Chevrolet Astro brake problems

SERVICE BRAKES

WHILE DRIVING THE 2000 CHEVY ASTRO THE ENGINE SHUT OFF AND NO BRAKES. HAPPENED TO ME IN TWO WEEKS. LIFE OR DEATH SITUATION.

NHTSA complaint #11372342 — an unverified report by a vehicle owner.

SERVICE BRAKES

BEGINNING ABOUT A YEAR AGO, HAVE HAD INTERMITTENT HARD PEDAL WHEN BRAKING. OCCURS RARELY, WITHOUT WARNING. NO ABS LIGHT SEEN BUT SUSPECT POSSIBLE ABS MALFUNCTION. PEDAL DOES NOT PULSATE BUT A FAINT GROWLING, GRINDING, OR BUZZING NOISE IS HEARD. MAY BE ABS MOTOR CYCLING. DURING FAILURE BRAKES ARE BARELY OPERATIVE. USUALLY RETURNS TO NORMAL OPERATION AFTER 2-3 PEDAL PRESSES. SOMETIMES PULLS SHARPLY LEFT, OCCASIONALLY RIGHT, ON BRAKE APPLICATION. THERE IS NO LOSS OF POWER STEERING. OCCURS MOST OFTEN AT FREEWAY SPEED BUT HAS ALSO OCCURRED AT SLOWER SPEEDS. HAS OCCURRED BOTH IN SUDDEN, HARD BRAKING AND IN VERY LIGHT USE. HAVE HAD ALL POWER COMPONENTS, ALL RUBBER HOSES, POWER STEERING PUMP, AND BOTH FRONT WHEEL BRAKE COMPONENTS PROFESSIONALLY REPLACED. VEHICLE HAS FRONT DISC/REAR DRUM AND HYDROBOOST. MECHANIC USUALLY CANNOT DUPLICATE THE PROBLEM BUT HAS DONE SO ONCE AND HAS NO EXPLANATION FOR IT. SEEKING TO LEARN POSSIBLE REASONS AND CURE.

NHTSA complaint #11286510 — an unverified report by a vehicle owner.

SERVICE BRAKES

PIN HOLES IN STEEL BRAKE LINES CAUSING COMPLETE BRAKE FAILURE. FORTUNATELY VEHICLE WAS SITTING WHEN BRAKE PETAL WAS APPLIED FOR STARTING. WHEN PRESSING BRAKE TO START VEHICLE, PETAL WENT COMPLETELY TO FLOOR. WHEN CHECKING UNDER VEHICLE TO ANALYZE PROBLEM, PIN HOLES LEAKS WERE OBSERVED IN VARIOUS PLACES FROM FRONT TO REAR IN STEEL LINES. I FEAR WHAT MAY HAVE HAPPENED HAD THE VEHICLE BEEN IN MOTION, AROUND PEDESTRIANS, AND/OR, ON THE ROAD.

NHTSA complaint #10816261 — an unverified report by a vehicle owner.

SERVICE BRAKES

ANTILOCK BRAKING SYSTEM WARNING LIGHTS AND BRAKE LIGHT CAME ON WHEN I WAS ENTERING THE FREEWAY. THE LIGHTS CONTINUE TO COME ON WHENEVER I AM DRIVING. I HAD IT CHECKED AT CORNING CHEVROLET AND WAS TOLD THE PART ALONE WAS $900 PLUS LABOR TO REPLACE IT. THE BRAKES WORK, BUT NOT THE ANTILOCK SYSTEM INSTALLED BY THE MANUFACTURER.

NHTSA complaint #10717422 — an unverified report by a vehicle owner.

SERVICE BRAKES

I GOT IN MY VAN TO DRIVE TO A STORE AND THE BRAKE PEDAL WENT RIGHT TO THE FLOOR. THERE WAS BRAKE FLUID LEAKING FROM NEAR THE REAR TIRE. THE STEEL HARD BRAKE LINE RUNNING FROM THE ABS UNIT TO THE REAR AXLE IS RUSTED THROUGH AND IS LEAKING. THIS WAS A SUDDEN EVENT. ALSO THE FUEL LINES LOOK TO BE JUST AS BAD. I'M SURE STAINLESS STEEL LINES WOULD NOT HAVE ADDED MUCH TO THE VEHICLES COST AND WOULD HAVE PREVENTED THIS HAZARD AND EXPENSE.

NHTSA complaint #10706501 — an unverified report by a vehicle owner.

SERVICE BRAKES

WE LIVE IN THE COUNTRY WITH GRAVEL ROADS. ALL OF OUR CHEVROLET VEHICLES HAVE HAD BRAKE LINES ROT OUT. OUR FORD AND DODGE VEHICLES HAVE NOT. THE CHEVROLET ASTRO VANS WE HAVE EXHIBIT A PROPENSITY FOR THE BRAKE LINE ROTTING OUT OVER THE GAS TANK AS WELL AS THE BRAKE LINES OVER THE FRONT FRAME MEMBERS. THE BRAKE LINES ON 20 YEAR OLD FORD VEHICLES LOOK AS GOOD AS NEW UNDER THE SAME CONDITIONS. MY 1994 CHEVROLET K-3500 PICKUP HAS BLOWN BRAKES LINES DUE TO ROT ALONG WITH THE BACK PART OF THE FRAME THAT RUSTED OUT. I JUST READ WHERE YOU HAVE ADVISED WASHING THE UNDERSIDE OF CHEVROLET VEHICLES SEVERAL TIMES A YEAR. WELL THE LINES ROTTING OUT ON TOP OF THE GAS TANK AND THE FRONT FRAME RAILS WILL NOT GET WASHED. WHOEVER MADE THE "WASH IT" DECISION EVIDENTLY DOES NOT DRIVE OLDER CHEVROLETS. IF THERE WAS NO PROBLEM THEN WHY DID CHEVROLET EVIDENTLY CHANGE THEIR LINES? OR MAYBE THEY DID NOT AND THE NEWER ONES JUST HAVE NOT STARTED ROTTING OUT YET. WHY DO FORD BRAKE LINES, EXHAUST SYSTEMS, FRAMES, AND BODIES NOT RUST LIKE GM. SOMEONE IS HIDING SOMETHING. THE CHEVROLET BRAKE LINE ARE DEFINITELY A SAFETY HAZARD DUE TO RUSTING THRU.

NHTSA complaint #10704745 — an unverified report by a vehicle owner.

SERVICE BRAKES

I AM A LICENSED CAR DEALER. I AM VERY CONCERNED AT WHAT I AM SEEING WITH MY CUSTOMERS, WITH CARS I SEE AT THE AUCTIONS, AND WITH BLOG SITES ON THE INTERNET CONCERNING CHEVY'S EBCM COMPUTER MODULE. AT THE AUCTIONS I AM SEEING AT LEAST 25% OF CHEVROLETS AND ABOUT 10% OF FORDS COMING THROUGH WITH BRAKE AND ABS LIGHTS ON. MY MAIN CONCERN IS WITH THE CHEVY'S EBCM. THESE VERY EXPENSIVE UNITS FAIL AT THE RELAY POINT ON THE PRINTED CIRCUIT BOARDS DUE TO BAD SOLDER JOINTS FROM THE FACTORY. WHEN THEY FAIL, THE DRIVER GETS A BRAKE LIGHT AND AN ABS INDICATOR LIGHT ON THE DASH. THE BRAKES STILL WORK ON THE CAR, BUT THEY DON'T WORK AS DESIGNED. IN FACT THE DRIVER GETS A FALSE SENSE OF SECURITY BECAUSE HIS CAR IS STOPPING, BUT IN A SLIPPERY SITUATION IT WILL NOT STOP AS DESIGNED. WHEN I WENT TO THE INTERNET FOR IDEAS TO FIX THE PROBLEM, I AM FINDING A LOT OF POSTINGS SAYING JUST TAKE THE BULB OUT OF THE DASH! I AM ALSO SEEING ADS ON E BAY WHERE YOU CAN SEND YOUR EBCM TO A REPAIR STATION, THEY TAKE IT APART, AND RE SOLDER THE JOINTS FOR $49. I CALLED THE CHEVY DEALER AND THEY WANT OVER $1000 TO FIX THE PROBLEM! I HAVE HEARD OF PEOPLE SELLING THEIR VEHICLE AS IS AND TELLING THE BUYER THAT IT'S OK. THE BRAKES WORK. I CAN'T GET THE LIGHT TO SHUT OFF! THIS IS A VERY DANGEROUS SITUATION AND IT WILL BECOME MORE DANGEROUS AS MORE AND MORE CARS ARE DRIVING WITH INOPERATIVE EBCM COMPUTERS. IT LOOKS LIKE THE DEFECT COMES FROM HAVING THE COMPUTER DIRECTLY ATTACHED TO THE FRAMES NEAR THE TRANSMISSION AND THEY ARE TAKING ALL THE SHOCK AND VIBRATION IN THAT AREA. I AM ASKING THE GOVERNMENT TO LOOK INTO THIS PROBLEM AND ISSUE A RECALL NOTICE FOR DEFECTIVE EBCM COMPUTERS. I ALSO FEEL THIS PROBLEM IS FAR WORSE THAN THE DODGE CLOCK SPRING RECALL, AND THAT EFFECTED ALL DODGE VEHICLES. THIS BRAKING PROBLEM WE ARE SEEING IS BAD ENOUGH THAT IT MAY CAUSE A LARGE LOSS OF LIFE.

NHTSA complaint #10637686 — an unverified report by a vehicle owner.

SERVICE BRAKES

I HAVE 2- CHEVY ASTRO VANS. 1-1998, 1-1999. THE 1999 HAS CORRODED BRAKE LINES AND GAS LINES. THE MAIN BRAKE LINES ARE CORRODED INTO. I WAS COMING BACK FROM A LONG TRIP YESTERDAY AND I NOTICED THAT THE BRAKES WERE SOFT. WHEN I GOT HOME UPON INSPECTION I CHECKED THE BREAK FLUID AND IT WAS LOW. I FILLED IT. I NOTICED A PUDDLE OF FLUID BY THE BACK TIRE. AND LOOKED, I DISCOVERED ALL OF THE BRAKE AND GAS LINES WERE EAT UP WITH CORROSION. GM NEEDS TO TAKE THIS AS A VERY SERIOUS PROBLEM AND FIX IT IMMEDIATELY. I COULD HAVE BEEN KILLED , OR I COULD HAVE KILLED SOMEONE IF THE BRAKES FAILED TO HOLD. I INSPECTED THE 1998 ASTRO VAN TO SEE IF IT HAD A PROBLEM TO. AND UPON DOING SO DISCOVERED IT IS FINE, NO PROBLEMS. I HAVE PICS OF BOTH VANS THE PICS WILL SHOW THAT MY STATEMENT IS TRUE. I BOUGHT THE 1999 VAN (THE ONE WITH CORRODED LINES) IN THE STATE OF OHIO. AND I BOUGHT THE 1998 VAN IN ALABAMA.I DO NOT KNOW WHY THIS IS, BUT I KNOW I AM NOT THE ONLY ONE WITH A FAULTY GM PRODUCT WITH CORROSIVE BRAKE AND GAS LINES. I AM VERY THANKFUL I DISCOVERED THIS BEFORE TRAGEDY HAPPENED. THIS IS A POTENTIAL DEADLY PROBLEM, AND GM NEEDS TO RESOLVE THIS BEFORE SOMEONE LOOSES THEIR LIFE, NOT AFTER. ANY HELP WITH GETTING THIS RESOLVED IS GREATLY APPRECIATED! I JUST WANT TO LET UNSUSPECTING GM OWNERS KNOW ABOUT THIS DANGER!

NHTSA complaint #10609436 — an unverified report by a vehicle owner.

SERVICE BRAKES

I WAS DRIVING PULLING A TRAILER ON THE FREEWAY WHEN SUDDENLY THE TRAFFIC STOP. I APPLIED THE BRAKES AT A SAFE DISTANCE WHEN SUDDENLY MY BRAKES WHEN ALL THE WAY TO THE FLOOR I APPLIED THE EMERGENCY BRAKES AND STOP. I HAD TO GO THRU THE EMERGENCY LANE. I TOLD MY SON TO PUSH THE BRAKE PEDAL WHILE I WAS UNDERNEATH AND THE BRAKE LINES BROKE. THEY WHERE ALL RUSTED OUT. I HAD TO GET A WRECKER TO TAKE IT HOME.IF YOU NEED TO SEE MY VAN CALL ME SO YOU CAN SEE THE BRAKE LINES.

NHTSA complaint #10594005 — an unverified report by a vehicle owner.

SERVICE BRAKES

HI, I WAS DRIVING THIS VAN WHEN ALL OF A SUDDEN IT STOPS. I HAD A VERY HARD PROBLEM OF TRYING TO GET OFF THE ROAD WITH NO BRAKES OR STEERING. I HAD IT TOWED INTO SERVICE. THEY REPLACED EVERYTHING FUEL PUMP, SENDING UNIT, FUEL FILTER, PLUGS, PLUG WIRES, DISTRIBUTOR AND RESET THE TIMING. IT NEVER DID SHOW UP A CHECK ENGINE LIGHT OR SHOWED A CODE THAT SOMETHING WAS WRONG. I DROVE IT TWO DAYS LATER AND IT DID THE SAME THING. THEY CHECKED IT OUT AND DROVE IT AGAIN FOR A WEEK AND IT HAPPEN AGAIN. I SPENT $1200 TRYING TO GET THIS SAFE TO DRIVE. IT IS AS IF THE KEY WAS SHUT OFF. FINALLY WITH SOME OF MY KNOWLEDGE ABOUT WHAT CAN CAUSE THIS TO HAPPEN I CHECKED THE BATTERY. IT WAS ONLY ONE YEAR OLD. IT SHOWED UP AS BAD UNDER A LOAD. WHEN I TOOK THE VAN BACK TO THE REPAIR SHOP THEY SAID BATTERY SHOWED GOOD. FINALLY I TOOK THE BATTERY BACK TO AUTO ZONE THEY SHOWED IT AS BAD ALSO AND REPLACED IT. NEVER HAD A PROBLEM AFTER THAT. SO THE PROBLEM YOU ARE HAVING WITH THE KEY SWITCH IN ALL THOSE CARS YOU MAY HAVE TO DOUBLE CHECK THE BATTERY'S. VOLTAGE TO THE MICROPROCESSOR SHOULD STAY WITHIN LIMITS OF APX 8 VOLTS. THIS MIGHT BE MORE OF A PROBLEM THAN THE KEY SWITCH. THANKS FOR READING THIS LETTER.

NHTSA complaint #10593059 — an unverified report by a vehicle owner.

SERVICE BRAKES

MY SPOUSE WAS DRIVING AND WE WERE STOPPED AT A YARD SALE. WE RETURNED TO THE VEHICLE AND STARTED TO BACK OUT WHEN SHE NOTICED THE STEERING WHEEL WAS EXTREMELY HARD TO TURN. THEN WHEN SHE WANTED TO STOP THE VEHICLE THE BRAKES WERE EXTREME HARD TO OPERATE. AFTER SOME RESEARCH WE LEARNED OF HUNDREDS OF BRAKE MALFUNCTIONS ON SIMILAR VEHICLES AND OTHER CARS THAT USE SIMILAR BRAKE BOOSTER TECHNOLOGY.

NHTSA complaint #10577639 — an unverified report by a vehicle owner.

SERVICE BRAKES

I AM COMPLAINING OF THE SAFETY ISSUES REGARDING THE ABS COMPUTER SYSTEM. I HAVE PUT MY VEHICLE IN THE SHOP TO BE CHECKED OUT BY A FEW CAR REPAIR FACILITIES AND ALL HAVE SAID THE SAME THING MY ABS CPU. MY VAN IS HESITATING TERRIBLY AND CAUSING THE VAN TO NOT ACCELERATE PROPERLY. I HAVE NEARLY BEEN IN THREE ACCIDENTS SINCE THE PROBLEM HAS BEEN OCCURRING. I HAVE ALSO DONE SOME RESEARCH ON THIS ISSUE VIA INTERNET AND FOUND THAT MANY PEOPLE ARE HAVING THE SAME PROBLEM ACROSS THE USA. AND GM IS BLAMING IT ON THE WEATHER CONDITIONS IN THE NORTH BUT THE PROBLEMS ARE HAPPENING TO ASTRO VANS(2003) ACROSS THE ENTIRE US. THIS IS A PROBLEM THAT SHOULD BE ADDRESSED AS SOON AS POSSIBLE.. THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT 20MPH OR LESS, THE ABS ACTIVATED WITH AN INCREASED STOPPING DISTANCE. THE VEHICLE WAS SEEN BY AN INDEPENDENT REPAIR SHOP. A DIAGNOSTIC TEST WAS PERFORMED WHICH INDICATED A FAILURE IN THE RIGHT FRONT WHEEL SPEED SENSOR. THE MECHANIC DETERMINED THE WHEEL SPEED SENSOR OF THE ANTILOCK BRAKES NEEDED TO BE REPLACED. THERE IS A NHTSA RECALL, # 05V379000, REGARDING THE ANTILOCK BRAKES. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THIS VEHICLE CURRENTLY HAS THIS ISSUE, AND WAS CHECKED BY A REPAIR SHOP. THEY DESCRIBED THE PROBLEM UNDETECTABLE; THE RECALL WAS ON MODELS UP TO 2002. IT SEEMS THAT IT CARRIED OVER TO THIS MODEL, CAN THE DEALER ASSIST IN REPLACING THE PARTS. I WOULD PAY THE LABOR BUT THE PARTS INVOLVED ARE ABOUT $1500.00 FROM THE DEALER ALONE. CAN I GET HELP FROM THE NHTSA TO GET THIS CRITICAL ISSUE RESOLVED.

NHTSA complaint #10547421 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

I AM COMPLAINING OF THE SAFETY ISSUES REGARDING THE ABS COMPUTER SYSTEM. I HAVE PUT MY VEHICLE IN THE SHOP TO BE CHECKED OUT BY A FEW CAR REPAIR FACILITIES AND ALL HAVE SAID THE SAME THING MY ABS CPU. MY VAN IS HESITATING TERRIBLY AND CAUSING THE VAN TO NOT ACCELERATE PROPERLY. I HAVE NEARLY BEEN IN THREE ACCIDENTS SINCE THE PROBLEM HAS BEEN OCCURRING. I HAVE ALSO DONE SOME RESEARCH ON THIS ISSUE VIA INTERNET AND FOUND THAT MANY PEOPLE ARE HAVING THE SAME PROBLEM ACROSS THE USA. AND GM IS BLAMING IT ON THE WEATHER CONDITIONS IN THE NORTH BUT THE PROBLEMS ARE HAPPENING TO ASTRO VANS(2003) ACROSS THE ENTIRE US. THIS IS A PROBLEM THAT SHOULD BE ADDRESSED AS SOON AS POSSIBLE.. THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT 20MPH OR LESS, THE ABS ACTIVATED WITH AN INCREASED STOPPING DISTANCE. THE VEHICLE WAS SEEN BY AN INDEPENDENT REPAIR SHOP. A DIAGNOSTIC TEST WAS PERFORMED WHICH INDICATED A FAILURE IN THE RIGHT FRONT WHEEL SPEED SENSOR. THE MECHANIC DETERMINED THE WHEEL SPEED SENSOR OF THE ANTILOCK BRAKES NEEDED TO BE REPLACED. THERE IS A NHTSA RECALL, # 05V379000, REGARDING THE ANTILOCK BRAKES. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THIS VEHICLE CURRENTLY HAS THIS ISSUE, AND WAS CHECKED BY A REPAIR SHOP. THEY DESCRIBED THE PROBLEM UNDETECTABLE; THE RECALL WAS ON MODELS UP TO 2002. IT SEEMS THAT IT CARRIED OVER TO THIS MODEL, CAN THE DEALER ASSIST IN REPLACING THE PARTS. I WOULD PAY THE LABOR BUT THE PARTS INVOLVED ARE ABOUT $1500.00 FROM THE DEALER ALONE. CAN I GET HELP FROM THE NHTSA TO GET THIS CRITICAL ISSUE RESOLVED.

NHTSA complaint #10547421 — an unverified report by a vehicle owner.

SERVICE BRAKES

VEHICLE LOST ALL ELECTRICAL POWER TO EVERY SYSTEM THAT IS CONTROLLED BY THE IGNITION BEING TURNED ON. DRIVER WAS IN THE PROCESS OF MAKING A U-TURN AROUND A CURBING ISLAND IN THE DIVIDED TRAFFIC ROAD WHEN ALL ELECTRICAL WAS INTERRUPTED WHILE THE STEERING WHEEL WAS TURNED ALL THE WAY TO THE LEFT. CONDITION CAUSED STEERING TO BECOME DIFFICULT, BRAKE PEDAL WENT CLEAR TO THE FLOOR, AIR CONDITIONING AND RADIO AND HEADLIGHTS ALL WENT OFF. CONDITION WAS REPEATABLE WITH EXCEPTION OF BRAKE PEDAL, EACH TIME STEERING WAS TURNED TO THE LEFT. INSPECTION UNDER VEHICLE FOUND THAT MAIN POWER CABLE IS ROUTED ACROSS FRONT SIDE OF MAIN FRAME MOTOR MOUNT MEMBER. THERE WAS A SLIGHT CURVE IN THE WAY THE WIRE WAS ROUTED AND EACH TIME THE STEERING WAS TURNED TO THE LEFT, THE INNER TIE ROD END FOR THE RIGHT WHEEL CAME IN CONTACT WITH THE WIRE HARNESS. AFTER MANY MILES, THE PROTECTIVE COVER AND THEN THE ACTUAL WIRE INSULATION WAS RUBBED THROUGH. THIS CAUSED A DIRECT SHORT TO GROUND THROUGH THE STEERING PARTS OF ALL (SWITCHED WHILE RUNNING) ELECTRICAL COMPONENTS OF THE VEHICLE. PROBLEM WAS CORRECTED BY TAPING THE WIRE INSULATION, THEN TAPING THE PROTECTIVE COVERING. I THEN HAD TO FABRICATE A BRACKET TO SCREW TO THE STEEL CRUMPLE MEMBER TO HOLD THE HARNESS BACK FROM THE STEERING LINKAGE.

NHTSA complaint #10546973 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2000 CHEVROLET ASTRO VAN. THE CONTACT STATED THAT FUEL FUMES WERE EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE HE NOTICED THAT THERE WAS A FUEL LEAK. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FUEL LINES WERE SEVERELY CORRODED AND NEEDED TO BE REPLACED. IN ADDITION, THE CONTACT STATED THAT WHILE DRIVING 25 MPH, HE ATTEMPTED TO ENGAGE THE BRAKES BUT THE BRAKE PEDAL SUNK INTO THE FLOOR BOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE BRAKES LINES WERE ALSO CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 82,257 AND THE CURRENT MILEAGE WAS 88,000. UPDATED 12/30/13*CN THE CONSUMER ALSO STATED RUST CAUSED THE ABS TO ENGAGE AT LOW SPEEDS ON DRY PAVEMENT, CAUSING THE VEHICLE TO CONTINUE TO MOVE, EVEN THOUGH THE BRAKE PEDAL WAS DEPRESSED.

NHTSA complaint #10545126 — an unverified report by a vehicle owner.

SERVICE BRAKES

I JUST GOT HOME & WAS BACKING AROUND TO WHERE I PARK WHEN THE BRAKE PEDAL STARTED VIBRATING. I DID MANAGE TO PARK. THE NEXT DAY THE VIBRATING STOPPED WHEN A GRATING NOISE WAS MADE. SUDDENLY THE BRAKE PEDAL CAME WAY UP. IT DOES HAVE SOME BRAKES BUT THEY ARE HARD TO DEPRESS. SUDDENLY MY POWER STEERING IS GONE. THERE WAS NO INDICATION OF PROBLEMS WITH EITHER BEFOREHAND. THIS VAN JUST PASSED INSPECTION IN MID-AUGUST, AND HAS ALWAYS BEEN TAKEN CARE OF.

NHTSA complaint #10538376 — an unverified report by a vehicle owner.

SERVICE BRAKES

BRAKE AND ABS LIGHTS COME ON INTERMITTENTLY, I HAD THE CODE PULLED AT THE AUTO PARTS STORE, IT IS THE ELECTRONIC ABS CONTROL MODULE AND UPON GOOGLING "CHEVROLET BRAKE ABS LIGHTS" IT CAME TO MY ATTENTION THAT THEIR APPEARS TO BE THOUSANDS OF VEHICLES WITH FAULTY ABS ELECTRONIC MODULES WHICH PREVENTS THE ABS FUNCTION FROM WORKING.

NHTSA complaint #10536053 — an unverified report by a vehicle owner.

SERVICE BRAKES

GOING TO STOP AT A SLOW SPEED ENGAGES ABS , CAUSING VAN TO NOT STOP UNLESS BREAKERS WERE SLAMMED ON HARD AND HOPS OF STOPPING!

NHTSA complaint #10534307 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2003 CHEVROLET ASTRO VAN. THE CONTACT STATED THAT THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR WHILE MAKING A LEFT TURN. THE CONTACT ALSO STATED THAT THE VEHICLE FAILED TO START WHEN THE VEHICLE WAS PARKED AND THE WHEELS WERE TURNED TO THE LEFT. A MECHANIC LOOKED UNDER THE VEHICLE AND FOUND THAT THE WIRING HARNESS THAT WAS LOCATED NEAR THE FRONT PASSENGER SIDE TIRE HAD BURNED OUT. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE CONTACT WAS UNSURE OF WHAT WOULD BE REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN BUT THE CURRENT MILEAGE WAS 67,000.

NHTSA complaint #10526083 — an unverified report by a vehicle owner.