125 of the
1,271 complaints filed about the Lexus RX
are about the braking system —
10% of everything owners reported.
The worst model year for it is 2010.
Brake actuator makes a shriek when I engage the pedal. Problem is ongoing and applies to 2015-2019 Lexus RX450 Hybrid models. Problem is getting worse, and I am afraid of brake failure. Lexus has been repairing this problem, gratis, for owners under their Customer Support Program 23LE04. I contacted Lexus and was told that Hawaii-based Lexus Vehicles are part of the Japan Dealer Network and to contact them. I made an appointment and the car was inspected on April 16, 2026. The outcome was that Lexus of Hawaii/Japan will not repair my vehicle unless I pay $4,000 for a new brake booster pump assembly /labor. Lexus of N. America is covering this repair for 10 years or 150,000 miles, but they refuse to honor it here in Hawaii.
NHTSA complaint #11758069 — an unverified report by a vehicle owner.
Vehicle: 2014 Lexus RX 450h Component: ABS / Brake Actuator System I am submitting this complaint regarding a safety-related brake system defect in my 2014 Lexus RX 450h. The vehicle experienced ABS/brake actuator failure consistent with a known defect that was previously addressed by Lexus/Toyota through a Customer Support Program (extended coverage program, not a recall). I was never notified of this program. I have confirmed that Lexus mailed notification to an incorrect address (Temple City), despite the fact that my vehicle registration address has never changed and has always been accurately maintained with the DMV. As a result, I was deprived of the opportunity to repair a known safety-related defect within the coverage period. Key facts: - Brake/ABS actuator system failure occurred at approximately 150,000 miles - Lexus had previously issued a Customer Support Program for this known defect - No notification was received by me during the coverage period - Lexus confirmed notices were sent to an incorrect address - My DMV registration address has remained unchanged I raised this issue directly with Lexus Customer Assistance, including escalation to a supervisor. Lexus denied goodwill assistance and stated no remedy is available despite the documented notification issue. This raises concerns regarding: - Adequacy of manufacturer notification procedures for safety-related defects - Potential failure to reasonably notify owners using accurate registration data - Loss of repair opportunity for a known braking system defect due to administrative error Because this involves a braking system (critical safety component), I am requesting that NHTSA review whether the notification process used for this defect was adequate and whether other owners may have been similarly affected. Supporting documentation is available, including proof of DMV address history and evidence of incorrect mailing address used by the manufacturer.
NHTSA complaint #11743831 — an unverified report by a vehicle owner.
The contact owns a 2017 Lexus RX450H. The contact stated that while driving at an undisclosed speed and depressing the brake pedal, there was an abnormal sound coming from the vehicle. The vehicle was taken to the dealer to be diagnosed. The vehicle was diagnosed with brake actuator assembly, bleeder plug cap, brake actuator cover, and brake fluid reservoir assembly failures. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 59,380.
NHTSA complaint #11733292 — an unverified report by a vehicle owner.
I am reporting a serious and potentially dangerous braking issue with my 2007 Lexus RX400h. The vehicle currently has approximately 126,296 miles. While driving, the vehicle emits a continuous and intermittent warning beeping sound. At the same time, the braking system becomes unreliable. The brake pedal becomes extremely difficult to press, requiring excessive force, and the vehicle does not respond consistently when braking. In addition, there are instances where the vehicle appears to brake unpredictably or inconsistently, which creates a significant safety hazard for myself, passengers, and other drivers on the road. Based on my research, this issue appears to be related to a known defect involving the ABS brake actuator assembly. Lexus previously issued a warranty enhancement program for this component due to internal malfunctions that affect brake pressure and system performance. However, this issue was not issued as a formal recall tied to VIN eligibility. Despite my vehicle being under 150,000 miles, I have been informed that I may be outside the time-based warranty window, and no active recall is listed for my VIN. This defect directly impacts the braking system, which is a critical safety component. Failures in the brake actuator can lead to improper brake pressure, reduced stopping ability, and increased risk of a crash. Given the safety implications and known history of this defect, I believe this issue warrants further investigation and potential recall consideration. I am submitting this complaint to request that the NHTSA review this matter for safety risk and determine whether broader action is necessary to protect consumers.
NHTSA complaint #11732484 — an unverified report by a vehicle owner.
On April 1, 2026, while pulling into a parking space at our church, I was applying the brake when the vehicle suddenly and forcefully surged forward without warning. The unintended acceleration was intense and unexpected, occurring despite continuous braking input. This resulted in the vehicle striking the building and causing significant damage to both the vehicle and the structure. This incident has occurred twice within a 10 day period, both times during low-speed parking/stopping maneuvers. There were no warning lights, alerts, no automatic emergency braking engagement, no air bag deployment, or prior indications of malfunction. I did report this to the police and they filed an Incident Report. Lexus was notified and an independent analysis engineer examined the data from the vehicle's CDR System. This report was sent to me and to Lexus.
NHTSA complaint #11731649 — an unverified report by a vehicle owner.
While trying to leave my driveway my brakes went out almost causing me to go through a pasture fence. On the dash board popped up ABS and VSC warning. Now the module and regulator is making a horrible sound. And clicks
NHTSA complaint #11731465 — an unverified report by a vehicle owner.
I purchased this vehicle on January 5, 2026, from a family-owned dealership in Broken Arrow, OK. The vehicle was purchased “as-is” with a guarantee of sale and a Carfax report. After purchasing the vehicle, I drove it home and it remained parked until January 8, 2026. On Thursday, January 8, 2026, the vehicle experienced an unexpected engine stall while I was driving. At the same time, the slip indicator light and traction control appeared to engage. I contacted the dealership immediately to report the issue, and the vehicle was towed back to JT Wholesale Auto Sales on Friday, January 9, 2026. On Tuesday, January 13, 2026, I was informed by the dealership that the vehicle had undergone a complete inspection and that no mechanical issues were found. Relying on this representation, I retrieved the vehicle and drove it home. However, after retrieving the vehicle, I continued to have concerns regarding its condition. On Thursday, January 15, 2026, I took the vehicle to Stellar Auto Service located at 2209 N. Yellowood Ave., Broken Arrow, OK 74012 for an independent inspection. Stellar Auto Service specializes in Lexus and Toyota vehicles. During their inspection, they identified the following issues: • Engine timing chain cover leak • Worn drive belt Stellar Auto Service was informed of the slip indicator light activation and the engine stalling that I had experienced. However, at the time of their inspection, they were unable to identify or reproduce any issues related to the slip indicator light or the stalling concern that I reported. On Sunday, February 15, 2026, the slip indicator light illuminated again, and the vehicle stalled while in operation. I was forced to safely pull off the roadway. I turned the car off, waited, restarted the vehicle, and drove home. The same issue occurred again on Sunday, March 8 and 15th, 2026. While driving, the slip indicator light illuminated and the vehicle stalled. I pulled off the road turned the vehicle off, restarted it.
NHTSA complaint #11725110 — an unverified report by a vehicle owner.
The contact owned a 2023 Lexus RX 350. The contact stated that while the vehicle was stopped at a traffic light, it suddenly accelerated without warning. While driving in a parking lot, the vehicle again surged forward approximately 20 feet. The contact was able to swerve to avoid striking a pedestrian. The vehicle became uncontrollable, and the brakes were inoperable. The vehicle ultimately crashed into a dumpster fence, which fell onto the vehicle. The contact sustained injuries to her mouth, including cuts to the inside and outside of her mouth, and medical attention was provided by a plastic surgeon. The fire department responded to the scene. The air bags did not deploy during the crash. There was no fire, and a police report was not filed. The fire department was on the scene. The vehicle was towed to a local dealer; however, the vehicle was not diagnosed or repaired. The insurance company later deemed the vehicle a total loss. The manufacturer has not been notified. The failure occurred at approximately 18,000 miles.
NHTSA complaint #11723281 — an unverified report by a vehicle owner.
I was stopped at a red light with brake on, my vehicle leaped forward on its own three times, with the brake on, the force was so strong I thought someone rear-ended me. No warning lights, the acceleration was load.
NHTSA complaint #11723240 — an unverified report by a vehicle owner.
I was just driving regular and the rx350 started to jerk and apply the breaks by itself and slip and go side ways and the car behind me almost hit me because my Lexus started to stop hard and fast .im pressing the gas but it’s not accelerating.the engine wanted to stop and very dangerous I’m scared to even drive the vehicle.i am the 3rd owner and now i know why the otheer people don’t want it .there is a recall for that problem but im new to the car recalls so im not to shure what to do to get the car repaired .i would like this fix especially because it is a recall .thanks
NHTSA complaint #11718143 — an unverified report by a vehicle owner.
My vehicle is experiencing a mechanical failure of the brake actuator/booster assembly, manifested by a "squawk/bark" noise and abnormal pedal feel during braking. This is a known defect recognized by Lexus under Customer Support Program 23LE04. The dealership technician confirmed the noise is present and recommended a full replacement of the ABS actuator. However, Lexus is denying coverage because the onboard computer has not yet triggered a Diagnostic Trouble Code (DTC). By denying the repair, Lexus is requiring me to operate a vehicle with a confirmed mechanical brake malfunction, which increases the risk of a crash, increased stopping distance, or total brake power assist failure. March 2021 (60k miles): Actuator was replaced under warranty for this exact failure. December 2021 (74k miles): The failure recurred. Lexus and the dealer refused to cover the diagnosis/bleed, forcing me to drive a defective vehicle. February 2026 (110k miles): A Lexus dealer confirmed the part is failing again and quoted $3,000 for replacement. Despite a manufacturer program (CSP 23LE04) existing for this exact part, Lexus refuses to honor it without an electronic code, even though the mechanical failure has been physically confirmed by their own technicians. The component is available for inspection.
NHTSA complaint #11718075 — an unverified report by a vehicle owner.
On Feb. 10th 2026 I was driving north I405 (Los Angeles). The car suddenly applied emergency breaks in the middle of the freeway, while there was no car in front of me, at least for 100m. I was lucky that the car behind me didn't hit me. It could be a serious multi-car collision.
NHTSA complaint #11717700 — an unverified report by a vehicle owner.
The contact owns a 2009 Lexus RX 350. The contact stated that while driving approximately 70 MPH, there was an abnormal sound coming from the engine compartment with the check engine oil warning light illuminated. The failure had occurred on several occasions. The vehicle was taken to an independent mechanic, where it was diagnosed, and it was determined that the oil cooler hose was leaking due to a hole. The vehicle was not repaired. The vehicle was taken to a different independent mechanic, where it was diagnosed and determined that the oil cooler hose was leaking due to a hole. The vehicle was not repaired. A dealer was contacted and informed that there was no recall associated with the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The manufacturer made the contact aware of the Limited Service Campaign Number: LSC9LH. The failure mileage was approximately 190,000.
NHTSA complaint #11716172 — an unverified report by a vehicle owner.
My Lexus 2019 RX450H is making a squishing squeaking brake actuator noise when pressing the brake pedal. I located well publicized TSB’s documenting the awareness by Toyota/Lexus of the problem. (TSB: MC-10245447-9999) Brake Squawk/Knock Noise. I checked with my local Lexus dealership to see if my vehicle had been repaired. It had Not!. Temecula Valley Lexus, 42081 Dealer Drive, Temecula, Ca. 92591. (951)365-6834. I scheduled an appointment for repair on 1/26/26. They rejected making the repair because my vehicle DID NOT have any codes in the computer OR any lights on the dash. They did in fact, confirm the brake actuator noise. I reject that concept because WHO could know ahead of time if a part experiences a (1st time) total failure without throwing codes and turning on dashboard lights? As I read the symptoms of severe problems experienced in a higher level of failure by brake actuators, I would not want to have to experience a crash accident in which the actuator would operate correctly in a hard stop condition or have ABS failure and brake lockup occur. Personal harm and property damage should not have to be an indicator if I can have the manufacturer cover a repair. Please advise What I should do to increase the response in the direction of getting this known problem repaired. Sincerely, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11713697 — an unverified report by a vehicle owner.
Brake system sets a high tone pitch indicating failure accompanied by all Brake, ABS, PS, Traction Control Lights. This is an know failure for Hybrid systems. It can occur completely random, while driving without notice. Complete brake pressure is lost with exception of a hard feel to the pedal that allows some incomplete breaking to occur and can also cause locking of the brakes at slower speeds. We replaced The brake actuator as recommended with factory new in March of 2024 Started much earlier. Problem has returned Summer of 2025.
NHTSA complaint #11710717 — an unverified report by a vehicle owner.
ABS, TRACTION CONTROL, BRAKE LIGHTS & BEEPING SOUND ALL ON. BRAKE PEDAL IS HARD. PEDESTRIANS, OTHER DRIVERS & FAMILY ARE AT RISK DUE TO SAFETY RISK. DIAGNOSIS CODES C1253 - C1256 DURING TEST INDICATES ABS PUMP ASSEMBLY ISSUES. THIS PROBLEM WAS NOTICED BY ME IN LATE AUGUST 2025.
NHTSA complaint #11693944 — an unverified report by a vehicle owner.
Heard clicking noise coming from steering wheel. Car shimmied when breaking off of freeway. Newish car, only 20,611 miles. Took into dealership before anything went awry. Dealership said never heard of the steering problem before. Turned out it was a tie rod going bad and repair was covered by warranty. Break issue was also covered by warranty.
NHTSA complaint #11693872 — an unverified report by a vehicle owner.
2025 Lexus RX
at 106 milesRancho Cucamonga, CACrash1 injured
SERVICE BRAKES
The contact owns a 2025 Lexus RX 350. The contact stated that while driving into a parking space, the vehicle suddenly experienced unintended acceleration and drove forward at a high rate of speed before crashing into the brick wall of an office building. During the crash, no air bags deployed, and the brake pedal was hard when pressed and did not stop the vehicle. Also, the manufacturer's APP indicated a malfunction in the engine and engine throttle during the incident. The driver sustained injuries to the knees, arms, and hips, which required medical treatment. An incident report was filed by the facility Patrol Officer, and the vehicle was towed to the collision center. The cause of the failures was not determined. The manufacturer and local dealer were notified of the incident. An engineer from the manufacturer was sent to examine the vehicle and reported no trouble found. The contact indicated that upon delivery of the vehicle, several electronic features did not function properly, including the display and navigation screen. The manufacturer and local dealer were notified of the failure. The failure mileage was 106.
NHTSA complaint #11690554 — an unverified report by a vehicle owner.