183 of the
1,239 complaints filed about the BMW 528I
are about the electrical system —
15% of everything owners reported.
The worst model year for it is 2015.
the vehicle was driven for approximately 30 minutes, operating with zero dashboard warnings or performance indicators. The vehicle was then parked on my property and turned off completely. Approximately two hours and thirty minutes later, the vehicle spontaneously ignited while stationary and unoccupied. The local fire department responded and successfully extinguished the blaze. Both physical observations and my home security camera footage confirm that the point of origin was the front right passenger side of the engine compartment. This exact location houses the factory electric water pump and its electrical plug connector, directly matching the failure mechanism detailed in NHTSA Campaign 24V608000, wherein fluid intrusion causes a severe, persistent electrical short circuit capable of igniting a fire hours after the vehicle is parked. The car is completely totaled because of this.
NHTSA complaint #11746090 — an unverified report by a vehicle owner.
car was brought in for a recall could erupt fire from engine and electrical brought car to bmw 8/2025 have checked list when brought in car was in perfect condition per bmw .pick up car checked engine light was on brought back immediately manager took to shop and cleared light immediately came back on i called them then i drive screen was saying low coolant oil low drivetrain overheating oil leaks burning smell coolant smell etc called bmw na service manager etc waited for appointment 1/26 bmw had for 8 days only to say it had nothing to do with recall car now has no power excessive smoke smell undriveable been in garage for 3 months if ran would catch on fire 🔥
NHTSA complaint #11745013 — an unverified report by a vehicle owner.
The contact owns a 2015 BMW 528i. The contact stated that while his vehicle was parked, the coolant pump connector caught on fire, which was connected to a after market Coolant pump. The failure experienced was a localized electrical fire that originated at the coolant pump connector and aftermarket coolant pump while the vehicle was parked. The contact referenced NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM) but was told by the dealer they could not repair the recall due to the vehicle having an aftermarket coolant pump. The contact stated he originally replaced the coolant pump with an aftermarket one due to a failure, as advised in the recall notice. The vehicle was occupied during the failure. There was grey smoke coming from the engine and inside the vehicle, with flames that were coming from the hood and under the engine. The fire originated specifically within the coolant pump assembly and its associated electrical connector, with the thermal damage concentrated in that area before spreading. The fire department was able to extinguish the fire. The vehicle was towed to the dealer. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 120,000.
NHTSA complaint #11716235 — an unverified report by a vehicle owner.
On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V-608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.
NHTSA complaint #11713522 — an unverified report by a vehicle owner.
See attached document for complaint. Greetings: I am writing pursuant to recalls No. 24V‑608, both remedy unavailable and remedy available, ten months later. During the intervening ten months, I experienced hardship, expense and loss of use of my vehicle. The attached documents represent my correspondence to BMW Customer relations. The docs were submitted on September 22, 2025 and October 14, 2025, by email. I have received no response, to date; not even acknowledgement of receipt. I hereby submit my belief that BMW has some responsibility for failure to cure the smoke condition they knew about for ten months. Please note the BMW service inspection of August 14, 2025 in which it was stated that my warning lights passed the inspection. Meanwhile, the warning lights on my dashboard look like a “xmas tree”. I am being ghosted by BMW and I have no power, unless you say I do. Please help in any way which is fair. Thank You.
NHTSA complaint #11708800 — an unverified report by a vehicle owner.
I am filing a complaint regarding the recall work performed on my 2011 BMW 528i for the VANOS bolt safety recall. The recall notice stated the vehicle was unsafe to drive until repaired. I arranged towing to Jackie Cooper BMW in Edmond, Oklahoma because of this safety warning. The dealership performed the recall repair and released the vehicle back to me. Immediately after picking it up, the vehicle experienced a failure and became inoperable. The vehicle had to be towed again. This time, the dealership covered the towing cost and had the vehicle returned to my residence. Staff present at the time included a technician named Luke and the Service Drive Manager, Tayler Hawkins. Staff statements indicated that diagnostic charges would have applied if issues outside the recall were found, but no diagnostics were ultimately billed. There were also inconsistencies regarding the availability of the service manager. I am filing this complaint because the vehicle failed immediately after recall service and required towing. I am concerned that the recall work may not have been performed correctly or that the vehicle was released in a condition that was not suitable for operation. I am requesting that this incident be documented as part of the recall and safety record for this vehicle.
NHTSA complaint #11699975 — an unverified report by a vehicle owner.
My coolant line overheated. From the leaking water pump and pcv that exploded all over my engine causing it to overheat and now how has not turned back on. Ive been without a car for months and when I seen the recall and reached out to the dealer expressing my situation they said they would get back to me and have not called or emailed or even responded in months.
NHTSA complaint #11697057 — an unverified report by a vehicle owner.
The contact owns a 2015 BMW 528I. The contact previously received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical Systems). The vehicle was taken to the dealer, where it was only inspected for the plug connector, and a protective shield was installed. The contact stated that the vehicle was not inspected for the water pump as part of the recall. The contact stated that while driving at an undisclosed speed, the engine overheated, with several unknown messages displayed. The vehicle was taken back to the dealer, where it was diagnosed and determined that the water pump had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for additional assistance. The approximate failure mileage was 174,000.
NHTSA complaint #11694178 — an unverified report by a vehicle owner.
The contact owns a 2015 BMW 528I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that after driving approximately 2 hours or more, there was smoke coming from underneath the hood of the vehicle and entering the cabin of the vehicle. The contact would pull over to a safe location and park for approximately an hour before continuing to drive. The failure was persistent and recurred after driving for approximately 2 hours or more. The check engine warning light was illuminated. The vehicle was taken to a certified mechanic, who diagnosed a failure with the water pump. The mechanic replaced the ignition coils twice. The contact stated that one coil was replaced the first time, and the entire four ignition coils were replaced the second time however, the failure persisted. The vehicle was taken to the dealer and the dealer related the failure to the recall; however, the part was not yet available. The manufacturer was notified of the failure and confirmed that parts were not yet available. The failure mileage was approximately 80,000.
NHTSA complaint #11683691 — an unverified report by a vehicle owner.
A critical component failure has rendered my 2016 BMW 528xi inoperable and unsafe. The water pump failed, forcing the car into a safety "limp mode," limiting its speed to approximately 40 miles per hour. This issue mirrors NHTSA Recall 24V-608 regarding an electrical connector on the water pump that can short circuit, potentially causing a "thermal event or fire." The problem began with dashboard warnings about overheating, despite the coolant reservoir being full. Following these warnings, the vehicle entered "limp mode," posing a significant safety risk in normal traffic. The potential for fire is also a major concern. An independent service center has confirmed the water pump and its electrical connector as the point of failure. The failed component is available for inspection by a NHTSA investigator. I contacted BMW's customer relations line and was informed that no remedy is currently available. I must wait for an official letter before any action can be taken, including reimbursement. The representative did not provide a case number, making it impossible to track my complaint. The vehicle has not been inspected by the manufacturer, law enforcement, or an insurance representative. I am unable to transfer the title because the car cannot pass a safety inspection in its current state. I am in a severe catch-22: I must receive a recall letter for a vehicle that I am unable to finalize ownership of. This failure to assist an owner with a known safety recall has left me stranded with a dangerous, undrivable vehicle.
NHTSA complaint #11683511 — an unverified report by a vehicle owner.
The contact owns a 2013 BMW 528I. The contact stated that after driving and parking the vehicle, the contact smelled an abnormal burning odor. The contact stated the burning odor occurred frequently. The contact stated that the vehicle was towed to the dealer where the vehicle was purchased. The contact was aware of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System). The contact was unaware that the vehicle needed to be taken to an authorized BMW dealer for the recall repair. The vehicle remained at the dealer unrepaired. The manufacturer was not informed of the failure. The contact was referred to a BMW dealer for assistance. The failure mileage was approximately 107,000.
NHTSA complaint #11680731 — an unverified report by a vehicle owner.
The contact owns a 2015 BMW 528I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11675613 — an unverified report by a vehicle owner.
The contact owns a 2016 BMW 528I. The contact stated that while the vehicle was parked and running, the contact became aware of an abnormal burning odor. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was not made aware of the failure. The approximate failure mileage was 45,000. VIN tool confirms parts not available.
NHTSA complaint #11675593 — an unverified report by a vehicle owner.
The contact owns a 2016 BMW 528I. The contact stated that while her son was driving at undisclosed speeds, there was an abnormally loud knocking sound coming from the vehicle. The contact stated that there was coolant leaking from the vehicle. The contact was adding coolant to the coolant reservoir every other day. The contact stated that the vehicle was smoking and there was an abnormal rattling sound coming from the vehicle and the engine was overheating. The vehicle was inoperable. The coolant message was displayed. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.
NHTSA complaint #11675103 — an unverified report by a vehicle owner.
The contact owns a 2015 BMW 528I. The contact received notification of NHTSA Campaign Number: 24V608000(Engine and Engine Cooling; Electrical System) however, the part to do the recall repair was not yet available. An unknown local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11672662 — an unverified report by a vehicle owner.
The contact owns a 2016 BMW 528I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11671590 — an unverified report by a vehicle owner.
My vehicle is a 2016 BMW 528i xDrive. There is an active safety recall listed under NHTSA Campaign Number 24V-608, issued in August 2024. The affected component is the engine coolant pump. As of June 2025, no remedy has been made available by BMW, and I have been told by both BMW corporate and my local dealer that they cannot provide a fix or a timeline. This component is essential to keeping the engine within safe temperature limits. Failure of the coolant pump could lead to overheating and potentially increase the risk of fire, as the recall suggests. This places my safety and that of others on the road at risk every time I drive the vehicle. I rely on this car for regular transportation and feel I have no choice but to drive a vehicle with an unresolved critical safety issue. The vehicle has not yet experienced a failure or warning light specific to the coolant system, and it has not been inspected or repaired due to the lack of remedy. However, I should not be forced to wait indefinitely or risk a dangerous situation developing before action is taken. BMW’s failure to provide a remedy or meaningful updates in nearly a year shows a lack of urgency and accountability. I am submitting this complaint to formally document the issue and ask that NHTSA take action to compel BMW to issue a fix or provide alternatives to affected owners.
NHTSA complaint #11669076 — an unverified report by a vehicle owner.
Incident Description: This complaint concerns both the lack of navigation system support and the unresolved recall status for my 2014 BMW 5 Series. 1.Navigation System: BMW no longer supports map or system updates for this vehicle, and no hardware or retrofit upgrade is available. The outdated GPS system results in inaccurate directions, missing roads, and potentially unsafe routes. BMW dealerships confirm there are no solutions, creating a long-term safety hazard for owners who rely on navigation systems. 2.Recall Incomplete: I have an open recall on this vehicle, but BMW dealerships have only responded with vague statements such as, “it should be coming soon.” There has been no formal notification, letter, or resolution from BMW. This lack of transparency and urgency in addressing safety recalls is unacceptable. 3.Unethical Service Tactics: BMW dealerships are often more focused on convincing customers to upgrade their vehicle than resolving legitimate service issues. Staff push expensive services and frame them as “complaints” on invoices—using high-pressure tactics to imply serious mechanical threats unless those services are purchased. This raises concerns about ethics and misrepresentation. This experience is based on NY but all BMW dealership operate same way overpricing and if you tell them a BMW dealership gives you less than what is on their quote, they want them to show it to you , reflecting their unethical manner to overprice everything when it comes to service or selling. Safety Concern: The combination of an unsupported navigation system and delayed recall resolution undermines vehicle safety and consumer trust. BMW's conduct demonstrates a disregard for long-term customer support and safety compliance. Resolution Requested: •Require BMW to provide retrofit or updated navigation options. •Enforce clear timelines and communication for resolving recalls. •Investigate dealership practices that prioritize upselling over safety and truthfulness.
NHTSA complaint #11668430 — an unverified report by a vehicle owner.