405 of the
1,361 complaints filed about the Chevrolet Bolt EV
are about the electrical system —
30% of everything owners reported.
The worst model year for it is 2017.
2027 CHEVROLET BOLT – SUDDEN FORWARD LURCH / PROPULSION EVENT WITH MULTIPLE COMMUNICATION FAULT CODES While driving my new 2027 Chevrolet Bolt, I was stopped at a traffic light. When the light changed, I applied the accelerator gently to move forward. The vehicle suddenly produced a loud bang or clunk and lurched sharply forward. All of the yellow instrument panel lights flashed on for a few seconds. The acceleration was abrupt and substantially different from my accelerator input. Surrounding drivers were alarmed. The event was sufficiently forceful and unexpected that I considered it a safety issue involving propulsion control. I was not accelerating aggressively; this was a gentle acceleration, in traffic, making a left turn onto a freeway ramp. I subsequently brought the vehicle to the Chevrolet dealer for diagnosis. The dealer retrieved the following diagnostic trouble codes: U164B; U164E (5 times); U0485; U11FD; P3013; U1A25; U160A (3 times)l U197A (3 times); U0159; U1126 (2 times); U1150; B1A25; U1607; U1151 Several of the retrieved codes are U-series communication/data-network codes. The vehicle has now been at the dealership for three days; so far the dealer has not provided an explanation for the sudden lurch or identified the underlying cause of the diagnostic codes. Previously the car was at the dealership for 15 days. I am concerned that an intermittent electronic, communication-network, propulsion-control, power-supply, software, or related fault could cause another unexpected propulsion event. The vehicle has also experienced charging/range abnormalities, and code P3013 was among the codes retrieved by the dealer. I do not know whether those issues are related to the lurch event, and I am not asserting that they are. I am reporting them because they may be relevant to NHTSA’s evaluation of the vehicle’s electrical and control systems. I am requesting that this incident be recorded as a potential safety defect
NHTSA complaint #11755494 — an unverified report by a vehicle owner.
The vehicle suffers from severe, unresolvable electrical failures causing recurring loss of propulsion, shifting lockouts ("No Driving Conditions" / stuck in Park), complete exterior lighting failures, and loss of communication with the Restraints Control Module (RCM) and airbag impact sensors. The primary failure involves short circuits, open circuits, poor terminal contact, and thermal damage with melted, charred wiring and exposed copper in the main harness[cite: 6]. On May 25, 2026, OnStar telematics issued a critical red alert for the Regenerative Braking System[cite: 7]. All damaged components and diagnostic reports are available for inspection upon request[cite: 6, 7]. Safety risks include sudden loss of propulsion at highway speeds, total headlight and tail light loss during night driving, and potential non-deployment or malfunction of airbag restraint systems during a collision. The issues have been repeatedly reproduced and confirmed by an authorized dealership through 7 repair attempts between Sept 2024 and Apr 2025. Diagnostic steps included opening GM TAC Case 9-13634782861, consulting GM engineers, and testing 33 ground points. On Oct 28, 2024, the dealer and an insurance adjuster officially confirmed the failures are covered under GM warranty and unrelated to any accident[cite: 8]. Symptoms first appeared on Sept 10, 2024 (at 5,144 miles) with a "Waiting initialization to shift" message, blown Fuse 58, and loss of power to the ECM. Warning signs prior to subsequent failures included "Service Trans" warnings, "Reduced Propulsion" alerts, dim headlights, Check Engine Lights, SRS/Airbag warning lights, and total shifting lockouts after hitting road bumps. Despite replacing Fuse 58 (multiple times), Fuse 64, IP Fuse 7, the underhood fuse block, ECM connector terminals, headlamp assemblies, the RCM module, and multiple airbag impact sensors, the underlying electrical instability remains unresolved.
NHTSA complaint #11754113 — an unverified report by a vehicle owner.
The main infotainment screen provides the critical safety rear view display screen for the rear view camera. This is a legally required function for this vehicle, a 2027 Chevrolet Bolt RS. The failure of the screen means that a clear view towards the back of the vehicle is unavailable. Reversing without the display is hazardous and may result in hitting an object, animal, or person. Online Chevrolet customer service suggested a soft reset. This did not solve the problem. The problem has been intermittent, but is now permanent. The vehicle, which has only 500 miles and is under its new car warranty, was brought back to a Chevrolet dealer. The dealer disassembled the screen and confirmed the screen failure. The dealer does not have the part. The manufacturer doesn't have the part. The dealer is ordering it from a 3rd party. There is no estimated time for receiving the part.
NHTSA complaint #11751154 — an unverified report by a vehicle owner.
Vehicle infotainment system on 2023 Chevrolet Bolt completely stopped functioning in May of May of 2026. Screen/radio/bluetooth and associated components had no functionality, including backup camera, safety warning features, etc. Dealership confirmed that the system needed replacement entirely and was non-functional. Vehicle was not inspected by any other parties but it was confirmed by the dealership that this is a "common issue" for Chevrolet vehicles, even newer models. There were no warnings prior to the issue - the system simply did not work one day and never functioned again.
NHTSA complaint #11745689 — an unverified report by a vehicle owner.
General Motors is using the arbitrary 6,213-mile tracking window of Recall 944 to deny coverage for a diagnosed Cell Section 3 hardware failure at 123,582 miles. However, this vehicle is directly impacted by the failure parameters outlined in the expanded GM Safety Recall N242470160 / N242470162, where GM openly acknowledges to federal regulators that the advanced diagnostic software has failed to properly detect defective battery modules. By denying a physical battery replacement when a manufacturing defect is caught during a mandatory corporate software reconfiguration, GM is violating the spirit and legal intent of their ongoing federal safety recall campaigns.
NHTSA complaint #11745256 — an unverified report by a vehicle owner.
When driving the car through a busy intersection there was a sudden, brief surge of acceleration, followed by deceleration and the vehicle cutting all motor power and becoming inoperable. The MIL lamp illuminated and the "Ready" light went out. I was unable to move the vehicle out of traffic until I got out and disconnected / reconnected the 12v battery to reset the car systems. The problem is difficult to reproduce, happening randomly, sometimes with multiple months between incidents. The incidents happen with no warning, and there are no other symptoms associated with the issue. The dealer mechanic indicated it is likely the issue indicated in Chevrolet TSB 19-NA-220, indicating the root cause is the resolver feedback connector on the electric drive unit damaged during vehicle assembly.
NHTSA complaint #11741473 — an unverified report by a vehicle owner.
Without any warning or physical impact, the central infotainment screen completely blanked out and suffered an irreversible hardware failure. This screen acts as the mandatory display terminal for the vehicle's rear-visibility backup camera, as well as the audio generation module for the vehicle's driver alerts. Because of this component failure, the vehicle is in direct non-compliance with Federal Motor Vehicle Safety Standards (FMVSS): 1.FMVSS 111 (Rear Visibility): The vehicle completely fails to display a rear-view image when shifted into reverse, creating an immediate blind-spot hazard for pedestrians. 2. FMVSS 101 (Controls and Displays): All critical audible safety alerts, pedestrian alerts, and driver warning chimes have been entirely silenced. The manufacturer (General Motors) and the authorized franchise dealership (F.H. Dailey Chevrolet) have acknowledged the failure and have the part on backorder, but refuse to fully cover the safety restoration under warranty or provide a temporary loaner vehicle. This forces the primary driver, a [XXX] senior citizen, to choose between total isolation or operating a hazardous, federally non-compliant vehicle. This appears to be a systemic manufacturing or design defect inherently tied to the internal HMI module architecture on the late-model Chevrolet Bolt EV platform, rather than individual wear and tear. A formal investigation is requested to mandate a safety recall and enforce full manufacturer accountability. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11740712 — an unverified report by a vehicle owner.
Recurring electronic transmission shift control failure on a 2023 Chevrolet Bolt EV. The Electronic Transmission Shift Control Pushbutton Circuit Board (GM part designation K212) has failed twice within approximately 9,300 miles. First failure occurred at approximately 45,695 miles in July 2025. The dashboard displayed a malfunction indicator and a "Service Transmission" warning. Diagnostic trouble code U18D2 was set: Lost Communication with Transmission Range Selector Control Module on the Powertrain Sensor CAN Bus. The selling Chevrolet dealer replaced the K212 pushbutton circuit board and reprogrammed the HPCM2 module. Second failure occurred at approximately 54,969 miles in March 2026, only about 9,300 miles after the first repair. Same diagnostic code family, including the identical U18D2 code, plus U0076, U18C6, and U240E. The same dealer replaced the same K212 pushbutton circuit board a second time. The repair was processed under manufacturer warranty. Safety risk: when the failure occurs, communication with the transmission range selector is lost intermittently and without warning, leaving the vehicle unable to be reliably shifted into Drive, Reverse, or Park. This creates a clear hazard in traffic, parking lots, and on inclines. The failure mode is sudden and the warning lamps appear only after the malfunction has begun. The component is located beneath the center cup holder area. There is no visible waterproofing or moisture isolation around the circuit board, despite its location directly under a known liquid exposure zone. The failed component from the second repair was reportedly shipped back to GM by the dealer. The vehicle is available for inspection. The failure has been confirmed twice by an authorized Chevrolet dealer.
NHTSA complaint #11736684 — an unverified report by a vehicle owner.
The contact owns a 2020 Chevrolet Bolt EV. The contact stated that the vehicle's charge was designed to last for 259 miles, but failed to exceed 100 miles. The vehicle was taken to the dealer and was repaired under NHTSA Campaign Number: 24V812000 (ELECTRICAL SYSTEM); however, the failure persisted. The vehicle recently failed to charge, with an error message that the vehicle was unable to charge displayed. The contact stated that the recall repair failed to correct the issue. The dealer was contacted, and a service appointment was scheduled. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 36,000.
NHTSA complaint #11732423 — an unverified report by a vehicle owner.
VEHICLE FAILS TO CHARGE. Receiving error message that the vehicle fails to accept a charge. I've attempted charging using 3 separate chargers and all fail. This issue has been in service at numerous dealerships with no resolve. I was able to charge previously at a reduced rate but now the battery will no longer accept a charge and gives me an error message.
NHTSA complaint #11732425 — an unverified report by a vehicle owner.
I started losing Regen braking intermittently, when this happens the brakes themselves don't work well and there's no warning, you lift of the pedal expecting the car to stop and its rolling freely, to push brake and its not stopping like you expect, then it thuds and lunges forward a bit and stops. It was rarely happening, now the car can barely be driven. I have not got it into a shop yet. It throws DTC P182B, P182D, P1840, and U0401 every time. Clearing them, even while still moving brings it all back to normal, except an image of my previous drive will be frozen on infotainment that I have to hard reset to get it to work. Also backup camera does now work when these codes are active. I have found 1 person online that is having this exact issue. It's terrifying to approach a stop light and used to 1 pedal driving and I'm rolling freely instead. the first incident of it was 03/05/26 and has progressively worsened. My code scanner keeps records of when I clear the codes,
NHTSA complaint #11732285 — an unverified report by a vehicle owner.
This is the second time since owning car this has happened the recall battery is not working again this time me and my sister were at the gas station were I work and this is all on camara at Chevron gas station were I work I went inside sister stayed in car it started making a buzzing sound under my dash car shut off windows wouldn't go down locked doors could not get car to turn on trapped us in car this is scary and smelled a wire burning smell started to get scared pounded on window couldn't get out ! Couldn't unlock doors this is very scary tried hitting window and it would not break we were stuck this has happened once before car just needed plug in to dealership computer to reset car it was fine for 2weeks and bam a month later I'm again having to take it back to have it reset because of this battery recall it's not fixed I still owe 14k for car I totally have been ripped off it's scary that these cars catch fire and u can not get out! Can't unlock doors windows nothing and u just get stuck I don't feel safe whatsoever in this car
NHTSA complaint #11730613 — an unverified report by a vehicle owner.
While driving at approximately 45 mph, the regenerative braking feature of the vehicle suddenly failed, and also generated a master caution light on the dashboard display. This is the second time this has happened while driving and resulted in a sudden, alarming change in vehicle dynamics. Regenerative braking is the normal operation regime of the vehicle, with the traditional mechanical-hydraulic brake pedal available for added braking, as demonstrated by the Chevrolet dealership during a test drive and confirmed with the vehicle manual. Furthermore, the vehicle will no longer shut itself off and could pose a fire risk when stored in a garage, parking deck, other vehicles, etc. These issues happened in November 2024. The car was returned to the dealer for warranty repair. Even after extensive repairs to the electrical system, the car has repeated the alarming failure mid-drive. This indicates that there is a serious problem with the electronic and poses a serious safety risk.
NHTSA complaint #11729055 — an unverified report by a vehicle owner.
My 2021 Chevy Bolt keeps showing a battery or power-Propulsion warning light related to the high-voltage system. The warning keeps coming back even after multiple repairs. The first repair was on April 28, 2025, the second was on December 17, 2025, and it is scheduled again for another repair on March 3, 2026. The light is the same every time and affects the car’s performance and reliability. I’m concerned this could be a safety issue involving the battery or propulsion system. The dealer repairs it temporarily, but the warning keeps returning, and the problem has never been fully resolved.
NHTSA complaint #11721358 — an unverified report by a vehicle owner.
Water has infiltrated the lower trunk area and fried the sound amplifier. The result is no sounds can be heard from the speakers. This includes sounds and warnings from the safety systems. Seat belt, ADAS, BLIS, OnStar, Turn Signals, Radio. The rear hatch seals seem to be intact and it is unclear how water is entering this lower area as there is no evidence of water anywhere else in the rear cargo area. A google search reveals many other Bolt owners are experiencing the same issue
NHTSA complaint #11717281 — an unverified report by a vehicle owner.
While waiting to turn left at a light and driving in "L" (one pedal) mode, I started to release the break in anticipation of oncoming lanes clearing, as I lifted the pedal the car lurched into the intersection. The Bolt normally accelerates very gently in L mode when no break is applied, but does not lurch forwards like this under normal conditions. The breaks did work, and I was able to stop, but I was now in the middle of the intersection and slightly encroaching into oncoming lanes. I tried to accelerate to pull through, but the car did not respond. After several second of frantically pushing the accelerator, the car slowly and jerkily moved forward and cleared the intersection. My Chevy dealer says this is a known problem with service bulletin "Chevrolet TSB 19-NA-220". In my opinion this is incredibly dangerous and should have been recalled. However, there is no recall that I can find and outrageously Chevy will not cover this manufacturing defect under warranty as they specifically exclude wiring harnesses due to past issues with rodent damage, and they are hiding behind that rule.
NHTSA complaint #11709509 — an unverified report by a vehicle owner.
I am reporting a safety issue involving the high-voltage battery system of my vehicle. Vehicle: 2017 Chevrolet Bolt EV VIN: [XXX] Mileage: 87,125 miles The vehicle has generated a P302F diagnostic trouble code, which indicates high-voltage battery cell imbalance. This condition may pose a safety risk related to battery performance and thermal stability. The authorized Chevrolet dealership has refused to diagnose the issue under warranty unless I pre-authorize a $600 diagnostic fee. The vehicle is covered under an active GM buyback warranty and a 10-year / 100,000-mile battery warranty due to a recall battery replacement. Due to the safety implications of a high-voltage battery fault, I believe refusal to diagnose the issue under warranty may pose a risk and warrants review. I am submitting this complaint to document the issue and request investigation. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11707136 — an unverified report by a vehicle owner.
THIS VEHICLE JUST STOPPED IN THE MIDDLE OF TRAFFIC, NOT GIVING ME TIME TO PULL OVER. THE SCREEN JUST SAID, "SERVICE MODE", AND WOULD NOT GO INTO NEUTRAL TO ENABLE THE CAR TO BE PUSHED TO A SAFE SPOT. HIGHWAY PETROL HAD TO STOP TRAFFIC AND HAVE IT TOWED OFF. THIS WAS ENDANGERING EVERYONE INVOLVED. IF THIS IS A COMMON PROBLEM WITH OTHER CHEVY BOLTS, IT DEFINITELY NEEDS ADDRESSING.
NHTSA complaint #11705604 — an unverified report by a vehicle owner.