KIA Optima suspension problems

SUSPENSION

I just bought this car and it runs thru oil fast.

NHTSA complaint #11746667 — an unverified report by a vehicle owner.

SUSPENSION

While driving my KIA Optima on the interstate the rear subframe suffered catastrophic structural failure, resulting in the steering wheel going out of alignment, the rear passenger side wheel tilting with the bottom of the tire being far out compared to the top. This resulted in the rear of the vehicle swaying side to side and being difficult to maintain in a straight path. This vehicle was previously serviced under KIA Campaign SC141 (internal subframe corrosion) at Griffin KIA on April 27, 2017. Despite this safety remedy being performed the subframe rotted through and snapped. This is a remedy failure. The anti-corrosion was applied by the manufacturer failed to prevent the exact structural failure it was designed to mitigate. I have physical evidence (Repair Order #92144) proving the remedy was performed and photographic/video evidence of the subsequent structural break. The manufacturer (KIA) has denied assistance, claiming the failure is "unrelated" to the corrosion campaign despite the part being the exact component covered by the campaign." SC141 involved the inject of wax into the metal components of the subframe of the vehicle and was KIA's response to the NHSTA's concerns about the metal components of their vehicles being unable to withstand salt in the Rust Belt states. The campaign only was for the vehicles in the rust belt states. KIA was very aware this was a safety issue and attempted to avoid a recall by issuing this campaign. The campaign failed and as a result my life was put at risk. I asked KIA for a good will repair of the rusted subframe but they refuse indicating the believe the part that clearly broke due to rust is unrelated to the safety campaign. Several of their employees stated it was very clear the part broke due to rust with one indicating he had a list of rusted parts needing replaced. I'd like the NHTSA to review this failed campaign and ensure the safety of all vehicles relying on this failed safety measure.

NHTSA complaint #11733232 — an unverified report by a vehicle owner.

SUSPENSION

Pep boys told me in Panama City that this is a recall for Kia and it's a safety issue and my steering is loose I'm taking it to Kia on May 28th to get them to fix it

NHTSA complaint #11662021 — an unverified report by a vehicle owner.

SUSPENSION

Had some noise coming from the front of the car, had my mechanic look at it, he said we needed a control arm. When he took off the cover to replace the control arm, he found the sub frame had rotten and was cracking. As I looked online, I saw that KIA had a recall for this issue. When I contacted KIA, their response was "as my car is not under warranty, they are not required to repair the car" The car in question has 70, 558 miles on it. We are the 2nd owner.

NHTSA complaint #11642022 — an unverified report by a vehicle owner.

SUSPENSION

I noticed my oil was not staying in the engine. Oil has been changed but seems not to retain. The car stalled out on February 2nd and would not restart. I believe it is seized. Noticed a very new and recent shake during braking days before it stalled. The fuel seems to show like 42 miles to go until empty but run out , i guess fuel pump or fuel float. Also a fuel smell. Also the digital service option does not work never a check engine light or anything .I've read many things by others who own same vehicle and had same issues. I purchased this car in August/September. I feel the dealer may have known of these issues and still sold the car.Please help me figure out how to address these issues to get it fixed.

NHTSA complaint #11640543 — an unverified report by a vehicle owner.

SUSPENSION

While driving on the roadway, I was almost to a four way intersection, as i was going to get into the left turn lane, I turned the steering wheel slightly to the left as the steering wheel turned but the car almost did little adjusting to turn into the left turn lane. As this occurred you could here a noise underneath the vehicle . As I wasn't sure exactly what had happened, I attempted to limp the vehicle down the road to a friend's. As I did the steering got worse and as I could nearly stear the vehicle something was in the road which because of the steering I couldn't avoid it as it was late at night and raining and I ran over something that gave me a flat on the passenger side front tire . I got to my friends drive a few feet away and almost didn't get it pulled in because of the steering. As I took a look at my car, I noticed that two bolts on the driver side on the rack and pinion were almost about to fall out, two ball joints were bent and one nut was completely missing from the lower ball joint, as well as the sway bar was out of place and If I would have been driving down the highway, I do belive I would have wrecked.

NHTSA complaint #11640256 — an unverified report by a vehicle owner.

SUSPENSION

Complaint Summary: I am the current owner of a 2014 Kia Optima, which is affected by recall 23V652 related to the Hydraulic Electronic Control Unit (HECU). The vehicle was imported to the UAE, and the recall was not addressed by the previous owner. As a result, I am now facing significant safety issues. Since taking ownership, I have encountered multiple engine problems, including sudden power loss, severe vibrations, and abnormal behavior from the throttle. These symptoms align with the issues outlined in the recall notice, indicating that the vehicle may pose a safety risk to me and other road users. Despite my efforts to diagnose the problems, I have already incurred costs exceeding 13 AED on various repairs and diagnostic services, all while being unaware of the existing recall. It was only recently that I discovered the recall information online, which has heightened my concern regarding the safety of my vehicle and the potential for further complications. Given these circumstances, I am requesting assistance from the NHTSA in resolving this recall issue and guidance on how to proceed with the necessary repairs while the vehicle is registered under my name in the UAE. It is crucial for me to ensure the safety of my vehicle for my own protection and for the safety of others on the road. I appreciate your attention to this urgent matter and look forward to any support you can provide. Please let me know if further information or documentation is needed Thanks alot

NHTSA complaint #11622155 — an unverified report by a vehicle owner.

SUSPENSION

After getting HECU recall done , it has caused issues with the HECU module to where the brake lights no longer work and the ESC light comes on the cluster panel. Up on reading the code C2130, it says Brake lamp relay error. Mind you that my car was in working order before this recall was even done. This a huge safety issue not having your brake lights work. I can get rear-ended and i have kids in the car. This has been a issue since July when i got the recall done and KIA has yet to find a fix for this matter.

NHTSA complaint #11614735 — an unverified report by a vehicle owner.

SUSPENSION

Coming to a stop and breaks go to floor u will freak out this happens in 2 different times

NHTSA complaint #11578289 — an unverified report by a vehicle owner.

SUSPENSION

Dear National Highway Transportation Safety Administration, I am writing to bring to your attention a grave safety concern regarding my 2019 Kia Optima SX. Despite diligent maintenance and care, my vehicle has experienced persistent alignment issues, particularly on the right side. Additionally, I have encountered premature axle shaft and axle boot failures, all of which have occurred well before reaching 60,000 miles. These issues have not only posed a significant financial burden but have also jeopardized the safety of myself and other road users. The repeated alignment problems have resulted in the rapid deterioration of tires, leading to baldness within a month of replacement, creating a hazardous driving condition and increasing the risk of accidents. The premature failure of axle shafts and boots is unacceptable for a vehicle of this age and mileage. Such failures not only compromise the vehicle’s performance but also raise serious concerns about the overall quality and safety standards of the Kia Optima SX. I urge the National Highway Transportation Safety Administration to conduct a thorough investigation into these recurring issues affecting the 2019 Kia Optima SX model. Immediate action is necessary to ensure the safety of consumers and to hold Kia accountable for any design or manufacturing defects contributing to these alarming problems. Your swift attention to this matter is crucial in preventing potential accidents and ensuring the well-being of motorists nationwide.

NHTSA complaint #11574794 — an unverified report by a vehicle owner.

SUSPENSION

After 131,500 miles, struts, rotors and pads wore out. Lower ball joint and control arm also wore out, No injuries or accident.

NHTSA complaint #11554765 — an unverified report by a vehicle owner.

SUSPENSION

I purchased my 2018 Kia Optima directly from the dealership, brand new. I've had the vehicle since then and have followed all of the warranty guidelines and only went to them for oil changes & other maintenance issues. Since February 2023 I've noticed where i've been having oil loss, but no sign of an oil leak. When I first noticed this, I would take a turn and my oil light would come on. I'd check the oil and it'd be low so I would refill my oil. However, this was happening 2 months after my last oil change which wasn't normal. I took the vehicle to Kia and they did an "Engine Consumption Test" where I had to drive for 1000 miles with a seal on the drain plug. After the 1000 miles, I came back and I was only 1/2 quart low. According to Kia it didn't meet the guidelines for engine replacement so they topped off my oil and I left. About 2 weeks after, my oil light came back on. I went back to Kia and spoke with the Shop Manager who stated I was 3 1/2 quarts low! He added oil to my engine and we did another round of the consumption test. When I came back in after that, I was 2 quarts low so that meant I qualified for a "Consumption Cleaning". They kept my vehicle overnight & I had to drive another 1000 miles. When I came in after my 1000 miles again I was only 1/2 quart low and therefore Kia said there wasn't an issue. I've reached out to multiple auto repair shops who state it is a Kia problem, that the engine is using it and processing it out of the exhaust. I don't know what else I have to do in order for Kia to honor the 20 year, 200k warranty. I have all documentation for all of my oil changes and from the consumption tests also.

NHTSA complaint #11550168 — an unverified report by a vehicle owner.

SUSPENSION

My car is consuming major oil. I am having to put at minimum 3 to 4 quarts of oil every 3 days. I am having major loss of power. My car has oil fouled far too many spark plugs. In the last 3 months, I have had to replace the spark plugs three separate times. Within the last 3 weeks I have replaced the following: 1. Ignition Coils 2. Valve Cover Gasket 3. PCV Valve 4. 2 separate sets of spark plugs and 1 singular spark plug for Cylinder #4. My car is having a major oil consumption problem and the performance has been severely affected.

NHTSA complaint #11509681 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2002 Kia Optima. The contact stated that after he replaced all four tires, the vehicle was taken to an independent mechanic for an alignment; however, the mechanic was unable to perform an alignment due to the subframe corrosion. The vehicle was not repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 09V183000 (Suspension) however, the VIN was not included in the recall. The failure mileage was approximately 111,000.

NHTSA complaint #11493468 — an unverified report by a vehicle owner.

SUSPENSION

Vehicle has engine failure at 156600mi. Bearings and axle are worn out which caused the engine to go into limp mode (code P1326). Car is accelerating poorly and does not oprate over 60mph. Vehicle required a new engine. Dutch Miller of Charlotte Kia, 7725 South Blvd, Charlotte, NC ensured that engine would be brand new. However, the engine was used, and obtained at LKQ costing $3600. Total cost for the engine and labor totalled $5117.18. Kia also confirmed the problematic suspension which led to the engine failure was fixed. Once again this obligation was not met.

NHTSA complaint #11439423 — an unverified report by a vehicle owner.

SUSPENSION

I bought my car in 2008 a Kia optima lx I stored it till 2021. But in 2013 i took my car to El Paso tx. And I felt that beer to the side and stored it again in a garage toil this it's only got 6000 miles can it still qualify for a recall

NHTSA complaint #11432605 — an unverified report by a vehicle owner.

SUSPENSION

I WAS REPAIRING BRAKELINES, WHILE OBSERVING UNDER CARRIAGE I NOTICED SUSPENSION RUST, FRAME. LOOKED UP RECALLS AND THIS IS ONE. I INCLUDED SCREENSHOT OF PROOG

NHTSA complaint #11405889 — an unverified report by a vehicle owner.

SUSPENSION

LO QU PASA ESQ EL CARRO TIRA GASOLINA Y LO EMOS ARREGLADO 4 VESES Y TIRA TODA LA GASOLINA YA ISIMOS UN RECLAMO Y NOS NOS QUIEREN DAR NINGUNA COMPENSACIN LO QUE ASE ES QUE SE LE TIRA LA GASOLINA Y TENGO MIEDO QUE SE YEGUE A QUEMAR PORQUE CADA VEZ QUE LE A PASADO SOLO EMPIEZA A TIRAR GASOLINA NO IMPORTA SI EST PARADO A CONDUCIENDO LA LTIMA VEZ QU PAS LO ESTBAMOS CONDUCIENDO Y ME PERCAT Y ME REGRESE Y LO TENGO EN MI CASA Y YA NO LO EH VUELTO A MOVER PORQUE TENGO MIEDO QUE SE QUEME ESTOY ENVIANDO UNA FOTO DE LA MANGUERA UN VIDEO DE QUE ES LO Q LE PASA TENGO UN VIDEO DE PERO NO LO PUDE ENVIAR .

NHTSA complaint #11378289 — an unverified report by a vehicle owner.