Owners have filed 11 complaints
about the 2020 Mini Cooper with NHTSA between 2020 and 2026.
The largest single group is the airbags.
Across this model's run it ranks 17 of 19 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 4
Against the median year of the Mini Cooper. 50 means typical for this
model; 100 means roughly double.
Severity — 100
45.5% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — not reported
Too few complaints recorded a mileage to measure this.
Complaints filed with NHTSA, by model year. Bar colour is the FaultScore grade:
A
B
C
D
F
ungraded
What breaks on a 2020 Mini Cooper
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
Airbags
327.3%
3 crashes, 0 fires
Electrical System
218.2%
Driver Assist & Collision Avoidance
19.1%
Windows, Mirrors & Wipers
19.1%
Fuel & Propulsion
19.1%
Brakes
19.1%
Steering
19.1%
Transmission & Drivetrain
19.1%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jun 2020peak 3Feb 2026
Complaints that involved harm
Reports where the owner recorded a crash, a fire, an injury or a death.
Los Angeles, CACrash1 injured
AIR BAGS
A driver drove head on into my drivers seat door hard enough that his front bumper completely detached from his car and my door could not open, close, or lock, and my car was not drivable. My car has side airbags. No airbag deployed. I had to go to the hospital immediately after the accident. There is no open recall on my 2020 Mini 2 door hardtop. Shouldn't an airbag have deployed?
NHTSA complaint #11719915 — an unverified report by a vehicle owner.
Beaufort, SCCrash
AIR BAGS
Run out of lane over raised median hit 2 road signs head on they flew over the car into opposite side of traffic and into a ditch at 45mph. Airbags did not deploy despite broken frame, collapsed suspension, all 4 no flat tires were flat and front end damage.
NHTSA complaint #11513759 — an unverified report by a vehicle owner.
Los Angeles, CACrash1 injured
AIR BAGS
I was stopped at a red light. A Buick SUV traveling at an admitted 65mph rear ended me and pushed my car into the car in front of me. My seatbelt was on. My head hit the steering wheel resulting in a massive brain bleed. I have ruptured and herniated disks and severe whiplash as well as a fractured skull. My airbag did not deploy although My car was announcing a loud message over the speakers “we have alerted emergency services”. I can’t find a lawyer to take the case because there hasn’t been a recall on this year yet. It was a 2020 Mini Cooper S.
NHTSA complaint #11461923 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Los Angeles, CACrash1 injured
AIR BAGS
A driver drove head on into my drivers seat door hard enough that his front bumper completely detached from his car and my door could not open, close, or lock, and my car was not drivable. My car has side airbags. No airbag deployed. I had to go to the hospital immediately after the accident. There is no open recall on my 2020 Mini 2 door hardtop. Shouldn't an airbag have deployed?
NHTSA complaint #11719915 — an unverified report by a vehicle owner.
Houston, TX
POWER TRAIN
Originally problem started with a about five warning messages, a brake system one, a chassis stabilization one, Collision warning one, pedestrian warning one, and a drive train message. They were would appear while drive at any speed but, would go away after the car was shut off and restarted. A couple of months later the car started to shut off and put itself in park while driving, this problem has occurred multiple times and at speeds around 30mph. I started trying to get this fixed by a dealership in December of 2023. It went in and out a couple of times before they were able to replicate the problem. First they replaced the EME module and that worked for about 2000 miles before it started acting up again. Took it back to the same dealership in April when it started acting up. They updated the EME software and replaced a high voltage connector that was corroded. This repair took them until July 2nd. I went to pick up the car and made it about 3 blocks from the dealership it shut itself off on me. Took it back right away. They have had the car since then. Lastly I informed them about the most recent recall back on august 29th and it still shows as incomplete.
NHTSA complaint #11622035 — an unverified report by a vehicle owner.
Houston, TX
ELECTRICAL SYSTEM
Originally problem started with a about five warning messages, a brake system one, a chassis stabilization one, Collision warning one, pedestrian warning one, and a drive train message. They were would appear while drive at any speed but, would go away after the car was shut off and restarted. A couple of months later the car started to shut off and put itself in park while driving, this problem has occurred multiple times and at speeds around 30mph. I started trying to get this fixed by a dealership in December of 2023. It went in and out a couple of times before they were able to replicate the problem. First they replaced the EME module and that worked for about 2000 miles before it started acting up again. Took it back to the same dealership in April when it started acting up. They updated the EME software and replaced a high voltage connector that was corroded. This repair took them until July 2nd. I went to pick up the car and made it about 3 blocks from the dealership it shut itself off on me. Took it back right away. They have had the car since then. Lastly I informed them about the most recent recall back on august 29th and it still shows as incomplete.
NHTSA complaint #11622035 — an unverified report by a vehicle owner.
Houston, TX
FUEL/PROPULSION SYSTEM
Originally problem started with a about five warning messages, a brake system one, a chassis stabilization one, Collision warning one, pedestrian warning one, and a drive train message. They were would appear while drive at any speed but, would go away after the car was shut off and restarted. A couple of months later the car started to shut off and put itself in park while driving, this problem has occurred multiple times and at speeds around 30mph. I started trying to get this fixed by a dealership in December of 2023. It went in and out a couple of times before they were able to replicate the problem. First they replaced the EME module and that worked for about 2000 miles before it started acting up again. Took it back to the same dealership in April when it started acting up. They updated the EME software and replaced a high voltage connector that was corroded. This repair took them until July 2nd. I went to pick up the car and made it about 3 blocks from the dealership it shut itself off on me. Took it back right away. They have had the car since then. Lastly I informed them about the most recent recall back on august 29th and it still shows as incomplete.
NHTSA complaint #11622035 — an unverified report by a vehicle owner.
Fairfield, CT
STEERING
When I plugged my phone cord into the USB port on the Click and Drive while the car was on but stationary, the screen indicated that the stabilization system was resetting. I promptly unplugged the cord and notifications started popping up on the screen. There were 4: steering assist not working, drive with care; stability control not working, drive with care; front collision detector not working; I do not recall the fourth notice. I was parked at a Starbucks 2+ hours from home so decided to try driving around parking lot hoping to continue journey. The steering was inoperable and all I could do was pull straight out of parking space and go straight back in. Turned car off, waited about 5 minutes and turned car back on, no change, no steering. Waited 3 hours for AAA tow and finally impatient, tried turning car on again. All notices cleared and I drove car home without incident (150 miles). My local Mini dealer said it was a wiring issue and they fixed it. Salesman at same dealer, who sold me the car 9 days before the incident, admitted he had heard of similar incident with Click and Drive once before, about a year ago. If I had plugged the cord in while I was driving I would likely have been unable to control the car in motion.
NHTSA complaint #11542290 — an unverified report by a vehicle owner.
Fairfield, CT
ELECTRICAL SYSTEM
When I plugged my phone cord into the USB port on the Click and Drive while the car was on but stationary, the screen indicated that the stabilization system was resetting. I promptly unplugged the cord and notifications started popping up on the screen. There were 4: steering assist not working, drive with care; stability control not working, drive with care; front collision detector not working; I do not recall the fourth notice. I was parked at a Starbucks 2+ hours from home so decided to try driving around parking lot hoping to continue journey. The steering was inoperable and all I could do was pull straight out of parking space and go straight back in. Turned car off, waited about 5 minutes and turned car back on, no change, no steering. Waited 3 hours for AAA tow and finally impatient, tried turning car on again. All notices cleared and I drove car home without incident (150 miles). My local Mini dealer said it was a wiring issue and they fixed it. Salesman at same dealer, who sold me the car 9 days before the incident, admitted he had heard of similar incident with Click and Drive once before, about a year ago. If I had plugged the cord in while I was driving I would likely have been unable to control the car in motion.
NHTSA complaint #11542290 — an unverified report by a vehicle owner.
Fairfield, CT
FORWARD COLLISION AVOIDANCE: WARNINGS
When I plugged my phone cord into the USB port on the Click and Drive while the car was on but stationary, the screen indicated that the stabilization system was resetting. I promptly unplugged the cord and notifications started popping up on the screen. There were 4: steering assist not working, drive with care; stability control not working, drive with care; front collision detector not working; I do not recall the fourth notice. I was parked at a Starbucks 2+ hours from home so decided to try driving around parking lot hoping to continue journey. The steering was inoperable and all I could do was pull straight out of parking space and go straight back in. Turned car off, waited about 5 minutes and turned car back on, no change, no steering. Waited 3 hours for AAA tow and finally impatient, tried turning car on again. All notices cleared and I drove car home without incident (150 miles). My local Mini dealer said it was a wiring issue and they fixed it. Salesman at same dealer, who sold me the car 9 days before the incident, admitted he had heard of similar incident with Click and Drive once before, about a year ago. If I had plugged the cord in while I was driving I would likely have been unable to control the car in motion.
NHTSA complaint #11542290 — an unverified report by a vehicle owner.
Beaufort, SCCrash
AIR BAGS
Run out of lane over raised median hit 2 road signs head on they flew over the car into opposite side of traffic and into a ditch at 45mph. Airbags did not deploy despite broken frame, collapsed suspension, all 4 no flat tires were flat and front end damage.
NHTSA complaint #11513759 — an unverified report by a vehicle owner.
Oyster Bay, NY
SERVICE BRAKES
At 15,000 miles, front brake pads and rotors were badly worn and rear brake pads. Replaced brake pads front and rear.
NHTSA complaint #11500592 — an unverified report by a vehicle owner.
Los Angeles, CACrash1 injured
AIR BAGS
I was stopped at a red light. A Buick SUV traveling at an admitted 65mph rear ended me and pushed my car into the car in front of me. My seatbelt was on. My head hit the steering wheel resulting in a massive brain bleed. I have ruptured and herniated disks and severe whiplash as well as a fractured skull. My airbag did not deploy although My car was announcing a loud message over the speakers “we have alerted emergency services”. I can’t find a lawyer to take the case because there hasn’t been a recall on this year yet. It was a 2020 Mini Cooper S.
NHTSA complaint #11461923 — an unverified report by a vehicle owner.
North Bethesda, MD
VISIBILITY:SUN/MOON ROOF ASSEMBLY
TL* THE CONTACT OWNS A 2020 MINI COOPER. THE CONTACT STATED THE WHILE DRIVING AT 55 TO 60 MPH, THE VEHICLE SUNROOF GLASS EXPLODED WITHOUT IMPACT. NO INJURIES WERE SUSTAINED. THE CONTACT DROVE THE VEHICLE TO THE RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO BE INSPECTED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS NOT AVAILABLE. THE VIN WAS NOT AVAILABLE.
NHTSA complaint #11327954 — an unverified report by a vehicle owner.