546 of the
4,578 complaints filed about the BMW X5
are about the electrical system —
100% of everything owners reported.
The worst model year for it is 2019.
My 2020 BMW X5 sDrive40i has experienced recurring and serious electrical, shutdown, and drivability problems that have not been resolved despite BMW service and a recall-related repair. The vehicle has unexpectedly restarted after being turned off and has also failed to shut down properly. On September 6, 2026, after being parked at Costco for approximately 40–60 minutes, I returned to find the vehicle off but not secured. The brake lights were on, the windows were down even though I had left them up, and the interior systems were operating. The radio was playing an unfamiliar station, although I do not listen to the radio. I documented this on video. Later that same day at Whole Foods, after parking, turning the vehicle off, and getting out to retrieve my dogs, the vehicle appeared to still be running. Video captured the engine running for approximately one second. I shut it off and locked it, but the vehicle then unlocked itself, also captured on video. These were two separate incidents within nine days, occurring after BMW performed a recall-related repair intended to address unexpected vehicle reactivation. In addition, the vehicle has twice shut off unexpectedly while accelerating on the freeway. These incidents, combined with the unexpected restarting, failure to shut down, windows opening, and vehicle unlocking itself, create serious safety concerns. I purchased this vehicle specifically to transport my dogs. If the vehicle can unlock itself or lower the windows while I am away, my dogs could escape or be exposed to being taken. I no longer have confidence that the vehicle will remain safely shut down and secured when I leave it. The recurring nature of these failures and the fact that they have continued after BMW’s attempted repair require a thorough investigation and permanent resolution. I am requesting that BMW review the complete history and consider repurchase or replacement if the defect cannot be permanently corrected.
NHTSA complaint #11764210 — an unverified report by a vehicle owner.
The starter motor malfunctioned, which then prevented the car from starting when it was hot. It could only be started after it had completely cooled down. Additionally, the fault code indicated that there was a problem with the starter motor. I also noticed that there was a similar recall before, so I'm wondering if this one might also pose a risk of fire.
NHTSA complaint #11763905 — an unverified report by a vehicle owner.
Odometer Fraud. The contact purchased a 2015 BMW X5. It was discovered that there was a mileage discrepancy after the purchase. The vehicle was a dealer sale. At the time of purchase, the mileage was 130,514. However, the Auto Check Vehicle History report indicated that the mileage was 160,258 when it was last registered with the DMV on 11/26/2024.
NHTSA complaint #11763454 — an unverified report by a vehicle owner.
I am writing to formally document serious and recurring safety concerns with my Certified Pre-Owned 2024 BMW X5e, which I purchased from BMW of Sterling on XXX. On XXX I was merging onto [XXX] during morning rush hour when my vehicle suddenly lost power and shut down in the middle of traffic. The vehicle first displayed a yellow drivetrain warning indicating that I could continue driving at reduced power to the nearest service center. Almost immediately afterward, a red drivetrain warning appeared instructing me to seek service immediately. At that point, the vehicle would not restart and continued displaying the error message. Having a vehicle suddenly become disabled in the middle of a major interstate during rush-hour traffic was both frightening and extremely dangerous. I contacted BMW Assist but was transferred among several representatives without receiving meaningful assistance. VDOT ultimately responded, and the vehicle was towed at my expense to BMW of Sterling. Ultimately, I was informed that BMW of Sterling could not identify the cause of the failure or replicate the problem. I was told that BMW in Germany had been consulted and that the vehicle's electronics had been reset. When I picked up the vehicle, I specifically asked whether it had been tested in electric, hybrid, and sport modes and was told that it had. However, my BMW app indicated that the vehicle had not been charged since before I brought it in for service, which raised concerns for me about the extent of the testing that was performed. On XXX, I drove the vehicle to [XXX], for work. When I returned to the vehicle that afternoon and attempted to start it, I received the same drivetrain warning messages. After approximately 15 minutes, the vehicle eventually started normally, and I was able to drive home without further incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11763444 — an unverified report by a vehicle owner.
The contact owns a 2021 BMW X5. The contact stated that the AC was inoperable. The vehicle was taken to a dealer and an independent mechanic on several occasions to repair the AC; however, the failure reoccurred after each repair. The AC was not replaced. The contact believed that the issue was caused by Hybrid system.
NHTSA complaint #11762762 — an unverified report by a vehicle owner.
Vehicle: 2021 BMW X5 xDrive40i (G05) Mileage: 54,423 miles Component: Central Information Display (CID)/ MGU (Media Graphics Unit) Head Unit Safety Defect: The CID intermittently goes completely blank without warning. When this occurs, the backup camera is unavailable, creating a safety hazard when reversing. Navigation, radio, Apple CarPlay, and vehicle settings are also unavailable. Failure History/Diagnosis: The first failure occurred about one month ago while I was reversing. After several hard resets and leaving the vehicle unused for two days, the display began working again. The failure occurred again yesterday when my spouse started the vehicle. I took it to Bobby Rahal BMW of South Hills, PA. The BMW technician confirmed that the head unit (MGU) and RAM (Receiver Audio Module) are not communicating. The technician also found corrosion on the head-unit power connector and inside the head unit, suggesting moisture intrusion and/or an internal electrical short. The dealer recommended replacing the head unit, with the part costing over $4,000, plus labor and additional diagnosis to identify the source of the leak/moisture causing the corrosion. Inspection: The defect was inspected and confirmed by the BMW dealer. The failed component is available for inspection upon request. There were no police or insurance inspections. Warning Signs: There were no warning lights or messages before either failure. The display simply went blank. The failure is intermittent and unpredictable. Safety Concern: The CID can suddenly fail during operation, including while reversing, causing loss of the backup camera and other critical functions. Corrosion inside the head unit and on its power connector raises concern about a recurring moisture-intrusion or electrical/design defect. I request that NHTSA investigate whether this is a recurring safety defect affecting BMW X5 G05 vehicles and determine whether a recall or corrective action is warranted.
NHTSA complaint #11762076 — an unverified report by a vehicle owner.
COMPONENT / FAULT CATEGORY: ELECTRICAL SYSTEM / POWER TRAIN / BLIND SPOT WARNING SUMMARY OF THE DEFECT: On April 11, 2026, my 2019 BMW X5 suffered a sudden electronic system shutdown at highway speeds near the 210 exit, stranding the car on the roadway and requiring AAA towing. BMW of Ontario falsely blamed "liquid damage" in the GSW shifter and texted an inflated quote of $6,616.05, later reduced to $3,616.05 on Invoice #BFCS684959 before waiving fees for oil changing and so on due to communication errors. NO liquid spill occurred. The GSW module near cup holders suffers from an unsealed design defect where ambient condensation causes total drive power loss. DETAILED INCIDENT NARRATIVE: The center console in the BMW X5 (G05) lacks basic liquid/moisture isolation. Condensation or ambient humidity short-circuits critical shifting electronics, causing immediate loss of drive power on public roadways and creating an extreme crash risk. This incident is part of a clear pattern of systemic electrical vulnerabilities on this specific vehicle: 1. STARTER SAFETY RECALL & HIGHWAY SHUTDOWN: Last year, this vehicle suffered a sudden highway shutdown caused by a faulty starter. BMW failed to send a recall notice beforehand. After I was forced to pay out-of-pocket for emergency repairs at Coast BMW, BMW later recognized the recall and issued a full reimbursement this year. 2. BLIND SPOT WARNING SYSTEM FAILURE: The vehicle also suffered an unexplained, premature failure of the Blind Spot Warning system (quoted at over $3,000 to repair and left unaddressed), proving broader electronic/sensor vulnerabilities. Furthermore, dealership handling involved deceptive, erratic quotes ($6,616.05 texted initially vs. $3,616.05 on the invoice) to shift financial liability for a latent design defect onto the consumer.
NHTSA complaint #11761190 — an unverified report by a vehicle owner.
The contact owns a 2021 BMW X5. The contact stated that the vehicle failed to immediately start. The vehicle started later. The engine and a yellow warning light flashed on the instrument panel. Upon research, the contact located the German Federal Motor Transport Authority (Kraftfahrt-Bundesamt), for KBA Reference Number: 16131R, which was associated with the starter motor. The contact stated that the failure was associated with NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling) and 25V644000 (Electrical System). The vehicle was taken to an independent mechanic who determined that the failure was associated with the starter motor, which was replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and the contact was informed that there was no recall on the VIN associated with the failure. The failure mileage was approximately 49,000.
NHTSA complaint #11759048 — an unverified report by a vehicle owner.
The contact’s wife who owns a 2019 BMW X5. The contact stated that while the vehicle was parked, there was an abnormal sound and the vehicle intermittently stalled. No warning lights were illuminated. The failure had occurred on several occasions. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the starter needed to be replaced. The vehicle was not repaired and was taken back to the residence. The contact stated that the vehicle stalled again and failed to return to normal operation. A dealer was contacted; however, the vehicle was not yet diagnosed or repaired. The contact researched and was made aware of an unknown recall; however, the VIN was not under recall. The manufacturer was not notified of the failure. The failure mileage was approximately 79,000.
NHTSA complaint #11758202 — an unverified report by a vehicle owner.
2025 BMW X5...warning lights appeared and voice said emergency stop... emergency stop and tried to pull me off the road. shut down the vehicle for a while... and started up. finished errands. got home. vehicle would not start in the morning. dealership said it was an issue with the braking system... electronics and dead battery . said repaired. got it back. happened again...but got it going. dealership said if it happened again... press the gas pedal and it would clear up the problem. recent issue August 18, 2026. vehicle would not start. got a jump and emergency lights again.. emergency stop. vehicle towed to dealership. was told it had faults with the brake control unit. believed to be fixed but further testing to make sure. I'm worried this will happen on highway or the vehicle is not sellable if I ever want to sell or trade it in
NHTSA complaint #11758309 — an unverified report by a vehicle owner.
I was driving at 70 mph on the highway when the car suddenly and without warning went into neutral, lost all functionality, and displayed the warning "Drivetrain Malfunction--Stop Driving Immediately--Call Roadside Assistance." I had to drift (barely) to side of a busy highway and exit the vehicle to get to safety. The dealer review of fault codes include: High-voltage system: No voltage established; No communication possible with: Accumulator-management electronics; SME: Software action required; Function: Acceleration not possible; Function: It is not possible to establish the drive-ready state; Drive function: Repair measure will soon be necessary. This happened on XXX around noon on XXX in [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11757606 — an unverified report by a vehicle owner.
I put a new battery and I need to unplugged the negative every time I turn it off. If I don’t do this, the next day, the battery would be dead. I checked with the Ancel OBD2 and there’s nothing wrong. It doesn’t detect anything bad.
NHTSA complaint #11756877 — an unverified report by a vehicle owner.
My 2026 BMW X5 xDrive50e experienced a serious freeway safety event involving loss of braking/brake power, loss of vehicle power/functionality, and multiple vehicle warnings/errors. The incident occurred while I was driving on the freeway and substantially affected my ability to safely operate the vehicle. BMW Emergency Services subsequently towed the vehicle to Irvine BMW on 07/09/2026. Irvine BMW later attributed the event to Emergency Stop Assist (ESA) and the Driver Monitoring System (DMS), rather than identifying a mechanical brake failure. Its written explanation states that ESA can take over vehicle guidance and decelerate the vehicle using multiple short braking jolts. The dealership reported a stored DMS fault but stated that it could not duplicate my reported condition. I have not been provided evidence that the original freeway event was reproduced or that its cause was conclusively established. Irvine BMW initially represented that material covering the display was an aftermarket screen protector and stated that BMW Technical required its removal because it could interfere with the DMS camera. On 07/27/2026, the General Manager apologized and confirmed that the material was actually original BMW transportation protection film. The dealership also proposed reducing ESA sensitivity as an alternative. I remain concerned that the combination of loss of braking/brake power, loss of vehicle power/functionality, and the reported ESA/DMS behavior may represent a serious safety defect or malfunction affecting braking, vehicle control, or driver-monitoring systems. I kindly request that NHTSA review this reported safety event, including ESA, DMS, related vehicle-control systems, and the interaction with the display/driver-monitoring system, and determine whether further investigation is warranted. I can provide dealership records, BMW App data, communications, and diagnostic documents.
NHTSA complaint #11756626 — an unverified report by a vehicle owner.
The contact owns a 2026 BMW X5. The contact stated that after several days of not driving the vehicle, the messages "Starter Battery Low," "Starter Battery Severely Discharged”, and “You can Still Drive - However Power-Consuming Functions Disabled to Preserve the Battery," were displayed on the BMW App. The contact stated that the battery was severely drained after being fully recharged. In addition, the contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated and the vehicle was pulled over the shoulder of the road, where the vehicle remained until a local independent mechanic arrived on scene to attempt to restart the vehicle; however, the vehicle failed to start. The vehicle was towed to a local dealer where it remained for further investigation. The vehicle was previously repaired at the same local dealer for internal BMW Technical Campaign: B12032626E-A01; however, the failure reoccurred. The vehicle was repaired for Sensing and Module Electronics (SME) and Battery Management Electronics (BME) units. The manufacturer was made aware of the failure. The failure mileage was approximately 644.
NHTSA complaint #11756521 — an unverified report by a vehicle owner.
The high-voltage battery system (this is a plug-in hybrid) began intermittently displaying a "battery not properly charging" warning approximately 6 months ago; the issue would resolve after plugging in and charging. On July 14, 2026, while driving, the vehicle displayed a "critical battery failure - pull over immediately and drive slowly" warning. The driver pulled over and shut off the vehicle; the warning cleared and the car appeared to drive normally afterward. This warning recurred several times over the following weeks under the same pattern. On August 6, 2026, the same critical battery failure warning appeared while driving; this time steering feel and drivetrain response were abnormal, and the air conditioning and several electronic features stopped working. Our safety, and the safety of other drivers on the road, was put at risk by the sudden loss of full vehicle control while in motion. The vehicle has been at an authorized BMW dealership for inspection since August 7, 2026; a full diagnosis is pending. Dealer service staff independently remarked that two other BMW X-series plug-in hybrids came in that same morning with the identical warning and symptoms, suggesting this may be a widespread component defect rather than an isolated issue.
NHTSA complaint #11755843 — an unverified report by a vehicle owner.
The drivetrain warning light came on shortly after I started the vehicle. I noticed acceleration issues both while driving on side streets and on the freeway. I took the X5 45e into the repair center the day after the notice came on especially given the experience on the freeway, which happened during rush hour traffic. Upon inspection, I was told the starter was beginning to fail and that while there had been a recall on starters on many other BMW models, it did not include the X5 45e. BMW advised I replace the starter immediately due to safety, which cost $2,600. Two weeks later, the same drivetrain light has come on and the X5 is back at the service center for diagnosis.
NHTSA complaint #11755801 — an unverified report by a vehicle owner.
I have a 2026 BMW X5 50E. I experienced the same malfunction twice in the same day. The first occurrence was when I was taking my husband to a doctors appointment. While parking the car and when I was almost at a stop the vehicle lurched forward and was stopped by the concrete curb. My husband asked me what happened and I said I don’t know. The second occurrence was about two hours later after visiting a second doctors office I headed to a lunch spot. I pulled into a parking spot and had come almost to a stop and once again the vehicle lurched forward with an even more powerful sudden acceleration. The vehicle struck a metal railing, bordering, an outdoor dining area. Once the railing was hit It pushed into a large freestanding metal continuous privacy panel. The privacy panel collapsed on people and caused multiple injuries. This incident endangered the safety of myself and the safety of many others. There were multiple injuries. I have not yet had the vehicle inspected by a third-party. I received no warnings on the car or through the app prior to the failure. These incidents occurred on July 31, 2026 between 10 AM and 12 PM. I have read and saved the error codes available on the car. There may be some that are associated with the incident. Also of note the incident occurred several days after a software update on July 26 at 1:30 AM
NHTSA complaint #11754180 — an unverified report by a vehicle owner.
A manufacturer defect caused connector pin corrosion and thus the head unit dash stopped working completely and needs to be replaced. The head unit is what the back up camera comes through causing safety concern. It is no longer under warranty because of the miles, otherwise yearwise it would be. BMW won’t provide any good will assistance. This happened in 2026 on a 2023 model year. It has been brought to a bmw service center with a quote of over 6k to fix. No warning symptoms.
NHTSA complaint #11753617 — an unverified report by a vehicle owner.
The driver’s door lock has malfunctioned for the second time. The door became stuck in the locked position and could not be opened normally. There were no warning lights or messages indicating a problem with the door latch or lock system. This creates a serious safety hazard because the driver could be unable to exit the vehicle during an emergency. The right rear passenger seat belt also does not retract properly and cannot be used. The vehicle has previously been taken to a BMW dealership for this same issue, but the problem has returned. Because the seat belt cannot be used, a rear passenger cannot be properly restrained, creating a significant safety risk in the event of a crash.
NHTSA complaint #11752936 — an unverified report by a vehicle owner.