Owners have filed 105 complaints
about the 2016 BMW 528I with NHTSA between 2018 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 4 of 13 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 55
Against the median year of the BMW 528I. 50 means typical for this
model; 100 means roughly double.
Severity — 69
13.3% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 33
19% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
10,000 – 24,999 miles
513.9%
25,000 – 49,999 miles
513.9%
50,000 – 74,999 miles
719.4%
75,000 – 99,999 miles
925.0%
100,000 – 149,999 miles
616.7%
150,000+ miles
411.1%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Apr 2018peak 9Jul 2026
NHTSA investigations into the 2016 BMW 528I
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C...
Recalls on the 2016 BMW 528I
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
24V608000
ENGINE AND ENGINE COOLING:COOLING SYSTEM:PUMP
BMW of North America, LLC. (BMW) is recalling certain 2012-2015 X1 sDrive28i, X1 xDrive28i, 2012-2016 Z4 sDrive28i, 528i, 528i xDrive, 328i, 328xi, 2016-2018 X5 xdrive 40e, 2014-2016 228i, 228xi, 428i, 428i xDrive, 328xi Gran Turismo, 2013-2017 X3 sDrive28i, X3 xDrive28i, 2015-2018 X4 xDrive28i, 2015-2016 428xi vehicles. An improperly sealed electrical connector on the water pump may be exposed to water and short circuit.
Risk: An electrical short increases the risk of a fire.
16V914000
AIR BAGS
BMW of North America, LLC (BMW) is recalling certain model year 2017 BMW 640i, 640i xDrive, 650i, 650i xDrive, M6, 535i, 535i xDrive, 430i, 430i xDrive, 440i, 440i xDrive, M4, X1 sDrive28i, X1 xDrive28i, i3, i8, Rolls-Royce Dawn, Mini Clubman Cooper, Clubman Cooper S, Cooper All4, Cooper S All4, Mini 4-Door Cooper, Cooper S, Mini 2-Door Cooper, Cooper S, John Cooper Works and 2016 BMW 528i, 528i xDrive, 535i, 535i xDrive, 550i, 550i xDrive, M5 and 535d vehicles. The affected vehicles have seat- mounted side air bag inflator initiators that may fail to ignite during a crash.
Risk: If the air bag inflator initiator fails to ignite, the seat-mounted air bag will not deploy, increasing the risk of injury.
16V747000
SEAT BELTS:FRONT:RETRACTOR
BMW of North America, LLC (BMW) is recalling certain model year 2016-2017 X1 sDrive28i, X1 xDrive28i, MINI Hardtop 4 Door Cooper, Mini Hardtop 4 Door Cooper S, MINI Cooper Clubman, and Cooper S Clubman, 2017 Rolls-Royce Ghost, and 2016 528i vehicles. The vehicle-sensitive locking mechanism of the seat belt Emergency Locking Retractor (ELR) for the driver's seat may not lock as designed. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies."
Risk: In the event of a crash where heavy braking is applied, the Emergency Locking Retractor (ELR) may activate when the occupant is more forward in the seat, possibly increasing the risk of injury.
15V718000
CHILD SEAT
BMW of North America, LLC (BMW) is recalling certain model year 2016 528i, 528i xDrive, 535i, 535i xDrive, 535d xDrive, M5, 550i, 550i xDrive, and 535d sedans. The affected vehicles have an inboard lower anchor for child restraints on the left rear seat that may have been bent downwards, preventing the child seat from fully engaging both lower anchors. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 225, "Child Restraint Anchorage Systems."
Risk: If the child seat is not properly attached to the lower anchors, it can increase the child's risk of injury in the event of a crash.
Reports where the owner recorded a crash, a fire, an injury or a death.
West Hollywood, CAFire
STRUCTURE:BODY
On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V-608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.
NHTSA complaint #11713522 — an unverified report by a vehicle owner.
West Hollywood, CAFire
ELECTRICAL SYSTEM
On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V-608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.
NHTSA complaint #11713522 — an unverified report by a vehicle owner.
West Hollywood, CAFire
ENGINE
On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V-608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.
NHTSA complaint #11713522 — an unverified report by a vehicle owner.
Victorville, CAFire1 injured
ELECTRICAL SYSTEM
My coolant line overheated. From the leaking water pump and pcv that exploded all over my engine causing it to overheat and now how has not turned back on. Ive been without a car for months and when I seen the recall and reached out to the dealer expressing my situation they said they would get back to me and have not called or emailed or even responded in months.
NHTSA complaint #11697057 — an unverified report by a vehicle owner.
Victorville, CAFire1 injured
ENGINE
My coolant line overheated. From the leaking water pump and pcv that exploded all over my engine causing it to overheat and now how has not turned back on. Ive been without a car for months and when I seen the recall and reached out to the dealer expressing my situation they said they would get back to me and have not called or emailed or even responded in months.
NHTSA complaint #11697057 — an unverified report by a vehicle owner.
at 120,000 milesAnniston, ALFire
ELECTRICAL SYSTEM
The contact owned a 2016 BMW 528I. The contact stated that while driving at 30 -35 MPH with the windows down, there was a smoke odor present. The contact pulled over into a parking lot and smoke was discovered coming from the front of the vehicle. The vehicle suddenly engulfed in flames as the contact was still seated in the vehicle. The contact was able to safely exit the vehicle. The fire department arrived on the scene and was able to extinguish the fire. The origin of the fire was unknown. It was unknown if a fire report was filed. No injuries were sustained. The vehicle was towed to an independent mechanic who determined that the vehicle was destroyed and the cause was unknown since the fire destroyed the front end of the vehicle including the dashboard and both front driver and passenger side door panels were melted. The dealer was not contacted. The manufacturer was not made aware of the failure. The VIN was included in NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System) however, the part to do the recall repair was unavailable. The failure mileage was 120,000. VIN tool confirms parts not available.
NHTSA complaint #11621539 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Chantilly, VA
FUEL/PROPULSION SYSTEM
Vehicle: 2016 BMW 528i xDrive (VIN: [XXX]) Safety Issue / Defect Description: Strong, hazardous raw gasoline fumes began entering the passenger cabin and trunk area. On XXX, the vehicle was brought to an authorized dealership (BMW of Sterling) for diagnostic evaluation. The dealership's technician conducted a multi-point inspection and produced video evidence documenting fluid leaking from the top of the plastic fuel tank. The dealership issued Repair Order Quote #$4,824.92 to "REPLACE FUEL TANK DUE TO FUEL LEAK" and declared the vehicle unsafe. Despite diagnosing a structural fuel tank leak that allows raw gasoline and fumes to migrate into the cabin—presenting an immediate fire, explosion, and toxic vapor risk—BMW of North America and the dealership have refused warranty coverage or goodwill assistance, claiming the tank is "not leaking actively enough" under Service Bulletin SI B01 03 22 (NHTSA ID: MC-10212779-9999). An uncontained raw fuel leak on a plastic fuel tank is a critical safety defect that requires immediate investigation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11753570 — an unverified report by a vehicle owner.
Chantilly, VA
FUEL/PROPULSION SYSTEM
The vehicle developed a strong, toxic odor of raw gasoline inside the passenger cabin and trunk area. The vehicle was brought to an authorized franchise, BMW of Sterling, where technicians performed a multi-point inspection. The technician confirmed that the factory plastic fuel tank assembly is structurally defective and leaking raw fuel from the top weld seams. The dealer provided an official invoice quoting $4,824.92 to replace the tank due to the fuel leak, noting it is an active hazard, but refused to cover the failure under BMW’s active 15-year/150,000-mile extended warranty for N20 plastic fuel tanks (SI B01 03 22). Driving a vehicle with raw fuel pooling on the exterior of the tank and migrating into the cabin creates an immediate fire hazard and health risk to occupants."
NHTSA complaint #11751663 — an unverified report by a vehicle owner.
at 32,400 milesPembroke Pines, FL
ENGINE
The contact owns a 2016 BMW 528i. The contact stated that the vehicle was repaired under an unknown recall, and after the recall repair, while driving at an undisclosed speed, there was an abnormal oil-burning odor entering the cabin of the vehicle. The vehicle was taken to a local Midas, where it was discovered that oil was leaking onto the engine. The vehicle was not repaired due to the cost. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 32,400.
NHTSA complaint #11719874 — an unverified report by a vehicle owner.
Elkridge, MD
EXTERIOR LIGHTING
I have 2016 BMW 5 series car, for past two to three years headlights are getting condensation inside on colder months. Dealer is not able to fix the condensation, they are advising to replace the headlights. Some of my friends replaced OEM headlights, but after few years they are started condensation, it’s looked like defect from manufacturer, I had few Honda vehicles older than my BMW car, they never had any condensation complaints. It’s look like manufacturer used cheap materials causing condensation, it is causing low light at night times may lead to accidents. Please look at this issue and consider it as a safety issue and please recall these headlights. Dealer is asking $2500 + $500 labor to fix each headlight. All of my friends are having same problem, I bet other BMW car owners too. Please issue a recall on this safety issue.
NHTSA complaint #11716890 — an unverified report by a vehicle owner.
West Hollywood, CAFire
STRUCTURE:BODY
On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V-608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.
NHTSA complaint #11713522 — an unverified report by a vehicle owner.
West Hollywood, CAFire
ELECTRICAL SYSTEM
On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V-608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.
NHTSA complaint #11713522 — an unverified report by a vehicle owner.
West Hollywood, CAFire
ENGINE
On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V-608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.
NHTSA complaint #11713522 — an unverified report by a vehicle owner.
Victorville, CAFire1 injured
ELECTRICAL SYSTEM
My coolant line overheated. From the leaking water pump and pcv that exploded all over my engine causing it to overheat and now how has not turned back on. Ive been without a car for months and when I seen the recall and reached out to the dealer expressing my situation they said they would get back to me and have not called or emailed or even responded in months.
NHTSA complaint #11697057 — an unverified report by a vehicle owner.
Victorville, CAFire1 injured
ENGINE
My coolant line overheated. From the leaking water pump and pcv that exploded all over my engine causing it to overheat and now how has not turned back on. Ive been without a car for months and when I seen the recall and reached out to the dealer expressing my situation they said they would get back to me and have not called or emailed or even responded in months.
NHTSA complaint #11697057 — an unverified report by a vehicle owner.
Wayne City, IL
ENGINE
During initial cold starts there is blue smoke billowing from the exhaust for approx 20 seconds. The odor is horrible.
NHTSA complaint #11687010 — an unverified report by a vehicle owner.
Florence, AZ
POWER TRAIN
A critical component failure has rendered my 2016 BMW 528xi inoperable and unsafe. The water pump failed, forcing the car into a safety "limp mode," limiting its speed to approximately 40 miles per hour. This issue mirrors NHTSA Recall 24V-608 regarding an electrical connector on the water pump that can short circuit, potentially causing a "thermal event or fire." The problem began with dashboard warnings about overheating, despite the coolant reservoir being full. Following these warnings, the vehicle entered "limp mode," posing a significant safety risk in normal traffic. The potential for fire is also a major concern. An independent service center has confirmed the water pump and its electrical connector as the point of failure. The failed component is available for inspection by a NHTSA investigator. I contacted BMW's customer relations line and was informed that no remedy is currently available. I must wait for an official letter before any action can be taken, including reimbursement. The representative did not provide a case number, making it impossible to track my complaint. The vehicle has not been inspected by the manufacturer, law enforcement, or an insurance representative. I am unable to transfer the title because the car cannot pass a safety inspection in its current state. I am in a severe catch-22: I must receive a recall letter for a vehicle that I am unable to finalize ownership of. This failure to assist an owner with a known safety recall has left me stranded with a dangerous, undrivable vehicle.
NHTSA complaint #11683511 — an unverified report by a vehicle owner.
Florence, AZ
VEHICLE SPEED CONTROL
A critical component failure has rendered my 2016 BMW 528xi inoperable and unsafe. The water pump failed, forcing the car into a safety "limp mode," limiting its speed to approximately 40 miles per hour. This issue mirrors NHTSA Recall 24V-608 regarding an electrical connector on the water pump that can short circuit, potentially causing a "thermal event or fire." The problem began with dashboard warnings about overheating, despite the coolant reservoir being full. Following these warnings, the vehicle entered "limp mode," posing a significant safety risk in normal traffic. The potential for fire is also a major concern. An independent service center has confirmed the water pump and its electrical connector as the point of failure. The failed component is available for inspection by a NHTSA investigator. I contacted BMW's customer relations line and was informed that no remedy is currently available. I must wait for an official letter before any action can be taken, including reimbursement. The representative did not provide a case number, making it impossible to track my complaint. The vehicle has not been inspected by the manufacturer, law enforcement, or an insurance representative. I am unable to transfer the title because the car cannot pass a safety inspection in its current state. I am in a severe catch-22: I must receive a recall letter for a vehicle that I am unable to finalize ownership of. This failure to assist an owner with a known safety recall has left me stranded with a dangerous, undrivable vehicle.
NHTSA complaint #11683511 — an unverified report by a vehicle owner.
Florence, AZ
ELECTRICAL SYSTEM
A critical component failure has rendered my 2016 BMW 528xi inoperable and unsafe. The water pump failed, forcing the car into a safety "limp mode," limiting its speed to approximately 40 miles per hour. This issue mirrors NHTSA Recall 24V-608 regarding an electrical connector on the water pump that can short circuit, potentially causing a "thermal event or fire." The problem began with dashboard warnings about overheating, despite the coolant reservoir being full. Following these warnings, the vehicle entered "limp mode," posing a significant safety risk in normal traffic. The potential for fire is also a major concern. An independent service center has confirmed the water pump and its electrical connector as the point of failure. The failed component is available for inspection by a NHTSA investigator. I contacted BMW's customer relations line and was informed that no remedy is currently available. I must wait for an official letter before any action can be taken, including reimbursement. The representative did not provide a case number, making it impossible to track my complaint. The vehicle has not been inspected by the manufacturer, law enforcement, or an insurance representative. I am unable to transfer the title because the car cannot pass a safety inspection in its current state. I am in a severe catch-22: I must receive a recall letter for a vehicle that I am unable to finalize ownership of. This failure to assist an owner with a known safety recall has left me stranded with a dangerous, undrivable vehicle.
NHTSA complaint #11683511 — an unverified report by a vehicle owner.
Atlantic Highlands, NJ
EXTERIOR LIGHTING
My driver headlight is constantly getting moisture trapped in it. It’s been replaced twice and the seals were checked, but it keeps happening and shorting out my headlight. It’s $4000 to fix. Just had it replaced 1.5 weeks ago and it’s broken already. I took it to bmw the moment I noticed the moisture was back and they told me it was fine. This is a widespread problem and they are not fixing their product
NHTSA complaint #11682405 — an unverified report by a vehicle owner.
Port St. Lucie, FL
ENGINE
Multiple critical BMW engine components are manufactured from plastic, including the oil pan, coolant expansion tank, valve cover, and turbo inlet pipe. These parts are prone to premature failure from normal heat & stress, as confirmed by independent mechanics. Failures can cause sudden loss of oil or coolant, persistent oil leaks, overheating, loss of power, and roadside breakdowns. The use of plastic for an oil pan is concerning. Plastic cannot withstand impacts with common road hazards such as tire fragments, etc. Striking a retread at highway speed could easily crack the pan, dump all engine oil, and lead to catastrophic engine seizure, endangering people. In my case (2016 BMW 528i), several plastic components have already failed, including the oil pan, turbo inlet pipe, coolant expansion tank, valve cover, and multiple coil packs. While BMW considers coil pack replacement a normal maintenance item, there are widespread complaints of premature failures. Most of the heat-related plastic failures occur above 70,000 miles. Despite several related breakdowns, the previous owner and I avoided dangerous situations. These failures are widely documented by other owners online and by independent mechanics, who often recommend aftermarket aluminum replacements for improved safety and reliability. BMW is aware of these issues but continues to use plastic for critical components--they recently lost a class-action lawsuit related to internal plastic engine parts that caused catastrophic engine damage, showing prior knowledge of the risks. These failures also create environmental hazards, as leaking plastic oil pans & valve covers contaminate roads and driveways. Because repairs are $$$, many consumers delay fixing the problems, increasing both safety and environmental risks. This design prioritizes cost savings over durability and safety. These parts should be made of metal to withstand normal use and protect drivers, passengers, and the public from unnecessary hazards.
NHTSA complaint #11682147 — an unverified report by a vehicle owner.
Long Beach, CA
VEHICLE SPEED CONTROL
Coolant pump failure engine failure also caused fire in engine bay. Insurance inspector. Pre shop inspection. No light were on prior to explosion.
NHTSA complaint #11681035 — an unverified report by a vehicle owner.
Long Beach, CA
ELECTRICAL SYSTEM
Coolant pump failure engine failure also caused fire in engine bay. Insurance inspector. Pre shop inspection. No light were on prior to explosion.
NHTSA complaint #11681035 — an unverified report by a vehicle owner.
Long Beach, CA
ENGINE
Coolant pump failure engine failure also caused fire in engine bay. Insurance inspector. Pre shop inspection. No light were on prior to explosion.
NHTSA complaint #11681035 — an unverified report by a vehicle owner.
Towaco, NJ
POWER TRAIN
Very often, when I change the gear to 'Drive' or 'Reverse' I get a message on the dashboard screen - "secure Vehicle against rolling" and the car DOES NOT move unless I shift the auto gear lever several times or sometimes shut off the engine to get back to normal driving. Once when I was in such a situation, no matter what I do, the error message would not go away and I had to call the tow truck to get home. And when tow truck person brought the car home, the problem fixed itself!! I only have 81000 miles on this car. It is a very serious safety issue as far as I am concerned. PLEASE HELP.
NHTSA complaint #11676315 — an unverified report by a vehicle owner.
Towaco, NJ
ENGINE
Very often, when I change the gear to 'Drive' or 'Reverse' I get a message on the dashboard screen - "secure Vehicle against rolling" and the car DOES NOT move unless I shift the auto gear lever several times or sometimes shut off the engine to get back to normal driving. Once when I was in such a situation, no matter what I do, the error message would not go away and I had to call the tow truck to get home. And when tow truck person brought the car home, the problem fixed itself!! I only have 81000 miles on this car. It is a very serious safety issue as far as I am concerned. PLEASE HELP.
NHTSA complaint #11676315 — an unverified report by a vehicle owner.
Rancho Cucamonga, CA
ELECTRICAL SYSTEM
The contact owns a 2016 BMW 528I. The contact stated that while the vehicle was parked and running, the contact became aware of an abnormal burning odor. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was not made aware of the failure. The approximate failure mileage was 45,000. VIN tool confirms parts not available.
NHTSA complaint #11675593 — an unverified report by a vehicle owner.
Rancho Cucamonga, CA
ENGINE AND ENGINE COOLING
The contact owns a 2016 BMW 528I. The contact stated that while the vehicle was parked and running, the contact became aware of an abnormal burning odor. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was not made aware of the failure. The approximate failure mileage was 45,000. VIN tool confirms parts not available.
NHTSA complaint #11675593 — an unverified report by a vehicle owner.
New Britain, CT
ELECTRICAL SYSTEM
The contact owns a 2016 BMW 528I. The contact stated that while her son was driving at undisclosed speeds, there was an abnormally loud knocking sound coming from the vehicle. The contact stated that there was coolant leaking from the vehicle. The contact was adding coolant to the coolant reservoir every other day. The contact stated that the vehicle was smoking and there was an abnormal rattling sound coming from the vehicle and the engine was overheating. The vehicle was inoperable. The coolant message was displayed. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.
NHTSA complaint #11675103 — an unverified report by a vehicle owner.
New Britain, CT
ENGINE AND ENGINE COOLING
The contact owns a 2016 BMW 528I. The contact stated that while her son was driving at undisclosed speeds, there was an abnormally loud knocking sound coming from the vehicle. The contact stated that there was coolant leaking from the vehicle. The contact was adding coolant to the coolant reservoir every other day. The contact stated that the vehicle was smoking and there was an abnormal rattling sound coming from the vehicle and the engine was overheating. The vehicle was inoperable. The coolant message was displayed. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.
NHTSA complaint #11675103 — an unverified report by a vehicle owner.
Weatogue, CT
ELECTRICAL SYSTEM
The contact owns a 2016 BMW 528I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11671590 — an unverified report by a vehicle owner.