2018 Volkswagen GTI problems

STRUCTURE:BODY

I am reporting a water intrusion issue involving the rear hatch area of my 2018 Volkswagen Golf GTI Autobahn. Water leaks into the vehicle through the hatch wiring boot area and travels into the interior of the car, causing the headliner to become saturated with water. During periods of rain or after washing the vehicle, water enters near the rubber hatch wiring boots and leaks into the interior roof area. The vehicle has two rubber hatch boots (left and right) that route wiring harnesses from the body to the liftgate. These harnesses carry wiring for several rear hatch components including the backup camera, center high-mount brake light, rear wiper motor, hatch release switch, rear defroster, license plate lights, and other electrical systems located in the liftgate. Water intrusion in this area can allow moisture to travel along the wiring harnesses and into the vehicle interior, resulting in a soaked headliner and moisture accumulation inside the cabin. Because these wiring boots contain electrical harnesses for important components such as the center brake light and backup camera, continued water exposure could potentially lead to electrical faults, corrosion, or failure of these systems. The vehicle has approximately 23,000 miles. The leak occurs during normal weather conditions such as rain. Numerous owners of similar Volkswagen Golf and GTI/R vehicles have reported similar rear hatch water intrusion issues. I have been scared to drive the car in the rain and wash my car after the incident. The hatch boots have been replaced twice per side and are still causing issues. I request that this issue be investigated as a potential design or sealing defect allowing water to enter the passenger compartment and electrical harness areas.

NHTSA complaint #11722115 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I am reporting a water intrusion issue involving the rear hatch area of my 2018 Volkswagen Golf GTI Autobahn. Water leaks into the vehicle through the hatch wiring boot area and travels into the interior of the car, causing the headliner to become saturated with water. During periods of rain or after washing the vehicle, water enters near the rubber hatch wiring boots and leaks into the interior roof area. The vehicle has two rubber hatch boots (left and right) that route wiring harnesses from the body to the liftgate. These harnesses carry wiring for several rear hatch components including the backup camera, center high-mount brake light, rear wiper motor, hatch release switch, rear defroster, license plate lights, and other electrical systems located in the liftgate. Water intrusion in this area can allow moisture to travel along the wiring harnesses and into the vehicle interior, resulting in a soaked headliner and moisture accumulation inside the cabin. Because these wiring boots contain electrical harnesses for important components such as the center brake light and backup camera, continued water exposure could potentially lead to electrical faults, corrosion, or failure of these systems. The vehicle has approximately 23,000 miles. The leak occurs during normal weather conditions such as rain. Numerous owners of similar Volkswagen Golf and GTI/R vehicles have reported similar rear hatch water intrusion issues. I have been scared to drive the car in the rain and wash my car after the incident. The hatch boots have been replaced twice per side and are still causing issues. I request that this issue be investigated as a potential design or sealing defect allowing water to enter the passenger compartment and electrical harness areas.

NHTSA complaint #11722115 — an unverified report by a vehicle owner.

SERVICE BRAKES

During moderate braking, the ABS system was violently pulsing the brakes on the left front wheel. This occured on about one dozen braking events over a 5-7 mile distance. Afterwards upon inspection, the left front brake smelled and radiated intense amounts of heat. There were no Warning Lights displayed at any time during or after. The tires, original equipment size, are almost brand new. All tires were at recommended air pressure. A Volkswagen dealer will inspect the vehicle today. The ABS hydraulic assembly is suspect. The vehicle has 46,000 miles and has had its brake fluid replaced in the past as part of normal recommended service.

NHTSA complaint #11652252 — an unverified report by a vehicle owner.

SERVICE BRAKES

6/1/20 BRAKES GOOD MEASURED 8 (IN THE GREEN) THIS IS WHEN I RECEIVED A NEW WATER PUMP (I KNOW! UNDER WARRANTY ISSUE ALSO IMO). MILAGE 25490. SEPTEMBER GOT NEW TIRES. ANTI LOCK BRAKES WENT OFF RIGHT A WAY X2. 10/10/20 TOOK CAR IN FOR 30,000 MILE CHECK AT 29,053 MILES. BRAKES MEASURED AT 3. MCKENNA SUGGESTED NEW BRAKES(PADS, ROTORS) $700.00. WHAT WOULD CAUSE BRAKES GOING FROM 8 TO 3 IN 4 MONTHS? I HAVE CONCERNS WITH ANTILOCKING BRAKES. I BELIEVE THEY ARE TOO SENSITIVE AND CAUSED BRAKE ISSUES

NHTSA complaint #11365285 — an unverified report by a vehicle owner.

STRUCTURE:BODY

VW CORPORATION DID NOT HONOR THEIR WARRANTY ON MY 2018 VW, GTI. MY 2018 VW, GTI WAS PARKED, AND I WAS INSIDE THE VEHICLE, WHEN THE SUNROOF SPONTANEOUSLY SHATTER. THE SUNROOF WAS NOT HIT BY ANY DEBRIS. THE 2018 VW GTI IS STILL UNDER WARRANTY SO I TOOK THE DAMAGED VEHICLE TO OURISMAN VW OF LAUREL. OURISMAN VW STATED THAT VW DECLINED TO HONOR WARRANTY BECAUSE THEY SAID IT WAS IT BY A ROCK. THE ROOF WAS NOT HIT BY ANYTHING. VW STATED THAT AS A GESTURE OF GOOD FAITH BECAUSE I HAD BEEN A LOYAL CUSTOMER, THEY WOULD PICKED UP 40% OF THE REPAIR COST. I PICKED UP 60% OF THE COST, $3,239.38. I'M FILING THIS COMPLAINT BECAUSE VW SHOULD HAD PICKED UP THE ENTIRE REPAIR COST BECAUSE THE SUNROOF WAS NOT HIT BY ANY OBJECTS. THIS HAS HAPPEN TO OTHER VW CUSTOMERS AS WELL, CLASS ACTION FILED AGAINST VOLKSWAGEN ALLEGING EXPLODING SUNROOFS. VOLKSWAGEN EXPLODING SUNROOF CLASS ACTION UPDATE: A FEDERAL COURT RULED ON FEBRUARY 26, 2019, THAT CONSUMER PROTECTION CLAIMS AND CLAIMS OF FRAUDULENT CONCEALMENT AGAINST VOLKSWAGEN CAN MOVE FORWARD.

NHTSA complaint #11320753 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2018 VOLKSWAGEN GTI. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, THE EMERGENCY BRAKE ASSIST ACTIVATED INDEPENDENTLY. THE CONTACT STATED THERE WAS A WARNING MESSAGE STATING AN OBJECT WAS IN FRONT OF THE VEHICLE HOWEVER, THERE WAS NOTHING IN FRONT OF THE VEHICLE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE MILLAGE WAS 14,426.

NHTSA complaint #11316109 — an unverified report by a vehicle owner.

POWER TRAIN

AN ISSUE EXISTS WHERE THE START STOP SYSTEM (S/S) CAN CAUSE THE VEHICLE TO STALL AT A STOP LIGHT. AT ONE POINT, THE DRIVER WAS IN STOPPED IN TRAFFIC, WHICH CAUSED MY S/S TO ACTIVATE, TURNING OFF THE VEHICLE'S ENGINE. THE DRIVER UNBUCKLED HIS SEAT BELT SO HE COULD PUT SOMETHING INTO THE GLOVE BOX, THEN RE BUCKLED HIS SEAT BELT. TRAFFIC BEGAN MOVING AGAIN, SO THE DRIVER HIT THE ACCELERATOR. THE VEHICLE DID NOT ACCELERATE. THERE WAS A NOTIFICATION ON THE DASH STATING "PLEASE START ENGINE MANUALLY". THE DRIVER ATTEMPTED TO START THE ENGINE, BUT THE VEHICLE WAS STILL IN DRIVE, SO THE VEHICLE NOTIFIED HIM TO PUT THE TRANSMISSION INTO P OR N. THE DRIVER SHIFTED THE VEHICLE INTO N, RESTARTED THE ENGINE, SHIFTED BACK INTO DRIVE AND THEN RESUMED DRIVING. (AFTER CREATING A SMALL TRAFFIC JAM) LATER, THE DRIVER TOOK THE VEHICLE TO THE DEALERSHIP AND EXPLAINED THE ISSUE. THE SERVICE DEPARTMENT POLITELY EXPLAINED THAT THE S/S SYSTEM DOES THAT, AND THERE IS NOTHING THAT THEY CAN DO. THEY EXPLAINED THAT MULTIPLE FACTORS STIPULATE THE S/S SYSTEM'S DECISIONS, SUCH AS ENGINE TEMPERATURE, POWER CONSUMPTION (JUST TO NAME A FEW). THE DRIVER ALSO ASKED IF THE DEALERSHIP COULD JUST REMOVE S/S SYSTEM, THEY EXPLAINED THAT THEY WERE NOT ALLOWED TO DUE TO EPA REGULATIONS. ATTACHED IS A PNG FILE CONTAINING SCREENSHOTS OF A MP4 THAT THE DRIVER TOOK ON 03/01/20 WHILE ATTEMPTING TO RECREATE THE INCIDENT. IT SHOULD BE NOTED THAT THE DRIVER COULD NOT RECREATE THE INCIDENT PERFECTLY. THE DRIVER WAS ONLY ABLE TO MAKE IT SO THAT THE S/S MECHANISM WOULD RESTART THE ENGINE AFTER THE DRIVER RE BUCKLED HIS SEAT BELT AND SUBSEQUENTLY DEPRESSED THE ACCELERATOR MOST OF THE WAY DOWN (NOT REQUIRING THE DRIVER TO SHIFT THE VEHICLE INTO P OR N AND RESTARTING THE ENGINE).

NHTSA complaint #11315480 — an unverified report by a vehicle owner.

SERVICE BRAKES

ON 3 OCCASIONS THE MANUAL PARKING BRAKE HAS RELEASE FULLY WHEN THE CAR HAS BEEN PARKED UPHILL ON A SIDE STREET WITH A STEEP INCLINE. TWICE THIS WAS AFTER I HAD GOTTEN OUT OF THE CAR, AND ONCE WHILE IN THE CAR IT HAPPENED IMMEDIATELY AFTER THE HILL-HOLDER BRAKE RELEASED. EACH TIME, THE CAR WAS IN GEAR AND DID NOT ROLL MORE THAN A FEW INCHES; AND AN ADULT PASSENGER WAS IN THE FRONT AND WITNESSED IT AND REAPPLIED THE BRAKE. THE PARKING BRAKE WAS APPLIED TIGHTLY, AND FULLY RELEASED WITH A BIG NOISE 2-20 SECONDS LATER. THE FROM THE SOUND MADE, IT SEEMS THAT THE RATCHETING PAWL ON THE HANDBRAKE SLIPPED OUT AND DID NOT CATCH ON THE NEXT TOOTH. THE DEALERSHIP COULD NOT RECREATE THE ISSUE AND HAS NOT MADE ADJUSTMENTS. THE MOST RECENT FAILURE WAS A FEW WEEKS AFTER MY MOST RECENT SERVICE.

NHTSA complaint #11307211 — an unverified report by a vehicle owner.

VISIBILITY:SUN/MOON ROOF ASSEMBLY

TL* THE CONTACT OWNS A 2018 VOLKSWAGEN GTI. WHILE THE CONTACT'S SON WAS DRIVING 65 MPH, THE SUN ROOF EXPLODED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO CAMELBACK VOLKSWAGEN (499 E CAMELBACK RD, PHOENIX, AZ 85014, (602) 648-9181) WHERE IT WAS DIAGNOSED THAT THE GLASS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 19018636, BUT DID NOT ASSIST. THE FAILURE MILEAGE WAS 5,000.

NHTSA complaint #11276914 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

LOSS OF POWER CYLINDER 2 MISSFIRES LOSS OF CAM CRANK SYNCHRONIZATION AND LACK OF CAM SIGNAL EVEN AFTER REPLACING BOTH CAM SENSORS IT STILL READS 0 RPM AND HAS BECAME VERY FRUSTRATING

NHTSA complaint #11229618 — an unverified report by a vehicle owner.

ENGINE

LOSS OF POWER CYLINDER 2 MISSFIRES LOSS OF CAM CRANK SYNCHRONIZATION AND LACK OF CAM SIGNAL EVEN AFTER REPLACING BOTH CAM SENSORS IT STILL READS 0 RPM AND HAS BECAME VERY FRUSTRATING

NHTSA complaint #11229618 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2018 VOLKSWAGEN GTI. WHILE DRIVING, THE VEHICLE LOST POWER AND ACCELERATED SLOWER THAN NORMAL. IN ADDITION, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. WHEN THE VEHICLE WAS POWERED OFF AND RESTARTED, THE FAILURE REMAINED. THE CONTACT WAS A CERTIFIED MECHANIC AND STATED THAT HE USED VOLKSWAGEN FACTORY SOFTWARE TO DIAGNOSE THE VEHICLE. THE CONTACT FOUND FAILURE CODES PERTAINING TO THE LOSS OF CAMSHAFT SYNCHRONIZATION AND FAILURE OF CYLINDER TWO. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 10,000.

NHTSA complaint #11222639 — an unverified report by a vehicle owner.

ENGINE

TL* THE CONTACT OWNS A 2018 VOLKSWAGEN GTI. WHILE DRIVING, THE VEHICLE LOST POWER AND ACCELERATED SLOWER THAN NORMAL. IN ADDITION, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. WHEN THE VEHICLE WAS POWERED OFF AND RESTARTED, THE FAILURE REMAINED. THE CONTACT WAS A CERTIFIED MECHANIC AND STATED THAT HE USED VOLKSWAGEN FACTORY SOFTWARE TO DIAGNOSE THE VEHICLE. THE CONTACT FOUND FAILURE CODES PERTAINING TO THE LOSS OF CAMSHAFT SYNCHRONIZATION AND FAILURE OF CYLINDER TWO. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 10,000.

NHTSA complaint #11222639 — an unverified report by a vehicle owner.

POWER TRAIN

WHEN DOWN SHIFTING THE TRANSMISSION SHIFTS ROUGHLY. (ONLY IN TRAFFIC) WHEN DOWN SHIFTING FROM 3,2,1 THE BRAKE PEDAL FOR SOME REASON DECIDES TO BRAKE HARDER THAN SUPPOSED TO, MAKING THE CAR JERKY. ( REGULAR DRIVING AND COMING UP TO A STOP LIGHT. ) AUTOMATIC TRANSMISSION AND IT'S THE AUTOBAHN EDITION.. ALSO WHEN THE CAR IS IDLING (COLD START) THE ENGINE VIBRATES ALOT MORE THAN NORMAL

NHTSA complaint #11193984 — an unverified report by a vehicle owner.

ENGINE

WHEN DOWN SHIFTING THE TRANSMISSION SHIFTS ROUGHLY. (ONLY IN TRAFFIC) WHEN DOWN SHIFTING FROM 3,2,1 THE BRAKE PEDAL FOR SOME REASON DECIDES TO BRAKE HARDER THAN SUPPOSED TO, MAKING THE CAR JERKY. ( REGULAR DRIVING AND COMING UP TO A STOP LIGHT. ) AUTOMATIC TRANSMISSION AND IT'S THE AUTOBAHN EDITION.. ALSO WHEN THE CAR IS IDLING (COLD START) THE ENGINE VIBRATES ALOT MORE THAN NORMAL

NHTSA complaint #11193984 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

SUNROOF SHATTERED FOR NO APPARENT REASON. I WAS DRIVING ON A RESIDENTIAL ROAD AND HEARD A LOUD "BOOM." I LOOKED UP TO SEE THAT THE SUNROOF WAS COMPLETELY SHATTERED. THE TEMPERATURE WAS MILD, THERE WERE NO BUMPS ON THE ROAD, NO BRIDGES NEARBY FROM WHICH SOMETHING COULD BE THROWN, AND NO SIGN OF EXTERNAL IMPACT TO CAUSE THE BREAKAGE.

NHTSA complaint #11156426 — an unverified report by a vehicle owner.

WHEELS

2018 VOLKSWAGEN GTI S. WAS ACTUALLY LEAVING MY HOUSE ON THE WAY TO THE DEALER FOR AN UNRELATED ISSUE. AS I WAS LEAVING MY HOUSE, DRIVING AT LIKE 10-15 MPH ON MY STREET. MY TPMS LIGHT COMES ON SAYING I HAVE LOW PRESSURE. I STOP IMMEDIATELY TO CHECK TO SEE. MY REAR DRIVER TIRE HAD A HUGE SIDEWALL BULGE AND YOU COULD SEE THE BEAD SITTING ON THE RIM LIP. THIS WAS WITHIN LESS THE 400 MILES OF THE VEHICLE BEING ON THE ROAD. I HAD NOT HIT ANY POTHOLES OR ANYTHING JUST SMOOTH PAVEMENT WENT IT HAPPENED(OR EVER). I PUT THE SPARE AND CONTINUED TO THE DEALER. IT WAS REPLACED WITH A NEW TIRE. BUT I FEEL THIS TIRE BRAND IS A SAFETY CONCERN. I HAVE THE SAME TIRES ON MY 2017 FORD EXPLORER AND THEY ARE ALREADY WORN DOWN AT 15000 MILES. HANKOOK VENTUS TIRES ARE GARBAGE AND DEF A SAFETY CONCERN.

NHTSA complaint #11149644 — an unverified report by a vehicle owner.

TIRES

2018 VOLKSWAGEN GTI S. WAS ACTUALLY LEAVING MY HOUSE ON THE WAY TO THE DEALER FOR AN UNRELATED ISSUE. AS I WAS LEAVING MY HOUSE, DRIVING AT LIKE 10-15 MPH ON MY STREET. MY TPMS LIGHT COMES ON SAYING I HAVE LOW PRESSURE. I STOP IMMEDIATELY TO CHECK TO SEE. MY REAR DRIVER TIRE HAD A HUGE SIDEWALL BULGE AND YOU COULD SEE THE BEAD SITTING ON THE RIM LIP. THIS WAS WITHIN LESS THE 400 MILES OF THE VEHICLE BEING ON THE ROAD. I HAD NOT HIT ANY POTHOLES OR ANYTHING JUST SMOOTH PAVEMENT WENT IT HAPPENED(OR EVER). I PUT THE SPARE AND CONTINUED TO THE DEALER. IT WAS REPLACED WITH A NEW TIRE. BUT I FEEL THIS TIRE BRAND IS A SAFETY CONCERN. I HAVE THE SAME TIRES ON MY 2017 FORD EXPLORER AND THEY ARE ALREADY WORN DOWN AT 15000 MILES. HANKOOK VENTUS TIRES ARE GARBAGE AND DEF A SAFETY CONCERN.

NHTSA complaint #11149644 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

THE "FRONT ASSIST" AUTOMATIC FORWARD COLLISION WARNING AND BRAKING SYSTEM RANDOMLY ACTIVATES WHEN DRIVING, BRAKING THE CAR WHEN THERE IS NOTHING TO TRIGGER IT. (THIS IS OCCURRING EVEN ON EMPTY ROADS WITH NO OTHER VEHICLES IN SIGHT) THE LAST OCCURRENCE WAS ON AN EMPTY 4-LANE SUBURBAN STREET. THERE WERE NO OTHER CARS ON THE ROAD. I WAS IN THE MIDDLE OF A GENTLE CURVE IN THE ROAD WHEN THE WARNING SOUND ACTIVATED AND THE CAR BRAKED.

NHTSA complaint #11112054 — an unverified report by a vehicle owner.