106 of the
1,331 complaints filed about the Subaru Ascent
are about the engine —
8% of everything owners reported.
The worst model year for it is 2019.
My 2021 Subaru Ascent (40,000 miles) suffered multiple major mechanical failures that pose ongoing safety concerns: 1. Engine Oil Leak: The vehicle developed an active engine oil leak at 20,000 miles, posing a risk of fluid contacting hot exhaust/engine components under the hood or causing low oil levels during operation. Repair time more than 35 days due to parts not available. 2. Loose Factory Engine Mounts: At 25,000 miles, excessive engine shifting, vibration when braking, the dealer discovered loose engine mounts. 3. Transmission Valve Body Failure: At 40,000 miles The transmission Valve Body Failure and need replacement.
NHTSA complaint #11753410 — an unverified report by a vehicle owner.
Oil leaking from upper and lower oil pan. Oil seeping from head gasket and CVT chain pump cover. RTV sealant failure. $4800 to repair. Subaru needs to solve these oil leak issues. Leaking oil is bad for the environment and engine failure could cause accidents and injury.
NHTSA complaint #11749720 — an unverified report by a vehicle owner.
On May 14, 2026, while driving a 2021 Subaru Ascent (approx. 94,291 miles) on a Texas expressway at highway speed during rush hour, I experienced a sudden and significant loss of engine power. There were no warning lights, no safety system activation, and no advance indication of the failure. The vehicle decelerated abruptly with traffic behind it. Live OBD-II data was being logged during the drive and was provided to the service advisor at the authorized Subaru retailer. This incident occurred only 3 days and approximately 125 miles after the vehicle was returned following a major engine repair performed at an authorized Subaru retailer in Texas under active powertrain warranty. That repair was supervised by a Subaru of America District Quality Manager and Field Technical Specialist, who conducted a 110-mile validation drive prior to release. Prior to the highway failure, visible fluid leaks were documented across the intake ducting, residue on lower engine components, a sweet and burning odor after driving, and milky sludge returning to the coolant reservoir — all within 125 miles of pickup. These are consistent with ongoing oil and coolant cross-contamination, which was the original diagnosis documented in the dealership's digital service portal. The vehicle has now undergone three major engine teardowns since March 17, 2026 — over 100 days out of service — for the same underlying powertrain issue on the FA24 engine. The current repair involves cylinder heads sent to a third-party machine shop. Vehicle telematics confirm the vehicle has not been started since May 27, 2026. This report is filed to establish a federal safety record of the highway power loss incident and the recurring nature of this powertrain failure. An active Subaru of America customer advocacy case is on file regarding this vehicle.
NHTSA complaint #11746580 — an unverified report by a vehicle owner.
The front exhaust pipe on my 2022 Subaru Ascent cracked at approximately 77,800 miles. The component is available for inspection. Prior to diagnosis, I noticed a rattle/fluttering noise coming from the undercarriage during acceleration. The problem was confirmed by an authorized Subaru dealership. Subaru has issued TSB 09-106-23 acknowledging this is a known design defect affecting 2019-2023 Ascents, and has redesigned the part to correct the issue. Despite being within the 8 year/80,000 mile federal emissions warranty period, the dealership denied warranty coverage, claiming coverage only applies in California and Maryland. This is incorrect - the federal emissions warranty applies nationwide. The dealership quoted over $1,000 out of pocket for a known manufacturing defect on a 4 year old vehicle. The cracked exhaust pipe poses a safety risk as exhaust fumes can enter the vehicle cabin. I am requesting NHTSA to investigate whether Subaru is improperly denying federal emissions warranty claims on affected vehicles outside of California and Maryland.
NHTSA complaint #11746584 — an unverified report by a vehicle owner.
The contact owns a 2022 Subaru Ascent. The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated. The vehicle experienced a loss of power steering assist, the speedometer was inoperable, and the transmission failed to shift into gear. The vehicle was taken to an independent mechanic, who inspected the brakes and reset the check engine warning light, but the failure persisted. The vehicle was then taken to the dealer, who determined that the rear radar sensor module beneath the rear bumper had corrosion from car wash or road salt. The dealer replaced the rear radar sensor module and sealed it with silicone. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 60,000.
NHTSA complaint #11746149 — an unverified report by a vehicle owner.
31 May 2026 (AM) Operating vehicle north on MD Rte 147 traveling appr. 45 MPH when vehicle started experiencing uncontrolled electrical activation of features e.g., heat, air, radio, main display. This proceed a shuddering in the drive train like one would experience with a transmission issue. Then, without warning, while at full speed, there was a complete loss of engine power i.e., it turned off, which also resulted in loss of steering and breaking resulting in a complete loss of control of the vehicle. As the vehicle drifted to a rolling stop, the main display indicated to turn off the vehicle and it was forced into park to stop it and then the ignition control button was pushed. The car was restarted and moved off the road. Subsequent restarts and terminations occurred without issue. No fault code was generated or captured by the vehicle computer and the dealer could not reproduce the problem.
NHTSA complaint #11741773 — an unverified report by a vehicle owner.
While pulling up to a drive thru window the vehicle shuddered and the engine shut off. I lost all power steering and had to come to a stop, shift into park, then restart the engine. No check engine lights or warnings illuminated. There were no status messages to indicate what caused it to shut off. Also the driver side mirror shakes a lot, just like all the other reports say.
NHTSA complaint #11740740 — an unverified report by a vehicle owner.
Exhaust "Nut" mysteriously went missing, causing noises, and Subaru technician stated to replace exhaust if issues persist. Vehicle was under warranty, only been serviced by certified Subaru technicians, and multi-point inspections were allegedly performed during every service, however, the exhaust "nut" were somehow still went missing.
NHTSA complaint #11738890 — an unverified report by a vehicle owner.
The pressure sensor coming out of the transmission has failed, and it's pushed transmission fluid throughout the engine harness, transmission harness, the bull harness in the dash and the 02 sensors. All of those have been damaged. The car is now unsafe to drive due to the pressure sensor failing. This information comes directly from the Subaru dealership. There was nothing prior to this that indicated there was a problem. I bought the car from a certified dealership 8 months ago and it was a certified pre owned vehicle.
NHTSA complaint #11738197 — an unverified report by a vehicle owner.
2023 Subaru Ascent, under manufacturer basic warranty. Factory OEM battery has repeatedly failed. Voltage drops below 11.5V in normal use. Three documented failures in six weeks. SAFETY INCIDENT: Vehicle died on a public street and became completely immobilized. Brake warning light activated. Vehicle would not move even after a jump start. Passengers had to exit in a live traffic lane. A second vehicle was used to transport a replacement battery. The original battery is in my possession and available for inspection. A subsequent failure occurred when the original battery was reinstalled for a manufacturer-required diagnostic. Vehicle again would not start. KNOWN DEFECT: Subaru TSB 07-213-22R (revised 03/28/24) covers the 2023-24 Ascent battery and acknowledges the factory specification as inadequate, directing dealers to replace the battery, tray, cover, and holding rod with higher-capacity parts. This TSB was not proactively applied to my vehicle. The dealer did not identify or disclose it at earlier service visits where the battery concern was reported and "could not be reproduced." No recall or proactive owner notification has been issued. Dealers are not applying the TSB preventively. A complaint is open with Subaru of America Customer Advocacy. The manufacturer has declined to reimburse the out-of-pocket emergency replacement and has required a dealer diagnostic that has been repeatedly blocked by manufacturer/dealer procedural requirements.
NHTSA complaint #11733168 — an unverified report by a vehicle owner.
I was driving and I got check engine light and all safety features disabled while I was in the freeway, luckily I was able to drive to nearby Subaru dealer for inspection and I found out that there was a recall on the engine for this vehicle and when I contacted the manufacturer they asked me to take it for diagnostics and I did that at a Subaru retailer, but the case manager told me that this recall is being completed for the previous owner of the vehicle and cannot help me with anything, which was never disclosed when I was buying the vehicle.
NHTSA complaint #11726964 — an unverified report by a vehicle owner.
The contact owns a 2019 Subaru Ascent. The contact stated that while his wife was driving at approximately 75 MPH, a deer ran across the highway and hit the left driver's side of the vehicle. The air bags did not deploy upon impact. A grayish smoke began to emit from the vehicle as the contact's wife immediately pulled off to the side of the road. Due to the damaged cause by the impact of the deer, the contact's wife had difficulty exiting the vehicle. The contact's wife used excessive force to open a crack in the door, which was enough to slide herself out of the vehicle. The vehicle became engulfed in flames soon after exiting the vehicle, and the authorities were called to the scene. The fire department arrived at the scene and managed to extinguish the fire. The contact's wife sustained bruising to her left shoulder, left leg, and left arm but did not seek medical attention. A police report was filed. The vehicle was initially towed to an independent tow yard and was later towed to an insurance holding facility. The contact stated that the vehicle was destroyed as a result of the fire, but the insurance adjuster had yet to determine a final ruling on the vehicle. Neither the dealer nor the manufacturer had yet been notified of the failure. The failure mileage was unknown.
NHTSA complaint #11726659 — an unverified report by a vehicle owner.
Oil Leak(s) (found cam carriers leaking, front timing cover leaking, oil cooler leaking, upper and lower oil pan leaking. recommend engine reseal). Massive oil leaks found in car due to RTV sealant. Subaru uses RTV silicone sealant (formed-in-place gaskets) instead of traditional rubber gaskets for many sealing surfaces (cam carriers to heads, timing cover, oil pans, etc.). Transmission failure at 37,000miles which needed replacement. In dealership service for 52 days at that time. Transmission symptoms continued after replacement. Car hesitates while accelerating making it dangerous to accelerate to speed needed to merge into traffic. Same transmission symptoms occurring now that were present prior to complete transmission failure in 11/2021 that left me in middle of busy freeway with a disabled car. Subaru not taking transmission symptoms seriously. Continuous brush off from service and Subaru. Car is a lemon. Subaru not standing by product. Oil should not be leaking from every orfice of engine.
NHTSA complaint #11719539 — an unverified report by a vehicle owner.
Car has 82,000 miles, has been maintained and requires an engine replacement due to 'Sludge'. Reading a lot of forums that indicate this is a common situation with this make and model and likely due to manufacturer's defects.
NHTSA complaint #11717930 — an unverified report by a vehicle owner.
The contact owns a 2019 Subaru Ascent. The contact stated that while the engine was idling, exhaust fumes entered the cabin of the vehicle. Additionally, immediately after starting the vehicle, there was a loud ticking sound coming from the exhaust system. The vehicle was inspected by the local dealer, and it was determined that the exhaust manifold lines were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 120,000.
NHTSA complaint #11717497 — an unverified report by a vehicle owner.
While driving my Subaru Ascent, a check engine warning light appeared on the dashboard. Shortly afterward, I noticed smoke coming from the engine compartment. I immediately pulled over and turned the vehicle off. Within moments, flames began coming from under the hood. The fire spread rapidly, and within 5-10 minutes the entire vehicle was fully engulfed in flames. The fire originated from the engine compartment. The vehicle was a total loss. Subaru of America was notified on 12/23/2025, but no follow-up or update on investigation has been responded. The vehicle was always serviced with Subaru. This sudden, traumatizing and catastrophic failure with no prior warning.
NHTSA complaint #11712180 — an unverified report by a vehicle owner.
The transmission on our 2021 Subaru Ascent is slipping and failing to accelerate, RPMs reving, and every issue indicator notification light is on. We took the car to our mechanic, then to the Subaru dealership service dept for diagnosis. A full transmission replacement is required plus associated repairs for a cost of $14,543.98. Service estimate attached. This repair is more than 2/3 of the value of the vehicle. This make/model and transmission type have documented problems and Subaru has previously issued an extended warranty on other model years for this same transmission issue. We are trying to communicate with the Subaru customer service but have had limited response due to the holidays and have not had a resolution yet in the past month.
NHTSA complaint #11710776 — an unverified report by a vehicle owner.
I hit a deer on CA 395 north, my braking system worked and my air bags deployed, and then my engine immediately caught fire. I’m lucky i was able to get out of the car through a back door. Every police and fire who responded said they have never seen a car catch fire after hitting a deer and i should report a vehicle malfunction
NHTSA complaint #11706345 — an unverified report by a vehicle owner.
The contact owns a 2020 Subaru Ascent. The contact stated that the vehicle was taken to the local dealer for routine service, where it was discovered that the cam carrier was leaking from the engine. While having an oil change, the mechanic informed the contact that there were no further leaks found. There were no warning lights illuminated. After driving and parking the vehicle, there was an abnormal odor of oil coming from the vehicle. The vehicle was taken to the local dealer, where it was diagnosed that an overhaul of the engine was needed. While driving, there was an abnormal oil-burning odor coming from the vehicle. The vehicle was taken to another local dealer, Adventure Subaru (2269 N Henbest Dr, Fayetteville, AR 72704), who confirmed there was no recall coverage for the failure. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 120,000.
NHTSA complaint #11697702 — an unverified report by a vehicle owner.