Owners have filed 93 complaints
about the 2017 RAM Promaster with NHTSA between 2017 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 3 of 11 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 57
Against the median year of the RAM Promaster. 50 means typical for this
model; 100 means roughly double.
Severity — 50
9.7% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 80
47% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
24.4%
1,000 – 9,999 miles
1328.9%
10,000 – 24,999 miles
511.1%
25,000 – 49,999 miles
1022.2%
50,000 – 74,999 miles
511.1%
75,000 – 99,999 miles
613.3%
100,000 – 149,999 miles
24.4%
150,000+ miles
24.4%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Feb 2017peak 8May 2026
Recalls on the 2017 RAM Promaster
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
20V582000
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
Prime-Time Specialty Vehicles (Prime-Time) is recalling certain 2014-2019 Paratransit vehicles equipped with 3.6L engines. The transmission shifter cable may separate and disconnect from the transmission, causing the vehicle to not perform shifts intended by the driver and the gear shift lever position not matching the actual transmission gear.
Risk: The driver may be unaware of the actual gear position and unintended vehicle movement can occur, increasing the risk of a crash.
20V036000
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
Chrysler (FCA US LLC) is recalling certain 2014-2019 Ram ProMaster vehicles equipped 3.6L engines. The transmission shifter cable may separate and disconnect from the transmission, causing the vehicle to not perform shifts intended by the driver and the gear shift lever position not matching the actual transmission gear.
Risk: The driver may be unaware of the actual gear position and unintended vehicle movement can occur, increasing the risk of a crash.
19V818000
EQUIPMENT:APPLIANCE:AIR CONDITIONER
Chrysler (FCA US LLC) is recalling certain 2015-2018 Ram ProMaster vehicles equipped with 3.0L diesel or 3.6L gasoline engines and air conditioning (A/C). The engine cooling fan may seize which can cause the cooling fan motor to overheat.
Risk: An overheated fan motor increases the risk of a fire.
19V333000
SEATS
New England Wheels (New England) is recalling certain 2014-2018 Ford Transit and 2014-2019 Ram Promaster 2500 and 3500 vehicles modified to be equipped with Freedman Go-ES Foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Risk: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
19V313000
SEATS
Mobility Transportation Services (MobilityTrans) is recalling certain 2014-2018 Ford Transit and Ram Promaster vehicles and 2014-2015 Ford Econoline vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Risk: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
19V332000
SEATS
Prime-Time Specialty Vehicles (Prime-Time) is recalling certain 2016-2018 Ram ProMaster and Ford Transit vehicles modified to be equipped with Freedman GO-ES Foldaway Seats. When the seat back cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Risk: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
17V824000
EQUIPMENT
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Risk: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
17V786000
EQUIPMENT
Midwest Automotive Designs, LLC (Midwest) is recalling certain Custom Vans and Camper Van recreational vehicles built on 2014-2017 Mercedes Benz Sprinter chassis and 2016-2017 RAM Promaster chassis. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' fire extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Risk: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2024548314,717 units in Canada
Label
Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". Canadian regulations require the information to be listed on the label in both English and French. Safety Risk: This error does not affect vehicle safety. Corrective Actions: This is not a recall. The company has corrected the tire and loading information label for all new vehicles.
Recall 202120038 units in Canada
Label
Issue: On certain wheelchair-accessible vehicles, the compliance label has incomplete information. Also, the tire and loading information label may not have been updated to include the new seating capacity and the maximum weight of occupants and cargo. This could lead to overloading of the vehicle and cause poor handling or a tire failure. Safety Risk: Overloading of the vehicle could cause a loss of control and result in a crash. Corrective Actions: Dynamic Specialty Vehicles will mail new compliance and tire and loading information labels to each owner, along with instructions for how to install them.
Recall 202002219,877 units in Canada
Powertrain
Issue: On certain vehicles equipped with a 3.6 L engine, the transmission gear shift cable may have been damaged during vehicle assembly. As a result, the shift cable could disconnect from the transmission. If this happens, the transmission will not shift gears when the shift lever is moved. If a driver attempts to exit the vehicle while the transmission is not in the Park position, and the parking brake is not applied, the vehicle could move suddenly. Safety Risk: Sudden and unexpected movement of the vehicle could increase the risk of a crash. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealer to replace the transmission shift cable.
Recall 20195788,095 units in Canada
Electrical
Issue: On certain vehicles equipped with air conditioning (A/C), the engine cooling fan could potentially stall or seize. This could cause the cooling fan circuit to overheat. In some cases, this may cause the Check Engine and/or the Engine Temperature Malfunction Indicator Lights to turn on. Safety Risk: A cooling fan circuit that overheats could increase the risk of a fire. Corrective Actions: FCA will notify owners by mail and instruct you to take your vehicle to a dealer to replace the engine cooling fan module.
Recall 20176637,391 units in Canada
Accessories
On certain vehicles equipped with the Roadside Emergency Kit containing a Kidde fire extinguishers with black plastic handles and valves, the fire extinguishers may become clogged or require excessive force to activate. Also, the nozzle may detach from the valve assembly with enough force that it could cause injury, and fail to discharge. In case of fire, failure of the extinguisher to function could result in injury and/or property damage. Correction: Dealers will replace the suspect Kidde fire extinguisher with a new Kidde fire extinguisher with a steel nozzle. For more information about recalled fire extinguishers, please visit <a href="https://inmarmarketaction.com/kidde/Kidde284CA/">www.kidde.com</a>.
Recall 20172269,987 units in Canada
Label
Certain vehicles may fail to comply with the requirements of Canada Motor Vehicle Safety Standard (CMVSS) 208 - Occupant Protection in Frontal Impacts. The sunvisor airbag warning label, User Guides and Owner’s Information DVDs incorrectly identify the vehicle’s passenger and driver frontal airbag systems as “Advanced Airbags”. In the event that occupants rely on the Owner’s Information or User Guide, they may position themselves closer to the airbag than they would if compliant information regarding the airbag system had been provided, which may increase the risk of injury to a front seat occupant in a crash where frontal airbag deployment is warranted. Correction: FCA Canada will provide vehicle owners with a supplement to the Owner’s Information DVD and User Guide to reflect the use of non-advanced airbags. Additionally, FCA Canada will also provide a replacement sunvisor airbag warning label to identify airbags as non-advanced.
Reports where the owner recorded a crash, a fire, an injury or a death.
Somerville, ALCrash
ENGINE
Went to use the brakes and they would not work. Had to swerve into a ditch to stop. ABS and Traction issue.
NHTSA complaint #11634291 — an unverified report by a vehicle owner.
Somerville, ALCrash
SERVICE BRAKES
Went to use the brakes and they would not work. Had to swerve into a ditch to stop. ABS and Traction issue.
NHTSA complaint #11634291 — an unverified report by a vehicle owner.
at 85,000 milesSt. Simons, GAFire
ELECTRICAL SYSTEM
The contact owned a 2017 Ram 2500. The contact stated that after parking the vehicle in the parking lot of a residential building and turning the engine off, approximately 36 hours later the contact was alerted by the property manager that the vehicle was on fire. The fire department was called to the scene and extinguished the flames. During the failure, the vehicle was destroyed. A fire report was taken at the scene and the vehicle was towed to a local holding yard. The fire department indicated that the fire originated in the center dashboard of the vehicle. The exact cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The contact referred to the NHTSA campaign number 19V818000 (Equipment, Engine, Engine Cooling) and indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 85,000.
NHTSA complaint #11527396 — an unverified report by a vehicle owner.
at 85,000 milesSt. Simons, GAFire
ENGINE AND ENGINE COOLING
The contact owned a 2017 Ram 2500. The contact stated that after parking the vehicle in the parking lot of a residential building and turning the engine off, approximately 36 hours later the contact was alerted by the property manager that the vehicle was on fire. The fire department was called to the scene and extinguished the flames. During the failure, the vehicle was destroyed. A fire report was taken at the scene and the vehicle was towed to a local holding yard. The fire department indicated that the fire originated in the center dashboard of the vehicle. The exact cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The contact referred to the NHTSA campaign number 19V818000 (Equipment, Engine, Engine Cooling) and indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 85,000.
NHTSA complaint #11527396 — an unverified report by a vehicle owner.
at 85,000 milesSt. Simons, GAFire
EQUIPMENT
The contact owned a 2017 Ram 2500. The contact stated that after parking the vehicle in the parking lot of a residential building and turning the engine off, approximately 36 hours later the contact was alerted by the property manager that the vehicle was on fire. The fire department was called to the scene and extinguished the flames. During the failure, the vehicle was destroyed. A fire report was taken at the scene and the vehicle was towed to a local holding yard. The fire department indicated that the fire originated in the center dashboard of the vehicle. The exact cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The contact referred to the NHTSA campaign number 19V818000 (Equipment, Engine, Engine Cooling) and indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 85,000.
NHTSA complaint #11527396 — an unverified report by a vehicle owner.
at 70,000 milesDingmans Ferry, PAFire
STRUCTURE:BODY
The contact owned a 2017 Ram Promaster 3500. The contact stated that after parking the vehicle on the side of his house, he received an alert from a sensor camera attached to his home. When the contact checked the alert, he saw that the vehicle had caught fire. The contact immediately called the fire department and they were able to extinguish the fire once they arrived. No injuries were reported. The contact sustained property damage side of his garage and the siding of the garage had become warped due to the fire. The vehicle had yet to be removed from the property and had been deemed a total loss. The contact posted pictures of his damaged vehicle to an online forum and the manufacturer reached out to him for assistance. The contact was asked if he would like a team to come to his home to investigate the cause of the failure; the contact had yet to make arraignments for the finding. The contact stated that the rear passenger side of the trailer; however, the cause of the failure had yet to be determined. The failure mileage was approximately 70,000.
NHTSA complaint #11452127 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Conshohocken, PA
ENGINE
COMPONENT FAILED: Left transmission mount bracket and its fasteners on a 2017 RAM ProMaster with 3.6L V6 Pentastar (sales code ERB) and 62TE 6-speed automatic (sales code DG2). At least one bracket-to-transaxle bolt sheared. The bracket separated from the transmission, the powertrain dropped on the driver side, the left front CV axle pulled out of the transaxle, and transmission fluid loss occurred. The transmission case casting also appears cracked at the bracket mounting boss. All failed components are preserved and available for inspection. SAFETY RISK: Failure occurred during LOW-SPEED MANEUVERING. Had it occurred at highway speed, the dropped powertrain and separated front drive axle could have caused loss of vehicle control, sudden disabling of the vehicle in traffic, and roadway debris from dragging components. Industry-published cases describe identical failures at 40+ mph (Certified Transmission, May 2019). Multiple owner reports of the same failure exist for 2015-2021 ProMasters. CONFIRMED BY: Failure confirmed by visual inspection at an independent service facility. The failure mode matches FCA Service Bulletin 23-022-19 (8/27/2019), which warns the bracket fasteners are torque-to-yield, single-stage, one-time use, and that reuse can lead to bracket bolt failure. The TSB is classified Information Only — no recall has been issued. INSPECTED BY: Inspected by the owner and an independent repair technician. Not yet inspected by the manufacturer, police, or insurance. The vehicle had recent service in the transmission area; whether the one-time-use fasteners specified by the TSB were replaced during that service is under investigation. WARNING SIGNS: None. No warning lamps, messages, or symptoms preceded the failure. Given the documented failure mode, manufacturer service bulletin, and multiple owner reports of identical failures across model years, a formal investigation into a potential safety recall is requested.
NHTSA complaint #11738594 — an unverified report by a vehicle owner.
Odometer Fraud. The contact purchased a 2017 Ram Promaster 1500. The vehicle was purchased on February 16, 2024. The contact stated that at the time of purchase, the mileage was 84,000. The vehicle was taken to Valvoline, where the odometer was reported in 2018 February 2023 at 346,000. The contact purchased a Carfax report, which indicated that the mileage was 346,544 in January 2023. In addition, the dealer was made aware of the discrepancy, and the contact was informed that the vehicle would be collected, and the sale would be voided; however, the down payment would not be returned.
NHTSA complaint #11719802 — an unverified report by a vehicle owner.
Camano, WA
ENGINE AND ENGINE COOLING
The contact owns a 2017 Ram Promaster 3500. The contact received notification of NHTSA Campaign Number: 19V818000 (Equipment, Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11662389 — an unverified report by a vehicle owner.
Camano, WA
EQUIPMENT
The contact owns a 2017 Ram Promaster 3500. The contact received notification of NHTSA Campaign Number: 19V818000 (Equipment, Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11662389 — an unverified report by a vehicle owner.
Powell, OH
POWER TRAIN
I am the original owner of a 2017 Dodge ProMaster made by Chrysler. My vehicle is currently at a dealership waiting for a complete transmission. I had to have it towed there as this issue happened while I was driving. Luckily, I was not far from home. The van is no longer under warranty at 5 years or100,000 miles. I purchased it new in May 2018. It has only 37000 miles on the odometer. There was a recall unrelated to this problem and fixed. In the beginning I had to Contact Chrysler Customer Service per my dealer who gave me their Customer Care number. I was given a case number by a lower Chrysler representative, who then had me talk to her supervisor. This representative said that there was no forwarding phone contact number for their complaint department and she gave me an address with a US mail PO Box for Chrysler in Auburn Hills, MI. No transmission should go out at 37,000 miles. My dealer is charging me $9000 USD for the transmission repair! A review of social media (Facebook) by various ProMaster owners has lead me to contact you. Groups on Facebook such as ProMaster Owners and Roadtrek ProMaster Class B RV owners have complained about transmissions going out. From what I understand, Chrysler has recalled vehicles from 2019 model years up through maybe 2023, for transmission issues. Why the 2018 model year was not included is beyond me. It is also my understanding that Chrysler is now building a completely new transmission for vehicles built since the current model year. Previous owners like me will have to settle fro re-manufactured transmissions from Chrysler. I am sure the NHTSB has been contacted by people like me. There are hundreds of us with transmission issues which can be considered driving safety issues.
NHTSA complaint #11650681 — an unverified report by a vehicle owner.
San Rafael, CA
STEERING
The windshield cowl on this vehicle is poorly designed, allowing water intrusion from multiple points. This is not a minor leak but a severe design flaw that creates immediate and dangerous safety hazards while driving, particularly at highway speeds. The most critical issue is water pouring directly onto the serpentine belt and pulley system. While driving at highway speeds in heavy rain, I lost power steering after water intrusion caused the belt to slip. This sudden loss of steering assist made the vehicle extremely difficult to control, especially in traffic and during turns. Another major safety risk is water intrusion onto the engine fuse box. While driving at highway speeds, water poured into the fuse box, causing electrical shorting. This led to severe overheating that burned my windshield wiper wiring, making the wipers inoperable and drastically reducing visibility. Surrounding wires also melted, posing a significant fire hazard. The sudden electrical failure and loss of visibility created an extremely dangerous situation. Additionally, water pooling on the transmission can drain into the breather hole, allowing significant water intrusion into the transmission fluid. This can cause erratic shifting, transmission failure, or complete power loss. At highway speeds, this can lead to sudden deceleration or loss of acceleration, putting drivers and others at serious risk. This issue has been experienced by multiple owners and confirmed by independent service centers. It is not a DIY repair—the defective cowl design allows excessive water ingress. There are no warning lights or messages before failure, only sudden and dangerous symptoms once water intrudes. This is a major safety concern, particularly at highway speeds, where sudden power steering loss, electrical failure, or transmission issues can lead to catastrophic consequences. Immediate investigation and corrective action are necessary to prevent accidents, injuries, or fatalities.
NHTSA complaint #11648025 — an unverified report by a vehicle owner.
San Rafael, CA
ELECTRICAL SYSTEM
The windshield cowl on this vehicle is poorly designed, allowing water intrusion from multiple points. This is not a minor leak but a severe design flaw that creates immediate and dangerous safety hazards while driving, particularly at highway speeds. The most critical issue is water pouring directly onto the serpentine belt and pulley system. While driving at highway speeds in heavy rain, I lost power steering after water intrusion caused the belt to slip. This sudden loss of steering assist made the vehicle extremely difficult to control, especially in traffic and during turns. Another major safety risk is water intrusion onto the engine fuse box. While driving at highway speeds, water poured into the fuse box, causing electrical shorting. This led to severe overheating that burned my windshield wiper wiring, making the wipers inoperable and drastically reducing visibility. Surrounding wires also melted, posing a significant fire hazard. The sudden electrical failure and loss of visibility created an extremely dangerous situation. Additionally, water pooling on the transmission can drain into the breather hole, allowing significant water intrusion into the transmission fluid. This can cause erratic shifting, transmission failure, or complete power loss. At highway speeds, this can lead to sudden deceleration or loss of acceleration, putting drivers and others at serious risk. This issue has been experienced by multiple owners and confirmed by independent service centers. It is not a DIY repair—the defective cowl design allows excessive water ingress. There are no warning lights or messages before failure, only sudden and dangerous symptoms once water intrudes. This is a major safety concern, particularly at highway speeds, where sudden power steering loss, electrical failure, or transmission issues can lead to catastrophic consequences. Immediate investigation and corrective action are necessary to prevent accidents, injuries, or fatalities.
NHTSA complaint #11648025 — an unverified report by a vehicle owner.
San Rafael, CA
VISIBILITY/WIPER
The windshield cowl on this vehicle is poorly designed, allowing water intrusion from multiple points. This is not a minor leak but a severe design flaw that creates immediate and dangerous safety hazards while driving, particularly at highway speeds. The most critical issue is water pouring directly onto the serpentine belt and pulley system. While driving at highway speeds in heavy rain, I lost power steering after water intrusion caused the belt to slip. This sudden loss of steering assist made the vehicle extremely difficult to control, especially in traffic and during turns. Another major safety risk is water intrusion onto the engine fuse box. While driving at highway speeds, water poured into the fuse box, causing electrical shorting. This led to severe overheating that burned my windshield wiper wiring, making the wipers inoperable and drastically reducing visibility. Surrounding wires also melted, posing a significant fire hazard. The sudden electrical failure and loss of visibility created an extremely dangerous situation. Additionally, water pooling on the transmission can drain into the breather hole, allowing significant water intrusion into the transmission fluid. This can cause erratic shifting, transmission failure, or complete power loss. At highway speeds, this can lead to sudden deceleration or loss of acceleration, putting drivers and others at serious risk. This issue has been experienced by multiple owners and confirmed by independent service centers. It is not a DIY repair—the defective cowl design allows excessive water ingress. There are no warning lights or messages before failure, only sudden and dangerous symptoms once water intrudes. This is a major safety concern, particularly at highway speeds, where sudden power steering loss, electrical failure, or transmission issues can lead to catastrophic consequences. Immediate investigation and corrective action are necessary to prevent accidents, injuries, or fatalities.
NHTSA complaint #11648025 — an unverified report by a vehicle owner.
Somerville, ALCrash
ENGINE
Went to use the brakes and they would not work. Had to swerve into a ditch to stop. ABS and Traction issue.
NHTSA complaint #11634291 — an unverified report by a vehicle owner.
Somerville, ALCrash
SERVICE BRAKES
Went to use the brakes and they would not work. Had to swerve into a ditch to stop. ABS and Traction issue.
NHTSA complaint #11634291 — an unverified report by a vehicle owner.
Los Angeles, CA
UNKNOWN OR OTHER
There’s already a recall on the engine cooling fans. I was driving on the freeway when the cooling g fans failed causing overheating and major damage to the engine, specifically the head gasket, thermostat, and radiator. I took it to the dealer after finding out about the recall. They replaced the fans but are still not working correctly. They also refused to repair the other damages that were caused due to the recall part failure. I use my vehicle for work and have been unable to work for more than 2 weeks now due to the damages and have had to decline a lot of work in that time. This is affecting my livelihood. So far the dealer and manufacturer have only wanted to charge me for any additional diags or repairs when my vehicle was running great until this incident. The vehicle is unsafe to drive and the recall report stated the engine could catch fire. I took my vehicle to the dealer, a second time to see what they could do for me, Just to find out, they only wanted to charge me for multiple diagnostic diagnosis and would have me wait. At least a week before they could even begin touching my vehicle also refusing to give me a loaner vehicle in the meantime.
NHTSA complaint #11614481 — an unverified report by a vehicle owner.
Los Angeles, CA
ELECTRICAL SYSTEM
There’s already a recall on the engine cooling fans. I was driving on the freeway when the cooling g fans failed causing overheating and major damage to the engine, specifically the head gasket, thermostat, and radiator. I took it to the dealer after finding out about the recall. They replaced the fans but are still not working correctly. They also refused to repair the other damages that were caused due to the recall part failure. I use my vehicle for work and have been unable to work for more than 2 weeks now due to the damages and have had to decline a lot of work in that time. This is affecting my livelihood. So far the dealer and manufacturer have only wanted to charge me for any additional diags or repairs when my vehicle was running great until this incident. The vehicle is unsafe to drive and the recall report stated the engine could catch fire. I took my vehicle to the dealer, a second time to see what they could do for me, Just to find out, they only wanted to charge me for multiple diagnostic diagnosis and would have me wait. At least a week before they could even begin touching my vehicle also refusing to give me a loaner vehicle in the meantime.
NHTSA complaint #11614481 — an unverified report by a vehicle owner.
Los Angeles, CA
ENGINE
There’s already a recall on the engine cooling fans. I was driving on the freeway when the cooling g fans failed causing overheating and major damage to the engine, specifically the head gasket, thermostat, and radiator. I took it to the dealer after finding out about the recall. They replaced the fans but are still not working correctly. They also refused to repair the other damages that were caused due to the recall part failure. I use my vehicle for work and have been unable to work for more than 2 weeks now due to the damages and have had to decline a lot of work in that time. This is affecting my livelihood. So far the dealer and manufacturer have only wanted to charge me for any additional diags or repairs when my vehicle was running great until this incident. The vehicle is unsafe to drive and the recall report stated the engine could catch fire. I took my vehicle to the dealer, a second time to see what they could do for me, Just to find out, they only wanted to charge me for multiple diagnostic diagnosis and would have me wait. At least a week before they could even begin touching my vehicle also refusing to give me a loaner vehicle in the meantime.
NHTSA complaint #11614481 — an unverified report by a vehicle owner.
Los Angeles, CA
UNKNOWN OR OTHER
What happened: While driving on the freeway, the engine cooling fans failed, causing the engine temperature to rise excessively and increasing pressure within the cooling system. This resulted in a hole being blown through the thermostat, and all the coolant leaked out. Only after the coolant was lost did the engine overheating warning lamp come on. I safely pulled over, but the engine had already overheated severely. I was unable to drive the vehicle for a week while waiting for the dealer to replace the cooling fans under the recall. After the recall repair was completed, I picked up my vehicle from the dealer. On my way home, I noticed a loss of power, poor acceleration, and engine shaking, especially after the engine had been off for a few hours. I replaced the thermostat and radiator myself, but I believe the overheating caused internal engine damage, potentially a blown head gasket, cracked, or warped heads. Additionally, before taking the vehicle back to the dealer, I noticed the newly installed cooling fans (replaced under the recall) stopped working again. Despite all these issues clearly being related to the initial fan failure and overheating, the dealer is now charging me for further repairs and is not addressing the underlying problem with the cooling system. The fact that the cooling fans have a recall due to failure and have caused other issues are trying to tell me I’m responsible. They wouldn’t give me a loaner vehicle while they were performing the initial recall repair or now since I’ve taken it back.
NHTSA complaint #11614112 — an unverified report by a vehicle owner.
Los Angeles, CA
ELECTRICAL SYSTEM
What happened: While driving on the freeway, the engine cooling fans failed, causing the engine temperature to rise excessively and increasing pressure within the cooling system. This resulted in a hole being blown through the thermostat, and all the coolant leaked out. Only after the coolant was lost did the engine overheating warning lamp come on. I safely pulled over, but the engine had already overheated severely. I was unable to drive the vehicle for a week while waiting for the dealer to replace the cooling fans under the recall. After the recall repair was completed, I picked up my vehicle from the dealer. On my way home, I noticed a loss of power, poor acceleration, and engine shaking, especially after the engine had been off for a few hours. I replaced the thermostat and radiator myself, but I believe the overheating caused internal engine damage, potentially a blown head gasket, cracked, or warped heads. Additionally, before taking the vehicle back to the dealer, I noticed the newly installed cooling fans (replaced under the recall) stopped working again. Despite all these issues clearly being related to the initial fan failure and overheating, the dealer is now charging me for further repairs and is not addressing the underlying problem with the cooling system. The fact that the cooling fans have a recall due to failure and have caused other issues are trying to tell me I’m responsible. They wouldn’t give me a loaner vehicle while they were performing the initial recall repair or now since I’ve taken it back.
NHTSA complaint #11614112 — an unverified report by a vehicle owner.
Los Angeles, CA
ENGINE
What happened: While driving on the freeway, the engine cooling fans failed, causing the engine temperature to rise excessively and increasing pressure within the cooling system. This resulted in a hole being blown through the thermostat, and all the coolant leaked out. Only after the coolant was lost did the engine overheating warning lamp come on. I safely pulled over, but the engine had already overheated severely. I was unable to drive the vehicle for a week while waiting for the dealer to replace the cooling fans under the recall. After the recall repair was completed, I picked up my vehicle from the dealer. On my way home, I noticed a loss of power, poor acceleration, and engine shaking, especially after the engine had been off for a few hours. I replaced the thermostat and radiator myself, but I believe the overheating caused internal engine damage, potentially a blown head gasket, cracked, or warped heads. Additionally, before taking the vehicle back to the dealer, I noticed the newly installed cooling fans (replaced under the recall) stopped working again. Despite all these issues clearly being related to the initial fan failure and overheating, the dealer is now charging me for further repairs and is not addressing the underlying problem with the cooling system. The fact that the cooling fans have a recall due to failure and have caused other issues are trying to tell me I’m responsible. They wouldn’t give me a loaner vehicle while they were performing the initial recall repair or now since I’ve taken it back.
NHTSA complaint #11614112 — an unverified report by a vehicle owner.
Peoria, AZ
ENGINE
Both cams need to be replaced. Upon doing internet research and talking with the service advisor this is a very commom problem and recalls have been done on other years but not 2017. Henry Miller Dodge Ram is where my vehicle is currently at and who advised the issues at hand. The check engine light comes on and computer shows misfire.
NHTSA complaint #11573013 — an unverified report by a vehicle owner.
at 85,000 milesSt. Simons, GAFire
ELECTRICAL SYSTEM
The contact owned a 2017 Ram 2500. The contact stated that after parking the vehicle in the parking lot of a residential building and turning the engine off, approximately 36 hours later the contact was alerted by the property manager that the vehicle was on fire. The fire department was called to the scene and extinguished the flames. During the failure, the vehicle was destroyed. A fire report was taken at the scene and the vehicle was towed to a local holding yard. The fire department indicated that the fire originated in the center dashboard of the vehicle. The exact cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The contact referred to the NHTSA campaign number 19V818000 (Equipment, Engine, Engine Cooling) and indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 85,000.
NHTSA complaint #11527396 — an unverified report by a vehicle owner.
at 85,000 milesSt. Simons, GAFire
ENGINE AND ENGINE COOLING
The contact owned a 2017 Ram 2500. The contact stated that after parking the vehicle in the parking lot of a residential building and turning the engine off, approximately 36 hours later the contact was alerted by the property manager that the vehicle was on fire. The fire department was called to the scene and extinguished the flames. During the failure, the vehicle was destroyed. A fire report was taken at the scene and the vehicle was towed to a local holding yard. The fire department indicated that the fire originated in the center dashboard of the vehicle. The exact cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The contact referred to the NHTSA campaign number 19V818000 (Equipment, Engine, Engine Cooling) and indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 85,000.
NHTSA complaint #11527396 — an unverified report by a vehicle owner.
at 85,000 milesSt. Simons, GAFire
EQUIPMENT
The contact owned a 2017 Ram 2500. The contact stated that after parking the vehicle in the parking lot of a residential building and turning the engine off, approximately 36 hours later the contact was alerted by the property manager that the vehicle was on fire. The fire department was called to the scene and extinguished the flames. During the failure, the vehicle was destroyed. A fire report was taken at the scene and the vehicle was towed to a local holding yard. The fire department indicated that the fire originated in the center dashboard of the vehicle. The exact cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The contact referred to the NHTSA campaign number 19V818000 (Equipment, Engine, Engine Cooling) and indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 85,000.
NHTSA complaint #11527396 — an unverified report by a vehicle owner.
The Villages, FL
ELECTRICAL SYSTEM
2017, 119,000 miles. 8/9/18: maintenance transmission service at 62,651 miles. 6/4/20 Recall WOO shifter cable replaced. 11/11/21 AGM Interstate battery MTX-49 replaced. ISSUE: End of May 2022 (~117,000 miles) had driven from Florida & back 2x without any problems but was slowing down by taking my foot off the gas for exit ramp - the engine started roaring louder & the vehicle apparently had shifted to ?neutral - pulled off the road & shifted to P & then to D & drove on home without any further problem. That was #1 occurrence & I took it to a transmission shop in July (had not had the problem again) to see what they thought. They did road test, fluid check & scan of control modules for trouble codes/errors & analyzed data stream for inconsistencies - found no error codes or inconsistencies. Incidentally, have been having some type of parasitic draw on my new battery for the past year. Occurrence #2: almost a year later April 2023 I am driving up to 55 mph running errands & I slow down to 45 mph & the engine starts to roar & the van is coasting & the light up area of P-R-N-D backlight is not lit up that is normally lit up & no check codes/warnings have appeared - everything else including front drivers light panel all normally lit. I pull off into a parking lot, put in park, turn it off, then turn back on (still with unlit gear display) & I put in drive & it runs normally around the parking lot & the remaining way home.I have driven it locally for 40-60 miles each time with intermittent stops for about 4-5 times since then & can’t replicate the problem again. Incidentally still parasitic draw on battery. 1) could replaced shifter cable be a problem? 2) fuse #38 problem causing loss of power to solenoids? 3) transmission range sensor failing causing it to fall out of gear? 4) transmission control module problem? 5) solenoid problem? 6) worn/broken transmission bands? 7) worn out gears? - some cause putting into “limp mode”? This is dangerous situation?
NHTSA complaint #11526688 — an unverified report by a vehicle owner.
The Villages, FL
ENGINE
2017, 119,000 miles. 8/9/18: maintenance transmission service at 62,651 miles. 6/4/20 Recall WOO shifter cable replaced. 11/11/21 AGM Interstate battery MTX-49 replaced. ISSUE: End of May 2022 (~117,000 miles) had driven from Florida & back 2x without any problems but was slowing down by taking my foot off the gas for exit ramp - the engine started roaring louder & the vehicle apparently had shifted to ?neutral - pulled off the road & shifted to P & then to D & drove on home without any further problem. That was #1 occurrence & I took it to a transmission shop in July (had not had the problem again) to see what they thought. They did road test, fluid check & scan of control modules for trouble codes/errors & analyzed data stream for inconsistencies - found no error codes or inconsistencies. Incidentally, have been having some type of parasitic draw on my new battery for the past year. Occurrence #2: almost a year later April 2023 I am driving up to 55 mph running errands & I slow down to 45 mph & the engine starts to roar & the van is coasting & the light up area of P-R-N-D backlight is not lit up that is normally lit up & no check codes/warnings have appeared - everything else including front drivers light panel all normally lit. I pull off into a parking lot, put in park, turn it off, then turn back on (still with unlit gear display) & I put in drive & it runs normally around the parking lot & the remaining way home.I have driven it locally for 40-60 miles each time with intermittent stops for about 4-5 times since then & can’t replicate the problem again. Incidentally still parasitic draw on battery. 1) could replaced shifter cable be a problem? 2) fuse #38 problem causing loss of power to solenoids? 3) transmission range sensor failing causing it to fall out of gear? 4) transmission control module problem? 5) solenoid problem? 6) worn/broken transmission bands? 7) worn out gears? - some cause putting into “limp mode”? This is dangerous situation?
NHTSA complaint #11526688 — an unverified report by a vehicle owner.
Aurora, CO
POWER TRAIN
Was not notified that my Ram Promaster 2017 needed two recalls when purchasing it from an official Ram dealership in 2020 with 35k miles on it. Now, at 90k miles I'm having to replace a radiator and cables that failed as a result of the coolant fan being replaced. Took it to two separate shops (first shop couldn't lift it) which both confirmed that my radiator experienced failure and caused electrical faults including blowing a 60amp fuse because this part was not replaced. I never was notified by Ram over the phone regarding this issue or from the dealership I purchased it from. Now, I'm having to pay a lot out of pocket to repair these parts (because I can't get my vehicle into any Ram dealership in the area for over a month) and having a third party, high quality mechanic do the repairs instead. I had to also pay to have the vehicle towed to the shop at my own expense as the vehicle had the check engine light on and was deemed by the first mechanic to not be safe to drive. I will upload files of the repair costs once the repairs are complete. $315 tow, $300 in diagnosing fees that won't be covered, and $1600 out of pocket for repairs is what I'm looking at. If I didn't have a 3rd party extended warranty, it would cost me close to $5k for repairs.
NHTSA complaint #11525077 — an unverified report by a vehicle owner.
Aurora, CO
ELECTRICAL SYSTEM
Was not notified that my Ram Promaster 2017 needed two recalls when purchasing it from an official Ram dealership in 2020 with 35k miles on it. Now, at 90k miles I'm having to replace a radiator and cables that failed as a result of the coolant fan being replaced. Took it to two separate shops (first shop couldn't lift it) which both confirmed that my radiator experienced failure and caused electrical faults including blowing a 60amp fuse because this part was not replaced. I never was notified by Ram over the phone regarding this issue or from the dealership I purchased it from. Now, I'm having to pay a lot out of pocket to repair these parts (because I can't get my vehicle into any Ram dealership in the area for over a month) and having a third party, high quality mechanic do the repairs instead. I had to also pay to have the vehicle towed to the shop at my own expense as the vehicle had the check engine light on and was deemed by the first mechanic to not be safe to drive. I will upload files of the repair costs once the repairs are complete. $315 tow, $300 in diagnosing fees that won't be covered, and $1600 out of pocket for repairs is what I'm looking at. If I didn't have a 3rd party extended warranty, it would cost me close to $5k for repairs.
NHTSA complaint #11525077 — an unverified report by a vehicle owner.
Aurora, CO
ENGINE
Was not notified that my Ram Promaster 2017 needed two recalls when purchasing it from an official Ram dealership in 2020 with 35k miles on it. Now, at 90k miles I'm having to replace a radiator and cables that failed as a result of the coolant fan being replaced. Took it to two separate shops (first shop couldn't lift it) which both confirmed that my radiator experienced failure and caused electrical faults including blowing a 60amp fuse because this part was not replaced. I never was notified by Ram over the phone regarding this issue or from the dealership I purchased it from. Now, I'm having to pay a lot out of pocket to repair these parts (because I can't get my vehicle into any Ram dealership in the area for over a month) and having a third party, high quality mechanic do the repairs instead. I had to also pay to have the vehicle towed to the shop at my own expense as the vehicle had the check engine light on and was deemed by the first mechanic to not be safe to drive. I will upload files of the repair costs once the repairs are complete. $315 tow, $300 in diagnosing fees that won't be covered, and $1600 out of pocket for repairs is what I'm looking at. If I didn't have a 3rd party extended warranty, it would cost me close to $5k for repairs.
NHTSA complaint #11525077 — an unverified report by a vehicle owner.