FaultScore report
Owners have filed 13 complaints about the 2002 Lexus RX with NHTSA between 2006 and 2026. The largest single group is the transmission & drivetrain. Across this model's run it ranks 23 of 26 worst.
FaultScore 37/100
Higher is worse. Measured against the other years of the Lexus RX.
How this is worked out13
Complaints
4
Crashes reported
0
Fires reported
3
Injuries reported
101,930 mi
Median mileage at failure
Half of reported failures happened before this
0%
Failed under 36,000 miles
Inside a typical bumper-to-bumper warranty
The letter says how bad. This says what kind — whether this year drew an unusual number of complaints, unusually dangerous ones, or failures that arrived unusually early.
Click any bar to open that year's report.
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
2 crashes, 0 fires · median 74,000 mi
Median failure at 115,860 miles
1 crashes, 0 fires · median 115,000 mi
1 crashes, 0 fires
Median failure at 166,000 miles
Odometer readings owners gave when they filed. About half of all complaints include one.
A spike years after the car went on sale usually means a part wearing out on schedule across the whole fleet — the kind of pattern no single owner can see from inside their own car.
Reports where the owner recorded a crash, a fire, an injury or a death.
POWER TRAIN
Transmission wouldnt shift all of the sudden on the high way no prior mechanical issues was t boned and broke my leg abs and trac off lights mechanic says total transmission failure 121000 miles and this is the second owner of this vehicle
NHTSA complaint #11426214 — an unverified report by a vehicle owner.
VEHICLE SPEED CONTROL
Transmission wouldnt shift all of the sudden on the high way no prior mechanical issues was t boned and broke my leg abs and trac off lights mechanic says total transmission failure 121000 miles and this is the second owner of this vehicle
NHTSA complaint #11426214 — an unverified report by a vehicle owner.
AIR BAGS:SIDE/WINDOW
A CAR CRASHED INTO SIDE DOOR OF PASSENGER AND SIDE AIR DID NOT INFLATE IN MY 2002 LEXUS RX 300. MY CAR WAS THEN IN A ROLL OVER AND NO OTHER AIR BAGS DEPLOYED INCLUDING THE DRIVER SIDE AIR BAG.
NHTSA complaint #10203605 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
VEHICLE WAS PARKED WITH TRANSMISSION IN PARK AND EMERGENCY BRAKE ENGAGED. WHILE UNATTENDED THE VEHICLE STARTED MOVING FORWARD SLOWLY, I (THE DRIVER) JUMPED INTO FRONT SEAT TO APPLY THE FOOT BRAKE AND PEDAL WENT TO FLOOR (NO BRAKES!) VEHICLE COULD NOT BE STOPPED AND RAN IN TO THE WALL OF MY GARAGE.
NHTSA complaint #10157959 — an unverified report by a vehicle owner.
In the owners' own words, exactly as filed with NHTSA.
UNKNOWN OR OTHER
I want to raise concern about the safety issue and health issues relating to the new LED headlights on cars now. In the morning and evenings, I regularly encounter these extremely bright headlights. It's a big distraction and my driving visual field is impacted by these lights. I would like to see this addressed and resolved! Please advise. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11714594 — an unverified report by a vehicle owner.
AIR BAGS
The contact owns a 2002 Lexus RX300. The contact stated while driving at various speeds, the air bag warning light flashed on the instrument panel. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not yet diagnosed or repaired. The failure mileage was approximately 190,000.
NHTSA complaint #11613023 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
The system component that malfunctioned was the Fuel Tank Overfill Check Valve, also referred to the Rollover Valve located in the top of the gas tank. The valve is suppose to prevent any fuel purging or fuel leaking during a rollover accident. Unfortunately, the valve can malfunction during normal refueling without the owner being aware. For a few years, I have been smelling fuel fumes during and after refueling. I would sometimes discover a pool of raw fuel under the gas tank and charcoal canister during/after refueling and up to 12 miles later. The vehicle started hesitating, missing and actually stalling after refueling. Three professional mechanics couldn't solve the problem. In an attempt to eliminate this safety issue, I replaced the gas tank, gas filler tube, fuel vapor purge valve and charcoal canister. I finally discovered a tube from the malfunctioning Overfill Valve was sending raw fuel directly to the charcoal canister, filling the charcoal canister and ultimately overflowing onto the ground outside of the vehicle. I decided to cut a hole in the vehicle floor under the rear seat and replace the Fuel Tank Overfill Check Valve. The design of the replacement valve was different from the original and incorporated a float type check valve rather than just the simple diaphragm in the original. Maybe Toyota/Lexus quietly redesigned the valve, but all owners should be aware of the redesign and the vehicles should be recalled. Thousands of these vehicles are still on the road because people love them. These vehicles and the valves are aging and failing. Dangerous fire potential certainly exist. One previous owner did have this problem, I believe, and his vehicle burned to the ground. It's an extreme safety issue not just because of the hesitating/stalling in traffic after refueling, but mostly because of the raw fuel leaking from the charcoal canister under the vehicle right in the immediate vicinity of the hot exhaust and the gas tank.
NHTSA complaint #11439600 — an unverified report by a vehicle owner.
TIRES
4 new tyres were installed by Firestone but driver side wore out despite balancing rotation, alignment performed during install. TyrePlus sister concern replaced with new tyre and prorated as the tyre was at fault. Same tyre blew out on the road. The tread, side all etc damaged the wire harness and car went out of control causing damage to suspension and fuel tank. Fuel began to leak. Car is toatled due to several other damages. TyrePlus does not want to take ownership. However they have all records of up to date maintenance. They referred me to Bridgestone wherein I need to submit 2 estimates. Tyre purchase dates maintenence etc. I have secured the tread and parts of the tyre which blew out and they want me to submit that. I am hesitatnt to submit it as they may tamper with the proof I have to fix it.
NHTSA complaint #11431343 — an unverified report by a vehicle owner.
POWER TRAIN
Transmission wouldnt shift all of the sudden on the high way no prior mechanical issues was t boned and broke my leg abs and trac off lights mechanic says total transmission failure 121000 miles and this is the second owner of this vehicle
NHTSA complaint #11426214 — an unverified report by a vehicle owner.
VEHICLE SPEED CONTROL
Transmission wouldnt shift all of the sudden on the high way no prior mechanical issues was t boned and broke my leg abs and trac off lights mechanic says total transmission failure 121000 miles and this is the second owner of this vehicle
NHTSA complaint #11426214 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
VEHICLES RETRACTABLE ANTENNA STOPPED RETRACTING AND ANTENNA MOTOR CONTINUES TO RUN TRYING TO PULL THE TELESCOPING ANTENNA BACK DOWN. VEHICLE WAS STATIONARY, ENGINE HAD BEEN SHUT DOWN AND KEYS REMOVED, BUT ANTENNA MOTOR KEPT RUNNING.
NHTSA complaint #11307336 — an unverified report by a vehicle owner.
ENGINE
CHECK ENGINE LIGHT KEPT COMING ON. TOOK TO DEALERSHIP AND THEY SAID THEY REPAIRED PROBLEMS. WAS ACCELERATING FROM STOP LIGHT ON BUSY CITY STREET, HIGHWAY FRONTAGE ROAD AND ENGINE DIED IN MIDDLE OF INTERSECTION CAUSING NO POWER OR STEERING AND HAD TO COME/COAST TO FINAL STOP WITH NO POWER OR STEERING CAPABILITIES. ENGINE DIED AND WOULD NOT RESTART. CAR WAS DISABLED UNDER HIGHWAY BRIDGE IN BUSY INTERSECTION. COULD NOT GET IT STARTED. DRIVERS WOULD TURN LEFT FROM THE LIGHT AND ALMOST REAR END ME BECAUSE I WAS DISABLED RIGHT AFTER THE TURN. TURNED OUT TO BE THE INFAMOUS TOYOTA RECALL AND CLASS ACTION LAWSUIT OF ENGINE SLUDGE. PAID $6000 TO REPAIR ALL CAR COMPONENTS AFFECTED BY THE LAWSUIT.
NHTSA complaint #10872278 — an unverified report by a vehicle owner.
POWER TRAIN
I WAS OUT OF TOWN I WAS DRIVING, NOTHING WAS WRONG WITH MY RX AT ALL. IT'S A 2002 LEXUS RX 300, THEN ALL OF THE SUDDEN I GO TO TAKE OFF AT THE STOPLIGHT AND IT WAS HESITATING TO TAKE OFF. MY TRANSMISSION IS NOW COMPLETELY GONE. NO WARNING AT ALL. IF I TAKE MY VEHICLE OVER 35 MPH IS JERKS. TRANSMISSION SLIPS AT STOP LIGHTS, (WITH NO INCLINE). 115000 MILES, AND THE TRANNY GOES OUT. I DO BELIEVE IT HAS BEEN REPLACED BEFORE I PURCHASED THE CAR AS WELL. GREAT JOB LEXUS, NOT. I THOUGHT GOING WITH A LEXUS I WOULD HAVE A QUALITY VEHICLE. MAN WAS I WRONG.
NHTSA complaint #10465713 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
TL* THE CONTACT OWNS A 2002 LEXUS RX. THE CONTACT STATED THAT THE TRANSMISSION GEARS WOULD BECOME STUCK. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS ADVISED THAT THE TRANSMISSION WOULD NEED REPLACING. THE VEHICLE WAS NOT UNDER RECALL. THE MANUFACTURER WAS CONTACTED WHO STATED THAT THEY WOULD CONTACT THE DEALER FOR MORE INFORMATION ON THE FAILURE BEFORE MAKING A DECISION IF THEY COULD ASSIST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000.
NHTSA complaint #10381142 — an unverified report by a vehicle owner.
AIR BAGS:SIDE/WINDOW
A CAR CRASHED INTO SIDE DOOR OF PASSENGER AND SIDE AIR DID NOT INFLATE IN MY 2002 LEXUS RX 300. MY CAR WAS THEN IN A ROLL OVER AND NO OTHER AIR BAGS DEPLOYED INCLUDING THE DRIVER SIDE AIR BAG.
NHTSA complaint #10203605 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
DT*: THE CONTACT STATED THAT WHILE DRIVING AT 5 MPH, THERE WAS A LACK OF RESPONSIVENESS IN THE VEHICLE WHILE DEPRESSING THE ACCELERATOR. THE VEHICLE DID NOT MOVE WHEN THE ACCELERATOR WAS DEPRESSED. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER DETERMINED THAT THE TRANSMISSION HAD FAILED, BUT WAS UNABLE TO DETERMINE THE CAUSE.
NHTSA complaint #10162186 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
VEHICLE WAS PARKED WITH TRANSMISSION IN PARK AND EMERGENCY BRAKE ENGAGED. WHILE UNATTENDED THE VEHICLE STARTED MOVING FORWARD SLOWLY, I (THE DRIVER) JUMPED INTO FRONT SEAT TO APPLY THE FOOT BRAKE AND PEDAL WENT TO FLOOR (NO BRAKES!) VEHICLE COULD NOT BE STOPPED AND RAN IN TO THE WALL OF MY GARAGE.
NHTSA complaint #10157959 — an unverified report by a vehicle owner.