The failure mileage was 125,000.
NHTSA complaint #11638081 — an unverified report by a vehicle owner.
Ephrata, PA
ELECTRICAL SYSTEM
See attached document for complaint.
NHTSA complaint #11629733 — an unverified report by a vehicle owner.
Lafayette, CO
ELECTRICAL SYSTEM
The contact owns a 2009 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11602800 — an unverified report by a vehicle owner.
Miami, FL
ELECTRICAL SYSTEM
My car started acting up when it rains and all the electrical goes crazy, all the lights turning on and off and all the locks opening and closing and it seems to have short-circuit and drained my battery, car left me stranded twice in the middle of the street. No electrical wire seems to be exposed and was informed it might be a footwell module issue, I see there is a recall happening yet my vehicle doesn't seem to be included eventhough it fits the specs and the has the same issues.
NHTSA complaint #11600524 — an unverified report by a vehicle owner.
Austin, TX
SEATS
The passenger occupancy seat sensor is defective (as reported by many other owners of this vehicle model). The sensor is very costly to replace in terms of parts ($1,500) and labor ($1,500) and MINI does not sell the sensor separately as it is embedded in the seat foam. The defective sensor does not recognize a passenger sitting in the passenger seat and deactivates the passenger airbag which is an essential, lifesaving device fitted to a small vehicle. When involved in a major vehicle collision, without a working airbag, the risk of fatality drastically increases. The sensor is also responsible for NOT deploying the airbag if a passenger under 100lbs is sitting in the seat ie. a child. Again, this is a massive safety concern especially due to other owners resorting to a cheap aftermarket bypass module which will always deploy the airbag. This solution could seriously injure or cause fatalities for passengers under 100lbs. Other MINI models with the same electronic occupancy sensor problems have had recalls issued by the NHTSA and has not issued recalls for vehicles with the same issue consistently. It is the NHTSA's responsibility to hold the manufacturer accountable for ALL vehicle models with similar defects impacting the safe and consistent operation of life preservation devices such as airbags especially when repair costs for these defective devices are cost prohibitive for vehicle owners to replace.
NHTSA complaint #11577181 — an unverified report by a vehicle owner.
Austin, TX
SEAT BELTS
The passenger occupancy seat sensor is defective (as reported by many other owners of this vehicle model). The sensor is very costly to replace in terms of parts ($1,500) and labor ($1,500) and MINI does not sell the sensor separately as it is embedded in the seat foam. The defective sensor does not recognize a passenger sitting in the passenger seat and deactivates the passenger airbag which is an essential, lifesaving device fitted to a small vehicle. When involved in a major vehicle collision, without a working airbag, the risk of fatality drastically increases. The sensor is also responsible for NOT deploying the airbag if a passenger under 100lbs is sitting in the seat ie. a child. Again, this is a massive safety concern especially due to other owners resorting to a cheap aftermarket bypass module which will always deploy the airbag. This solution could seriously injure or cause fatalities for passengers under 100lbs. Other MINI models with the same electronic occupancy sensor problems have had recalls issued by the NHTSA and has not issued recalls for vehicles with the same issue consistently. It is the NHTSA's responsibility to hold the manufacturer accountable for ALL vehicle models with similar defects impacting the safe and consistent operation of life preservation devices such as airbags especially when repair costs for these defective devices are cost prohibitive for vehicle owners to replace.
NHTSA complaint #11577181 — an unverified report by a vehicle owner.
Austin, TX
AIR BAGS
The passenger occupancy seat sensor is defective (as reported by many other owners of this vehicle model). The sensor is very costly to replace in terms of parts ($1,500) and labor ($1,500) and MINI does not sell the sensor separately as it is embedded in the seat foam. The defective sensor does not recognize a passenger sitting in the passenger seat and deactivates the passenger airbag which is an essential, lifesaving device fitted to a small vehicle. When involved in a major vehicle collision, without a working airbag, the risk of fatality drastically increases. The sensor is also responsible for NOT deploying the airbag if a passenger under 100lbs is sitting in the seat ie. a child. Again, this is a massive safety concern especially due to other owners resorting to a cheap aftermarket bypass module which will always deploy the airbag. This solution could seriously injure or cause fatalities for passengers under 100lbs. Other MINI models with the same electronic occupancy sensor problems have had recalls issued by the NHTSA and has not issued recalls for vehicles with the same issue consistently. It is the NHTSA's responsibility to hold the manufacturer accountable for ALL vehicle models with similar defects impacting the safe and consistent operation of life preservation devices such as airbags especially when repair costs for these defective devices are cost prohibitive for vehicle owners to replace.
NHTSA complaint #11577181 — an unverified report by a vehicle owner.
at 100,000 milesIthaca, NY
ELECTRICAL SYSTEM
The contact owns a 2009 Mini Cooper. The contact stated that several electrical features had failed to operate as needed with several warning lights flickering on the instrument panel. The vehicle was taken to the dealer where it was confirmed that water and salt had entered the footwell circuit causing wiring corrosion. The contact was given an estimate for the repair. The contact then received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 100,000. VIN tool confirms parts not available.
NHTSA complaint #11575999 — an unverified report by a vehicle owner.
at 110,000 milesMinneapolis, MN
ELECTRICAL SYSTEM
The contact owns a 2009 Mini Cooper Hardtop. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the remedy to do the recall repair was not yet available. The contact stated less than half the lights are working on the vehicle. The vehicle was taken to the dealer and it was confirmed that water and salt could enter the circuit and corrode and this service falls under the recall repair. The contact was informed the vehicle could be repaired if the contact paid out of pocket. The vehicle was not repaired due to cost. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The approximate failure mileage was 110,000.
NHTSA complaint #11571729 — an unverified report by a vehicle owner.
Canaan, NH
VEHICLE SPEED CONTROL
This has a major recall and won’t pass inspection. Engine light is on . I’ve called dealership and was told parts are on back order . Last year I was told the same thing before I received a letter in the mail.
NHTSA complaint #11569949 — an unverified report by a vehicle owner.
Canaan, NH
UNKNOWN OR OTHER
This has a major recall and won’t pass inspection. Engine light is on . I’ve called dealership and was told parts are on back order . Last year I was told the same thing before I received a letter in the mail.
NHTSA complaint #11569949 — an unverified report by a vehicle owner.
Canaan, NH
ENGINE
This has a major recall and won’t pass inspection. Engine light is on . I’ve called dealership and was told parts are on back order . Last year I was told the same thing before I received a letter in the mail.
NHTSA complaint #11569949 — an unverified report by a vehicle owner.
at 22,000 milesGreenville, WI
AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION:FRONT PASSENGER
The contact owns a 2009 Mini Cooper. The contact stated while driving approximately 30 MPH, the passenger occupant sensor light illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the mat switch needed to be replaced. The vehicle was not repaired. The contact was advised by the dealer that there was a recall for the mat switch however, neither the VIN nor the vehicle was included. The manufacturer was informed of the failure. The failure mileage was approximately 22,000.
NHTSA complaint #11569241 — an unverified report by a vehicle owner.
at 102,000 milesLafayette, CO
ELECTRICAL SYSTEM
The contact owns a 2009 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The contact stated that the windows failed to roll up or down intermittently. The manufacturer was made aware of the issue. The approximate failure mileage was 102,000. VIN tool confirms parts not available.
NHTSA complaint #11564174 — an unverified report by a vehicle owner.
Olympia, WA
ELECTRICAL SYSTEM
The car horn was going off randomly. I inspected the interior electrical panel on the passenger side of the car and it was damp. There is water getting into the passenger side of the car and infiltrating the panel causing this one issue and likely others. There is a recall for this problems in some places, but my vehicle is not included, currently.
NHTSA complaint #11553589 — an unverified report by a vehicle owner.
at 70,000 milesTomkins Cove, NY
ELECTRICAL SYSTEM
The contact owns a 2009 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the parking brake warning light and the tire pressure warning light was illuminated. Additionally, the contact stated that after the front driver’s and passenger side doors were closed, the windows failed to readjust. The vehicle was not diagnosed or repaired. An undisclosed dealer was contacted and confirmed that parts were not available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000. VIN tool confirms parts not available.
NHTSA complaint #11545250 — an unverified report by a vehicle owner.