Owners have filed 408 complaints
about the 2002 Chevrolet Silverado 2500 with NHTSA between 2001 and 2025.
The largest single group is the brakes.
Across this model's run it ranks 3 of 29 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the Chevrolet Silverado 2500. 50 means typical for this
model; 100 means roughly double.
Severity — 62
12% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 18
11% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2002 compares with every other Chevrolet Silverado 2500
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
20.6%
1,000 – 9,999 miles
61.7%
10,000 – 24,999 miles
92.5%
25,000 – 49,999 miles
5515.4%
50,000 – 74,999 miles
8323.2%
75,000 – 99,999 miles
6618.5%
100,000 – 149,999 miles
8022.4%
150,000+ miles
5615.7%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2001peak 14Aug 2025
NHTSA investigations into the 2002 Chevrolet Silverado 2500
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
COMPLAINT REPORTS ALLEGE POOR WELD QUALITY AND/OR BENDING OF THE SUBJECT VEHICLE ORIGINAL EQUIPMENT TRAILER HITCH RECEIVER.THE AGENCY'S INVESTIGATION INCLUDED ANALYSIS OF MANUFACTURER AND AGENCY INCIDENT REPORTS, REVIEW OF POLICE REPORTS, ANALYSIS OF THE AGENCY'S FATAL ANALYSIS REPORTING SYSTEM, A VEHICLE OWNER SURVEY, INSPECTION OF TOW VEHICLES/HITCHES AND ANALYSIS OF FAILED PARTS.INCIDENTS OF WELD FAILURE WERE RARE AND ASSOCIATED WITH VERY LOW-SPEED DRIVING (TURNING, BACKING AND SUDDEN STOPPING).INCIDENTS OF BENDING WERE ASSOCIATED WITH IMPROPER TRAILER HITCH ADJUSTMENT OR OVERLOADING. A SAF...
PE07025Opened 14 May 2007Closed 14 Sep 2007TRAILER HITCHES
TRAILER HITCH RECEIVER FAILURE
GM PROVIDED ADDITIONAL DATA REGARDING ALLEGATIONS OF FAILURE OF THE TRAILER HITCH.ODI REVIEWED THAT AS WELL AS OTHER DATA PROVIDED BY PEER MANUFACTURERS.BASED ON OUR REVIEW, ODI FINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.THIS PRELIMINARY EVALUATION IS UPGRADED TO AN ENGINEERING ANALYSIS (EA07-013) FOR FURTHER ASSESSMENT AND STUDY OF THIS ISSUE.
EA04012Opened 30 Apr 2004Closed 28 Feb 2005SERVICE BRAKES, HYDRAULIC:POWER ASSIST
HYDRAULIC PUMP FAILRES
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
PE04004Opened 8 Jan 2004Closed 30 Apr 2004SERVICE BRAKES, HYDRAULIC
HYDRAULIC PUMP SHAFT FAILURES
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AN...
Recalls on the 2002 Chevrolet Silverado 2500
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
06E043000
FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
06E010000
STEERING
CERTAIN FABTECH AFTERMARKET REPLACEMENT PITMAN ARMS, P/NOS. FTS71000 AND FTS71001, INSTALLED FOR USE ON CERTAIN 2001-2006 GM C/K 2500 PICK UP TRUCKS AND SPORT UTILITY VEHICLES. THE PIN LOCATED INSIDE THE PITMAN ARM CAN SHEAR OFF DUE TO A REVERSE BENDING FATIGUE CONDITION, RESULTING IN A TOTAL LOSS OF STEERING CONTROL.
Risk: LOSS OF STEERING CONTROL COULD LEAD TO A VEHICLE CRASH WITH POTENTIAL INJURY OR DEATH.
01V220000
INTERIOR LIGHTING
VEHICLE DESCRIPTION: CERTAIN PICKUP TRUCKS EQUIPPED WITH 6.6L DIESEL ENGINES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THESE VEHICLES HAVE A BRAKE SYSTEM WARNING LIGHT IN THE INSTRUMENT CLUSTER THAT MAY NOT ILLUMINATE WHEN THE BRAKE FLUID IS LOW. IN ADDITION, WHEN THE BRAKE FLUID IS LOW, THE VEHICLE MAY NOT MEET THE PARTIAL SYSTEM REQUIREMENTS OF FMVSS NO. 105.
Risk: THESE CONDITIONS COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD LEAD TO A CRASH.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 143,000 milesCocoa, FLCrash2 injured1 killed
SERVICE BRAKES
DRIVING UP TO CITY INTERSECTION WAS APPLING BRAKES, CAR IN FRONT APPLIED HIS QUICKER CAUSING HIS REAR TO RAISE UP, INDICATING PANIC STOP, I FOLLOWED AND APPLIED HARD PRESSURE TO MY BRAKES, PEDAL THEN WENT TO THE FLOOR AND LOST ALL BRAKE ACTION, THIS LEAD TO MY TRUCK REAR END OF OTHER CARS
NHTSA complaint #11343261 — an unverified report by a vehicle owner.
at 243,244 milesMarshall, TXFire
SEAT BELTS
AS I WAS DRIVING AT 75 MPH, THE INDICATOR LIGHT SAID, ENGINE OVERHEATED. I THEN NOTICED WHITE SMOKE COMING FROM THE HOOD. THE WHITE SMOKE TURNED BLACK. I PULLED OVER TO THE SIDE OF THE ROAD AND BEFORE I COULD SHUT THE ENGINE OFF, THE ENGINE SHUT OFF ON ITS OWN. FIRE BEGAN COMING UP WHERE THE WINDSHIELD WIPERS ARE LOCATED AND PROCEEDED THROUGH THE DASHBOARD. I TRIED TO UNLATCH MY SEAT BELT BUT IT WOULD NOT RELEASE. AFTER SEVERAL TRIES IT RELEASED. I ATTEMPTED TO OPEN THE DOOR; HOWEVER, I HAD THE SAME PROBLEM. THE DOOR DID NOT OPEN. AFTER BUMPING THE DOOR FORCIBLY MANY TIMES, IT ALSO CAME OPEN. MIND YOU, ALL THE WHILE THE FLAMES ARE COMING INSIDE THE CAB. I CALLED 911 AND THE COUNTY FIRE DEPARTMENT WAS DISPATCHED, BUT NOT BEFORE IT WAS FULLY ENGULFED IN FLAMES. THE VEHICLE WAS WELL MAINTAINED. I WANT TO KNOW WHAT STEPS TO TAKE TO PREVENT THIS FROM EVER HAPPENING AGAIN?
NHTSA complaint #10716507 — an unverified report by a vehicle owner.
at 247,433 milesMarshal, TXFire
SEAT BELTS
TL* THE CONTACT OWNED A 2002 CHEVROLET SILVERADO 2500 HD. WHILE DRIVING APPROXIMATELY 75 MPH, A MESSAGE INDICATING THAT THE ENGINE OVERHEATED DISPLAYED AND SMOKE APPEARED UNDER THE HOOD OF THE VEHICLE. THE FLAMES QUICKLY SPREAD TO THE CABIN OF THE VEHICLE. WHILE THE FLAMES WERE INSIDE THE CABIN, THE CONTACT ATTEMPTED TO EXIT THE VEHICLE BUT THE DRIVER SIDE SEAT BELT WOULD NOT IMMEDIATELY UNLOCK. THE SEAT BELT FINALLY UNLOCKED, BUT THE DRIVER SIDE DOOR WOULD NOT UNLOCK. THE DOOR EVENTUALLY UNLOCKED AND THE CONTACT WAS ABLE TO EXIT THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE TO EXTINGUISH THE FLAMES. THE VEHICLE WAS DESTROYED. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 247,433.
NHTSA complaint #10716521 — an unverified report by a vehicle owner.
at 247,433 milesMarshal, TXFire
LATCHES/LOCKS/LINKAGES
TL* THE CONTACT OWNED A 2002 CHEVROLET SILVERADO 2500 HD. WHILE DRIVING APPROXIMATELY 75 MPH, A MESSAGE INDICATING THAT THE ENGINE OVERHEATED DISPLAYED AND SMOKE APPEARED UNDER THE HOOD OF THE VEHICLE. THE FLAMES QUICKLY SPREAD TO THE CABIN OF THE VEHICLE. WHILE THE FLAMES WERE INSIDE THE CABIN, THE CONTACT ATTEMPTED TO EXIT THE VEHICLE BUT THE DRIVER SIDE SEAT BELT WOULD NOT IMMEDIATELY UNLOCK. THE SEAT BELT FINALLY UNLOCKED, BUT THE DRIVER SIDE DOOR WOULD NOT UNLOCK. THE DOOR EVENTUALLY UNLOCKED AND THE CONTACT WAS ABLE TO EXIT THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE TO EXTINGUISH THE FLAMES. THE VEHICLE WAS DESTROYED. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 247,433.
NHTSA complaint #10716521 — an unverified report by a vehicle owner.
at 243,244 milesMarshall, TXFire
ENGINE
AS I WAS DRIVING AT 75 MPH, THE INDICATOR LIGHT SAID, ENGINE OVERHEATED. I THEN NOTICED WHITE SMOKE COMING FROM THE HOOD. THE WHITE SMOKE TURNED BLACK. I PULLED OVER TO THE SIDE OF THE ROAD AND BEFORE I COULD SHUT THE ENGINE OFF, THE ENGINE SHUT OFF ON ITS OWN. FIRE BEGAN COMING UP WHERE THE WINDSHIELD WIPERS ARE LOCATED AND PROCEEDED THROUGH THE DASHBOARD. I TRIED TO UNLATCH MY SEAT BELT BUT IT WOULD NOT RELEASE. AFTER SEVERAL TRIES IT RELEASED. I ATTEMPTED TO OPEN THE DOOR; HOWEVER, I HAD THE SAME PROBLEM. THE DOOR DID NOT OPEN. AFTER BUMPING THE DOOR FORCIBLY MANY TIMES, IT ALSO CAME OPEN. MIND YOU, ALL THE WHILE THE FLAMES ARE COMING INSIDE THE CAB. I CALLED 911 AND THE COUNTY FIRE DEPARTMENT WAS DISPATCHED, BUT NOT BEFORE IT WAS FULLY ENGULFED IN FLAMES. THE VEHICLE WAS WELL MAINTAINED. I WANT TO KNOW WHAT STEPS TO TAKE TO PREVENT THIS FROM EVER HAPPENING AGAIN?
NHTSA complaint #10716507 — an unverified report by a vehicle owner.
at 247,433 milesMarshal, TXFire
ENGINE
TL* THE CONTACT OWNED A 2002 CHEVROLET SILVERADO 2500 HD. WHILE DRIVING APPROXIMATELY 75 MPH, A MESSAGE INDICATING THAT THE ENGINE OVERHEATED DISPLAYED AND SMOKE APPEARED UNDER THE HOOD OF THE VEHICLE. THE FLAMES QUICKLY SPREAD TO THE CABIN OF THE VEHICLE. WHILE THE FLAMES WERE INSIDE THE CABIN, THE CONTACT ATTEMPTED TO EXIT THE VEHICLE BUT THE DRIVER SIDE SEAT BELT WOULD NOT IMMEDIATELY UNLOCK. THE SEAT BELT FINALLY UNLOCKED, BUT THE DRIVER SIDE DOOR WOULD NOT UNLOCK. THE DOOR EVENTUALLY UNLOCKED AND THE CONTACT WAS ABLE TO EXIT THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE TO EXTINGUISH THE FLAMES. THE VEHICLE WAS DESTROYED. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 247,433.
NHTSA complaint #10716521 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Saint Charles, IL
SERVICE BRAKES
I pulled the truck out of the garage in working condition, left it running while parked in the driveway. It emptied the entire brake fluid reservoir through a leak in the distribution junction on the rear axle, leaving the truck with no brake function whatsoever. Had I not parked the truck in the driveway, I would have been involved in a serious collision due to sudden complete brake failure.
NHTSA complaint #11679616 — an unverified report by a vehicle owner.
Winchester, KY
SERVICE BRAKES
While driving on US60 East of Lexington Kentucky I was preparing to turn left using the left turn lane. There was another car in front of mine and as I approached it I began to lightly apply the brakes. The brake pedal went all the way to the floor with no decrease in speed. Fortunately I was able to switch back to the through lane and avoid an accident. While I was able to avoid an accident there was definitely a risk of injury to myself and the occupants of the other vehicle. When I was able to inspect the vehicle I found that the brakeline adjacent to the fuel tank was rusted through which caused a complete brake failure. I do the vehicle maintenance personally and have since made necessary repairs to the brake system. I was aware of problems with the brakelines on this vintage truck being prone to failure due to rusting. As I was making repairs it was obvious the routing of the brakelines was such as to making the rusting more likely to happen.
NHTSA complaint #11433593 — an unverified report by a vehicle owner.
at 182,000 milesEdmonds, WA
SERVICE BRAKES
HARD BRAKE LINE FAILURE DUE TO CORROSION FROM POOR QUALITY PARTS WITHOUT PROPER CORROSION PROTECTION OR CORRECT MATERIALS (I.E. STAINLESS STEEL VS MILD STEEL) WHEN VEHICLE IS USED IN AREAS WHERE DE-ICER IS USED ON THE ROADS.
NHTSA complaint #11413971 — an unverified report by a vehicle owner.
at 265,000 milesTulsa, OK
WHEELS
THE ABS LIGHT CAME ON AND THE BRAKE LIGHT. THE POWER STEERING IS BAD AND THE STEERING WHEEL SHAKES WHEN I BRAKE, I GOT THE BRAKES AND ROTORS CHANGED AND THE PROBLEM PERSISTED
NHTSA complaint #11403813 — an unverified report by a vehicle owner.
at 265,000 milesTulsa, OK
STEERING
THE ABS LIGHT CAME ON AND THE BRAKE LIGHT. THE POWER STEERING IS BAD AND THE STEERING WHEEL SHAKES WHEN I BRAKE, I GOT THE BRAKES AND ROTORS CHANGED AND THE PROBLEM PERSISTED
NHTSA complaint #11403813 — an unverified report by a vehicle owner.
at 265,000 milesTulsa, OK
SERVICE BRAKES
THE ABS LIGHT CAME ON AND THE BRAKE LIGHT. THE POWER STEERING IS BAD AND THE STEERING WHEEL SHAKES WHEN I BRAKE, I GOT THE BRAKES AND ROTORS CHANGED AND THE PROBLEM PERSISTED
NHTSA complaint #11403813 — an unverified report by a vehicle owner.
at 143,000 milesCreswell, OR
ENGINE
KNOWN TO GM INJECTOR PROBLEMS WITH CHEVY SILVERADO VEHICLES. MY INJECTOR CRACKED OR FAILED AND DIESEL WENT IN TO MY ENGINE OIL, CAUSING AN OVER FILL OF 2 GALLONS. OIL WAS LEAKING OUT ALL OVER FROM MY TRUCK WHILE I WAS DRIVING. THERE ARE MANY OTHER POST ABOUT THIS PROBLEM AND GM IS AWARE BUT HASN'T ISSUED A RECALL.
NHTSA complaint #11395766 — an unverified report by a vehicle owner.
at 267,000 milesSkowhegan, ME
SERVICE BRAKES
MY ABS SPEED SENSOR GOT SHEARED BY BACK OF MY FRONT DRIVERS SIDE TIRE IN WHICH I HAVE SEEN ON MULTIPLE SIGHTS A DEFECT THAT WAS DEEMED A RECALL FOR BEING POORLY SET UP ON THE ASSEMBLY LINE. SECONDLY, IVE SPENT THOUSANDS AND LOOKING ONLINE FOR A VARY SERIOUS ISSUE IVE BEEN HAVING WITH MY VEHICLE DUE TO INTERMEDIATE STALLING, BACKFIRING, AND VEHICLE DIEING DUE TO WHAT HAS FINALLY BEEN FOUND TO BE THE INFAMOUS CRANKSHAFT SENSOR. REPLACED MY COMPUTER, ALL 02 SENSORS, EGR VALVE EXC... THAN UPON LOOKING AND RESEARCHING, I FIND IT WAS A MAJOR ONE ON RECALL AS WELL FOR FAILING ALL THE TIME. I JUST FEEL IF THESE ARE FACTORY ERRORS AND BEEN ON THE RECALL, AND MY WOMAN WHO TRAVELS WITH ME THAT IS PARALYZED DUE TO AN ACCIDENT, I SHOULD BE ENTITILED TO THE RECALLS GIVING THEY WERE KNOWN FLAWS ON THE ASSSEMBLY LINE AND A DANGER TO OTHERS. WHEN THE VEHICLE STALLS OUT, IT STARTS CHOKING, BACKFIRING, AND BUCKING AND WANTS TO LOCK UP AND LOOSE CONTROL. NOT COOL. IVE BEEN CHASING THIS PROBLEM SPENDING THOUSANDS IN PARTS AND REPAIRS TO MAKE THIS TRUCK SAFE FOR WORK AND FEEL IF THERE HAS BEEN RECALLS FOR ALL THIS, WOULD BE NICE TO REAP SOMETHING OUT OF MY INVESTMENT IN THIS TRUCK
NHTSA complaint #11373725 — an unverified report by a vehicle owner.
at 267,000 milesSkowhegan, ME
FUEL/PROPULSION SYSTEM
MY ABS SPEED SENSOR GOT SHEARED BY BACK OF MY FRONT DRIVERS SIDE TIRE IN WHICH I HAVE SEEN ON MULTIPLE SIGHTS A DEFECT THAT WAS DEEMED A RECALL FOR BEING POORLY SET UP ON THE ASSEMBLY LINE. SECONDLY, IVE SPENT THOUSANDS AND LOOKING ONLINE FOR A VARY SERIOUS ISSUE IVE BEEN HAVING WITH MY VEHICLE DUE TO INTERMEDIATE STALLING, BACKFIRING, AND VEHICLE DIEING DUE TO WHAT HAS FINALLY BEEN FOUND TO BE THE INFAMOUS CRANKSHAFT SENSOR. REPLACED MY COMPUTER, ALL 02 SENSORS, EGR VALVE EXC... THAN UPON LOOKING AND RESEARCHING, I FIND IT WAS A MAJOR ONE ON RECALL AS WELL FOR FAILING ALL THE TIME. I JUST FEEL IF THESE ARE FACTORY ERRORS AND BEEN ON THE RECALL, AND MY WOMAN WHO TRAVELS WITH ME THAT IS PARALYZED DUE TO AN ACCIDENT, I SHOULD BE ENTITILED TO THE RECALLS GIVING THEY WERE KNOWN FLAWS ON THE ASSSEMBLY LINE AND A DANGER TO OTHERS. WHEN THE VEHICLE STALLS OUT, IT STARTS CHOKING, BACKFIRING, AND BUCKING AND WANTS TO LOCK UP AND LOOSE CONTROL. NOT COOL. IVE BEEN CHASING THIS PROBLEM SPENDING THOUSANDS IN PARTS AND REPAIRS TO MAKE THIS TRUCK SAFE FOR WORK AND FEEL IF THERE HAS BEEN RECALLS FOR ALL THIS, WOULD BE NICE TO REAP SOMETHING OUT OF MY INVESTMENT IN THIS TRUCK
NHTSA complaint #11373725 — an unverified report by a vehicle owner.
at 109,000 milesSAN Juan Capistrano, CA
WHEELS
VIBRATION IN VEHICLE PRIOR TO TIRE BLOW OUT ON FREEWAY TRAVELING APPROXIMATELY 70 MPH.. APPEARS TO BE A TREAD SEPARATION TYPE FAILURE. TIRES ARE BF GOODRICH ALL TERRAIN TA KO BAZ WITH APPROXIMATELY 27000 MILES ON THEM. SIZE IS LT265/75R16. TIRES WERE ROTATED AND CHECKED FOR PROPER INFLATION BY PROFESSIONAL TIRE SHOP APPROXIMATELY 4 DAYS PRIOR TO FAILURE.
NHTSA complaint #11355048 — an unverified report by a vehicle owner.
at 143,000 milesCocoa, FLCrash2 injured1 killed
SERVICE BRAKES
DRIVING UP TO CITY INTERSECTION WAS APPLING BRAKES, CAR IN FRONT APPLIED HIS QUICKER CAUSING HIS REAR TO RAISE UP, INDICATING PANIC STOP, I FOLLOWED AND APPLIED HARD PRESSURE TO MY BRAKES, PEDAL THEN WENT TO THE FLOOR AND LOST ALL BRAKE ACTION, THIS LEAD TO MY TRUCK REAR END OF OTHER CARS
NHTSA complaint #11343261 — an unverified report by a vehicle owner.
at 75,000 milesAlverton, PA
SERVICE BRAKES
TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 2500. WHILE DRIVING 25 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE CONTACT NOTICED A LEAK COMING FROM THE BRAKE LINE AND RUST. THE CONTACT DID NOT ENGAGE THE EMERGENCY BRAKE. THE CONTACT WAS UNSURE IF ANY WARNING INDICATORS WERE ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE RECURRED, BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 75,000.
NHTSA complaint #11120595 — an unverified report by a vehicle owner.
at 48,500 milesWoodland, PA
ENGINE
WHILE DRIVING, THE ENGINE WILL SUDDENLY SHUT DOWN AND WITHOUT WARNING STOP.
NHTSA complaint #11112067 — an unverified report by a vehicle owner.
Groves, TX
UNKNOWN OR OTHER
THE UNDERCARRIAGE. THE ROCKER ARMS THE BRAKE LINES ARE AND HAVE BEEN RUSTED OUT. ITS A RUSTED OUT FRAME. THIS NEEDS TO BE HANDLED AND RECALLED TO ALL GM OWNERS . THIS IS A COSTLY TIME CONSUMING MATTER FOR INDIVIDUALS TO HANDLE. GM SHOULD STEP UP TO THE PLATE AND HANDLE THESE ISSUES. KARMA HOPE U DONT NEED BAILING OUT AGAIN I BET THIS ISSUE ALONE AND GM NOT HELPING BY DOING RIGHT THING WILL CAUSE TREMENDOUS HURT TO U IM SURE YOUVE LIST AKOT OF BUSUNESS FROM THIS.
NHTSA complaint #11098254 — an unverified report by a vehicle owner.
Eldersburg, MD
ENGINE
2002 CHEVROLET SILVERADO. CONSUMER WRITES IN REGARDS TO ENGINE FUEL INJECTORS SAFETY RECALL. *LD THE CONSUMER STATED THE VEHICLE REQUIRED HAVING THE FUEL INJECTORS REPLACED MULTIPLE TIMES. THE VEHICLE WAS REPAIRED TWICE UNDER WARRANTY. THE CONSUMER REQUESTED FOR THE MANUFACTURER CONTINUE TO REPAIR THE INJECTORS UNDER THE WARRANTY.
NHTSA complaint #11061708 — an unverified report by a vehicle owner.
at 50,000 milesSAN Francisco, CA
ENGINE
EXHAUST MANIFOLD BOLTS BREAKING AND BOTH EXHAUST MANIFOLDS CRACKING EVRY 50000 MILES. OCCURS WHILE DRIVING.
NHTSA complaint #11020557 — an unverified report by a vehicle owner.
at 170,000 milesMchenry, IL
SERVICE BRAKES
BRAKE LINES RUSTED OUT CAUSING VEHICLE TO LOOSE BRAKING ABILITY AND AN ACCIDENT WITH MINOR VEHICLE DAMAGE..
NHTSA complaint #11011197 — an unverified report by a vehicle owner.
at 200,000 milesO Fallon, IL
SERVICE BRAKES
EXCESSIVE METAL BRAKE LINE CORROSION ON THIS VEHICLE. BRAKE LINES CORRODED THROUGH CAUSING AN IMMEDIATE LOSS OF BRAKE FLUID AND RESULTED IN ZERO BRAKING ABILITY WHILE VEHICLE WAS IN MOTION ON A BUSY CITY STREET. EMERGENCY BRAKE WAS DEPRESSED TO BRING VEHICLE TO A STOP. INFERIOR MATERIALS HAVE BEEN USED TO PRODUCE BRAKE LINES ON THIS VEHICLE. BRAKE LINE PLACEMENT IN CONJUNCTION WITH INFERIOR METAL THAT IS PRONE TO CORROSION IS AT FAULT. COST TO REPAIR THIS FLAW IN MANUFACTURING WILL BE NEARLY $2000.00
NHTSA complaint #10926216 — an unverified report by a vehicle owner.
at 90,000 milesAshland City, TN
SERVICE BRAKES
TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 2500 HD. WHILE THE VEHICLE WAS STOPPED WITH THE BRAKE PEDAL ENGAGED, THE VEHICLE BEGAN TO INDEPENDENTLY ROLL FORWARD WITHOUT WARNING. THE BRAKE PEDAL WAS DEPRESSED TO THE FLOORBOARD BEFORE THE VEHICLE EVENTUALLY STOPPED. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT THE BRAKE LINES WERE RUSTED THROUGH. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.
NHTSA complaint #10898426 — an unverified report by a vehicle owner.
at 84,000 milesStuart, FL
SERVICE BRAKES
TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 2500. WHILE DRIVING VARIOUS SPEEDS AND ATTEMPTING TO SLOW DOWN BY DEPRESSING THE BRAKE PEDAL, THE BRAKE PEDAL TRAVELED TO THE FLOOR AND MADE IT VERY HARD TO STOP. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKES LINES FAILED DUE TO CORROSION AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 84,000.
NHTSA complaint #10863446 — an unverified report by a vehicle owner.
Mineral, VA
UNKNOWN OR OTHER
TRAILER RELIEVER HITCH BENT AFTER NORMAL USE TOWING TRAVEL TRAILER. PROPER WEIGHT DISTRIBUTING HITCH WAS BEING USED ON INTERSTATE HIGHWAY. WINDS MAY HAVE BEEN CONTRIBUTING FACTOR. HITCH MUST BE REPLACED.
NHTSA complaint #10861109 — an unverified report by a vehicle owner.
at 157,000 milesMV, CA
ENGINE
THE GLOW PLUGS AND FUEL INJECTORS FAIL PREMATURELY I WAS TOLD BY THE LOCOL SERVACE MANAGER THAT THERE WAS PLENTY OF TIME TO GET THE REPAIRS BUT A FEW WEEKS LATER WHEN I BROUGHT IT IN FOR THE SUPPOSED FREE REPAIRS THEY TELL ME THE TIME FOR MINE IS OVER ITS TOO OLD. WHEN NO ONE HAD SHOWED ME A PRINT OUT AND THE COMPANY I BOUT IT FROM NEVER DISCLOSED THE ISSUE. IF THE VEHICLE STALLS IN TRAFFIC IT COULD CAUSE AN ACCIDENT.
NHTSA complaint #10859920 — an unverified report by a vehicle owner.
at 198,000 milesTavares, FL
TIRES
DRIVING AT 55 MPH ON HWY 528 ABOUT 20 MILES EAST OF ORLANDO, THE TRUCK BEGAN TO SHAKE AND THEN WE SUFFERED A CATASTROPHIC TREAD SEPARATION OF OUR REAR DRIVER'S SIDE TIRE. WE WERE TRAILERING A CAMPER AT THE TIME. BY THE TIME I WAS ABLE TO BRING THE TRUCK TO A STOP ON THE SHOULDER OF THE HIGHWAY WE HAD SUSTAINED CLOSE TO $3000 WORTH OF DAMAGE TO THE REAR DRIVER'S SIDE FENDER AND WHEEL WELL. THIS WAS THE 2ND KUMHO LT 245/75 R16 OF THE SET THAT HAD A SEPARATION. THE FIRST ONE WE WERE ABLE TO SLOW DONE IN TIME TO PREVENT ANY DAMAGE TO THE VEHICLE. THE TIRES ONLY HAD 18000 MILES ON THEM AND INFLATION PRESSURES HAD BEEN CHECKED WITHIN 24 HOURS OF THE INCIDENT EACH TIME. AFTER CALLING KUMHO SEVERAL TIMES AFTER THE 1ST INCIDENT, THEY GAVE A 67 DOLLAR CREDIT ON THE TIRE. THE SECOND TIME THEY HAVE NOT RETURNED MY MULTIPLE PHONE CALLS. I HAVE NOW REPLACED AND KEPT THE REMAINING TIRES OF THE SET. I KEPT THEM HOPING THAT NHTSA WOULD TAKE THEM FOR TESTING. I FILED A COMPLAINT BY PHONE WITH NHTSA ON 11/3015 AND MEKO TOLD ME I WOULD BE RECEIVING FORMS IN THE MAIL TO COMPLETE THE COMPLAINT. IT HAS NOW BEEN OVER 2 MONTHS, AND I HAVE NOT RECEIVED ANYTHING FROM YOU! MY COMPLAINT # WAS 10807471. THESE ARE DANGEROUS FAULTY TIRES AND NEED TO BE RECALLED. SOMEONE NEEDS TO HOLD KUMHO RESPONSIBLE FRO THESE TIRES BEFORE MORE LIVES ARE LOST SECONDARY TO CATASTROPHIC SEPARATIONS.
NHTSA complaint #10824010 — an unverified report by a vehicle owner.
at 158,000 milesImperial, MO
SERVICE BRAKES
ALL MY BRAKE LINES ARE CORRODED/RUSTING OUT. ONE LINE ALREADY HAD TO BE REPLACED. VERY DANGEROUS. ALL MY FUEL INES ARE STARTING TO CORRODE AND APPEAR TO REQUIRE REPLACEMENT SOON.
NHTSA complaint #10823804 — an unverified report by a vehicle owner.
at 158,000 milesImperial, MO
FUEL/PROPULSION SYSTEM
ALL MY BRAKE LINES ARE CORRODED/RUSTING OUT. ONE LINE ALREADY HAD TO BE REPLACED. VERY DANGEROUS. ALL MY FUEL INES ARE STARTING TO CORRODE AND APPEAR TO REQUIRE REPLACEMENT SOON.
NHTSA complaint #10823804 — an unverified report by a vehicle owner.