2019 Subaru Outback problems

VISIBILITY

The contact owns a 2019 Subaru Outback. The contact stated that while driving at 70 MPH the front windshield cracked approximately 6 inches from the heat sensor, no warning lights were illuminated. The local dealer was contacted however the vehicle was not diagnosed as the contact was advised that the vehicles VIN was not included in a recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 40,250.

NHTSA complaint #11754601 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Driver controls for windows do not work for front windows .. Can not put windows down. Therefore if window on passenger side or driver side gets foggy, can not lower to see out Dealer has stated that there is dirt in window. Not dirt , bad window motor per my experience. This has been occurring for about 2/3 years.

NHTSA complaint #11751582 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The touch screen monitor which controls the audio system, navigation, phone, and other car systems has delaminated. It turns on and off, makes phone calls, switches car systems like the audio, and turns off navigation. At best, it is a very annoying distraction. At worst, it is a safety issue when the screen is making emergency phone calls, canceling navigation, or turning on and off constantly and beeping and causing distraction to the driver. It is possible to turn the entire screen off, but it then randomly comes back on. A safety recall has been issued for 2018 but not 2019 Subaru Outbacks. I strongly urge you to consider a safety recall for the 2019 Subaru Outback as the very common screen delamination is widely known and causing issues for many Subaru drivers. The issue began in the summer of 2025 and has continued to be an issue, and is getting worse.

NHTSA complaint #11748449 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

CAR WOULDN'T START IN PARKING LOT, 40K MILES. I NEVER TOOK THE CAR IN TO THE DEALER AND RECEIVED A NOTICE ABOUT A FUEL PUMP REPLACEMENT/RECALL/REPAIR. I DIAGNOSED THIS PROBLEM MYSELF. THE VIN LOOKUP ON SUBARUS WEBSITE SAYS THAT THE PROBLEM WAS ADDRESSED/REPAIRED WHEN IT CLEARLY WAS NOT AND I NEVER RECEIVED ANY PAPERWORK OR VERBAL STATEMENT FROM SUBARU SAYING THEY PERFORMED THAT WORK WHEN I WENT IN FOR AN OIL CHANGE OR TO REPAIR THE BATTERY PROBLEM. THE BATTERY STILL DRAINS EXTREMELY FAST AS WELL. SO NEITHER THE BATTERY CHARGING WORK, OR THE ***SUPPOSED AND UNVERIFIED*** FUEL PUMP WORK HAVE BEEN DONE ON THIS CAR. NOT GOOD. ALSO - THE ORIGINAL SUBARU EL CAJON DEALERSHIP CLOSED AND THEN REOPENED WITH "NEW OWNERSHIP" AS A SUBARU DEALERSHIP. THIS ALL APPEARS EXTREMELY CROOKED.

NHTSA complaint #11748189 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Vehicle battery continues to drain. Since I have owned the vehicle, it has had 4 batteries. It has had 2 batteries within the last year and half. Installed another battery a 2 weeks ago, vehicle was completely dead after a week of not driving. The last 3 batteries were all purchased (or warranty replaced, new. All forums are pointing to DCM for other years. Yet, 2019's have the same issue, and I haven't received any service bulletin regarding such issues. I presume they need to have a certain number of complaints before action is taken.

NHTSA complaint #11746098 — an unverified report by a vehicle owner.

ENGINE

I am reaching out regarding the cam carrier leak on my 2019 Subaru Outback. After researching this issue, I discovered that cam carrier leaks are extremely common among Subaru vehicles equipped with the boxer engine, especially Outbacks from this generation. Many owners have reported the same exact issue, often at relatively low mileage, with repair costs commonly ranging between $3000 - 5000 What has been most discouraging is learning that Subaru dealerships and technicians openly acknowledge how common this problem is, yet Subaru has not issued a recall or meaningful warranty extension to help loyal customers facing these expensive repairs. This does not appear to be caused by neglect or misuse, but rather by a known design issue involving the sealant used on the cam carriers.

NHTSA complaint #11736217 — an unverified report by a vehicle owner.

ENGINE

Front exhaust pipe bellows cracked, allowing exhaust gases including carbon monoxide to enter the passenger cabin. This is the same defect Subaru acknowledged in Service Program WUJ-95R (2015-2016 models) and Warranty Extension WI22-013 (2017-2018 Foresters). The failure pattern extends to 2019 model year vehicles and should be investigated for a recall expansion. This is a design flaw, consistent problem across multiple years, and a dangerous problem that needs to be addressed. My local Subaru dealer diagnosed and acknowledges the issue but won't cover it. Subaru of America won't cover the full cost--only 25%. Thank you for your help.

NHTSA complaint #11734436 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

Windshield window crack without any reason couple month ago and it keep crack bigger

NHTSA complaint #11723685 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2019 Subaru Outback. The contact stated that while driving at an undisclosed speed, the touch screen on the radio failed to properly operate. The screen was delaminated, causing unintended operation of the radio, distracting the driver. This failure caused the back over prevention to become inoperable, and the HVAC defroster options were inoperable. The touch screen and the functions were inoperable. The vehicle was taken to a dealer, where it was diagnosed with an electrical system failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 119,000.

NHTSA complaint #11721704 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

The contact owns a 2019 Subaru Outback. The contact stated that after the vehicle was not started for approximately five days, the battery was completely drained. The battery was replaced two years previously because of the same issue. The vehicle remained at the residence and the battery was charged. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 122,000.

NHTSA complaint #11721447 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Battery completely dead after 4 days of not driving; this is after I purchased a $210 brand new batteyr from Autozone. Looks like there is potential class action lawsuit based on the parasitic draw by the DCM unit. I need this repaired at Subaru's expense.

NHTSA complaint #11720185 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2019 Subaru Outback. The contact stated that while driving approximately 45 MPH, the accelerator pedal was depressed, and the vehicle hesitated and almost stalled. The failure was intermittent but caused the vehicle to stall on several occasions. The check engine warning light and the low oil pressure warning lights recently illuminated. The vehicle was taken to a local dealer, and the contact was informed that oil was leaking from the upper and lower oil pan, the head gasket, and other engine seals. The contact was aware that the vehicle was included in NHTSA Campaign Number: 21V587000 (Fuel System, Gasoline). The contact researched and became aware that a failure of the fuel pump could lead to other failures with the engine oil seals. The contact stated that the fuel pump had been ordered; however, the vehicle was not yet repaired. The manufacturer was informed of the failure. The failure mileage was approximately 82,000.

NHTSA complaint #11719040 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2019 Subaru Outback. The contact stated that while driving approximately 45 MPH, the accelerator pedal was depressed, and the vehicle hesitated and almost stalled. The failure was intermittent but caused the vehicle to stall on several occasions. The check engine warning light and the low oil pressure warning lights recently illuminated. The vehicle was taken to a local dealer, and the contact was informed that oil was leaking from the upper and lower oil pan, the head gasket, and other engine seals. The contact was aware that the vehicle was included in NHTSA Campaign Number: 21V587000 (Fuel System, Gasoline). The contact researched and became aware that a failure of the fuel pump could lead to other failures with the engine oil seals. The contact stated that the fuel pump had been ordered; however, the vehicle was not yet repaired. The manufacturer was informed of the failure. The failure mileage was approximately 82,000.

NHTSA complaint #11719040 — an unverified report by a vehicle owner.

SERVICE BRAKES

Today 13 Feb 2026, around 3pm I was following traffic it was slow (5 miles an hour) and the traffic light turned red so I pushed on my brake to stop the car and it surged forward I pushed down on the brake again and the my vehicle stopped. Lucy I was travel a couple car lengths behind the vehicle in front of me or we would have ran into his back bumper. This is the second time this year this happen the other time was a couple of weeks back and I thought I did something wrong but my wife was in the car this time with me and she thought I did something I told her I pushed on the brake and the car surged forward. I told her I wasn't going nuts as this was the second time this year the car did this. I live in Central Florida and the weather was over 70 degrees, we were shopping and were heading home I estimate we were in the car traveling 4/5 minutes when this happened.

NHTSA complaint #11717942 — an unverified report by a vehicle owner.

ENGINE

The Tumble Generator Valve (TGV) assembly within the intake manifold failed on my 2019 Subaru Outback at only 48,000 miles causing catastrophic engine failure. This is a critical engine component that is expected to last significantly longer than the vehicle's current low mileage. The premature failure of this part triggers engine warning lights and disables key driver-assist safety features (such as EyeSight), creating a distraction and potential hazard while driving. This indicates a material defect in the TGV components used in this model year, causing catastrophic failure well before reasonable service life expectations.

NHTSA complaint #11712860 — an unverified report by a vehicle owner.

STRUCTURE:BODY

We were driving down an interstate highway going 70 mph on a foggy Christmas Eve 2025 approximately 7 a.m. No cars were close around us. We had been on the road for 30 minutes or so, and it was in the 50-60 degree temperature range. Suddenly we heard what sounded like a gunshot right above our heads. We opened the sunshade under the sunroof, and saw that our sunroof had exploded and left a hole. Before this, we heard nothing strike the sunroof or the car. It seemed like a spontaneous explosion. The explosion noise is recorded on our dash cam video. I was unable to upload the video because it must not be in the correct format.

NHTSA complaint #11708662 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The car repeatedly drains the battery after being left for a short time (a day or 2). This has now happened at least four times and has destroyed multiple batteries. I have taken it to the dealer and complained multiple times. They check for software updates and sell me a new battery and then the same thing happens again. Because of this, the car is essentially unusable because I can't trust it to run. The problem seems to come and go, though that may simply be due to having a new battery for a while. There doesn't seem to be any indication before this problem occurs.

NHTSA complaint #11707469 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

I was driving on I-95 South in Georgia on Thursday, 18 December at approximately 9:00 pm in my 2019 Subaru Outback (6 cylinder engine). There was good visiblity and dry road conditions. I did not have the cruise control on. I was traveling at 75 mph and wanted to pass a truck. As I increased my speed to 78 mph to pass the truck, the Subaru began to accelerate to 85 mph and my rpms went up to 4000. The car continued to accelerate. I checked the cruise control and it was in fact off. I felt with my foot to make sure the accelerator was not stuck and it was not. I pushed hard on the brakes to counter the acceleration and after about 1 minute the car became controllable again. I drove the rest of my trip going 70 mph and did not have a further incident that evening. Because of the traffic ahead of me, this acceleration caused me great concern for myself and the passenger in the car. I have not had this problem before and have not reported it to my Subaru dealer yet. No one else has examined the car since this incident yesterday. I did not receive any warning lights or dashboard messages prior to the incident.

NHTSA complaint #11706194 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Windshield cracking for no reason.

NHTSA complaint #11688808 — an unverified report by a vehicle owner.