2002 Honda Cr-V headlight problems

EXTERIOR LIGHTING

SMOKE STARTED ARISING FROM THE STEERING COLUMN WHILE DRIVING ON A CITY STREET DURING THE DAYTIME. DRIVER WAS NOT USING LIGHTS AT THE TIME AND WAS USING NORMAL OCCASIONAL TURN SIGNALS FOR A URBAN METROPOLITAN AREA. THE TURN SIGNAL WAS EVALUATED AND SHOWED MELTING OF THE TURN SIGNAL SWITCH AND THE TERMINAL HARNESS. THIS IS SIMILAR TO WHAT IS DESCRIBED IN NHTSA 12V-136 OR 12V-486. HONDA AMERICA AND HONDA DEALERSHIPS SAID THE 2002 HONDA CR-V WAS NOT INCLUDED, BECAUSE VIN WAS NOT INCLUDED IN THE RECALL. HOWEVER, THE MODEL AND YEAR OF THE CAR WERE INCLUDED AND HAVING THE SAME PROBLEMS DESCRIBED AS PREVIOUSLY MENTIONED RECALLS.

NHTSA complaint #11270135 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

"TAKATA INFLATORS" AIRBAG LIGHT SYMBOL KEEPS COMING ON IN DASHBOARD WHILE IN MOTION

NHTSA complaint #11173445 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

"TAKATA INFLATORS" AIRBAG WARNING LIGHT KEEPS COMING ON IN DASHBAORD WHILE DRIVING IN MOTION AT 15MPH SEATBELT WONT CLICK IN POSITION GOOD ALL THE WAY HAVE A HARD TIME BUCKLING THE SEATBELT INTO PLACE TAKE ABOUT 8 HARD TRIES INSTRUMENTAL PANEL LIGHTS WONT LIGHT UP IN DASHBARD AT NIGHT I CANT SEE THE ODOMETER OR SPEEDOMETER READINGS ALL THE LIGHTS ARE OUT AT NIGHT AND BOTH TURNING SIGNALS BLINKS TOGETHER ONLY AT NIGHT WHEN MAKING A TURN

NHTSA complaint #11173446 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

EVER SINCE I HAVE HAD MY CAR THE HEADLIGHTS BURN OUT WITHIN 3-4 MONTHS. CHANGE ONE, THE OTHER GOES OUT. AVERAGING 2000.00 OVER THE LIFETIME OF OWNING MY CAR. THE FRONT DRIVERS SEAT'S BOLT BROKE...THE SERVICE MANAGER SAID IT WAS BC OF WEIGHT...I WEIGH 135# I HAD TO PAY TO HAVE MY SEAT FIXED. NOT MY FAULT!! MY SEAT BELT WILL NOT BUCKLE UNTIL THE 4-5 TRY..IT KEEPS ON BOUNCING OUT OF THE CLICKER.

NHTSA complaint #11060702 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

WE RESPONDED TO A SAFETY RECALL ON OUR 2002 HONDA CRV IN 2013 TO REPLACE THE COMBINATION LIGHT SWITCH WHICH MIGHT CAUSE A FIRE OR THE LIGHTS TO GO OUT UNEXPECTEDLY. REPAIRS WERE COMPLETED 30 OCT 2013. IN MARCH 2017 THE ISSUES IDENTIFIED IN THE RECALL WERE EXACTLY WHAT HAPPENED. THE SWITCH STARTED SMOKING AND THE LIGHTS WENT OUT. I NOTIFIED THE CLOSEST DEALERSHIP TO SCHEDULE THE REPAIRS FOR THE ITEMS TO BE REPLACED. THE DEALER TOLD ME THAT YES THIS IS THE ITEM COVERED BY THE RECALL BUT WOULD NOT BE COVERED AND I WOULD HAVE TO PAY. THIS MADE NO SENSE TO ME BUT AS I HAD TO DRIVE 80 MILES TO RETURN HOME I WENT AHEAD AND PAID. I CONTACTED HONDA AND EXPLAINED THE PROBLEM. THEY RESPONDED THAT THE PARTS THEY HAD PREVIOUSLY INSTALLED WERE NOW OUT OF WARRANTY AND THEY WOULD NOT COVER THE COSTS. IT SEEMS THAT EVEN IF REPLACEMENT PARTS ARE USED AND THE SAFETY ISSUE STILL HAPPENS AS IDENTIFIED IN THE SAFETY RECALL, THEY SHOULD COVER THE REPAIR COSTS. THEY FELT OTHERWISE.

NHTSA complaint #11004883 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2002 HONDA CR-V. WHILE DRIVING AT 5 MPH, THE LOW BEAM HEADLIGHTS FAILED TO ILLUMINATE. THE FAILURE RECURRED TWICE. THE VEHICLE WAS REPAIRED BY THE CONTACT AND THE DETAILS WERE UNKNOWN. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.

NHTSA complaint #10749281 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2002 HONDA CR-V. THE CONTACT RECEIVED NOTIFICATION OF NHTSA NUMBERS: 15V320000 (AIR BAGS), 14V700000 (AIR BAGS) AND 12V136000 (EXTERIOR LIGHTING) HOWEVER STATED THAT THE PARTS NEEDED FOR THE RECALL REPAIR WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA complaint #10746537 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2002 HONDA CR-V. WHILE DRIVING AT 50 MPH, THERE WAS A NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V700000 (AIR BAGS), 14V351000 (AIR BAGS), AND 12V136000 (EXTERIOR LIGHTING); HOWEVER, THE PARTS NEEDED TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA complaint #10712137 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2002 HONDA CR-V. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V70000 (AIR BAGS), 14V351000 (AIR BAGS), 12V486000 (ELECTRICAL SYSTEM, VISIBILITY) AND 12V136000 (EXTERIOR LIGHTING); HOWEVER, THE PARTS NEEDED TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA complaint #10702908 — an unverified report by a vehicle owner.

INTERIOR LIGHTING

2002 HONDA CR-V. CONSUMER WRITES IN REGARDS TO VEHICLE ELECTRICAL PROBLEMS . *SMD THE CONSUMER STATED SHE WOULD ALWAYS PUT THE KEYS IN THE SEAT, WHILE AT THE GAS STATION. THE VEHICLE LOCKED AUTOMATICALLY IF THEY KEYS WERE IN THE VEHICLE, BUT NOT IN THE IGNITION. THE CONSUMER STATED SHE WAS LOCKED OUT SEVERAL TIMES, JUST BY LAYING THE KEYS DOWN. THERE WAS NO SIGNAL OR ALERT THAT THE HEADLIGHTS WERE ON, AS SHE ACCIDENTALLY LEFT THEM ON. ALSO, THE INTERIOR LIGHT WOULD NEVER COME ON, WHEN SHE OPENED THE DOOR, THE HEADLIGHTS WERE REPLACED, THE SEAT BELT WOULD NOT RETRACT. THE AIR BAG LIGHT ILLUMINATED. THE CONSUMER RECEIVED A RECALL NOTICE, REGARDING THE ISSUE. THE DEALER INFORMED THE CONSUMER, SHE WOULD HAVE TO PAY $100 DIAGNOSIS FEE, TO DETERMINE, WHY THE LIGHT WAS STILL ON.

NHTSA complaint #10619578 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2002 HONDA CR-V. THE CONTACT STATED THAT WHILE THE DRIVER REVERSING AT 5 MPH, SHE NOTICED THAT THAT A HEADLIGHT FAILED. THE CONTACT ALSO MENTIONED THAT THE WIRING OF THE HEADLIGHTS WAS THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 12V136000 (EXTERIOR LIGHTING) AND WAS ADVISED BY THE DEALER THAT THE VEHICLE WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

NHTSA complaint #10611290 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

I RECENTLY NOTICED THAT THE VEHICLE LIGHTS WERE PULSATING AT A LEVEL THAT WAS BARELY DETECTABLE. JUST YESTERDAY WHEN I ATTEMPTED TO USE THE VEHICLE AND TURNED ON THE LIGHTS ONLY THE RUNNING LIGHTS CAME ON. I HAVE NO HEADLIGHTS EITHER HIGH OR LOW BEAM. RESEARCH HAS DISCOVERED THAT 2002-2004 HONDA CRVS HAVE HAD THE IDENTICAL ISSUE DUE TO OVERHEATING CIRCUITRY CAUSING THE LIGHT SWITCH TO CATASTROPHICALLY FAIL.

NHTSA complaint #10532791 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

THE DRIVER'S SIDE DOOR ACTUATOR FAILED. I HAVE TO OPEN THE DRIVER'S DOOR WITH A KEY AND THE REMOTE DOESN'T WORK ON THE DRIVER'S SIDE. THE OTHER DOORS LOCK WITH THE REMOTE BUT ONLY AFTER THE DRIVER'S SIDE DOOR IS LOCKED BY KEY. THIS HAS ALSO AFFECTED THE INTERIOR LIGHTS WHICH DON'T LIGHT WHEN THE DOOR IS OPEN.

NHTSA complaint #10519628 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

LOW BEAM HEADLIGHTS INOPERATIVE. THERE IS A SAFETY RECALL IN PLACE DUE TO A KNOWN WIRING ISSUE. HOWEVER, CAUSE OF FAILURE IS CONCURRENT BURNOUT OF LOW BEAM FILAMENTS IN BOTH BULBS. THIS IS HIGHLY UNLIKELY UNLESS THERE IS A VOLTAGE SURGE OF SOME SORT. UNKNOWN WHETHER THIS IS RELATED TO THE WIRING RECALL, AS THE DESCRIBED FAILURE MODE IN THE CURRENT RECALL CAMPAIGN WOULD RENDER THE CIRCUIT OPEN AND NOT SUBJECT FILAMENTS TO OVERVOLTAGE. POSSIBILITY OF A SECOND CAUSE OF HEADLIGHT FAILURE IN THIS MODEL.

NHTSA complaint #10496405 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

2002 HONDA CRV. CONSUMER WRITES IN REGARDS TO TWO RECALLS AND NO PARTS BEING AVAILABLE. *TGW DOCUMENT WAS WRITTEN IN SPANISH.

NHTSA complaint #10468723 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

2002 HONDA CRV. CONSUMER WRITES IN REGARDS TO RECALL RESOLUTION RECALL 12V-136000.*TGW THE CONSUMER STATED BOTH HEADLAMPS FAILED AT THE SAME TIME. THE CONSUMER STATED AT THE TIME, NO RECALL HAD BEEN ISSUED. SHE PURCHASED AND REPLACED THE SWITCH WHICH FIXED THE PROBLEM. ONCE A RECALL WAS ISSUED, HONDA REIMBURSED HER FOR THE DEFECTIVE SWITCH, BUT NOT THE HEADLAMP BULBS. THE CONSUMER IS SEEKING REIMBURSEMENT FOR THE BULBS, BECAUSE THE DEALER SUGGESTED THE REPLACEMENT, EVEN THOUGH IT DID NOT SOLVE THE PROBLEM.

NHTSA complaint #10466103 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS

TL* THE CONTACT OWNS A 2002 HONDA CR-V. THE CONTACT STATED THAT THE HEADLIGHT LENSES WAS DEFECTIVE. THE LENSES WERE FOGGY AND THEY DID NOT PRODUCE PROPER ILLUMINATION. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED THAT THE LENSES COULD BE SAND CLEANED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE HEADLIGHT LENS WAS NOT REPAIRED. THE FAILURE MILEAGEWAS 90,000 AND THE CURRENT MILEAGE WAS 117,408. UPDATED 06/29/12 *BF UPDATED 07/09/12

NHTSA complaint #10458827 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS

TL* THE CONTACT OWNS A 2002 HONDA CR-V. THE CONTACT STATED THAT WHEN DRIVING WITH THE HEADLIGHTS IN ACTIVATION, THE HEADLIGHTS SEEMED ABNORMALLY DIM AND THE CONTACT WAS UNABLE TO SEE THE ROADWAY. THE VEHICLE WAS TAKEN TO A DEALER WHERE THEY ADVISED HIM THAT THE ENTIRE HEADLIGHT ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 96,000. UPDATED 05/08/12

NHTSA complaint #10453449 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2002 HONDA CR-V. THE CONTACT STATED THAT WHEN DRIVING WITH THE HEADLIGHTS IN ACTIVATION, THE HEADLIGHTS SEEMED ABNORMALLY DIM AND THE CONTACT WAS UNABLE TO SEE THE ROADWAY. THE VEHICLE WAS TAKEN TO A DEALER WHERE THEY ADVISED HIM THAT THE ENTIRE HEADLIGHT ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 96,000. UPDATED 05/08/12

NHTSA complaint #10453449 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2002 HONDA CR-V. THE CONTACT STATED THAT THE LOW-BEAM EXTERNAL HEADLIGHTS WERE INOPERATIVE. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 191,848.

NHTSA complaint #10452975 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS

TL* THE CONTACT OWNS A 2002 HONDA CRV. THE CONTACT STATED THAT AFTER ENTERING A RESIDENTIAL GARAGE, THE LOW BEAM HEADLIGHTS FAILED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE SWITCH WAS DEFECTIVE AND THE CONNECTORS WERE FOUND TO BE CORRODED. AS A RESULT, BOTH COMPONENTS WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 158,000. UPDATED 04/10/12

NHTSA complaint #10451536 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

TL* THE CONTACT OWNS A 2002 HONDA CRV. THE CONTACT STATED THAT AFTER ENTERING A RESIDENTIAL GARAGE, THE LOW BEAM HEADLIGHTS FAILED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE SWITCH WAS DEFECTIVE AND THE CONNECTORS WERE FOUND TO BE CORRODED. AS A RESULT, BOTH COMPONENTS WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 158,000. UPDATED 04/10/12

NHTSA complaint #10451536 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

THE LOW BEAM HEADLIGHTS STOPPED WORKING. I FOUND THE HEADLIGHT CONNECTOR SHORTED AT THE HEADLIGHT SWITCH...UPDATED 03/21/12 *BF

NHTSA complaint #10449711 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS

THE LOW BEAM HEADLIGHTS STOPPED WORKING. I FOUND THE HEADLIGHT CONNECTOR SHORTED AT THE HEADLIGHT SWITCH...UPDATED 03/21/12 *BF

NHTSA complaint #10449711 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

UPON LEAVING MY HOUSE LAST EVENING, I NOTICED THAT BOTH OF MY LOW BEAM HEADLIGHTS QUIT WORKING SIMULTANEOUSLY. I CAME BACK HOME AND INITIALLY CHECKED THE FUSES FOR BOTH HEADLIGHTS, FINDING THAT BOTH FUSES WERE IN WORKING ORDER. I THEN REMOVED EACH HEADLIGHT BULB FROM THE CASING TO SEE IF THEY HAD BURNED OUT. BOTH BULBS APPEAR TO BE PERFECTLY FINE WITH THE COIL INSIDE THE BULB BEING UNDAMAGED. I THEN CHECK THE HEADLIGHT CONNECTORS AND MADE SURE THAT EACH WAS FREE OF ANY MATERIAL THAT MAY INTERRUPT CONNECTION. I CALLED MY LOCAL HONDA DEALERSHIP THIS MORNING AND THE SERVICE MANAGER SAID IT SOUNDED LIKE A BAD HEADLIGHT SWITCH, WHICH I AM NOW GOING TO HAVE TO PAY $163.00 TO REPLACE. I WILL KEEP THE FAULTY SWITCH SO THAT IF THE NHTSA WOULD LIKE TO INVESTIGATE I WOULD BE MORE THAN HAPPY TO SEND IF IT LEADS TO A VEHICLE RECALL FOR THIS PARTICULAR EQUIPMENT FAILURE.

NHTSA complaint #10446652 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

UPON LEAVING MY HOUSE LAST EVENING, I NOTICED THAT BOTH OF MY LOW BEAM HEADLIGHTS QUIT WORKING SIMULTANEOUSLY. I CAME BACK HOME AND INITIALLY CHECKED THE FUSES FOR BOTH HEADLIGHTS, FINDING THAT BOTH FUSES WERE IN WORKING ORDER. I THEN REMOVED EACH HEADLIGHT BULB FROM THE CASING TO SEE IF THEY HAD BURNED OUT. BOTH BULBS APPEAR TO BE PERFECTLY FINE WITH THE COIL INSIDE THE BULB BEING UNDAMAGED. I THEN CHECK THE HEADLIGHT CONNECTORS AND MADE SURE THAT EACH WAS FREE OF ANY MATERIAL THAT MAY INTERRUPT CONNECTION. I CALLED MY LOCAL HONDA DEALERSHIP THIS MORNING AND THE SERVICE MANAGER SAID IT SOUNDED LIKE A BAD HEADLIGHT SWITCH, WHICH I AM NOW GOING TO HAVE TO PAY $163.00 TO REPLACE. I WILL KEEP THE FAULTY SWITCH SO THAT IF THE NHTSA WOULD LIKE TO INVESTIGATE I WOULD BE MORE THAN HAPPY TO SEND IF IT LEADS TO A VEHICLE RECALL FOR THIS PARTICULAR EQUIPMENT FAILURE.

NHTSA complaint #10446652 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

BOTH LOW BEAM HEADLIGHTS QUIT WORKING SIMULTANEOUSLY. THE HIGH BEAMS STILL WORK. I HAVE CHECKED THE HEADLIGHT BULBS AND THE FUSES FOR THE HEADLIGHTS AS ALL APPEAR NORMAL. I HAVE ALSO MADE SURE THAT THE CONNECTORS FOR THE HEADLIGHTS WERE FREE OF ANY TYPE OF MATERIAL THAT WOULD HINDER CONNECTION.

NHTSA complaint #10446620 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

LOW BEAMS QUIT WORKING. HIGH BEAMS CONTINUE TO WORK. BY SEARCHING ONLINE SEEMS LIKE QUITE A PROBLEM WITH THE 2002 MODEL.

NHTSA complaint #10442838 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

MULTIPLE PROBLEMS WITH LOW BEAM HEADLIGHTS GOING OUT - HIGH BEAMS CONTINUED TO WORK IN ALL INSTANCES. FIRST INCIDENT 11/19/2007 REPLACED PART OF WIRING HARNESS DUE TO THE WIRING HARNESS HAD MELTED. 9/20/2010 LOW BEAMS WENT OUT AGAIN - REPLACED THE HEADLIGHT SWITCH. 3/7/11 LOW BEAMS OUT AGAIN - REPLACED THE HEADLAMP SWITCH. 6/2/11 LOW BEAMS OUT AGAIN - REPLACED THE MULTIPLEX CONTROL MODULE. 12/2/11 LOW BEAMS OUT AGAIN - IN SHOP DISCONNECTED AND CONNECTED WIRING - LOW BEAMS WORKING. 12/24/11 LOW BEAMS WENT OUT. 12/25/11 LOW BEAMS CAME BACK ON BY THEMSELVES. 1/4/2012 LOW BEAMS OUT AGAIN - IN SHOP CHECKED CONNECTIONS. PICKED UP CAR LOW BEAMS WORKING. 1/5/2012 - LOW BEAMS OUT AGAIN. APPROXIMATELY 3 OTHER VISITS TO A MECHANIC - CONNECTIONS UNPLUGGED AND REPLUGGED TO GET LOW BEAMS WORKING AGAIN. ALSO AT LEAST 5 OTHER INSTANCES WHERE THE LOW BEAMS WENT OUT AND CAME BACK ON BEFORE I COULD GET THE CR-V TO A MECHANIC. 9/2011 MOTOR TRENDS MAGAZINE REPORTS ISSUE OF LOW BEAMS HEADLIGHTS GOING OUT ON HONDA CR-V MODELS 2002 - 2005. I HAVE SPENT OVER $1000 TRYING TO GET THIS ISSUE RESOLVED. ISSUE WITH WIRING HARNESS MELTING SOUNDS VERY MUCH LIKE THE RECALL THAT HONDA ISSUED FOR THE FIT - 'WIRING HARNESSES FOR THE HEADLAMP CONTROL SWITCH - THE CONNECTOR COULD OVERHEAT AND FAIL, RENDERING THE LOW-BEAM LAMPS INOPERABLE. HONDA NOTES THAT HIGH-BEAM HEADLAMP FUNCTIONALITY IS NOT IMPEDED BY THIS ISSUE.'

NHTSA complaint #10442724 — an unverified report by a vehicle owner.