36 of the
779 complaints filed about the Volkswagen Atlas Cross Sport
are about the fuel system —
5% of everything owners reported.
The worst model year for it is 2021.
On two consecutive occasions, my 2024 Volkswagen Atlas Cross Sport suddenly lost almost all ability to accelerate after highway driving. Both times, after exiting the highway and stopping at a traffic light, pressing the accelerator would only allow the vehicle to travel a few miles per hour. The vehicle was effectively unable to accelerate normally or keep up with traffic. Turning the vehicle completely off and restarting it restored normal acceleration. The same problem occurred again the following day under similar circumstances. Multiple dashboard warnings appeared, including the check-engine light. During the second occurrence, a red coolant-related warning also appeared. I took the vehicle to an authorized Volkswagen dealer. The dealer documented a fault for “ENGINE COOLANT FLOW LOW/PERFORMANCE” and found Volkswagen TSB 01-24-06 applicable. The repair order states that DTC P00B7, P0116 or P2681 was stored in the engine/motor control module. The dealer performed the prescribed ECM programming update under warranty. The dealer inspection showed the coolant system as OK and did not identify or repair a coolant leak or replace any cooling-system components. My safety concern is the sudden, severe loss of propulsion/acceleration in normal traffic. Had this occurred while merging onto a highway, crossing an intersection, or in other high-speed traffic, the inability to accelerate could have resulted in a collision. I am filing this complaint so NHTSA has a record of this loss-of-propulsion condition and its association with the documented ECM/coolant-flow fault and Volkswagen software update.
NHTSA complaint #11756349 — an unverified report by a vehicle owner.
This has happened to me a total of three times now And I have had the car one month. It stopped on me again in the middle of traffic Just driving without warning without any indicating lights on on June 25th. It stopped on me prior on July 21st and I just got it out of the shop July 24th. This is very dangerous and a dangerous situation especially to be driving one minute and the car just stop on you and go to a slow roll.
NHTSA complaint #11753164 — an unverified report by a vehicle owner.
I have not the slightest idea what is going on with the vehicle that I just bought on June 25th 2026. I have a 2021 Volkswagen Atlas crossover and the car stopped on me three times today. And when I arrived in my garage it said that the engine was hot. I will be taking it to the dealership tomorrow.
NHTSA complaint #11751935 — an unverified report by a vehicle owner.
Got the PCV valve repaired on February 13th and on February 18th the EPC light came on. The 2022 Volkswagen Atlas was taken to dealership and said the charge air inlet and the diverter valve leaking oil. Recommended to replace the turbo diverter valve and the charge air inlet seal at this time and re-testing the turbo. My car is shutting off when sitting at a light and car only has 52, 294 mileage
NHTSA complaint #11720257 — an unverified report by a vehicle owner.
GAS TANK SEAL FAILED CAUSING COLLAPSE OF GAS TANK AND DAMAGE TO FUEL PUMP. SIMILAR PROBLEM IN OTHER VOLKSWAGON VEHICLES SUCH AS JETTA AND GOLF THAT HAD RECALL IN PAST. VOLKSWAGON COSTUMER SERVICE WAS NOTIFIED, BE FAILED TO OFFER REPAIR COVERAGE DUE TO FACT I HAD THE OIL CHANGED AT A NON VOLKSWAGON SERVICE CENTER. NO WORK WAS DONE ON FUEL SYSTEM OUTSIDE OF OFFICIAL VOLKSWAGON DEALERSHIP.
NHTSA complaint #11706258 — an unverified report by a vehicle owner.
On going fuel system issues that pose significant safety risks, suggest potential design or manufacturing flaws, and are impacting vehicle performance. The primary component affected is the fuel injection system. I have had to replace the fuel leak detection pump, spark plugs, and ignition coils multiple times, as fault codes have repeatedly appeared even after repairs, indicating a persistent failure within the fuel injection system. Additionally, I believe that the use and recommendations regarding fuel grades are contributing to the problem. I was informed by a Volkswagen employee that I should have been using 93 octane fuel; however, I was never provided with this guidance at the time of purchase. The vehicle’s fuel tank clearly indicates the use of 87 octane fuel. This discrepancy raises concerns about whether consumers are adequately informed about the proper fuel to prevent issues. The lack of clear guidance on fuel grade requirements appears misleading and could be viewed as potentially deceptive. My vehicle has begun riding rough and shaking while driving. I have been informed that I now need a decarbonization (decarb) engine intake service and a fuel injection service to address these new symptoms. These issues further indicate that there may be underlying problems within the fuel and intake systems, possibly related to the ongoing deposit buildup and improper fuel use. The failed fuel leak detection pump, affected fuel system components, and the recent service needs are available for inspection and can be provided upon request. The malfunction of the fuel injection system and the fuel leak detection system substantially engine failure while driving which could endanger the driver, passengers, and others on the road.The issues manifested as the vehicle would jerk later my engine light came on, prompting me to seek repairs. It has not yet been formally inspected by the police, or insurance representatives, the mechanic’s diagnosis confirms the malfunction.
NHTSA complaint #11690879 — an unverified report by a vehicle owner.
On the afternoon of Wednesday August 6th I was no less that 3-4 miles from my home when the car stopped in the middle lane of a very busy 3 lane highway and never started again. It was 90+ degrees outside and even hotter inside the vehicle with leather seats. I became extremely nervous and my small 10 pound puppy began to have anxiety and overheat. When I pulled away from my home the car was bucking and jerking. The car had just completed an OTA software download and installation a few hours earlier so I assumed it was the after affect of the software update. As I pulled onto the main road the car was still driving very roughly and when I cam to a red light the car started to shake back and forth very roughly and once the light turned green I was unable to accelerate. Error messages where coming up on the screen. I tried to start the car to move out of the middle lane but it would not start. A state trooper had pulled behind me and got out to assist. She noted she saw gray smoke coming from behind the vehicle as I was driving up to the light which prompted her to get behind me initially. She and I both worked to try to get the car into park but it would not shift gears. She noted fluid was running out of the car but we both assumed it was coolant or antifreeze. She radioed the local police to assist since we were in the middle lane of a dangerous highway and I contacted VW roadside assistance. The local police officer arrived on the scene and was able to assist with getting the manual parking brake on. When the tow truck arrived he asked if the car would go into Neutral we advised NO he then stated we were standing in gasoline and if we tried to start the vehicle the car could have exploded or the engine could have caught fire. If someone had rear ended or hit us there would have been a fire because the entire gas tank has leaked onto the ground that was the fluid the state trooper saw running from the back of the vehicle.
NHTSA complaint #11689455 — an unverified report by a vehicle owner.
My fuel gauge was stating I had approx 300 miles to empty. I was traveling on the interstate when the vehicle lost power and different warning lights came on dash. I was able to safely get on to shoulder of highway. Vehicle stopped on its own. I was unable to get it to go into gear or even start. I had it towed to Volkswagen dealership. I was told my floating fuel sensor got lodged near fuel line which gave false fuel gauge readings. So basically it ran of gas but I never had any signs I was getting low on fuel since gauge still showed 300 miles. The battery also died from the attempts to start vehicle. They were able to reposition the sensor in fuel tank and battery was jumped off. The sensors on dash went away and car is operating normally.
NHTSA complaint #11688536 — an unverified report by a vehicle owner.
We had a cylinder 3 misfire according to the check engine light code. Replaced spark plugs, coils, and now VW in Doral (Miami, FL) is telling me it is a "carbon build up" when the car only has 42,000 miles on it.
NHTSA complaint #11682106 — an unverified report by a vehicle owner.
The Car has Stalled at Stoplights 3 different times. There was a message on the dashboard that told me to "manually restart the engine". I put the car in park and restarted the engine. Note: I don't use the "Eco Stop Start" mode. I'm not sure what caused this problem but in reviewing some forums it may be an N80 Valve and/or a Carbon Canister. Yes, the vehicle is available for inspection. Obviously, a stalled car could be a safety risk for the driver and others. I will be taking it to a dealer but they seemed to think it may be the battery. I don't think so, because the car started immediately once I pressed the Start Button. No Warning Signs or messages prior to Stall. Message to Manually restart after Stall.
NHTSA complaint #11681814 — an unverified report by a vehicle owner.
Vehicle is stalling/shutting off at low speed. Took it to dealership and no fix since its not throwing a code. Obviously something is wrong and a huge safety problem. Has happened several times in a few months with me having the vehicle/ bought it used.
NHTSA complaint #11679466 — an unverified report by a vehicle owner.
Start stop error on 7/15/25. Engine light on 7/16/25. Drove the car to AutoZone and the diagnostic code was P0496 EVAP System High Purge Flow. VW dealership said it was okay to drive vehicle with engine on until my appointment on 7/24/25. Filled up the car with gas on 7/18/25, but the fuel gauge only went up to 7/8 of a tank and 365 miles to empty. After driving 51 miles, the fuel gauge was full and 430 miles to empty. After driving 116 miles, the fuel gauge dropped back down to 7/8 of a tank and 365 miles to empty. The car stalled today while going through the busy Burlington Road roundabout. There was a popping sound coming from the rear of the vehicle near the fuel tank after I shut it off when I got home. There was also a hissing sound coming from the fuel tank. The EVAP purge solenoid was replaced on 5/30/25, the evap system failed again on 6/19/25 at which point the vehicle was sent to VW for a software update. The engine light is on again for the same EVAP issue and now the fuel system appears to be failing because of it. I’m leaving the vehicle parked until my appointment. This vehicle is not safe to drive considering it stalls unexpectedly in stop and go traffic.
NHTSA complaint #11674641 — an unverified report by a vehicle owner.
The car’s engine start/stop feature has failed multiple times while at an incomplete stop. This failure endangers the driver because the car will not drive, forcing the driver to put the car in park & manually restart the car. This failure has occurred at least 6 times, reported as the original owner of the car for 3+ years. Recently, as a potential result(?), the car’s check engine light has appeared (@52k miles). The dealership suggested replacement of the N80 purge valve,~$400 repair at VW dealership, to fix the tandem start/stop error & check engine light issue.
NHTSA complaint #11655588 — an unverified report by a vehicle owner.
About 6 months after purchasing a new 2024 VW Atlas Cross Sport, I started smelling gasoline inside the vehicle. It was a very strong smell, like someone had poured it on the carpet. After a few days, I noticed the smell when walking up to the car, not just inside. At this time, an error message appeared on the dash saying the start-stop system was malfunctioning, as well as the ABS system. That day, I took a look underneath and spotted a leak; gasoline was dripping from the bottom of the car. So, I scheduled service at the dealership where I purchased the vehicle. After a week, I received a call saying a rodent had entered the engine bay and chewed through the engine harness and a fuel line, and that these damages were not covered under the warranty. I asked for pictures of the "chewing"; however, the images they provided were not conclusive, in my opinion. My insurance paid, and the repair was started, but when they went to fix it, they said they found extensive damage to the primary harness, secondary harness, and a bunch of other things. Insurance again approved; however, the dealership has said that these parts need 30-90 days to come in. I believe there to be a defect in manufacturing that allows rodents into the vehicle since I have parked vehicles, including VW and just about every other brand, in the same location for 30 years and have never had this issue. Also, when I pressed the service department at the dealership, they said they had other cars here for the same issue and that it was "not uncommon."
NHTSA complaint #11638247 — an unverified report by a vehicle owner.
Multiple error codes populated on my vehicle while driving to work. This occurred less than 3 months & less than 1500 miles since ownership. The car went into a reduced power/speed mode and advised for me to get service asap. I barely made it off the highway to my destination. Dealer said it was the fuel pump. If it was a faulty fuel pump - should I have been a part of the stop sale/recall? Engine/Transmission/PowerTrain- Error: Drive System. Please service vehicle. (Engine) Error: Start/Stop (Engine)
NHTSA complaint #11628224 — an unverified report by a vehicle owner.
My 21 VW atlas cross sport now will not remote start. As well, it CONTINUES with the sputter and stall at low speeds. In and out of parking spots, backing in and out of driveway, the most important scenario being complete stall out crossing a median and multiple lanes of oncoming traffic…
NHTSA complaint #11624133 — an unverified report by a vehicle owner.
This vehicle is burning excessive engine oil. My vehicle required two quarts of oil before my oil change. This occurred at the 20,000-mile interval and again at 30,000 miles. This vehicle also had two coolant repairs before 30,000 miles. The car has not been in any accidents. The vehicle had no oil.
NHTSA complaint #11614839 — an unverified report by a vehicle owner.
8/22/2023- CEL code P0456 - dealership replaced N80 valve and carbon canister. The dealership told the fault occurred because I was likely "topping off" my gas tank, which I have never done. 9/14/2023- CEL code P0456 - dealership detected leak, valve full of particles, replaced N80 valve and carbon canister. Again told me the issue was likely caused by "topping off" my fuel tank, which I have never done. 4/23/2024- CEL code P0456- dealership detected leak though did not replace valve or canister. Dealership performed a software update and cleared the code. 5/7/2024- CEL code P0456- dealership detected leak, noted charcoal in valve. Replaced N80 valve and carbon canister. Dealership contacted Volkswagen for further insight into the issue. VW informed dealership that I was likely "topping off" my tank, which I have never done.
NHTSA complaint #11611939 — an unverified report by a vehicle owner.
The contact owns a 2021 Volkswagen Atlas Cross Sport. The contact stated that while attempting to refuel the vehicle, the fuel door failed to open. The contact physically broke open the fuel door to refuel the vehicle. The cause of the failure was not yet determined. The manufacturer and local dealer were not contacted regarding the failure. The failure mileage was 47,000.
NHTSA complaint #11609886 — an unverified report by a vehicle owner.