117 of the
12,381 complaints filed about the Subaru Outback
are about the wheels —
1% of everything owners reported.
The worst model year for it is 2018.
I am filing this complaint regarding the premature wear and replacement of all 4 tires on my 2024 Subaru Outback at approximately 30,000 miles. I believe the tire wear was excessive for a new vehicle and raises concerns about tire durability and vehicle safety. I am requesting that NHTSA document this complaint and review whether similar complaints have been reported. I have documentation service records and associated costs and can provide additional information. I also requested reimbursement from Subaru America (case #260709-1500515) which was denied. Subaru's response was to file a complaint with the tire manufacturer - Yokohama.
NHTSA complaint #11756969 — an unverified report by a vehicle owner.
The warning lights on our 2020 Subaru Outback have lit intermittently for the past 2 years. When bringing the vehicle into the dealer for service and oil changes, this was reported. Recently the TPMS light began to light intermittently. Tire pressure was checked and adjusted but the problem persisted. When we brought the vehicle in for service, it turned out that all tire pressure sensors needed to be replaced BUT the service techs identified other problems that surfaced JUST AS THE CAR WAS NOT COVERED BY WARRANTY - the most serious being an oil leak caused by FAILURE OF CAM CARRIER SEALS. This caused a dangerous condition where oil was leaking onto the engine and into the spark plugs. I find it odd that this EXPENSIVE issue was not discovered sooner. Subaru and only Subaru has been servicing this vehicle since new and they should have caught it.
NHTSA complaint #11751812 — an unverified report by a vehicle owner.
The CVT failed at 62 miles per hour on a busy interstate, XXX. This caused the drivetrain to lock. The car has been repaired and traded locally in [XXX]. The car was very difficult to steer with locked wheels in traffic. This was a rapid evasive manuver on a busy interstate. An undrivable vehicle on an interstate is life threatening to many. Flat bed driver told me I was lucky to steer off of lanes onto shoulder with four locked wheels. This incident put me in mild shock. The Subaru dealer had to replace the transmission. The dealer and Subaru Regional Rep. examined the CVT failure. It was outside of the 100,000-mile warranty by about 895 miles. Repair invoice attached. I did not have advanced warning of CVT failure. There were no warning lights on before the CVT failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11749073 — an unverified report by a vehicle owner.
I bought a brand new 2025 subaru outback in April of 2025. At first service (oil change and tire rotation) in Jan 2026, I complained that the vehicle keeps swerving left and right and Subaru of Ann Arbor said they will diagnose the i-Sight vehicle system and correct it. But right after delivery , i realized the steering had to be held at ~5 degrees to the right (off centered) to get the car go straight. I complained and I was made to bring the car in 3 times to Subaru of Ann arbor - only to go without a fix. The car fishtailed, the traction control system malfunctioned in normal roads and highways due to the steering angle error. I was asked my Subaru of Ann Arbor to not come there anymore and take it to a different dealership. I complained to Subaru of America (Customer advocacy) and they asked me to pick a different dealer - Lafontaine Subaru. Even there the technicians argued that the car is good and just did an alignment without fixing the steering angle error issue. The steering angle sensor is tied to the vehicle safety software controls, traction control system and safety systems such as lane keep. I have to keep the steering tilted to keep the vehicle in lanes and I am struggling to keep it safely within lanes since January 2026. Subaru of America has not intervened even after the 6th repair in 3 months as the problem is not fixed. the lives of my family including a [XXX] infant for whom I got the car is being threatened on a daily basis. I keep telling the urgency and grave danger and the last response from the second subaru dealer was this is the maximum we can do. I am feeling threatened as I paid a fortune for a new car and wanted to secure my infant and my family. Our safety has been disregarded despite multiple complaints and repairs in the first year of ownership. Mileage now is 6100 miles total. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11748229 — an unverified report by a vehicle owner.
Not really sure, I don’t remember. It’s a wooded area , lots of deer etc. But I honestly don’t remember I saw my car It it fully intact , all doors , hood,trunk Open, car starts too Only front drivers wheel is bent in and lowest part of front bumper needs repair
NHTSA complaint #11742914 — an unverified report by a vehicle owner.
Severe tramilining effect from tires. Risk of personal injury Tramilining effect confirmed by Courtesy Subaru, Rapid City and Heuberger Subaru Colorado Springs, CO. Inspected prior to accident right rear camber out of specification. No warning lights or messages from vehicle
NHTSA complaint #11645964 — an unverified report by a vehicle owner.
Vehicle had 45,000 miles on it when right rear wheel bearing failed. It was covered under 5 year/60,000 mile warranty and was repaired today by a certified Subaru dealer and I no longer have the bad part for inspection. Safety risks would be anything that occurs from a bad wheel bearing like wobble, seizing, overheating, and more damage to other drivetrain components. You could hear the wheel bearing noise at 20 mph constant while driving, only getting louder with increased speed. No warning lights were present on the dash. I feel like at 45,000 miles, a wheel bearing should not be failing.
NHTSA complaint #11637528 — an unverified report by a vehicle owner.
The contact owns a 2018 Subaru Outback. The contact stated upon inspecting the vehicle, he noticed all 4 wheels showed signs of cracks on the rims and spokes. The low-pressure tire warning light had illuminated. In addition, all tires required air frequently. The vehicle was not repaired. The local dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 84,000.
NHTSA complaint #11604022 — an unverified report by a vehicle owner.
The contact owns a 2018 Subaru Outback. The contact stated upon inspecting the vehicle, he noticed all 4 wheels showed signs of cracks on the rims and spokes. The low-pressure tire warning light had illuminated. In addition, all tires required air frequently. The vehicle was not repaired. The local dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 84,000.
NHTSA complaint #11604022 — an unverified report by a vehicle owner.
The car was built & sold new, with the rear suspension not aligned properly, and cannot be aligned to factory specifications. The car has been taken to 4 service stations, 3 Subaru dealer service repair shops, without being able to be aligned.after further investigation, I’ve found this to be a common problem for this vehicle type. I consider this Safety related due to the unusual tire wear & risk of tire failure.
NHTSA complaint #11582373 — an unverified report by a vehicle owner.
I have experienced premature rear brake wear and excessive tire wear. Issues with infotainment system and pre-collision braking system. (1) Regarding Tires: Performed all dealer recommended tire rotations and aligned vehicle when recommended. Needed new tires at 31,169 miles. Tires showed excessive inside wear. Bought new tires from a 3rd party shop and had alignment done with hunter alignment system. Showed rear right camber at -2.0. Subaru recommends -1.8 to 0.3. Rear camber is not adjustable on this model. Took vehicle back to dealer for brake job and they said camber was fine...there is a spec for a reason. Did not want to attempt to bring it in spec with aftermarket kits (i.e. adjustable cam bolt) or fix under warranty. (2) Regarding Brakes: Needed new brakes at 31,169 miles. Not covered under warranty and not what I would consider typical wear based on my driving style and my past experience with Subaru vehicles. If this is an expected side affect of the EBD system I would highly recommend Subaru consider ways of improving brake life on their vehicles. (3) I have the Onyx XT trim with navigation. Infotainment system is constantly glitchy. Examples include booting with blank black screen, failing to load, excessive lag while operating system or will freeze and beep repeatedly while buffing a menu selection. Also, had my car battery replaced under warranty within the first two years due to a bad battery. (4) Issues with ADAS system, specifically pre-collision breaking. This system is extremely sensitive and will over-react / take control in certain situations where I didn't need it to even when I was in the process of braking. Have had this system activate on the highway at high speeds while switching lanes on the highway or when having a vehicle merge quickly into my lane in front of me. Constantly, have to turn off this system which is a chore as this system is defaulted to always being on. Do not feel safe driving with this system on.
NHTSA complaint #11557430 — an unverified report by a vehicle owner.
Odd noise arising from Front driver side wheel while driving on the interstate at 70mph. No indicator/warning lights/messages. Noise became much louder prompting us to stop driving and inspect. One of the 5 lug studs had broken off. Two of the 5 lug nuts were loose enough to hand rotate. Once diagnosed, we tightened all 4 remaining lug nuts. After driving 15min on the interstate at reduced speed, the noise from the front driver side wheel returned. The car was slowly driven off the interstate and re-inspected. The lug nuts were loose again. At this point, I felt the car was unsafe to drive, so I and my two passengers had to find an alternative ride given our safety was at risk. We were about 200miles away from home. The car was towed to the Subaru dealership in Midlothian, Virginia (Hyman Bros) for further inspection/repair. The Subaru dealership repair team told me that the lug stud was corroded and snapped off. The same Subaru dealership had recently (2,500miles prior) serviced the car including tire rotation and inspection in which they report they inspect the lug studs and they were sufficient for driving.
NHTSA complaint #11552741 — an unverified report by a vehicle owner.
The camber on the right rear wheel is out of specification at -1.8 degrees. This causes the vehicle to constantly dart and sway on the highway and worsens at higher speeds >40mph. This erratic motion makes driving unstable. It is worse on grooved pavement. The manufacturer has measured the camber and showed the result as being out of specification but no fix was provided. Further they are saying that this is "how the vehicle is suppose to operate" There are no warning lamps and the lane control software was disabled. The Service department confirmed the erratic behavior when doing a test drive.
NHTSA complaint #11552693 — an unverified report by a vehicle owner.
Under 50,000 miles all 4 wheel bearings needed to be replaced. Under 50,000 miles all 4 struts needed to be replaced. The door key would not work , the dealer had to fix the mechanism. The passenger window stops working suddenly, the dealer has to reset it all the time. The car braked in the middle of highway two time, I was lucky that no one hit me in the back. Under 65,000 miles control arm broke and did $8,400 damage. Car would not let me in on one of the parking, dealer could no help. Subaru from India was able to unlock the car and make it active again. Car lane keep assistant is like drunk driver. The dealer told me, that I need to buy a newer car. I have been to dealer every month.
NHTSA complaint #11524895 — an unverified report by a vehicle owner.
In the morning of Jan 28th, I drove this car off highway(North bound MoPac) to the ramp to frontage road to 360 in Austin TX. the vehicle lost control out of sudden and crashed to the left side of the road. the accident caused total loss of the vehicle but luckily a>the passages and the the driver on the car are OK. b>no other vehicle was involved . As the drive of this vehicle , I feel the crash was so strange so later on I requested both insurance company (AAA) and Subaru to investigate the possibility of malfunctions of the car. AAA -- claim number 015641968 Subaru --case 230128-1800367 AAA claimed the total lost but refused to do further investigation. Subaru took my request in March. Early this month, Subaru said their finished the comprehensive inspection and simply claimed the car was running normal when the accident happened. They don't want to share any further information about what they've found and they also don't want the inspect technician to talk to me about the results. I would like ask NHTSA, as the regulatory authority, to look into the their inspection report to make sure this vehicle does not have any abnormalities as their claimed. Thanks!
NHTSA complaint #11523077 — an unverified report by a vehicle owner.
Wheel Lug bolts continue to snap off. Have had 5 so far and this could effect the ability of the wheel to stay attached to the vehicle. I have several friends with the same vehicle (different years) that have had the same issue multiple times. In 50 years of vehicle ownership have never had this happen once, let alone 5 times.
NHTSA complaint #11522605 — an unverified report by a vehicle owner.
This vehicle has 3 major issues that the dealership has not been able to resolve and are as follows: 1) Battery---is not able to hold charge. In early 2022, dealership replaced a new battery, however, the problem still exists. Battery size does not have the charge capacity REQUIRED to start the vehicle even less than 1 week of parking during warm weather months. 2) Heating System---has a defect, specially on driver side of the system. With seat and steering heating on, the vents on driver side emit uncontrollable hot air that forces the driver to shut the driver side heating system. During winter this is unreasonable! Did inform the dealership of this issue and were unable to resolve the problem as I understand was inherent with the design. This problem is likely to cause fire if electrical wires are exposed to the heat. 3)Tires---are supposed to be inflated with nitrogen, and this innovation is to maintain the tire pressures for most weather conditions. However, all of my five tires are unable to maintain the pressures. Did bring it to the attention of dealership at each service. However the problem still persists. Possible problem can be any of the following individually or in combination: a) Seal between the tire and rim is inadequate. b) Slow leakage in tire valves or c) Tires are of poor quality permitting air to escape from the body of the tires.
NHTSA complaint #11520961 — an unverified report by a vehicle owner.