GMC Sierra 1500 other reported problems

UNKNOWN OR OTHER

The front grille trim moulding failed and flew off on the highway. Also, the forward collision light on vehicle from the front camera not working and needing to be replaced.

NHTSA complaint #11764036 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

As I was driving down the road, I heard a loud explosion. I looked around, didn't see anything that could've hit the truck. I thought it was possibly a gunshot that went off. After driving for another 3 or 4 minutes, I heard glass going everywhere. It was the moonroof that exploded. Thankfully, the sunroof cover was in the closed position. Otherwise, glass would've been all over the interior of the vehicle. I called the dealership to report the incident and to see if this was something that could be covered under warranty. I'm still waiting for a call back. I then called my insurance company to report what happened. I was told to seek a repair shop and collect all receipts for the claim. No warning lights have appeared in the vehicle yet. Since we were driving home from a vacation, we stopped and got a roll of vinyl sticker to cover the outside from rain.

NHTSA complaint #11763807 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I was driving today with product resting on the tailgate and the tailgate dropped while turning a corner, spilling product on the street. It was a residential street, thankfully, but it has happened on the highway. Previously, I had bikes resting on the tailgate and the same thing happen. Tailgate will randomly drop while driving, especially with a little weight resting on it. I close it completely, but doesn't seem to matter. It has become a concern and safety issue.

NHTSA complaint #11763685 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The engine coolant control valve on my 2021 GMC Sierra 3.0L Duramax diesel failed. This specific component failure triggers an active vehicle 'No-Restart' safety event during automatic engine stop/start operations (per GM Service Bulletin #24-NA-070). This condition can suddenly prevent the vehicle from restarting when stopped at intersections or in active traffic, creating an immediate highway safety hazard and leaving the vehicle stranded. Additionally, the vehicle's radiator cooling fans run continuously at 100% maximum capacity as a system fail-safe, creating severe electrical drain. General Motors has issued a Special Coverage Adjustment (#N252508341) acknowledging the high failure rate of this part, but it is capped at 150,000 miles. Because this defect causes unexpected stalling/no-start safety risks in live traffic past this arbitrary mileage limit, a formal safety recall is required.

NHTSA complaint #11763419 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Hood Molding- While driving down highway 45 doing about 75 miles per hour the hood molding detached on the driver side and started beating against the hood. I was unable to reach and exit before the entire mood flew off and over car. Fortunately, there were no cars right behind me to cause and accident, except an 18-wheeler about 2 cars back and he ran over the molding. I contacted the dealership and GMC, but they said no recall on this issue. There were a recall 25V-060 for the 2022 (production dates NOV 09, 2021 - SEP 29, 2022). My vehicle production date is 08/19/2022 and they could have been using the same material. I feel this the same safety issue: If a front grille deflector detaches unexpectedly while driving, there is increased risk of a crash. The photo was taken when I got to the first exit to see what happen. You can see the clasps just broke off.

NHTSA complaint #11762889 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Upper grille flew off on interstate. Hit windshield and landed in median. I have the black grill not covered in the recall.

NHTSA complaint #11762560 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The infotainment system keeps having the sound completely shut off. The radio, GPS, blinker system sound will not work.

NHTSA complaint #11762558 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Safety Complaint – 2025 GMC Sierra 1500 Tailgate While driving our 2025 GMC Sierra 1500 and towing a trailer, the tailgate unexpectedly opened and dropped down while the vehicle was in motion. No one touched the tailgate button, key fob, or any other controls to activate the tailgate. We were unaware that the tailgate had opened. When we made a turn, the trailer contacted the tailgate and crushed/damaged it. This occurred without any intentional activation of the tailgate release. We believe this presents a significant safety concern because an unexpectedly opening tailgate while driving, especially while towing a trailer, could result in property damage, loss of cargo, or a more serious accident. We are requesting that this issue be investigated to determine whether there is a defect with the tailgate latch, release mechanism, or electronic controls on the 2025 GMC Sierra 1500.

NHTSA complaint #11761746 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

ENGINE STARTED KNOCKING AT 18K MILES AND TOOK TO DEALER AND THEY FOUND METAL IN THE FILTER AND INSTALLED A NEW ENGINE AND ALSO REPLACED THE MIDPLATE GASKET ON THE VALVEBODY DUE TO A HARSH DOWNSHIFT WITHOUT CODES IN THE SYSTEM THIS ENGINE IS GOING ON 2K MILES AND IT SEEMS TO BE FINE NOW BUT THE PROBLEM WITH 6.2 WAS ONLY SUPPOSED TO BE ON THE 21-24 MODELS AND MINE IS A 25 MODEL AND ALREADY HAD A REPLACED AND NOTHING FROM GM WAS SAID TO EXTEND THE WARRANTY ON THIS MODEL AND POWERTRAIN

NHTSA complaint #11760587 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Learned that GMC engines may have an issue. We haven't had one as yet.

NHTSA complaint #11760243 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

This truck was bought brand new by my father. Around 38,000 miles it begin having issues with shifting which eventually got worse. When I searched google for issues many others on different pages have had the same issues. The shifting would be so rough it feels like you're being hit by another vehicle. This could cause accidents for anyone who cannot afford to fix these known issues by GMC. I was told today by my local dealership their transmissions for my specific truck is on backorder. Should that not indicate an issue when this truck is a 2020. But to my father having a stroke I was not able to handle this issue sooner as he was very ill for four years and passed last year. The truck was not the priority at the time.

NHTSA complaint #11759816 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I purchased this new 2026 GMC Sierra 1500 on 07/16/2026. Beginning shortly after delivery, the vehicle began intermittently losing ALL audio, including the audible turn-signal indication. The condition now occurs approximately once every 3–4 vehicle starts/uses. When the failure occurs, there is no audio from the infotainment system, radio, Apple CarPlay, Bluetooth, or speakers, and there is no audible turn-signal sound. Because the failure also eliminates audible driver feedback from the turn signals, I am concerned this is not simply an entertainment-system issue. The vehicle is available for inspection upon request. The vehicle was presented to Ed Morse Sawgrass Auto Mall, an authorized GMC dealer, after the condition occurred again on approximately 08/20/2026. The dealer advised me that the vehicle already has the applicable software programming and that GM is aware of the condition. The Service Manager advised me in writing that GM currently instructs the dealer to recover/reset the radio and not replace the radio or amplifier because GM is working on a permanent correction. Restarting the infotainment system, Safe Mode, disabling Quick Startup, and allowing the vehicle to completely power down have not permanently corrected the condition. A full shutdown may temporarily restore the audio, but the failure returns. There are no warning lamps or messages before the failure. The audio simply does not function when the vehicle is started. The vehicle currently has approximately 976 miles. There has been no crash, fire, injury, or fatality. I have also formally reported the condition to GMC Customer Assistance. GMC Case #108458085.

NHTSA complaint #11758455 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The GMC Sierra has a known issue from the manufacturer in which the power sliding rear window can start to leak water into the cab of the truck during rain or other impact with outside water. This issue allows water into the cab through a cracked or faulty seal, which impacts visibility and allows water to penetrate inside, producing risk for moisture to collect on the back window and potentially cause mold to grow inside, further creating a health risk. Further, the water intrusion can lead to interior damage, as well as potentially cause electrical failure and unsafe operation. This is a known issue dating back to January 2019 when GM issued Technical Service Bulletin 18-NA-383 and has continued to be revised since. The component has been reviewed and inspected by the dealer and is known to the manufacturer; however, they are unwilling to fix without cost as this is not a recall.

NHTSA complaint #11757869 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The molding cover for the hood fell off by Hwy speed, and recently we I went to oil change after I get the car the technician said the bolt for tie the oil thing is not correct and it’s not for this car and this was the reason for leaking and need to replace with right one.

NHTSA complaint #11757322 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The OnStar module in the truck is broke it affects all communications. The truck has including things like let me know what the speed limit is. It happened after they did a software update, which seems a little fishy because there was nothing wrong with it before I understand. Some people were having problems with this module, causing their batteries to die, but now I’m the one having issues and they won’t seem to fix it unless I pay them $900.

NHTSA complaint #11756360 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Top Grill/Hood trim piece - it is separate from the main Grill. It detached and flew off at interstate speed. Thank God it missed several cars behind me. The passenger side corner came loose and before I could safely make my way off the interstate the piece ripped all the way across and flew over the top of the truck. May have gone 30 feet in the air prior to landing on the asphalt between the two lanes.

NHTSA complaint #11754992 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The grill deflector flew off while driving on the highway. I was driving roughly 55 mph. It is available now, but will be getting repaired in the near future. My concern is that it appears that this was an issue with the 2022 models and it’s still an issue on the 2023. The safety issue is if there was a vehicle or motorcycle behind me that it could have harmed whoever could have been driving behind me, caused and accident, or damaged their vehicle or mine in the process. The service advisor (J.R.) told me that “sometimes the wind gets underneath the bezel and makes it snap”. No it has not been inspected by any of this mentioned. No warning signs prior to the incident.

NHTSA complaint #11753855 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Subject: Event of engine failure • While driving on a level paved road at 15 miles per hour in a busy area my 2019 GMC Sierra Denali pickup truck stalled in the middle of a busy street. • Truck stalled in a heavy traffic area at an intersection putting myself and passengers in a dangerous area and situation. This obstructed the normal flow of traffic causing a danger to pedestrians and normal vehicle traffic pattern. Each had to go around my disabled truck into oncoming traffic putting them and normal traffic flow at risk. •Upon securing a towing service the truck was transported to the nearest GM dealership. This happened on a Friday afternoon and the truck got to the dealership after hours. I returned to the dealership the next morning and was told that they may not be able to check the truck until probably Tuesday. On Monday afternoon I called and they hadn't been able to get to it. I received a call the next day and was informed that the technician at the dealership had put a breaker bar to the crankcase and the engine would not move and therefore the engine is seized. • There were no warning lights that came on prior to the truck stalling in the street. There was no noise prior or any other symptom to give any indication that the truck was not operating in a normal fashion.

NHTSA complaint #11753006 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Upper front grill trim piece was repaired under recall. After being fixed I was driving and it broke off flying up in the air and behind the truck. It did not hit another vehicle. Adaptive cruise control stopped working. Lane assist stopped working. Brake pad wear sensor error message stating it doesn't work. Vehicle has 19,000 miles.

NHTSA complaint #11753087 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I bought the truck with 2 miles , shut off on me within 1,300 miles wouldn’t turn on , supposedly it was a bad fuse that was burned out , Second time it shut off on me again , all my sensors were going off and on and truck wouldn’t turn back on , they told me they couldn’t figure out the problem evaczue they had disconnected the battery and it erased all the codes 3rd time , they changed my oil and they forgot to torque the screw back correctly and all the oil spilled and cost my engine to lock up and mess up , they replaced the motor with a new one 4th time , supposedly it needs a replacement for a catalytic converter which is being replaced now as we speak or sometime this week

NHTSA complaint #11751712 — an unverified report by a vehicle owner.