529 of the
7,124 complaints filed about the Toyota Highlander
are about the glass, mirrors and wipers —
7% of everything owners reported.
The worst model year for it is 2002.
529
Complaints
7%
Share of all complaints
5
Crashes
2
Fires
Windows, Mirrors & Wipers complaints by model year
The contact owns a 2023 Toyota Highlander. The contact stated that while attempting to start the vehicle, the driver’s and passenger’s side mirrors moved downward independently, causing the contact to manually adjust the side mirrors. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed; however, the diagnostic result was unknown. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 28,000.
NHTSA complaint #11753982 — an unverified report by a vehicle owner.
The radio keeps freezing up all the time along with the back tail light area going in and out. I keep smelling like burnt wire smell. Engine sound really rough.
NHTSA complaint #11750492 — an unverified report by a vehicle owner.
Rear window on the tailgate spontaneously cracked and broke into small pieces. No warning and no one touched the glass. The glass crumbled into small pieces.
NHTSA complaint #11750185 — an unverified report by a vehicle owner.
The contact owns a 2025 Toyota Highlander. The contact stated that while she and her husband were driving at 60 MPH, she heard a loud explosion noise from above her head and felt air whipping on top of her head. The contact stated that the sunroof exploded; however, the sunroof shield prevented the glass from entering the vehicle. The vehicle was steered to the side of the road and inspected, but the contact did not find anything wrong at that time. The vehicle was taken to a dealer where it was diagnosed that a rock may have hit the sunroof. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 8,498.
NHTSA complaint #11741757 — an unverified report by a vehicle owner.
During very cold tempratures 25 F and below all windows fog up. Defroster is turned on but windows remain fogged. I can turn on rear defroster (electric grid) and clears back window. All windows fog so you cannot see out. With front defroster fan on high it will after a time (starting from the bottm) clear. Side windows on drivers and passenger side will some times clear. Not back passenger windows. Taken to dealer several times. Replaced thermostat. After more complaints dealer said there was no mechanical problem.
NHTSA complaint #11733272 — an unverified report by a vehicle owner.
The side mirrors are too large and located in a position that when the driver is turning left the driver's side mirror blocks the ability to see the crosswalk and also the center divider of the lane they are turning into and has almost caused me to strike a center divider and not see a pothole on a freeway on ramp causing damage to the left side strut and alignment. There were other multiple times I almost hit the smaller center dividers in town and the glare in the mirror causes glare that you can't see where you are going. terrible design
NHTSA complaint #11721079 — an unverified report by a vehicle owner.
The rear window on my car spontaneously shattered as I was driving. This was in light rain on the freeway. I had turned the rear-window defrost on at the beginning of my 20 minute drive to work in the dark at 5:30AM . When I was almost at my destination, I heard a noise and looked in the rear view mirror to see my rear window had shattered. My car is just three years old with about 30,100 miles on it. I drove to the dealer, waited until they opened, and they evaluated - saying it would take $1300 and three days to fix. They said it would not be covered by my bumper to bumper warranty as that had expired in the prior week. They said it would not be covered by my Toyota extended care warranty. As much rain was expected later in the day, I fixed paying for the repair myself as I found a third party installer who could do it for a fraction of the dealer's asking price on the same day. There were no warnings, messages or other symptoms. I had only turned on the rear defroster one other times in the three years I owned the vehicle. This happened without warning.
NHTSA complaint #11720659 — an unverified report by a vehicle owner.
The contact owns a 2018 Toyota Highlander. The contact stated that while driving at 58 MPH, there was an abnormal popping sound coming from the sunroof, and it was discovered that the sunroof glass had shattered. Neither an independent mechanic nor a dealer was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 165,000.
NHTSA complaint #11715940 — an unverified report by a vehicle owner.
The contact owns a 2014 Toyota Highlander. The contact stated that a hybrid system warning alert was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the windshield wiring system had failed and that the windshield needed to be replaced. The vehicle was not repaired. The mechanic informed the contact that the windshield failure was associated with NHTSA Campaign Number: 18E107000 (Electrical System, Visibility). The dealer was not contacted. The vehicle was not diagnosed or repaired. The windshield manufacturer was made aware of the failure; however, the vehicle manufacturer was not made aware of the failure. The approximate failure mileage was 190,000.
NHTSA complaint #11715109 — an unverified report by a vehicle owner.
The part that failed is the driver side mirror cover. It has never been struck by anything and just flew off the side of the car while driving on the highway. This part flying off the car could cause an accident if striking a motorist, motorcycle, pedestrian. I do not have the part that flew off because I can't go back and pick it up off the highway. This just happened today. I have called a body shop to order a new part. The plastic part can only be replaced by purchasing the whole $1500 side mirror assembly. There was no sign that it was going fly off the car as there has never been struck by anything. it was in perfect shape just as the rest of the car.
NHTSA complaint #11684033 — an unverified report by a vehicle owner.
Premature AC refrigerant leak and failure in system in the 2021 Toyota Highlander due to corroded/defective rear AC lines located near the exhaust/spare tire, observed at very low mileage and upon official inspection at the nearest Toyota dealership. Noticed early in ownership and decided to have the vehicle scanned when air being released only continued to grow warmer in the sweltering summer months. Reporting due to advice from friends and owners in my exact situation with the very same issue as well as the pricey three-thousand dollars and upwards quote to have this work done from Curry Toyota, 3026 E Main St, Cortlandt, NY 10567. Vehicle purchased new to avoid these very issues.
NHTSA complaint #11664841 — an unverified report by a vehicle owner.
This is a supplemental complaint to add more detail to a prior submission. I am the original owner of a 2021 Toyota Highlander with 10,000 miles at the time of the issue worsening to the point that I finally broke down and was forced to pay the Toyota dealership's hefty diagnostic fee. The air conditioning system has failed due to a refrigerant leak in the rear A/C lines, specifically near the exhaust area under the vehicle. The dealership diagnosed the issue and quoted me over $3,000 to replace “all necessary components in the rear.” They offered no coverage or goodwill repair despite the vehicle’s age and mileage. Upon researching the issue for longer than a year at this point, I discovered far too many similar complaints from other Highlander owners (years 2019–2021) describing identical failures — typically rear A/C lines corroding, cracking, or leaking prematurely. In some cases, customers were told Toyota is aware of the issue but not issuing a TSB or recall. In other cases, dealers said no permanent fix exists. These repairs are prohibitively expensive and, in some reports, recurring due to poor line placement or dissimilar metal corrosion near heat sources. This significantly impacts safety in several ways: Impaired Visibility: The AC system is integral to effective defogging and defrosting of the windshield, especially in humid or cold conditions. Without it, visibility is severely compromised, increasing the risk of an accident. Driver Impairment: In extreme temperatures, lack of climate control can lead to driver fatigue, distraction, and reduced concentration, posing an indirect safety risk. I am reporting it to request NHTSA monitor the trend. This seems to reflect a possible engineering or design flaw, and the number of similar owner reports suggests it may warrant further review by Toyota and NHTSA. Customers should not be facing multi-thousand-dollar repairs on near-new vehicles with basic systems failing. Thank you for tracking this issue.
NHTSA complaint #11664890 — an unverified report by a vehicle owner.
Windshield side beveled trim driver’s side snapped and flew off on the highway into oncoming traffic and the passenger side is also loss and almost coming off.
NHTSA complaint #11654176 — an unverified report by a vehicle owner.
The contact owns a 2021 Toyota Highlander. The contact stated that while operating the vehicle, the display screen malfunctioned and displayed a solid black screen. During the failure, several functions and features could not be accessed or activated, including the front and rear defrosters. The contact was unable to clear the front and rear windshields, which created a visibility hazard for the driver. The vehicle was taken to the local dealer, who diagnosed that the display screen unit needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 45,000.
NHTSA complaint #11649388 — an unverified report by a vehicle owner.
The contact owns a 2021 Toyota Highlander. The contact stated while driving at 55 MPH, the driver’s side mirror was vibrating abnormally. There were no warning lights illuminated. The vehicle was taken to a dealer and the vehicle was diagnosed and it was determined that the screw securing the mirror had loosened. The vehicle was repaired; however, the failure persisted. The manufacturer was not made aware of the failure. The failure mileage was approximately 38,000.
NHTSA complaint #11647068 — an unverified report by a vehicle owner.
Driver's side mirror has been vibrating since vehicle purchase. The issues causes vibration / shaking of the driver's side rearview mirror creating blurry traffic (in the mirror) at highway speed and is a serious safety concern. Dealership claims it is due to attachment of a blind spot mirror on my vehicle. However there are hundreds of posts online of other people discussing / complaining about this exact same issue on Toyota Highlanders and Rav4. Other people are also reporting dealers claiming there is no fix. The issue can be fixed quiet easily by using a glue / tacky adhesive (or double sided tape) between the rearview mirror glass assembly and the backing plate of the mirror motor. Toyota should issue a recall since the issue is obviously prevalent and poses a safety hazard. Here are some links to other people complaining about the same issue since 2020: [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11645528 — an unverified report by a vehicle owner.
The driver's side sun visor does not stay up against the roof of the car and falls down obstructing the driver's view. It will not stay up and falls down immediately when pushed up against the roof. We have resorted to tying the visor up but then are unable to use the sun visor while driving.
NHTSA complaint #11635145 — an unverified report by a vehicle owner.
Drivers side mirror vibrates during car operation and limits visibility. This is extremely hazardous during lane changes on multiple lane roads. I have reached out to Toyota multiple times about a resolution but their continued response is that they are aware of the issue but do not seem to be concerned.
NHTSA complaint #11633596 — an unverified report by a vehicle owner.