Owners have filed 502 complaints
about the 2004 Chevrolet Colorado with NHTSA between 2004 and 2025.
The largest single group is the electrical system.
Across this model's run it ranks 2 of 21 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the Chevrolet Colorado. 50 means typical for this
model; 100 means roughly double.
Severity — 55
10.6% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 61
36% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2004 compares with every other Chevrolet Colorado
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
338.3%
1,000 – 9,999 miles
348.6%
10,000 – 24,999 miles
4310.8%
25,000 – 49,999 miles
7919.9%
50,000 – 74,999 miles
5413.6%
75,000 – 99,999 miles
5814.6%
100,000 – 149,999 miles
6817.1%
150,000+ miles
287.1%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Feb 2004peak 22May 2025
NHTSA investigations into the 2004 Chevrolet Colorado
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
RQ09001Opened 25 Feb 2009Closed 30 Jul 2009EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
BRAKE LAMP SWITCH MALFUNCTION
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUS...
PE04076Opened 10 Nov 2004Closed 14 Mar 2005AIR BAGS:FRONTAL
INADVERTENT FRONT AIRBAG DEPLOYMENT
ALL REPORTS INDICATE INADVERTENT DEPLOYMENT DURING IGNITION START-UP (KEY-ON) AND WITH THE VEHICLE NOT IN MOTION.REPORTED INJURIES WERE MINOR AND CONSIST OF SKIN ABRASION AND BRUISES.THE INCIDENT DATES RANGED FROM JULY THROUGH NOVEMBER 2004.ODI HAS RECEIVED NO ADDITIONAL REPORTS SINCE OPENING THIS INVESTIGATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIS...
Recalls on the 2004 Chevrolet Colorado
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
10V575000
CHILD SEAT
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Risk: BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
09V310000
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
Risk: THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
06V139000
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
CERTAIN PICKUP TRUCKS MAY EXPERIENCE THE PERMANENT LOSS OF BRAKE LAMP FUNCTION OR BRAKE LAMPS THAT ARE ILLUMINATED AT ALL TIMES. THE CENTER HIGH-MOUNTED STOP LAMP (CHMSL) IS AFFECTED IN BOTH INSTANCES. ALSO, IF EQUIPPED, THE CRUISE CONTROL WILL BECOME INOPERATIVE. ANY TRAILER BRAKE LAMPS WHICH ARE CONNECTED TO THE VEHICLE'S BRAKE LAMP WIRING WILL MIMIC THE VEHICLE'S BRAKE LAMPS WHEN EITHER CONDITION OCCURS.
Risk: A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 201449214,242 units in Canada
Accessories
*** This notice is provided for information purposes only as the subject equipment is not regulated under the Motor Vehicle Safety Act *** A safety defect may exist in aftermarket ACDelco brake shoes manufactured between April 1st 2013 to April 19 2014, sold and/or installed as service replacement parts. The lining of the rear brake shoe may detach from the steel shoe during normal service, causing the affected brake to fail. If the lining detaches from the steel shoe, it could cause rear-wheel lockup and it will reduce the available braking force which could lengthen the required stopping distance, and increase the risk of a crash without prior warning. Correction: GM Dealers, ACDelco warehouse distributors and their professional installer customers are to inspect the manufacture date of the rear brake shoes and, if necessary, replace the shoes. Customers of the 125 vehicles that were serviced by GM Dealers with the suspect parts will be notified by first class letter.
Recall 20104187,193 units in Canada
Seats And Restraints
Certain vehicles with regular or extended cab without a rear seat, and equipped with a front 60/40 split bench seat, fail to conform to Canada Motor Vehicle Safety Standard 210.1 - User-ready Tether Anchorages for Restraint Systems. The child restraint top tether anchor for the front centre seat position in these vehicles is not accessible as required by the Standard. Without the top tether anchor, a child restraint may not be properly secured in the vehicle. Correction: If requested by the customers, dealers will modify the back panel trim cover to allow access to the top tether anchor. In addition, owner letters will include an Owner Manual Supplement that describes how to install a child restraint using a top tether in the centre seating position.
Recall 200609628,398 units in Canada
Electrical
On certain vehicles the brake lights may fail to illuminate or stay illuminated at all times. In addition the cruise control will be inoperative. A following driver may not know when the brakes have been applied, and a rear-end crash could occur without prior warning. Correction: Dealers will replace the stop light switch.
Recall 200608748 units in Canada
Lights And Instruments
Certain vehicles fail to comply with the requirements of CMVSS 101 & 108. The Body Control Module (BCM) was programmed incorrectly during vehicle assembly. The program that was installed resulted in an odometer reading that indicates miles per hour rather than kilometres per hour. It also allowed the daytime running lamps (DRL) to be manually turned off. Correction: Dealers will inspect for correct calibration and reprogram the BCM, if required.
Reports where the owner recorded a crash, a fire, an injury or a death.
Kingsport, TNFire
FUEL/PROPULSION SYSTEM
There apparently was fuel dripping onto the starter and soaking the starter so when we went to start the truck. It caught on fire 🔥🔥 And my truck is a total loss
NHTSA complaint #11549831 — an unverified report by a vehicle owner.
at 85,000 milesEnfield, CTFire
ELECTRICAL SYSTEM
I'VE HAD TO REPLACE 2 HEATER BLOWER RESISTORS DUE TO A MELTDOWN, THIS IS A POTENTIAL FIRE HAZARD AND SHOULD BE PUT ON A RECALL NOTICE. I WAS DRIVING AROUND 40 MPH AT THE TIME .
NHTSA complaint #11355441 — an unverified report by a vehicle owner.
at 130,000 milesRochester, NYFire
ELECTRICAL SYSTEM
I TOO HAVE EXPERIENCED PROBLEMS WITH THE HVAC SYSTEM OF THIS TRUCK. I HAVE HAD TO REPLACE NO LESS THAN 4 RESISTORS AND CONNECTORS DUE TO MELTING AND BURNED CONNECTIONS. I HAVE NOT HAD TO REPLACE A SINGLE FUSE. MY HVAC IS ONCE AGAIN INOPERABLE AND I HAVE OPENED AND INSPECTED EACH CONNECTION POINT TO LOCATE THE PROBLEM. I HAVE FOUND MULTIPLE CONNECTORS TO BE BURNED OR MELTED. THIS PROBLEM HAS BEEN FLAGGED BY THE NHSTA IN THE HUMMER H3 VEHICLES WHICH USE THE SAME HVAC SYSTEM. THE CHEVROLET/GMC/ISUZU COLORADO/CANYON (GMT355) SHOULD BE INCLUDED IN THIS RECALL. THERE IS NO REASON THESE CONNECTIONS SHOULD GET HOT ENOUGH TO BUBBLE AND BURN PLASTIC BEFORE BURNING OUT A FUSE. I CAN PROVIDE IMAGES UPON REQUEST. I CAN ALSO PROVIDE AN EXAMPLE OF A FAILED CONNECTOR IN THE HVAC SPEED CONTROL SWITCH FOR PHYSICAL INSPECTION. I HAVE SET THE "FIRE" FLAG ON THIS REPORT AS THERE HAS BEEN EVIDENCE OF MULTIPLE ELECTRICAL FIRES ON MULTIPLE OCCASIONS IN SEVERAL LOCATIONS IN THE HVAC SYSTEM OF THIS VEHICLE.
NHTSA complaint #10816920 — an unverified report by a vehicle owner.
at 73,060 milesCamdenton, MOFire
EXTERIOR LIGHTING
THE DASHBOARD LIGHTS WILL STOP WORKING IF YOUR DRIVING AT NIGHT AND TURN THE CAR OFF AND THEN TURN IT BACK ON. THEY WILL NOT WORK UNTIL THE CAR SITS FOR A LONG PERIOD OF TIME. THIS STARTED SOON AFTER BUYING THE CAR BRAND NEW, BUT THE DEALERSHIP COULDN'T FIND ANYTHING WRONG. SECOND COMPLAINT, THE HEATER/AIR CONDITIONER FAN HAD AN ELECTRICAL FIRE AT WHERE THE HARNESS PLUGS INTO THE FAN MOTOR. THE FAN WILL ONLY WORK ON HIGH. WHEN I LOOKED ONLINE AT OTHER COMPLAINTS ABOUT THE SAME PROBLEM, I UNPLUGGED THE FAN AND NOTICED THE PLUG WAS BURNT. I HAVE PHOTOS THAT I CAN SEND. IT APPEARED THE ELECTRICAL FIRE CONTINUED DOWN THE PLASTIC PLUG TO WHERE THE WIRES ARE EXPOSED. THIS COULD HAVE BEEN A MAJOR INCIDENT IF I DIDN'T NOTICE IT. THERE ARE A LOT OF COMPLAINTS ABOUT THIS WITH COLORADO TRUCKS ONLINE. ALSO WHEN DRIVING AT NIGHT, MY DASH LIGHTS AND INSTRUMENT LIGHTS FLICKER AS IF THERE IS ANOTHER ELECTRICAL SHORT SOMEWHERE IN THE WIRING HARNESS.
NHTSA complaint #10640178 — an unverified report by a vehicle owner.
at 73,060 milesCamdenton, MOFire
ELECTRICAL SYSTEM
THE DASHBOARD LIGHTS WILL STOP WORKING IF YOUR DRIVING AT NIGHT AND TURN THE CAR OFF AND THEN TURN IT BACK ON. THEY WILL NOT WORK UNTIL THE CAR SITS FOR A LONG PERIOD OF TIME. THIS STARTED SOON AFTER BUYING THE CAR BRAND NEW, BUT THE DEALERSHIP COULDN'T FIND ANYTHING WRONG. SECOND COMPLAINT, THE HEATER/AIR CONDITIONER FAN HAD AN ELECTRICAL FIRE AT WHERE THE HARNESS PLUGS INTO THE FAN MOTOR. THE FAN WILL ONLY WORK ON HIGH. WHEN I LOOKED ONLINE AT OTHER COMPLAINTS ABOUT THE SAME PROBLEM, I UNPLUGGED THE FAN AND NOTICED THE PLUG WAS BURNT. I HAVE PHOTOS THAT I CAN SEND. IT APPEARED THE ELECTRICAL FIRE CONTINUED DOWN THE PLASTIC PLUG TO WHERE THE WIRES ARE EXPOSED. THIS COULD HAVE BEEN A MAJOR INCIDENT IF I DIDN'T NOTICE IT. THERE ARE A LOT OF COMPLAINTS ABOUT THIS WITH COLORADO TRUCKS ONLINE. ALSO WHEN DRIVING AT NIGHT, MY DASH LIGHTS AND INSTRUMENT LIGHTS FLICKER AS IF THERE IS ANOTHER ELECTRICAL SHORT SOMEWHERE IN THE WIRING HARNESS.
NHTSA complaint #10640178 — an unverified report by a vehicle owner.
at 60,000 milesMckees Rock, PACrash
SERVICE BRAKES
PERIODIC ABS SYSTEM FAILURE OCCURRING WHILE DRIVING AND APPLYING THE BRAKES. HAS BEEN A FAILURE FOR FOUR YEARS MADE EFFORTS TO REMEDY THE PROBLEM BY CALLING THEM AND NO SATISFACTION. I'VE ASKED OTHER COLORADO OWNERS AND THEY SAID THEY HAVE THIS PROBLEM IN THE 05, 06.. I HIT INTO A SCHOOL BUS.
NHTSA complaint #10597529 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Honolulu, HI
TIRES:SIDEWALL
Tire size 245/45R20 I purchased a set a 4 Cooper Discoverer H/T Plus tires for my truck in 2022. I haven't driven a lot of miles on them due to the fact that I live on the Island of Oahu, in Honolulu, Hawaii and have a lot of thread life left. I noticed that the sidewalls on 2 of 4 tires are cracking and separating. I removed them from the vehicle due to the risk of tire blowout and injury in the event of an accident. I've emailed Cooper tires for information and warranty resolution and have yet had a reply.
NHTSA complaint #11663290 — an unverified report by a vehicle owner.
Kingsport, TNFire
FUEL/PROPULSION SYSTEM
There apparently was fuel dripping onto the starter and soaking the starter so when we went to start the truck. It caught on fire 🔥🔥 And my truck is a total loss
NHTSA complaint #11549831 — an unverified report by a vehicle owner.
Branchville, NJ
EXTERIOR LIGHTING
One day, after I turned my truck off, I noticed that my taillights and overhead cargo light remained on. Key was out, truck was off, but the lights stayed on. So for the time being, I disconnected the battery. I brought it to a mechanic, who ran the codes that came back that the rear driver turn signal was high, the rear passenger turn signal was high, and the overhead cargo light was high. He checked the entire truck for a short, replaced the taillights, replaced the fuse box, replaced the body control module, and numerous other attempts at a repair, with no success. I was without a vehicle for many months, since I can't afford the absurd prices of the current vehicle market and was hopeful it could be fixed. Reading through some other complaints/online threads, this seems like a fairly common problem with these vehicles. Electrical issues that affect my ability to use a turn signal are a huge safety concern and this needs to be addressed.
NHTSA complaint #11541503 — an unverified report by a vehicle owner.
Branchville, NJ
ELECTRICAL SYSTEM
One day, after I turned my truck off, I noticed that my taillights and overhead cargo light remained on. Key was out, truck was off, but the lights stayed on. So for the time being, I disconnected the battery. I brought it to a mechanic, who ran the codes that came back that the rear driver turn signal was high, the rear passenger turn signal was high, and the overhead cargo light was high. He checked the entire truck for a short, replaced the taillights, replaced the fuse box, replaced the body control module, and numerous other attempts at a repair, with no success. I was without a vehicle for many months, since I can't afford the absurd prices of the current vehicle market and was hopeful it could be fixed. Reading through some other complaints/online threads, this seems like a fairly common problem with these vehicles. Electrical issues that affect my ability to use a turn signal are a huge safety concern and this needs to be addressed.
NHTSA complaint #11541503 — an unverified report by a vehicle owner.
Dearborn Heights, MI
UNKNOWN OR OTHER
The frame on my 2004 Chevy Colorado has rusted/rotted to the point that it snapped, causing the bed to rub against the cab. Mechanic said it is not fixable.
NHTSA complaint #11533583 — an unverified report by a vehicle owner.
Thompsonville, IL
UNKNOWN OR OTHER
Frame rust
NHTSA complaint #11526273 — an unverified report by a vehicle owner.
Thompsonville, IL
STRUCTURE:BODY
Frame rust
NHTSA complaint #11526273 — an unverified report by a vehicle owner.
Sandown, NH
UNKNOWN OR OTHER
Frame of my vehicle is rotting away causing to fail inspection. Just finding out that Toyota did a recall on one of there pick up models replacing their frame due rotting frames that may be a safety factor if it gets into an accident. Does Chevy Colorado have a recall as such? Just had my frame recently welded on a piece of heavy metal to reinforce my frame in order to pass a safety inspection
NHTSA complaint #11525731 — an unverified report by a vehicle owner.
Caneyville, KY
POWER TRAIN
Ignition safety module known as pass lock security. This causes my vehicle not to start and give a code and a light on the dash for the Pass Lock security. The vehicle was fine then I went into a store came out and put the key in the ignition, the lights on the dash came on but it would not crank. This is very hazardous cause It could happen while you’re driving anytime, which could cause the vehicle to go into security mode and turn vehicle off making it very dangerous for passengers in vehicle. This is a problem with other Chevy Colorado's when I research this problem.
NHTSA complaint #11496968 — an unverified report by a vehicle owner.
Caneyville, KY
ELECTRICAL SYSTEM
Ignition safety module known as pass lock security. This causes my vehicle not to start and give a code and a light on the dash for the Pass Lock security. The vehicle was fine then I went into a store came out and put the key in the ignition, the lights on the dash came on but it would not crank. This is very hazardous cause It could happen while you’re driving anytime, which could cause the vehicle to go into security mode and turn vehicle off making it very dangerous for passengers in vehicle. This is a problem with other Chevy Colorado's when I research this problem.
NHTSA complaint #11496968 — an unverified report by a vehicle owner.
Batesville, AR
ELECTRICAL SYSTEM
Body Control Module, BCM. Controls everything. Air bag can deploy, breaks can lock up. Mine, the hazards were staying on. Chevy Dealer says they are on National Back Order and GM is canceling those orders after so long placed. “We can get you one from a junk yard for $350 but GM won’t let us properly program them with correct codes, and so many times they won’t take, and I can’t return the part”. My response to GM already and to Congressman Westerman, BBB, and the WH. A part such as the on board computer, SAFETY first, should never come from a junk yard and if GM doesn’t want to supply the part AS we all know they need them for newer cars right now….. You, the NHTSB and all of us are in danger. There is an expiration date on our cars, but we’re not being told. A computer that controls EVERYTHING in a vehicle is more important than a safety belt. Me not wearing it kills me. Me being told by the dealer I could leave my fuses out and put my arm out the window. Boy I hate being a retired SGM, cause I ain’t allowed to put my boot in a six.
NHTSA complaint #11479749 — an unverified report by a vehicle owner.
South Hadley, MA
UNKNOWN OR OTHER
Mechanic had the truck on the lift raised up to check the brakes for squeaking and while under the truck the mechanic inspected the frame because he noticed a lot of rust and called me to come look at it and pointed out that the frame has rotted to the point that he should not be driven and could break in half and cause major problems for the safety of the occupants and other drivers on the road. I looked up online if other Colorado owners had the same issue and others have the same problem. I’m am forced to junk this vehicle even though the rest of the truck is in very good condition
NHTSA complaint #11460332 — an unverified report by a vehicle owner.
South Hadley, MA
SUSPENSION
Mechanic had the truck on the lift raised up to check the brakes for squeaking and while under the truck the mechanic inspected the frame because he noticed a lot of rust and called me to come look at it and pointed out that the frame has rotted to the point that he should not be driven and could break in half and cause major problems for the safety of the occupants and other drivers on the road. I looked up online if other Colorado owners had the same issue and others have the same problem. I’m am forced to junk this vehicle even though the rest of the truck is in very good condition
NHTSA complaint #11460332 — an unverified report by a vehicle owner.
South Hadley, MA
STRUCTURE:BODY
Mechanic had the truck on the lift raised up to check the brakes for squeaking and while under the truck the mechanic inspected the frame because he noticed a lot of rust and called me to come look at it and pointed out that the frame has rotted to the point that he should not be driven and could break in half and cause major problems for the safety of the occupants and other drivers on the road. I looked up online if other Colorado owners had the same issue and others have the same problem. I’m am forced to junk this vehicle even though the rest of the truck is in very good condition
NHTSA complaint #11460332 — an unverified report by a vehicle owner.
Mound, MN
STRUCTURE:BODY
I was checking on the common rear cab rust and noticed the frame looked rusted through just in front of the rear wheel suspension mount. I took it to my local mechanic (Bob's Repair of Mayer) and they said it was not safe to drive. It is a complete blindside to me and now I have to find a spare (safe) car to help drive around my newborn and toddler. I am going to attempt to repair the frame as I do not have any other options for vehicles. There were obviously no warnings are notices that about this issue, but it seems to be uncannily common for this generation of Chevrolet vehicles. The truck only has 160,000 miles on it and surface rust on the cab. The vehicle is not drivable and not safe as the frame could give away at any moment.
NHTSA complaint #11458276 — an unverified report by a vehicle owner.
at 150,000 milesThomasville, PA
UNKNOWN OR OTHER
FRAME RUSTED OUT LIKE THE TOYOTAS DID AND IS NO LONGER SAFE TO DRIVE.
NHTSA complaint #11413031 — an unverified report by a vehicle owner.
Thomasville, PA
SUSPENSION
THE FRAME OF THE TRUCK ROTTED AND IS NO LONGER DRIVEABLE WITHOUT A CHANCE OF AN ACCIDENT. THE PA INSPECTION IS ABOUT TO RUN OUT ALSO AND WILL NOT PASS INPECTION. I BOUGHT THIS TRUCK USED AND JUST PAID IT OFF AND WAS HOPING I WAS CLEAR OF ANY VEHICLE PAYMENTS. AT THIS POINT THERE IS NO WAY I WILL EVEN GET CLOSE TO WHAT I PAID FOR IT AS IT IS ONLY GOOD FOR SCRAP. I AGREE WITH ANOTHER POST I SAW ON HERE THAT SAID IF TOYOTA HAD TO RECALL THEIR VEHICLES FOR THE SAME REASON THEN WHY DOES GM NOT HAVE TO DO THE SAME THING? IT ONLY SEEMS RIGHT. I KNOW THEY HAVE HEARD OF THIS ISSUE BUT ARE JUST TRYING TO BRUSH IT UNDER THE RUG HOPING IT DOESN'T COME UP. HOPING YOU HAVE OUR BACK ON THIS WITH TRYING TO PROTECT THE CONSUMER.
NHTSA complaint #11405597 — an unverified report by a vehicle owner.
at 96,800 milesNorth Smithfield, RI
SUSPENSION
VEHICLE HAS 96,800 MILES, AND THE FRAME HAS COMPLETELY RUSTED THROUGH CAUSING THE REAR SUSPENSION TO DETACH FROM THE FRAME, AS WELL AS THE BED TO DETACH FROM THE FRAME. VEHICLE IS NO LONGER ABLE TO BE PUT ON LIFT TO HAVE TIRES ROTATED AS THE FRAME DISINTEGRATES UPON CONTACT. THIS IS A VERY WELL KNOWN PROBLEM, AND I AM CURIOUS WHY THE FEDERAL GOVERNMENT HAS NOT FORCED GM TO RECALL THESE VEHICLES LIKE TOYOTA WAS FORCED TO DO WITH THEIR IDENTICAL SITUATION. DO YOUR JOBS, AND HOLD THESE CORPORATIONS ACCOUNTABLE FOR CHEAP WORKMANSHIP.
NHTSA complaint #11397449 — an unverified report by a vehicle owner.
at 96,800 milesNorth Smithfield, RI
STRUCTURE:BODY
VEHICLE HAS 96,800 MILES, AND THE FRAME HAS COMPLETELY RUSTED THROUGH CAUSING THE REAR SUSPENSION TO DETACH FROM THE FRAME, AS WELL AS THE BED TO DETACH FROM THE FRAME. VEHICLE IS NO LONGER ABLE TO BE PUT ON LIFT TO HAVE TIRES ROTATED AS THE FRAME DISINTEGRATES UPON CONTACT. THIS IS A VERY WELL KNOWN PROBLEM, AND I AM CURIOUS WHY THE FEDERAL GOVERNMENT HAS NOT FORCED GM TO RECALL THESE VEHICLES LIKE TOYOTA WAS FORCED TO DO WITH THEIR IDENTICAL SITUATION. DO YOUR JOBS, AND HOLD THESE CORPORATIONS ACCOUNTABLE FOR CHEAP WORKMANSHIP.
NHTSA complaint #11397449 — an unverified report by a vehicle owner.
Livonia, MI
UNKNOWN OR OTHER
I SOLD THIS TRUCK LAST SPRING WITH 243,829 ON THE ODOMETER, IT IS NOW FOR SALE WITH 155,000 ON IT
NHTSA complaint #11396814 — an unverified report by a vehicle owner.
at 166,000 milesBelpre, OH
STRUCTURE:BODY
THE FRAME UNDER THE CAB IS RUSTED OUT
NHTSA complaint #11394982 — an unverified report by a vehicle owner.
Camillus, NY
STRUCTURE:BODY
2004 CHEVY COLORADO THE WHOLE FRAME UNDERNEATH IS ROTTED OUT AND UNSAFE. I DON'T HAVE MONEY OR INCOME OR CREDIT TO GET A NEW VEHICLE. I WANT TO KNOW HOW CHEVY COULD ALLOW SUCH A TRAGIC MISTAKE ON THE METAL USED FOR THIS VEHICLE? I AM NOT THE ONLY PERSON WHO HAS HAD THIS ISSUE WITH THE FRAMES ON THESE VEHICLE?. IT IS ALL I HAVE TO DRIVE AND I AM PUTTING CHEVY UNDER WARNING!, THIS IS A DEFECT IN THE METAL YOU HAVE USED. IF ANYTHING HAPPENS TO ME OR ANYONE ELSE THEY ARE TO SUE CHEVY. THIS IS NOT A PROBLEM NOT CAUSED BY BUYER. THIS IS CAUSED BY CHEAP METALS FOR VEHICLE. THIS IS MY FIRST SUPPOSEDLY MADE IN USA VEHICLE AND NOW IT HAS LEFT A BAD TASTE IN MY MOUTH. I AM NOT GOING TO BE HELD RESPONSIBLE FOR YOUR DEFECT. I AM NOT THE ONLY ONE WITH THIS PROBLEM. IT NEEDS TO BE TAKEN CARE OF ASAP.
NHTSA complaint #11388139 — an unverified report by a vehicle owner.
at 85,000 milesEnfield, CTFire
ELECTRICAL SYSTEM
I'VE HAD TO REPLACE 2 HEATER BLOWER RESISTORS DUE TO A MELTDOWN, THIS IS A POTENTIAL FIRE HAZARD AND SHOULD BE PUT ON A RECALL NOTICE. I WAS DRIVING AROUND 40 MPH AT THE TIME .
NHTSA complaint #11355441 — an unverified report by a vehicle owner.
at 134,000 milesGarrettsville, OH
SUSPENSION
TL* THE CONTACT OWNS A 2004 CHEVROLET COLORADO. THE CONTACT DISCOVERED THAT THE UNDERCARRIAGE OF THE VEHICLE WAS SEVERELY CORRODED. THE CONTACT EXPRESSED CONCERN THAT THE CORROSION CENTERED AROUND THE SUSPENSION AND SUBFRAME SPRING MOUNTS. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED BY A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 134,000.
NHTSA complaint #11322958 — an unverified report by a vehicle owner.
at 134,000 milesGarrettsville, OH
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 CHEVROLET COLORADO. THE CONTACT DISCOVERED THAT THE UNDERCARRIAGE OF THE VEHICLE WAS SEVERELY CORRODED. THE CONTACT EXPRESSED CONCERN THAT THE CORROSION CENTERED AROUND THE SUSPENSION AND SUBFRAME SPRING MOUNTS. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED BY A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 134,000.
NHTSA complaint #11322958 — an unverified report by a vehicle owner.