128 of the
1,753 complaints filed about the Chevrolet Suburban 1500
are about the engine —
7% of everything owners reported.
The worst model year for it is 2007.
The contact owns a 2026 Chevrolet Suburban. The contact stated that while driving approximately 45 MPH, there was a popping sound coming from the vehicle and the vehicle stalled. The vehicle failed to restart. The vehicle was towed to a dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 1,700.
NHTSA complaint #11749935 — an unverified report by a vehicle owner.
3.0 Duramax engine failure at 5900 miles. Apparently is from the known thrust bearing issue. MIL, CEL, TCM illuminated. Failure occurred at 60 mph during rush hour traffic. Engine is being replaced under warranty. GM should issue recall for the affected lot of this engine.
NHTSA complaint #11738649 — an unverified report by a vehicle owner.
3.0 Duramax, thrust bearing engine failure. Less than 6000 miles on vehicle. Driving at 60 mph when vehicle went into major limp mode. Had TCM, Charging and coolant lights illuminate. GM is replacing engine under warranty. Indicated there was approximately a 2 week engine production window where this issue is being traced back to. GM should issue recall if they know the extent of condition and the cause(s).
NHTSA complaint #11738369 — an unverified report by a vehicle owner.
Today, 5/2/26 in Lewis Center, OH- My daughter and I were returning home from her Soccer game. The time was about 11am. We were in my brand new Chevy Z71 Suburban, with 4,100 miles. As we were slowing , approaching the roundabout, i noticed no power as i was preparing to enter the roundabout. I then see that the car powered off. It would not restart and i had no way to put into N. I had to call [XXX] to have the Sheriff direct traffic. I used Onstar, only to find out the tow was 216 min out. So the Sheriff called a tow and it was there in 30 min and towed to local Chevy dealership, thankfully before the closed for the weekend. I will find out Monday what the issue is- but it for sure seized up. So sad. I paid $100k for this truck. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11735312 — an unverified report by a vehicle owner.
While driving home from Costco with my entire family in the vehicle (4 children and my pregnant wife), I noticed the engine misfiring while traveling on Interstate 80 and mentioned to my wife that something felt off with the vehicle. After exiting I-80 onto Route 46 East at the Denville exit, the truck reached the first traffic light where the vehicle rumbled violently, shook, and completely shut off. The engine would not restart. Dashboard lights illuminated but the engine would not turn over, and the hazard lights would not activate. This created a dangerous roadside situation with traffic approaching from behind at approximately 50 MPH. I exited the vehicle and stood in the roadway directing traffic to prevent an accident while my wife attempted to restart the vehicle and called 911. Police arrived and a tow truck was dispatched. The tow truck driver attempted to jump start the vehicle, but it would not start. The vehicle had to be winched onto a flatbed tow truck.
NHTSA complaint #11724105 — an unverified report by a vehicle owner.
The contact owns a 2025 Chevrolet Suburban. The contact stated that while driving 25 MPH, a yellow triangle warning icon was displayed, and a message to "Please Add Oil" was displayed. The vehicle was taken to a dealer, where it was diagnosed with a broken part and oil was leaking oil onto the oil filter. The vehicle was repaired. The contact stated that approximately 1,000 miles later, the same triangle icon was displayed and with the same message displayed while driving. The vehicle was taken to the same dealer, where it was diagnosed that the oil needed to be changed. The vehicle was repaired. The contact stated that approximately 1,000 miles later; while driving at an undisclosed speed, the same triangle warning icon and the message were displayed with the check engine warning light illuminated. The vehicle was taken to another dealer, where it was diagnosed, and it was determined that the vehicle was consuming engine oil, and the oil needed to be changed. The vehicle was repaired, but the check engine warning light illuminated again, and the contact became aware that there was no oil in the oil pan. The manufacturer was notified of the failure. The failure mileage was 2,203.
NHTSA complaint #11723231 — an unverified report by a vehicle owner.
Driving on Highway at approx 70mph, lost propulsion and speedometer went to 0. Came back after approx. 5 seconds. After exiting highway and stopping, clear knocking/clanging noise from engine. GM states full engine replacement needed. This is a 2025 6.2 V8, thought these issues were fixed?
NHTSA complaint #11720174 — an unverified report by a vehicle owner.
On February 21st at approximately 9:30 AM, I was driving my brand-new 2026 Chevy Suburban High Country when I began hearing an unusual noise from the engine. There were zero dashboard warnings — no check engine light, no alerts, nothing indicating a failure. Out of caution, I immediately headed to the dealership so they could inspect it. I was driving slowly and carefully when, without any warning whatsoever, the engine suddenly and completely seized. The vehicle locked up abruptly. I barely had enough time to try to move toward the shoulder, and I was unable to fully clear the roadway — the rear half of the vehicle remained partially in traffic. It was an extremely dangerous situation. What is especially alarming is that I was not on the highway at the time. Had this occurred while traveling 80–85 mph on SH-130 in Texas — which is a normal speed limit there — the outcome could have been catastrophic. A complete engine seizure at highway speeds could have caused a major accident involving multiple vehicles. Even more concerning, my Chevrolet app (connected through OnStar) still shows no issues or alerts with the vehicle. The attached pictures are from the My Chevrolet app on Sunday, 02/22/2026, around 11:13 AM. This is a brand-new vehicle, and I was informed yesterday that the dealership has requested a full engine replacement. I have no timeline for the repair. For a vehicle of this price point, a sudden engine seizure with zero warnings is deeply concerning from both a safety and reliability standpoint.
NHTSA complaint #11720068 — an unverified report by a vehicle owner.
Car started making weird noises when being driven or accelerating on 2/14. Took it to the dealership on 2/16 first thing when they opened. After 5 hours, it was determined the engine had a catastrophic failure and needed to be replaced. This car has less than 6,000 miles and was purchased brand new.
NHTSA complaint #11718363 — an unverified report by a vehicle owner.
We have 8,625 miles on our 2025 Suburban. We were going down the highway when began to hear a unfamiliar noise. We pulled over into an error to inspect and didn't notice anything under the vehicle, which we thought might have cause the noise. We put into drive and went less than an 1/8 of a mile and our suburban lost acceleration and stopped. It would not start and couldn't not be moved, until roadside assistance took it to a Chevrolet dealership. The dealer stated the engine seized up and needs to be replaced. We were fortunate we were not going any more than 20 miles per hour and were not on a major highway.
NHTSA complaint #11715045 — an unverified report by a vehicle owner.
The engine self-destructed due to a thrust bearing failure as described in General Motors Technical Service Bulletin 25-NA-307 There were no warning lights prior to the engine failure. The vehicle has been inspected by Carl Black GMC in Roswell, GA and been found to fall under the Thrust Bearing Failure TSB According to the service technician, these engines have been failing in large numbers.
NHTSA complaint #11713080 — an unverified report by a vehicle owner.
Was driving on highway and engine started to make a noise, performance and power were impacted, the engine service light appeared. Exited highway on near offramp, when on offramp vehicle engine stopped working. Vehicle is a 2025 Chevrolet Suburban with 6.2L engine. Dealer has stated engine is seized. Seems exactly like the current 6.2L engine recall for 2021-2024 model years that results in engine failure. Vehicle is 7-8 months old, and only has roughly 12,000 miles.
NHTSA complaint #11712253 — an unverified report by a vehicle owner.
Engine failed going 70mph on highway at 2k miles. Display said acceleration no longer available and app said transmission code was needing to be checked however once taking to dealer I was told it was an oil sensor then told there was shredded metal in my engine and I needed a full engine replacement. My car was in the dealership for over 50 days. I was pregnant and with two small children in the car when engine failed at high speeds. After my car was returned to me the engine overheated and failed again. The dealer claimed GM sent them an engine with cut hoses. I was 9 months pregnant when this occurred also on the highway going 65mph. GM refused to buy back the vehicle 3 times.
NHTSA complaint #11710726 — an unverified report by a vehicle owner.
While driving we received a notification on our dash board stating “reduced acceleration drive with caution”. We had it towed to the dealership where they said we needed a full engine replacement. It took 22 days to get the vehicle back
NHTSA complaint #11710798 — an unverified report by a vehicle owner.
7/13/25: Car repeatedly jerking/shuddering/rough ride. A flashing check engine light came on for 10 or 15 minutes. After stopping car and restarting it, the check engine light went off. 9/15/25: Car jerking and another flashing check engine light. Took to dealership. They drove it and said no codes stored. Told it was probably the transmission "breaking in." Took home. Car continued to jerk/stumble. 8/28/25 to 9/15/25: Car jerking and flashing check engine light back on. Took to Autozone. A Random/Multiple Cylinder Misfire Code was detected (P0300). Took to dealership and confirmed P0300 Code stored. GM TAC engineers involved. Told they were unable to figure out why car was having multiple misfires. Returned car to me because no active code/light. 9/29/25: Car jerking and flashing check engine light back on. Got a warning of "reduced acceleration and drive with care." Car lost power. I have video of this and contacted On Star with report generated and P0300 code. On 10/1/25 on way to dealer, car making audible ticking noise. I have video of this. Took to dealer, the ECM was replaced and oil changed because it was "very dark" (in vehicle with 4,600 miles). Car continued to jerk/stumble. Told by dealer that problem would have to get worse before diagnosis could be made. 10/31/25: Jerking and another flashing check engine light with "reduced acceleration drive with care warning." Turned car off and engine light off. On Star report P0300. Took to dealer. The dealership was given the videos of check engine lights/reduced acceleration warnings and ticking noise video. All show problem happening around 1,200 rpms. Told by dealer on 11/11/25 that GM rep said they will not pay dealer for any work because no active engine light/codes. Told to pick up car. Asked dealer today for reason in writing, but no response. Very concerned about vehicle safety when repeatedly going into limp mode and flashing check engine lights with GM offering no solution.
NHTSA complaint #11698805 — an unverified report by a vehicle owner.
Purchased the vehicle on April 7, 2025. On 7/15/25, the car had 6948 mi. and started running rough, had a loss of power, an odor from the engine, and then on the display: check engine, blinking green vehicle light, and a message stating that the car was lowering for stability control. Took the vehicle to the closest Chevrolet service. The service dept. determined that code found P0307 and P0300, cylinder seven had the most misfires above 500. After completing oil service, the vehicle began to click on the passenger side; however, it was not misfiring. They inspected and found potential lifter issue. Found ticking coming from cylinder 7 and verified misfires. Found 2 pushrods damaged. Heard noise coming from cylinder 4, removed valve cover, removed rocker arms, and found 1 pushrod damaged. They removed and replaced all lifters and 3 pushrods. They stated there was no more noise //after this repair. These repairs were completed on July 25, 2025. On 8/15/25 took back to service because it continued to run rough and made excessive noise and whistling when starting the vehicle. The dealer inspected and heard the noise, inspected the vehicle exhaust leak, checked exhaust manifolds, pipe connections, and determined there were no issues found. On 9/26/25 at 11,821 miles the car was making excessive noise, running rough, and was losing power. Drove home, and the vehicle was running rougher and losing power. No check engine lights or warnings were present. Drove home, and the vehicle was running rougher and losing power until it turned off. Towed in. Maintenance techs determined catastrophic engine failure, all bearings and engine rods seized. After this repair hen the catalytic converter failed. This car has been out of service due to engine failures for 43 days out of the 204 of ownership.
NHTSA complaint #11696802 — an unverified report by a vehicle owner.
Cause unknown, however, I have discovered that the engine in my Suburban, the Engine code LZO 3.0L Duramax, has damaged itself internally. I have been told that there is a large batch of engines that have this same problem, and the dealership I sent my car to has several cars in the same position. This problem is causing the engine to lock up or completely quit. This could be serious depending on when this failure happens. Currently, they are telling me that I am months away from getting a new engine due to a back order. Vehicle still in shop, so I do not have records yet, but I will be happy to give them once I have them.
NHTSA complaint #11690942 — an unverified report by a vehicle owner.