2019 Ford Expedition other reported problems

UNKNOWN OR OTHER

I have 3 small children so I am concerned about my car. The gear shift goes out of drive while driving. If you push the gas and then let up and push the gas again it won’t go and if you keep pushing the gas it will start fishtailing all over the road. You have to take your foot off the gas for a period of time until it goes back in gear which causes you to completely slow down and can cause a crash. When trying to give excessive gas it will disengage and won’t go. It will only engage 1 tire and cause it to fishtail. It has almost caused an accident multiple times because it slips out of gear and it currently has a recall for a similar issue. You can’t pull over or move over wile it disengages because you can’t go anywhere if you push the gas it just accelerates like it was in park. This is not an if something happens it’s a when something happens. Nobody else can drive my vehicle because they won’t know how to stop it from happening and they may get seriously hurt. It has happened on multiple occasions

NHTSA complaint #11751428 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The manufacturer Ford issued three urgent safety recalls in May/June 2026, including recall #26S48 for transmission parking system failure and recall #26S34 for front seatbelt failures. The official status from Ford is 'Remedy Not Yet Available' and I was notified that parts might not be available until late 2026 or 2027. This vehicle is my essential tool for rideshare work (Uber/Lyft). Due to federal transportation safety regulations and Uber policies, I am legally prohibited from transporting passengers with active, unremedied safety recalls. This has completely destroyed my family's financial livelihood. Furthermore, driving this vehicle puts my life, my passengers, and my 4 children at an imminent risk of death or catastrophic injury due to potential transmission failure while driving or seatbelt failure during an accident. The manufacturer and the dealer (Findlay Chevrolet) are failing to provide a remedy within a reasonable timeframe under federal warranty laws, leaving me with a $38,000 active debt for an un-driveable, dangerous asset. I am requesting an official investigation to force a manufacturer buyback.

NHTSA complaint #11747426 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Backup camera is provides a distorted image more than 80% of the time. This is a known issue for 2018 Ford expeditions but it has not been reported as a problem for 2019’s. I am telling you that it is a problem that I am experiencing it. It is the same as the prior year issue. It affects all Ford SUVs in that era. Fixing it is a temporary solution - it is a known issue that they are frequently defective.

NHTSA complaint #11735225 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Less than a week from purchase , I was on the freeway doing 70 MPH and the sunroof exploded on us for absolutely no reason. I had just dropped off my [XXX] son , Had he been in the vehicle with his [XXX] brother and this happened I would be pursuing a lawsuit ! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11720289 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I got an oil change 12/20/2025 and was told I have an oil leak coming from under the timing cover. An estimated expense of $4000 to repair. My vehicle is newer, 2019 and only has 77,000 miles on it. This issue shouldn’t be happening to a newer car.

NHTSA complaint #11713821 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I don't know if there's issues with rearing was driving when we felt like another car had puh up forward an happen twice just several minutes apart felt like brakes were stuck while driving or like rear end was shifting weird I can still hear like a tapping somewhere in motor sent it to be fix where we bought it before warranty was expired but they really just screwed up my ac an couldn't fix because warranty expired had to fix it ourself out of pocket money all were asking is for dealers to send there recalls all to have it fixed I don't want to pay for a vehicle we can't trust in town or out of town plus we were at Dr appt in Odessa tx 11/3/2025 an we did notice something like with brakes like licking a little

NHTSA complaint #11697802 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The rear-view camera does not work 80+% of the time. It usually fails to connect at all and I do not have visibility or access to the rearview camera when backing up (in reverse). This has been ongoing for well over a year now and has been progressively getting worse. Before it would just happen once every 20-30 times or so but now it happens every day I use the vehicle about 80-90% of the time. This has resulted in at least 3 narrow-miss accidents so far as I can't see what directly behind me. On more limited occasions, if the rear camera does show up and connect, it will display the rear image upside down, sometimes it will freeze on the screen and won't go away even when not engaged in Reverse thus not allowing access to the screen. It continues to happen every day I use the car and most days the rear camera will not ever connect.

NHTSA complaint #11688358 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I purchased my 2019 Ford Expedition Max Limited on [XXX]. When we purchase the vehicle we signed a notice that we would have the recalls completed within a reasonable time. I took my vehicle for the recall to Feyer Ford in Edenton, North Carolina on May 30th. Prior to the recall I was having no issues at all with the vehicle. Once I pick the vehicle up on [XXX] and started my traveling home. Within 10 minutes of leaving, the vehicle made a loud screeching noise. The wrench light came on, and the vehicle seemed to not accelerate forward. I was able to pull off the road and turn the vehicle off. I called Feyer Ford to make them aware of the problem and they told me that it was because the PCM had been reprogrammed and would need to relearn how I drive. I had the same issue happen again further down the road, this is a very serious safety hazard that my vehicle suddenly stopped moving forward in traffic. I called Feyer Ford once again and was told that I had to drive the vehicle 1,000 miles before the PCM would relearn my driving patterns. I took the vehicle in on June 4th to have it checked out and was told that I would need a valve body replacement and torque converter replacement. That essentially my transmission was bad. Since that date the vehicle has gone into reverse numerous times when I put it in Drive, it will also get stuck in 4th 7th or 10th gear when you are trying to drive it in a parking lot or going slow on the road. When it gets stuck in those gears the vehicle will not go forward it will only allow you to go backwards. My car has been at Feyer Ford since July 29 trying to have the warranty cover the fix, but it was denied for warranty coverage because they stated the vehicle was broken by the recall. We were told we could pick up our un-fixed vehicle on Aug 27. We got the key and proceeded to leave only to find the car not put back together from a different seat belt recall. It is still at Feyer Ford today, September 6th 2025. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),

NHTSA complaint #11685454 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

At 60k miles the car started making noises when I start it. I took it in and they said it was the timing chain. Also my engine light keeps coming on and it says Emissions Error. I have purchased several Fords and I don’t plan on major repairs every 5 years. Especially the day it goes out of warranty. Apparently the timing chain is a big problem according to the repair company at around 5 years on these expeditions

NHTSA complaint #11675288 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

During a recent visit on 6/6/2025 to the Ford dealership in Torrance for an oil change, I've informed the service staff of my concern for the diminishing coolant levels. Upon completion of the oil change, they've informed they did not find any issues with the coolant and did not find any signs of leaking. Today is June 30, 2025 and I've come to a local mechanic for a different concern of vehicle shaking and they found that the coolant was indeed leaking.

NHTSA complaint #11670212 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Cam Phasers were recalled a couple years ago. I had the recall done and they were replaced. They are now worse than ever. My car horribly rattles every single time that I start it up and also now rattles when it idles. I should not have to pay for this out of my pocket. Clearly the part used in the recall did not do it's job.

NHTSA complaint #11662606 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

We had been driving for 3 hours and was in an extremely busy area in Houston, Tx. While entering another highway in extremely congested area the transmission shifted out of gear into Neutral engine revved and shut down. After about 3 -5 seconds it kicked hard into gear and continues on our way. This has happened several times in the past and was taken in previously for same problem. By being in congested traffic and with cars speeding around and honking horns it was a tense moment. Reported to dealer and transmission was dismantled and a part replaced in the transmission. Still don't feel comfortable with the transmission. Prior to this incident there were no immediate warning signs.

NHTSA complaint #11658649 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Transmission had to be rebuilt due to known bushings problem with 10 speed expedition transmission. I had to pay over 5k

NHTSA complaint #11644195 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The rear door latch failed. It was 8 degrees, and the door latch would not latch shut after opening the rear door.

NHTSA complaint #11643322 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

1. My Transmission failed and the car came to a complete stop in the middle of the highway, ford could not assist in replacing the Transmission and I have heard so many complaints about the 10 speed transmissions failing just after reaching 100,000 mileage. Mine failed under 108,000 mileage and this has been going on for years and consumers end up spending thousands of dollars on a $70,000 vehicle. This issue needs to be addressed. I paid over $8,000 to replace the transmission. 2. Ford Expeditions and F150 have a trim piece on the center console that's covered by an aluminum wrap which pops off and it's very sharp, so many ford owners have been cut by that piece and ford only replaces the whole center console if the vehicle is under warranty as there's no other solution to replace only the trim but you get to replace the whole center console which's Expensive. 3. For 3.5L engines have continued to have cam phaser failure for the past few years but Ford doesn't seem to address this issue which cost customers millions of dollars every year, we the customers do know that Ford benefits from selling parts and Ford 100% knows how expensive it's to replace a cam phaser which cam cost anywhere from $4,000 in parts and labor. We hope that NHTSA can step up and have ford address these issues.

NHTSA complaint #11637088 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

When I am stopped at a light or in traffic and the start/stop technology triggers the car to shut off while waiting, when I take my foot off the brake the engine does not turn back up. My other electrics are still on. A messaged pops up and says auto/startstop shift to P, then restart engine. This has happened multiple times. I have taken it to the dealer 3 times now. They say no error codes come up. They can’t replicate it. The last time the car rolled back and almost hit another car. It causes my car to obstruct traffic. And people start honking.

NHTSA complaint #11631150 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The driver and passanger rear doors have issues with the doul latches. They do not always security shut and the doors swing open while driving. When the temperatures drop, the latches do not work, therefore, the doors do not securely shut. I tool the vehicle to a Ford repair dealership and they informed me that this is an issue with millions of ford's. They suggested I contact you because there isn't a current recall on this vehicle. This issue has happened multiple times now.

NHTSA complaint #11622828 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

My Ford Expedition Max started to make a rattling noise after I start the vehicle, if the car was running for a while I could turn it off and on again and wouldnt hear the noise, but if the engine was cold it would make a rattling noise when started. Then if I do not let the SUV warm up long enough and start driving it would have a point where it would do a random hard slow down before it would kick into gear and then it would feel like it was running fine. This started a few weeks ago the I was driving on the highway and while i was doing about 55MPH the suv made a loud noise that made the vehicle change speed dramatically it cause me to be whiplashed forward before the engine seemed to catch back up to its orevious actions, it did not actually cause an accident at that point (but it very well could have if the road was busy as it was a dramatic chnage in speed as well as the noise it made). I pulled over to inspect but there was nothing in the road and nothing that was being done that seemed to cause the traumatic issue. The next day when I brought the car to the mechanic and explained the issue he was able to diagnose an issue with the timing chain. Upopn some resaerch there many complaints and issues with my that make/models particular engine and parts that have had issues but the dealer would not assist saying there is no formal recall and at 69K miles I am over the warrenty. My car doesnot have any codes or warning lights and has all regularly scheduled maintenance and repairs done regularly but the car is clearly not driving correctly, This issue is causing the SUV to dramatically change speed while driving which is likely to cause an accident and severe injury.

NHTSA complaint #11612311 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Approximately One week ago, I was on the freeway when at 70 miles an hour warning light came in with brake system. Failure came up, and I lost all power to the vehicle and shut down and I tried restarting it on neutral. I was in traffic, which made it more difficult to go onto the side of the road went to I was in the center divider. There was no power of any kind to left side of vehicle windows, door locks, etc. the vehicle was towed to the dealership in San Diego where they told me they couldn’t look at the vehicle For over a month, but their service tech and the repair person from the dealership was unable to attach a computer to the vehicle scanner was not showing anything wrong. I then had the vehicle towed again to my home where the dealer had told me it was a battery however I purchased a new battery from the dealer , and it made no difference approximately three days later I started the vehicle to roll up the window that was down and everything seem to work however, I put it in and proceeded forward. The same situation occurred once again with the statement system system failure, but this time parking assist downhill Was also showing on the dashboard warning indicator. I have replaced the motor transmission and turbo on this back in January 2024. Vehicle is still under warranty however this seems to be a problem if the vehicle is cutting out with very minimal warning and shutting down on the freeway, this can cause an accident with myself and anybody near me , because the vehicle and the braking system shut down. I don’t know if this is a recall, but it’s something that should be looked at in a timely matter. Please contact me with further details. God bless.

NHTSA complaint #11609282 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Since we bought our car, it has had a rattle upon startup. This was originally a recall, which we got repaired, but this repair did not make the rattle go away. I then had a transmission problem and had to have the transmission overhauled due to it having violent, jerky, unpredictable shifting between gears. When I mentioned the rattle again while they were fixing the transmission, they said that it’s a known problem with Ford cam phasers around our model year. They informed me that the fix offered in the recall was an electronic fix, but the actual parts need to be replaced and the recall didn’t cover that. The parts replacement was almost $4000, and from my research, not replacing these parts can cause the engine to stop functioning properly over time. In the past two weeks, I have been getting safety notices from my car that there are timing issues that need to be serviced. Contacting Ford did not help as there is no active recall for this problem. From my research, there is an active lawsuit open against Ford for this cam phaser problem with my year model car. Overall, cam phasers play a critical role in enhancing the efficiency, performance, and reliability of 10-speed engines by enabling precise control over the engine’s valve timing. However, after just replacing my transmission we cannot afford to pay another $4000 for this error. Ford said they cannot help unless there is a recall on the vehicle.

NHTSA complaint #11604266 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I am writing to urgently request the initiation of a safety investigation concerning a serious and potentially widespread defect in Ford vehicles, specifically related to the center console’s metal chrome trim on limited models. I own a Ford Expedition, purchased in October 2019, and have encountered a severe issue where the chrome plating on the center console has begun peeling away, forming sharp, dangerous shards that have already caused significant injury to myself and my children. Despite numerous attempts to resolve this issue through Ford’s customer service since first discovering the defect in 2020, the response has been dismissive, labeling the condition as "normal wear and tear." This is despite the fact that the sharp edges of the peeling chrome required medical attention on multiple occasions. The severity of this defect goes far beyond cosmetic degradation and enters the realm of serious safety hazard. Furthermore, this issue does not appear to be isolated. An examination of online consumer forums and resale platforms such as eBay reveals similar complaints from other Ford owners who note identical peeling issues in the same model and in analogous locations on the console. Historical precedence shows that similar defects in past models, like the Ford Explorer, have led to recalls. It is alarming that Ford has not only failed to recognize the defect as a legitimate safety concern but has also continued to sidestep responsibility even after the original factory warranty expired. This lack of accountability for a defect that directly impacts the physical safety of passengers and drivers is unacceptable. Given the potential risk to consumers and the apparent recurrence of this issue across multiple vehicles, I implore the NHTSA to initiate a thorough investigation into this matter. It is imperative that a recall be considered to prevent further injuries and ensure that Ford addresses this serious safety flaw promptly and effectively.

NHTSA complaint #11593690 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

We bought a 2019 Ford expedition max xlt. On a trip we kept having problems with it jumping out of gear and it felt like the transmission was going to fall out. We looked it up and found several complaints on this same problem with the 2019 models although I can't find any recalls that would have fixed the problem.

NHTSA complaint #11592135 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

There is an open recall with no remedy since February 2, 2024. The remedy should already be available, so I'm filing a complaint of remedy not available in timely manner.

NHTSA complaint #11583294 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The center console cup holder collapsed. It was a driving distraction and could have resulted in injury. We now have a have an open hole in the center of our car.

NHTSA complaint #11580323 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Drain Plug in Moon Roof has been repaired 15 times over 4 years for blockage. The blockage is causing the Floorboard of the passenger side vehicle to become soaked, causing a musty, moldy, mildew smell in the car. I don't park under any trees and car is garaged frequently.

NHTSA complaint #11571960 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

2019 Ford Expedition engine rattles on cold start, while driving at highway speeds, loss of engine power, and when Auto start/stop engages, it will, at times, "catch" and turn vehicle off due to lack of engine power- it will then flash a warning message stating driver must shift to park, then restart vehicle. Cam Phaser/Cam shaft wears prematurely, thus, not allowing it to open and close valves related to the crankshaft and pistons, which in turn poses a risk to both the vehicle operator as well as drivers on the road. Safety is a put at risk due to the cam phaser adjusting the camshaft so the car responds to low RPM- This causes reduced engine power and potential stalling- which is a major concern when driving any vehicle, especially on freeways with small children in the car. This problem has been confirmed by a dealing, specifically a dealer services manager, who stated "its a very known issue and somehow hasn't been recalled yet". The vehicle has been inspected a ford service manager The first known symptom is the rattle sound upon cold start, then other symptoms arose such as the lack of engine power, stalling, and auto start/stop not working correctly. The only "warning" is that of the auto start/stop malfunction that offers upon stalling (at a stop speed), this does not include stalling when at highway speeds.

NHTSA complaint #11546919 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

My Expedition Windshield fluid leaks into my front passenger floor rug. Safety issue can’t clean windshield without fluid in the tank as it is leaking into front passenger floor rug.

NHTSA complaint #11545740 — an unverified report by a vehicle owner.