Chrysler Pacifica Plug-In Hybrid electrical problems
236 of the
1,077 complaints filed about the Chrysler Pacifica Plug-In Hybrid
are about the electrical system —
22% of everything owners reported.
The worst model year for it is 2018.
The contact rented a 2025 Chrysler Pacifica Hybrid from Budget Car Rental (2176 Main St, Dunedin, FL 34698). The contact stated that while driving approximately 55 MPH, the contact believed that the vehicle was being tracked via Bluetooth throughout a trip from Florida to Kansas City to New York and back to Florida, as the vehicle was surrounded by other vehicles with suggestive and personalized license plates. The contact reported the issue to the Florida Department of Law Enforcement. The manufacturer was not notified of the issue.
NHTSA complaint #11757923 — an unverified report by a vehicle owner.
The contact owns a 2018 Chrysler Pacifica. The contact stated when attempting to charge the battery, the charger failed to work as intended . A dealer was contacted. The vehicle was towed to the dealer where it was diagnosed that the battery needed to be replaced and and they sent a request to the manfactuer in regards to replacing another battery. The vehicle was repaired as the battery was replaced three times. The manufacturer was notified of the failure and they could not give her an update and they informed her this is up to the dealer. The approximate mileage was 101,000.
NHTSA complaint #11739486 — an unverified report by a vehicle owner.
The contact owns a 2021 Chrysler Pacifica Plug-In Hybrid. The contact stated that the vehicle failed to start. The vehicle was towed to the dealer, where it was diagnosed with a power inverter module (PIM) failure. The dealer replaced the power inverter module (PIM); however, the failure persisted. The dealer determined that the hybrid battery needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 41,000.
NHTSA complaint #11702195 — an unverified report by a vehicle owner.
The contact owns a 2020 Chrysler Pacifica Plug-in-Hybrid. The contact stated that while driving approximately 55 MPH the vehicle lost motive power. The contact stated that the "Turtle Symbol” was displayed with the message "Vehicle Will Shut off Soon - Pull Over" displayed. The contact had taken the vehicle to a local dealer; however, the failure was not duplicated. The vehicle was not repaired. The contact stated that the failure reoccurred, and the vehicle was taken back to the same dealer. The dealer was unable to duplicate the failure again. The vehicle was not repaired. The contact stated that the failure occurred while driving at various speeds and was a recurring failure. The manufacturer was contact and referred the contact to a dealer for a diagnostic test. The failure mileage was 57,016.
NHTSA complaint #11662828 — an unverified report by a vehicle owner.
Vehicle lost power with no prior warning at highway speeds. Vehicle then displayed "Stop Safely Vehicle will shut off soon" message. In order to attempt a reset, driver must turn off, leave vehicle with FOB and secure vehicle. Then return to vehcile and start up in an attempt to reboot. Check engine light remained, but functioned nromally for a day. Vehicle did the same on another freeway at 70 mph, and continued with the same events above several times, some producing immediate repeat message, or other times getting a half mile down the road. Depending on availability of a shoulder or center divide, this is extremly dangerous to fail unexpectedly on the highway. In California there are freeways with over 6 lanes, try getting across 6 lanes of traffic with no power, in limp mode. Vehicle is now at dealer awaiting diagnosis and repair. I continued with the vehicle when the tow truck service via Chrysler corporate stated 60 -90 min response. My saftey was more of a concern if I had to wait that long.
NHTSA complaint #11650515 — an unverified report by a vehicle owner.
I was traveling at south bound on TOLL 130 going 80MPH (which is the speed limit on that road) when my Pacifica immediately slowed down and my accelerator gave out. In addition to my dash flashing that the cruise control was no longer available, but the van also said "Service Charging System" and "Shift to P to Start", the engine light and batter light both came on. I am sure that I almost died as I was in the middle lane and cars were whipping around me since I had slowed down so much, there was an 18 wheeler behind me and one of my righthand side, which is the shoulder I was trying to get to. I was finally able to coast to the shoulder and came to a stop, put the car in park and turned it off. I immediately started researching what the problem could be and I was alarmed to find out that this is an issue that others have had and that Chrysler has failed to issue a recall...I was able to start the car once more and get on to a little back road, after pushing through a barricade off the toll just for safety's sake, and my van broke down again, this time on a little 2 lane road, which thankfully had a little bit of a gravel shoulder. This time, my van took quite a bit longer to get started, but I was not safe where I was. I started it once more and was able to get to a Wal-Mart parking lot where my brother-in-law picked me up so that I could have a chance of making it to see my grandmother who was on her deathbed, I missed my window of opportunity to make it to see her, she died that afternoon. I had to pay an additional tow fee to get the vehicle moved from the parking lot to a Chrysler dealership since it was so far from where I usually go.
NHTSA complaint #11648682 — an unverified report by a vehicle owner.
The contact owns a 2022 Chrysler Pacifica Hybrid. The contact stated that while driving at various speeds in Hybrid Mode, the vehicle occasionally failed to accelerate as intended while depressing the accelerator pedal. In addition, the contact stated that the vehicle failed to maintain speed, and gradually decelerated while the accelerator pedal was being depressed. No warning light was illuminated. The contact stated that the vehicle was previously repaired several times by the local dealer. The vehicle was taken to a local dealer and remained with the dealer for further diagnostic tests and repair; however, the cause of the failure remained unknown. The manufacturer was made aware of the failure. The failure mileage was approximately 52,000.
NHTSA complaint #11645107 — an unverified report by a vehicle owner.
I have a 2018 Chrysler Pacifica Hybrid. I purchased it brand new in 2018. This van has had sooo many problems, it has been in and out of the shop, countless recalls. Last year it was in the shop for almost the entire year, I think I had possession of the van for less than 3 months of the year. I just brought my van in for a recall related to the hybrid battery and it was returned to me in December, within 2 weeks there were check engine lights on and when I googled the code that was showing I found a ton of blogs about how people had the same recall done and within a short period of time this code came up and it meant the hybrid battery needs to be replaced. I reached out to the dealer and brought it in to get looked at. After a couple weeks I was told that the replacement of the battery would not be covered under the recall since part of the recall solution is testing the battery, and it tested good. I literally had only had the van back for 2 weeks. And I have countless records of engine codes showing up for years. I currently have 8 active engine codes showing. I know there is an open investigation concerning the recall I just had the remedy done for and I am 100% sure that this defect is related to that recall.
NHTSA complaint #11642444 — an unverified report by a vehicle owner.
Vehicle had been operating less than 5 minutes. When I was on an on-ramp for a left entrance to a highway, several warning lights illuminated in addition to messaging on my dash. The car entered "turtle mode" which extremely limited the speed of the vehicle. I immediately pressed the button for my hazard lights to come on, but they did not operate correctly. They flashed so rarely that they did not warn vehicles behind me that I was having an incident. During this incident, the vehicle speedometer was inoperable, displaying "-- --" instead of a speed. I was lucky to be able to pull to the shoulder, but with the narrow shoulder and my child in the car I felt safer limping off the highway using primarily the shoulder. I was terrified and had some cars nearly hit me/honk as I was going approximately 10 miles per hour on a 55mph roadway. I have seen similar reports on online forums for chrysler pacifica minivans, so I am not the only one to encounter the issue. The vehicle has also at times refused to go into gear while in Park, which is a related problem but I don't deem it a safety issue. The problem is intermittent and the service center is able to see 'codes' when they examine the vehicle but as the issue is intermittent they have returned the car to me twice with no repairs performed since it didn't occur while they had it. The warning lights and turtle mode occurred simultaneously or within a few seconds. I have a video during the incident. I can see the fuel gauge needle rising and falling wildly, turtle mode, a picture of a wrench, check engine, parking brake, brake, collision avoidance, ABS, and others. Each time the vehicle has gone in for service they have seen and cleared codes but they did not come back immediately, so no repairs were attempted. It is in the shop again currently and I have escalated to the manufacturer to hopefully get greater assistance.
NHTSA complaint #11642219 — an unverified report by a vehicle owner.
Vehicle states "Stop Safely Vehicle Will Shut Off Soon" with a red turtle logo. I have restarted the vehicle, and the warning persists. I am bringing in the car to the dealer next.
NHTSA complaint #11639047 — an unverified report by a vehicle owner.
Hybrid system will not run on battery. Hybrid system shows 100% battery charge on dash. Hybrid mode screen shows Engine at 12KW, Battery use at 0KW, and climate at 7KW. S
NHTSA complaint #11638725 — an unverified report by a vehicle owner.
A Concerning Safety Issue with the Chrysler Pacifica Hybrid Last week, I experienced a serious safety incident with my newly purchased Chrysler Pacifica Hybrid that I feel compelled to share. Just a mile from my home, my vehicle's dashboard displayed an alarming message: "Stop Safely Vehicle Will Shut Off Soon." Within moments, the van lost power and the steering wheel locked - fortunately while I was already stopping at a stop sign. The vehicle became completely unresponsive. After researching online, I found this was a known issue requiring a specific reset procedure: exiting the vehicle, multiple attempts with the start/stop button, and then restarting. While this eventually worked, both the Check Engine and battery warning lights remained illuminated during my careful drive home. My attempts to get assistance through Chrysler Assist were unsuccessful, with their only recommendation being to visit a dealer. At the dealership, they identified three diagnostic codes: B1945-13 B10EB-00 P0A78-00 While they performed a recall-related firmware update, the underlying concern remains: What if this failure had occurred on a freeway, in adverse weather conditions, or with my family aboard? More concerning is the discovery that this isn't an isolated incident. Similar reports are appearing across owner forums and social media, suggesting this is a widespread issue affecting Chrysler's hybrid vehicles. Despite apparent awareness of the problem, Chrysler has yet to implement a comprehensive fix. As a new hybrid vehicle owner, this experience raises serious questions about vehicle safety and manufacturer responsibility. While the automotive industry pushes toward electrification, ensuring basic safety and reliability should remain paramount.
NHTSA complaint #11634443 — an unverified report by a vehicle owner.
The contact's mother owns a 2020 Chrysler Pacifica Hybrid. The contact stated while driving approximately 65 MPH, the vehicle started losing motive power. The contact stated that his mother observed the message "Stop Safely - Vehicle Will Shut Off Soon" and immediately after the warning light was illuminated the vehicle stalled. The contact stated that the vehicle was towed to the residence and was later restarted, and the vehicle was taken to a dealer. The contact stated that the dealer had diagnosed the vehicle but could not duplicate the failure. The dealer recommended that the vehicle be returned to the dealer if the failure was returned. The failure reoccurred and the vehicle was taken back to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Action Number: RQ24004 (Electrical System). The failure mileage was approximately 50,000.
NHTSA complaint #11633190 — an unverified report by a vehicle owner.
As I was driving on the highway, the warning "Stop Safely Vehicle Will Shut Off Soon" with a red turtle icon appeared. The warning indicator light also appeared. The car began to decelerate on its own as I tried to merge across several lanes of highway traffic to get to the shoulder and stop. This first happened on Thursday December 12 (also in a highway scenario). The vehicle was inspected by my dealer from December 16-18. During that time the dealer updated software and replaced drivers side PHEV engine mount. The dealer cites "Bulletin 21-042-24" as guidance for their troubleshooting. The dealer says if the problem returns, the vehicle will "need transmission according to bulletin 21-042-24." I drove the vehicle fine on December 19-20 but the problem returned on Saturday, December 21. So the problem has occurred twice in 9 days.
NHTSA complaint #11631913 — an unverified report by a vehicle owner.
On [XXX], my vehicle produced a large red wrench and a turtle warning on a busy highway and I was forced to pull to the side with my [XXX] son in the car, as the vehicle lost motive power. It was towed to the dealer and after several days, they told me the issue was due to normal wear and tear in the transmission. I had to escalate to a service manager to even get a diagnosis after 5 days in the shop. I believe my transmission issue is due to a failure of the fix implemented in the 03A/NHTSA 23V-010 recall. It has been documented that the software update did not fix the issue. My vehicle experienced the exact series of failures described in the recall. Chrysler is refusing to fix my vehicle, even though they had extended the warranty on my Pacifica to unlimited miles/unlimited years because of all of the transmission issues the model has experienced. I would appreciate it if someone could look into this and Chrysler's unwillingness to stand behind their products and provide fixes for their recalls that work. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11629611 — an unverified report by a vehicle owner.
While driving the car down a busy 4 lane road at 55mph on [XXX] around [XXX] in Irvine, CA, the car began to shake as the steering locked up and alerts came up on the dash that the power steering had failed. After turning the car off and on it did not fix it. Leaving it off for 15 mins seemed to make the error go away. We had it towed to Tustin Tuttle Chrysler dealership for service. The dealership found the fault code in the log, it was a power steering control failure. They could not replicate the circumstance and insist on releasing the car as safe to drive; putting my family and the public at great risk. The dealership refuse to even run diagnostics on the faulty identified part. They said if they cannot recreate the problem they won’t fix it, even though they see the error code on their scanner. They shouldn’t be telling me the car is safe when it is clearly not. They only drove it 30 miles and did not check wiring or even pop the hood. They have done no work to deem it safe and this is fraud. Rochelle, the service manager, has told us over the phone that she will not work on the car, because she believes she will not be reimbursed for the work. She has said she has had the car for too long and wants it picked up. Her service advisor Erik, has read us the codes found over the phone and also told us that no one has worked on it and only has test driven it. Our greatest concern is the dealership is not servicing or repairing vehicles and putting very dangerous cars on the road. This is a public safety issue for all of Southern California. Additionally, this car was purchased with a full manufacturer’s bumper-to-bumper warranty, of which it is still in its covered in the next 3 years or 40,000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11628082 — an unverified report by a vehicle owner.
Driving on highway in hybrid mode, van lost engine power and coasts to a stop in traffic. Dashboard light says Stop Safely Vehicle Will Shut Off Soon. The engine is effectively off with no motive power available. This happened 4 times in a row over the course of 1.5 hrs on [XXX] from Virginia to North Carolina! We were nearly killed by traffic trying to clear the roadway with no power from the engine whatsoever. Completely unacceptable! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11625907 — an unverified report by a vehicle owner.
I have a Chrysler Pacifica Hybrid which has had multiple recalls for the battery causing fires with no resolution. The NHTSA website said to submit a complaint "If the manufacturer has failed or is unable to remedy this safety recall for your vehicle in a timely manner". The most recent recall was in July without resolution but the battery has been recalled multiple times over the last few years without actual fix being done.
NHTSA complaint #11624854 — an unverified report by a vehicle owner.
Chrysler issued recall 72B back in July but has failed to provide a repair solution to the issue of a high voltage battery fire. They have advised to park the vehicle away from structures and to not charge. It's disappointing not to have a resolution or fix for this issue, especially going into the colder months and not being able to use the vehicle as intended.
NHTSA complaint #11624172 — an unverified report by a vehicle owner.