74 of the
1,580 complaints filed about the Ford Fusion Hybrid
are about the other systems —
5% of everything owners reported.
The worst model year for it is 2010.
The leather-covered dashboard panel, in the approximately 4-6 inch section between the base of the windshield and the first seam across the dash, has shrunk, rippled, and pulled away from the underlying substrate. This area also houses the driver-assist camera housing and the defrost vent. The vehicle was purchased new and has been Ford-maintained, professionally detailed, and garage-kept throughout ownership; the leather has been regularly cleaned and conditioned as part of routine dealership detailing, ruling out lack of care as a cause. The vehicle's build date is January 2018, which falls within the range covered by Ford Technical Service Bulletin 18-2283 ("Instrument Panel Sagging at the Windshield Glass"), issued for vehicles built between October 13, 2014 and February 2, 2018, describing the instrument panel sagging and separating near the windshield. I am filing this complaint because this appears to be a documented, recurring defect pattern affecting this vehicle's dash generation, rather than isolated cosmetic wear. Ford Customer Relations has twice declined goodwill assistance, citing the vehicle's age (just over 8 years) as the sole basis, without physical inspection or evaluation of the underlying condition. An independent repair estimate to replace the dash panel and remove/reinstall the windshield for access was quoted at approximately $3,100.
NHTSA complaint #11754944 — an unverified report by a vehicle owner.
The factory-installed rearview backup camera on my 2013 Ford Fusion fails intermittently. When shifting into reverse, the display screen frequently goes black, shows a distorted or flickering image with multicolored lines, or displays an error message stating the camera is unavailable. The failure is unpredictable but occurs more often in hot weather or after rain, suggesting a hardware defect. The component that has failed is the rearview camera system, likely the camera module itself, which is available for inspection. This malfunction creates a significant safety hazard by eliminating rear visibility, substantially increasing the risk of a back-over collision with pedestrians, children, or other objects. The failure to display a rearview image is a non-compliance with Federal Motor Vehicle Safety Standard No. 111. The problem has not been confirmed by a dealer due to its intermittent nature, making it difficult to reproduce on demand. The vehicle has not been inspected by the manufacturer or other parties regarding this issue. The symptoms first appeared several months ago and have become progressively more frequent. The primary warnings are the on-screen error messages and the loss of the video feed itself.
NHTSA complaint #11696672 — an unverified report by a vehicle owner.
Trunk is opening and car unlocks on it's on. Random Also, display screen frequently goes black or freezes. Sometimes it will freeze on the rear camera when I'm driving down the road.
NHTSA complaint #11612717 — an unverified report by a vehicle owner.
Airbags failed to deploy at 30-40 mph head on collision. Vehicle had an airbag light come up, was inspected by Ford and the RCM module was replaced as directed by manual. Airbags were also inspected at the time. Lights were cleared after the replacement. Was the car not reading the speed at the time of the accident? My wife and 2 toddlers were in the vehicle at the time of the accident. I have a wrist injury and whiplash. Injuries could have been worse if it was a vehicle of twice the size or a semi.
NHTSA complaint #11580473 — an unverified report by a vehicle owner.
The vin does not show a safety recall however the exact year, make, and model shows the same problem I am experiencing. my 2020 ford fusion hybrid is in service again. been getting service with same issues since 2022 to current. I lose power, had battery replaced check engine light on I had the battery replaced again, currently being service I was informed yesterday that in the back of the car by the motor there were noise and found out wires were fried, I was informed the car needs a new PCM... power control model. same as the recall on the 2020 ford fusion recall. but does not show up under my vin number which is. [XXX] . but the car is still at RON TIRAPELLI FORD. 4355 W JEFFERSON ST. SHOREWOOD, IL 60404. I was also informed that the PCM is on back order, and it is on back order until next November of next year. my car sits at the dealership until then. but the sound of things the car could have started on fire harm anyone in or near it and could have destroyed the car and leave me stranded. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11550476 — an unverified report by a vehicle owner.
1. Gear shift jammed (from 3 months of owning my car, until now -4 yrs). 2. Stop Safely Now Caution Light on. Vechile stops, then shuts off, can't turn it back on until about 20 minutes, Maybe Transmission? I am highly displeased! The transmission started to kick when this "Stop Safely Light" appeared. I could have been in a car accident.
NHTSA complaint #11546979 — an unverified report by a vehicle owner.
My 2016 Fusion Hybrid SE. All SYNC related functions ceased to function . Cant use bluetooth. cant do voice commands. USB is not working and not charging. Radio works fine, but phone button does nothing; menu button does nothing; voice command button on steering wheel does nothing. This is a safety hazard and I know I'm not the only one having this issue.
NHTSA complaint #11545899 — an unverified report by a vehicle owner.
On May 26, 2023, after I started moving from stop at a traffic light, I rear ended the vehicle in front of me when it came to a sudden stop. My speed was between 25 - 35 mph at most. My front and side curtain airbags deployed, the hood was crumpled and fascia was damaged as expected. However after 10 minutes or so, flames started coming from underneath the hood and within a few minutes the engine compartment was on fire. The Fire Department arrived and put out the fire but had to break the windshield and rip off the fender to aim the fire hoses.
NHTSA complaint #11526971 — an unverified report by a vehicle owner.
1. What component or system failed or malfunctioned, and is it available for inspection upon request? Screen for back up camera will black up within seconds of turning on. 2. How was your safety or the safety of others put at risk? I live in an apartment complex and the kids play outside. When back into or pulling out of a space it is a huge help to have the camera for kids who don't pay the closest attention to what is going on around them while playing. It is also disorienting when it is on & working and then suddenly turns off in the middle of reversing. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? No, I have video of it happening and it is also notated on multiple ford chat forums. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? not yet. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warnings prior to the glitching - on occasion during a black out a message will come up reading "backup camera unavailable, contact dealership" 6. How often - almost every time it is used over the last week.
NHTSA complaint #11526019 — an unverified report by a vehicle owner.
Ford installed 3g modems knowing the network would be shutdown. This causes most things on the infotainment center to stop working such as the vehicle GPS and most recently the Bluetooth command button. Updates have failed to resolve the issues. It is illegal for me to be distracted while driving, however, all of my distractions come from dealing with the infotainment and connectivity issues that were built into my vehicle.
NHTSA complaint #11522782 — an unverified report by a vehicle owner.
My trunk keeps popping open when it is not signaled to. This is a safety hazard for me because I do not want people to have access into my car. This is a safety hazard for others because my trunk can open while I am driving, resulting in my belongings flying out, becoming an obstacle for those driving behind me. According to the Car Gurus website, I am not the only one while this make and model who is having the same issue.
NHTSA complaint #11491284 — an unverified report by a vehicle owner.
Unknown. My wrench light has came on 3 times since owning this car. The first 2 times it has came on I was not able to switch out of park after starting my car, but shortly after the light went off on its own and I was able to drive my car. This Friday (8/26/22), when on my way to work the wrench light came on again and this time stayed on, I was not able to switch out of park from starting it as well. I had my car towed and I’m currently waiting for the mechanic to see what’s wrong with my car( 8/27/22)
NHTSA complaint #11481580 — an unverified report by a vehicle owner.
Code p2112, throttle body stuck closed. Lost power, no acceleration, no power steering. Has happened 3 times in the past 2 weeks. Check engine light comes on, no air bags, traction control or hill assist, messages pop up on dash. Too expensive too have Ford "diagnose" issue. No warning before this happens. There was no accident (yet) but it is my only vehicle so I have no choice about driving it.
NHTSA complaint #11481463 — an unverified report by a vehicle owner.
THE TRUNK DOOR OPENS UNEXPECTEDLY. IT HAS OPENED NUMEROUS TIMES. IT OPENED WHILE DRIVING. IT OPENED WHILE THE CAR ON AND IN PARK. IT OPENED WHILE IN A CAR WASH.
NHTSA complaint #11467984 — an unverified report by a vehicle owner.
When I put my car in reverse, the image displayed for the backup camera is inverted. Ex. If a car is on my right side, it will display that it is on the left side on the screen. It has been doing this for over a year and only seems to work maybe 1/50 trips, in particular when it is extremely cold. Newer fords have been recalled for this error as it is a major safety hazard when reversing.
NHTSA complaint #11449263 — an unverified report by a vehicle owner.
MY vehicle gets the tires rotated every 5,000 miles it has 55,000 miles in it the last time they rotated my tires they said the all 2 piece lug nuts will have to be replaced , I'm 75 years old and have worked on all my vehicles and never have I replaced all the lug nuts, I understand this has been happening to many ford products , I hope there is going to be a recall this becomes very expensive if they cannot remove the lug nuts with the impact tool .
NHTSA complaint #11442649 — an unverified report by a vehicle owner.
The contact owns a 2013 Ford Fusion Hybrid. The contact stated while driving at an undisclosed speed, the steering wheel became difficult to turn. The contact stated there was no warning light illuminated. The vehicle was towed to a local dealer where it was diagnosed with needing the steering assembly replaced. The vehicle was not repaired. The manufacturer was informed of the failure and informed the contact that the VIN was not under recall. The failure mileage was approximately 90,000.
NHTSA complaint #11440666 — an unverified report by a vehicle owner.