628 of the
4,530 complaints filed about the BMW X5
are about the airbag system —
14% of everything owners reported.
The worst model year for it is 2006.
On August 4, 2026, my vehicle was involved in a direct frontal collision with a brick wall. I was driving with two minor passengers, one seated in the front passenger seat and one seated in the rear passenger seat. The collision resulted in significant front-end damage and a total loss determination by USAA. Despite the frontal impact, none of the vehicle's airbags deployed. Prior to the collision, I observed no Airbag/SRS warning lights, Check Control warnings, or other indications of a restraint-system malfunction. I respectfully request that NHTSA review this incident for a potential Supplemental Restraint System safety issue involving the airbag control module, front impact sensors, deployment logic, passenger occupancy system, seat-belt pretensioners, or related SRS components. I am specifically requesting review of whether similar airbag non-deployment complaints, manufacturer communications, technical service bulletins, field reports, investigations, or other defect information exist for the 2018 BMW X5 or related F15-generation vehicles. I am a disabled military veteran and experienced injuries and aggravation of pre-existing service-connected disabilities following the collision. Two minor passengers were also involved. The attached complaint contains the complete incident description, vehicle information, insurance claim information, and requested safety investigation. Please confirm receipt of this complaint and advise if any additional documentation would assist NHTSA's review. I can provide accident photographs, insurance records, vehicle inspection information, medical documentation, and other supporting evidence. Because the vehicle has been declared a total loss, preservation of the vehicle and its safety-system data may be time-sensitive. Thank you for reviewing this serious safety concern.
NHTSA complaint #11756854 — an unverified report by a vehicle owner.
2023 September BMW issued me a "Stop Drive" letter in the mail. I parked the vehicle and haven't drove it since. Since then ive called the number in letter and visited website. At one time the individual handling and scheduling my "repair" had asked me if I could drive the car to nearest dealership to get repaired? I said absolutely not; i have recieved a letter stating to stop driving? Im not gonna drive it? When I asked about them coming to fix it and getting a loaner as the letter offered? They said when the vehicle makes it to the dealership for repair it will be up to the dealership doing repairs if im to get a loaner? I asked what am I to do until it gets fixed being that I cant drive? No logical answer given? I've attempted several more times to contact BMW per phone numbers given in mailers stating "stop drive"? Im completely at a loss as of today the vehicle has been sitting so long its now damaged, weathered, and so forth? I just recieved another letter in mail last week same thing about repair do not drive and so forth. I cant believe nothing has been done thus far? I see all the deadlines for repair have past and my address has. Never changed or phone number they are still the same as day they sent first "stop drive" letter was sent and that was actually way before September 2023 I dont know exactly when but September is when I first called about getting repair done and still remain unaddressed today?
NHTSA complaint #11736901 — an unverified report by a vehicle owner.
The contact owns a 2021 BMW X5. The contact stated that while driving at an undisclosed speed, the air bag warning light unexpectedly illuminated. The vehicle was taken to the dealer where it was diagnosed that the air bag had failed and that the air bag and/or the sensor needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA hotline for further assistance. The failure mileage was approximately 63,382.
NHTSA complaint #11736074 — an unverified report by a vehicle owner.
My daughter was driving my BMW X5, it went to neutral and not moving, she was panicked and stopped the car and ignition. After restarting the car, it worked for a day, then it happened again, also, I see notifications on dashboard for restraint warning, saying, airbag, and seat belt tension are reduced. I took to Fairfax BMW in VA, BMW quoted $2662, informed that my BMW went out of extended warranty over a month, I asked Goodwill request to BMW, still declined.
NHTSA complaint #11733217 — an unverified report by a vehicle owner.
The contact owns a 2025 BMW X5. The contact stated that while his wife was driving at an undisclosed speed, for an unknown reason, she lost control of the vehicle and hit a telephone pole, where the vehicle came to a stop. The driver-side and passenger-side air bags did not deploy. No warning lights were illuminated. A police report was filed. The contact's wife was taken to the hospital by ambulance. The contact's wife did not suffer injuries. The vehicle was towed to a towing yard. The insurance company was notified. The manufacturer was made aware of the failure. The manufacturer advised the contact that a field inspector would be sent to inspect the vehicle. The field inspector inspected the vehicle. However, no information was provided regarding why the air bags did not deploy. The failure mileage was approximately 8,000.
NHTSA complaint #11724623 — an unverified report by a vehicle owner.
The seal on the sunroof of the car allows water into the car. My car will be available for inspection upon request. This issue allows water into the car around the b pillar airbag and the side window airbag which can damage the airbag and make it deploy without any accidents or make them not deploy in the case of a accident. BMW has an internal document in which acknowledging the issue with the seal but even though they recognize placing a defective part on the vehicle. They will not assume the cost of the repair if outside de 50k miles warranty. In order for the dealership to take a look at the issue an 200 dollar diagnostic is required but I was informed that if they determined that the issue on hand is due to the defective part. I will still have to pay for the repairs. There weren’t any other signs before the incident.
NHTSA complaint #11719455 — an unverified report by a vehicle owner.
Car's information system was giving error stating: "Urgent interior functionality check up. The driver restraint system of your vehicle is malfunctioning. There is an increased risk of injury in case of a collision." Took it to the BMW dealer, they shared this info: Cause: Read out faults found fault 930949 knee air bag drivers short to negative need to replace harnesses as per SIB 65-27-24. Correction: Replace harness for knee air bags. The estimate for this is $2,013.72 which breaks down to parts at $288.96 and 7 hours worth of labor costing $1,724.76. This car is two years old. I would assume this is a manufacturing defect happening at only two years of age.
NHTSA complaint #11712478 — an unverified report by a vehicle owner.
During a recent auto collision my airbags did not deploy. I swerved to avoid another vehicle entering the intersection from my left, he hit my rear left driver's side quarter panel and I subsequently hit a tree. This was noted by the paramedics first on scene as well as by the firemen and police when they arrived. I have notified BMW of North America, USAA insurance (my insurance company), and now you. The vehicle is a total loss and was towed to Leesburg Virginia by roadrunner wrecker service.com
NHTSA complaint #11707095 — an unverified report by a vehicle owner.
On September 2, 2025, my 2025 BMW X5 xDrive50e was involved in a head-on collision with another vehicle. Despite the severity of the impact, the following safety systems failed to deploy: Front airbags Driver seatbelt pretensioner BMW Assist / automatic emergency notification Witnesses reported that my vehicle briefly went airborne before landing with the rear wheels up on a curb. I suffered neck injuries, and my vehicle sustained significant frontal damage. BMW later downloaded the Event Data Recorder (EDR) and confirmed: A frontal non-deployment event Three fault codes in the airbag control module (ACSM) post-crash The crash algorithm activated and reset ΔV reached approx. 12.4 mph longitudinal Forward Collision Mitigation system issued an acute warning 0.5 seconds before impact BMW states the “impulse was not sufficient” to trigger restraint deployment BMW has refused to provide: The deployment thresholds (ΔV criteria) for airbags or pre-tensioners Any engineering explanation for why restraint systems did not activate Any technical rationale for the ACSM fault codes Any escalation beyond Customer Relations All I have been given is an unsigned summary letter and the raw EDR file. BMW Customer Relations stated that engineering is “not customer-facing” and that no additional information will be provided. This leaves serious concerns that: The restraint systems did not function properly in a real-world impact. BMW is refusing to disclose the engineering basis for its conclusions. Consumers may be at risk if this is a repeatable failure mode. I am requesting NHTSA review this incident as a potential defect in the airbag, pretensioner, and/or crash-sensing system in the 2025 BMW X5. I can provide the EDR report, photos, BMW’s letter, and full correspondence upon request. VIN: [XXX] Mileage: ~10,700 Crash Date: 09/02/2025 BMW Case #: XXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11701093 — an unverified report by a vehicle owner.
Because of this water intrusion, the following safety systems have malfunctioned or failed: • ABS and DSC (stability control) warnings • Chassis stabilization warning • Frontal collision and pedestrian warning malfunction • Airbag system warning • Loss of audible warning tones • MOST bus communication failure • Electrical modules intermittently shutting down or throwing codes These failures affect braking, stability control, crash avoidance, and driver alerts, creating a significant safety risk while driving. This is not normal wear or maintenance. Many BMW owners have reported the same issue: clogged or poorly designed sunroof drains that route water directly into areas containing critical electronics. Once water reaches these modules, it causes electrical shorts and safety system failures that require expensive repairs. BMW dealerships typically diagnose this as “water damage,” but the location of the drains and the placement of the electronics indicate a design flaw that allows a simple drain issue to disable major safety systems. I am filing this complaint because the water intrusion should not be able to cause total failure of ABS, DSC, collision warning, and airbag-related systems. This is a safety-related design defect, not wear and tear. I request NHTSA review and investigate BMW sunroof drain failures and their impact on essential vehicle safety functions.
NHTSA complaint #11700942 — an unverified report by a vehicle owner.
Described by BMW as a "malfunctioning passenger restraint system", the sensor detecting weight in the seats is faulty without any external factors. The safety of both minors and adults is placed at risk when a system like this malfunctions, either keeping the airbag on or off. The automatically-adjusting seatbelt is also affected by this. There was a warning message for this displayed.
NHTSA complaint #11688338 — an unverified report by a vehicle owner.
I received a message of Restraint system malfunction and when I called the local dealer I was told the part is not availabel anywhere in the USA. What am I supposed to do with this. I was told the air bags and seatbelts may malfunction. The vehicle only has 85k miles. its a 2012. At this point who will take the car as a trade? It's not safe and they don't have an answer except to say I'm [XXX] and i guess you need to get a new vehicle!! Can you believe this? I have to get a whole new vehicle because they don't have a part! You can't make this stuff up. I spoke with BMW USA and was told they only honor 4yr and 50k miles and after 10years they are not responsible for parts to be made. The I was told to get it further diagnosed to the tune of 250.00 so they can "MAYBE" have the parts manufactured. What the heck! this company is saying our cars are garbage after 10yrs! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11678691 — an unverified report by a vehicle owner.
Airbag light is on for passenger and fuel injectors messed up. This is a 2008 and other ones had recalls. I don’t understand why mine did not lights are flickering a little bit and before it was smoking really bad and I had to get that fixed.
NHTSA complaint #11667236 — an unverified report by a vehicle owner.
I was making a left turn in stopped traffic. Lanes 1 and 2 yielded die to bumper to bumper traffic...as I crossed into lane 3 at 5 to 10 mph...struck by a vehicle going 55 mph plus in opposite direction. My vehicle spun into 3rd vehicle. I hit my head 2 times on driver windows. No airbags deployed. I suffered a traumatic brain injury.
NHTSA complaint #11660268 — an unverified report by a vehicle owner.
The contact owned a 2024 BMW X5. The contact stated that while driving approximately 40 MPH through an intersection, another vehicle ran a red light and t-boned the contact's vehicle on the front passenger side to the partial front rear door. The vehicle spun and crashed into a medium, causing the vehicle to come to a stop. No air bags deployed. The vehicle was towed and totaled. A police report was not filed. The contact received a concussion and injuries to their left arm that required medical attention. The contact was unsure if the other driver received any injuries or medical attention. The manufacturer was not made aware of the failure. The failure mileage was approximately 21,000.
NHTSA complaint #11656594 — an unverified report by a vehicle owner.
2020 BMW X5
at 65,327 milesPearland, TXCrash2 injured
AIR BAGS
The contact owned a 2020 BMW X5. The contact stated while the contact's mother was driving at an undisclosed speed, another vehicle attempted to make a left turn and crashed head-on into the front driver and passenger side of the vehicle. The driver's air bag did not deploy. During the impact, the driver's head hit the windshield causing it to crack. The police and paramedics arrived on the scene. The contact and the contact's mother were transported to the local medical center. The contact's mother was treated for a severe concussion and severe cuts and bruises. In addition, the contact's mother had broken glass in her hands which was removed. The contact sustained cuts and bruises. The contact's mother received additional testing because of the impact of the steering wheel on the chest, however the test results were negative. A police report was filed, however, the information was unavailable. In addition, the police officer inspected the vehicle and noticed the driver's seat belt had a lot of play, which could have contributed to the contact's mother's head injury. The vehicle was towed to the local tow yard and condemned as a total loss. The manufacturer was not made aware of the failure. The failure mileage was approximately 65,327.
NHTSA complaint #11648949 — an unverified report by a vehicle owner.
My vehicle is DO NOT DRIVE condition. I have not been able to schedule air bag recall repair because the dealerships in my area will not tow to and from my home, and say no mobile service is available. WHAT ARE MY OPINIONS? PLEASE REPLY .....I currently can't drive my car because I have a unexploded claymore in my face!
NHTSA complaint #11643454 — an unverified report by a vehicle owner.