2020 Nissan Titan problems

ENGINE

The contact owns a 2020 Nissan Titan. The contact stated that while driving at an undisclosed speed, the vehicle intermittently stalled; the contact waited several minutes for the vehicle to return to normal operation. The Check Engine warning light was illuminated. The failure had occurred on several occasions. The contact researched and was made aware of an unknown recall; however, the VIN was not under recall. The vehicle was taken to a dealer where it was diagnosed and determined that the fuel temperature valve needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was taken back to the dealer where it was diagnosed and determined that the radiator needed to be flushed and refilled. The vehicle was repaired; however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 85,000.

NHTSA complaint #11745630 — an unverified report by a vehicle owner.

SUSPENSION

Unknown, vehicle was purchased from Insurance Auto Auctions with minor front collision damage that occurred in the State of Georgia. Suspension damage was not revealed until vehicle was delivered by a transporter to my home. Upon inspection of the vehicle it was determined that the McPherson shock absorber was defective and broke in 2 pieces causing the release of the spring tension. The Nissan manufacturing defect occurred in the factory welds of the upper strut tower support in that the welds of the shock tower never fused with the vehicle chassis which caused the rupture of the entire upper right front suspension.

NHTSA complaint #11742246 — an unverified report by a vehicle owner.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

The Rear Automatic Braking (RAB) software fails to detect a connected trailer harness. The truck experiences un-commanded, sudden emergency braking during multi-point turns when going from forward to reverse when manueverimg a trailer, creating an immediate hazard of neck injury, trailer jackknifing on public roadways or loss of control. this is on a truck that has a brake controller for trailers, the truck knows a trailer is hooked up but repeatedly turns the RAB back on after it driver disables it, furthermore the truck does not have a driver configuration option in settings to permanently disable these features but rather has a temporary button on the center console which resets every time the truck goes from forward to reverse.

NHTSA complaint #11740235 — an unverified report by a vehicle owner.

POWER TRAIN

After replacing the truck frame and one day after returning the truck to me the transmission slipped out of gear while driving 75mph on the freeway. While attempting to brake the transmission seemed to lock up. When I slowed the truck down enough I hit the brakes and shifted the transmission into park. By doing this I was able to stop before hitting other vehicles and a guard rail. Nissan replaced the transmission. After several test drives they replaced the second transmission because of shifting problems. The current transmission just recently would not shift into second gear. I’ll be taking it back Monday. In short my transmission has been replaced twice in a months time and is going back to the dealership for additional repairs.

NHTSA complaint #11676077 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Peoria Nissan found a bad weld at the right front strut tower. The weld failed causing a crack in the frame. As a result the entire frame required replacement. Nissan refuses to offer any warranty other than a one year parts warranty for the frame beyond the original manufactures warranty which ends August 2025. Two service advisors advised me they have seen three frames fail in the same area at their dealership.

NHTSA complaint #11676076 — an unverified report by a vehicle owner.

POWER TRAIN

The issues I'm experiencing with this vehicle is delayed pedal response and a whole slew of transmission problems. There are no codes or check engine lights on. When coming to a stop and the vehicle downshifts you can visibly see the RPMs go up with each down shift and sometimes the downshift is so harsh going to 1st gear that it feels like another vehicle has bumped me from behind causing the truck to jerk forward and make a clunking sound. There is also a problem when upshifting where the RPMs will jump up before shifting into the next gear. I had a situation where I was turning left on a green light with traffic coming and had plenty of time to make it but when I rolled out into the intersection and hit the gas nothing happened for over 2 seconds. The RPMs didn't move and when I pressed the gas harder the vehicle went into a low gear and the RPMs shot up to about 5000 RPMs and accelerated rapidly to just miss an incoming vehicle. Vehicle has inconsistent shifting where it shifts ok one day and other days it acts erratically. I have been to two different dealerships and both say the truck drives as designed. I have had all the software updates done on this truck that were supposed to correct these issues but they have not helped. I opened up a case with Nissan support and they admitted these transmission problems were being addressed by their engineering team and a new software update would be available some point in the future, this was a year ago.

NHTSA complaint #11639611 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The issues I'm experiencing with this vehicle is delayed pedal response and a whole slew of transmission problems. There are no codes or check engine lights on. When coming to a stop and the vehicle downshifts you can visibly see the RPMs go up with each down shift and sometimes the downshift is so harsh going to 1st gear that it feels like another vehicle has bumped me from behind causing the truck to jerk forward and make a clunking sound. There is also a problem when upshifting where the RPMs will jump up before shifting into the next gear. I had a situation where I was turning left on a green light with traffic coming and had plenty of time to make it but when I rolled out into the intersection and hit the gas nothing happened for over 2 seconds. The RPMs didn't move and when I pressed the gas harder the vehicle went into a low gear and the RPMs shot up to about 5000 RPMs and accelerated rapidly to just miss an incoming vehicle. Vehicle has inconsistent shifting where it shifts ok one day and other days it acts erratically. I have been to two different dealerships and both say the truck drives as designed. I have had all the software updates done on this truck that were supposed to correct these issues but they have not helped. I opened up a case with Nissan support and they admitted these transmission problems were being addressed by their engineering team and a new software update would be available some point in the future, this was a year ago.

NHTSA complaint #11639611 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

from day one, it has had a hesitation on acceleration from both still and moving normal highway speeds. rarely is acceleration steady, smooth and immediate. dealer has had for regular oil change and this problem has been reported every time . answer was that factory recall was performed and should be better. but NO. over a year now, several visits and nothing resolved. a couple times when i needed that immediate acceleration but with severe hesitation and a semi truck hitting his brakes and blowing horn i would call it a safety problem. im not sure what work was preformed, assuming most time transmission but after research on computer there have been nissans with engine components causing this. please help. where do i go from here?

NHTSA complaint #11532702 — an unverified report by a vehicle owner.

ENGINE

from day one, it has had a hesitation on acceleration from both still and moving normal highway speeds. rarely is acceleration steady, smooth and immediate. dealer has had for regular oil change and this problem has been reported every time . answer was that factory recall was performed and should be better. but NO. over a year now, several visits and nothing resolved. a couple times when i needed that immediate acceleration but with severe hesitation and a semi truck hitting his brakes and blowing horn i would call it a safety problem. im not sure what work was preformed, assuming most time transmission but after research on computer there have been nissans with engine components causing this. please help. where do i go from here?

NHTSA complaint #11532702 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

from day one, it has had a hesitation on acceleration from both still and moving normal highway speeds. rarely is acceleration steady, smooth and immediate. dealer has had for regular oil change and this problem has been reported every time . answer was that factory recall was performed and should be better. but NO. over a year now, several visits and nothing resolved. a couple times when i needed that immediate acceleration but with severe hesitation and a semi truck hitting his brakes and blowing horn i would call it a safety problem. im not sure what work was preformed, assuming most time transmission but after research on computer there have been nissans with engine components causing this. please help. where do i go from here?

NHTSA complaint #11532702 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2020 Nissan Titan. The contact received notification of NHTSA Campaign Number: 22V671000 (Power Train) and 22V457000 (Power Train) however, the parts to do the recall repairs were not yet available. The vehicle was taken to the local dealer, for a routine recall repair where it was diagnosed that the transfer case needed to be replaced. The vehicle was not repaired. The mechanic informed the contact the repair would be at her expense. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA complaint #11521211 — an unverified report by a vehicle owner.

POWER TRAIN

When driving under normal road conditions and slowing down to stop at a light or stop sign the transmission shifts down abruptly to 1st gear and lunges forward like you have been hit in the rear end. Been doing this since new and dealer cannot diagnose or repair the issue. Seems common on these new Titans. Just had to adjust my driving habit to keep on the brakes as slowing down to a stop.

NHTSA complaint #11501324 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS:HIGH/LOW BEAM DIMMER SWITCH

The contact owns a 2020 Nissan Titan. The contact stated while driving 45 MPH on a dark roadway, the automatic high-beam headlights failed to activate as needed. The contact was able to manually activate the high-beam headlights. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 24,000.

NHTSA complaint #11498670 — an unverified report by a vehicle owner.

POWER TRAIN

The problem I am writing about concerns this vehicle and recall #PC773 EGI HARNESS. Reference must also be made to Nissan #NTB20-89 dated December 8, 2020. I purchased this vehicle from Bates Nissan (5501 East Central Texas Expressway, Killeen TX 76543, 254-781-3837) on February 18, 2021 used with 5448 miles. I was told that it had been owned by an employee at the dealership. It is my understanding, as described in NTB20-89, that a Nissan initiated "stop sale" was put into effect in December of 2020. However, Bates Nissan failed to complete this recall prior to selling it to me and did not inform me that there was an open recall on this vehicle. On July 22, 2022 I had a Nissan dealer (LeBrun Nissan, 396 Grant Ave, Auburn NY 13021, 315-253-7700) attempt to perform this recall. The technician did not find any evidence of visible damage on or near the transmission power wires OEM splice, however step 25's "continuity test" of the transmission power wire failed. I am a highly skilled engineer and have reviewed NTB20-89, and find that the transmission power wire continuity test to battery ground is flawed for the following reasons. 1) The process does not isolate (disconnect all ends) the transmission power wire. Therefore, it quite likely that some DVOM's will show continuity to battery ground causing a false positive. 2) Since the recall is to determine if this wires insulation has failed, a continuity test is not appropriate since it cannot measure the integrity of the wire insulation. Therefore, this test could also test as a false negative and allow vehicles to return to service with insulation that is still compromised/weak. Instead, an insulation dielectric test should be performed on this wire. Issue #2 is concerning, since vehicle safety may be at risk and is the primary reason I am informing NHTSA. My hope is that NHTSA has technical people that can review NTB20-89 and discuss with Nissan. I have no confidence that Nissan can fix this issue.

NHTSA complaint #11489979 — an unverified report by a vehicle owner.

POWER TRAIN

Please also reference NTB21-028, NTB21-073. The failed system appears to be the engine/transmission power control. My safety and passenger safety was at risk. A dealer did inspect in May of 2021 and was not able to duplicate and did not perform any corrective action. The problem is twofold. First the vehicle can fail to accelerate during a rolling stop (i.e. entrance into a traffic circle) and because there is no power can roll slowly into oncoming traffic. Second, the vehicle can shift erratically and is slow to shift into the next gear (high RPM before shifting) and can sometimes flair during shifting. I am now aware that Nissan is and has been aware of this issue however this issue is not currently identified as a recall. Bottom line, I think the hesitation/delayed acceleration is a safety issue and wanted to be sure the NHTSA is informed. Thank you

NHTSA complaint #11490010 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

Please also reference NTB21-028, NTB21-073. The failed system appears to be the engine/transmission power control. My safety and passenger safety was at risk. A dealer did inspect in May of 2021 and was not able to duplicate and did not perform any corrective action. The problem is twofold. First the vehicle can fail to accelerate during a rolling stop (i.e. entrance into a traffic circle) and because there is no power can roll slowly into oncoming traffic. Second, the vehicle can shift erratically and is slow to shift into the next gear (high RPM before shifting) and can sometimes flair during shifting. I am now aware that Nissan is and has been aware of this issue however this issue is not currently identified as a recall. Bottom line, I think the hesitation/delayed acceleration is a safety issue and wanted to be sure the NHTSA is informed. Thank you

NHTSA complaint #11490010 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The problem I am writing about concerns this vehicle and recall #PC773 EGI HARNESS. Reference must also be made to Nissan #NTB20-89 dated December 8, 2020. I purchased this vehicle from Bates Nissan (5501 East Central Texas Expressway, Killeen TX 76543, 254-781-3837) on February 18, 2021 used with 5448 miles. I was told that it had been owned by an employee at the dealership. It is my understanding, as described in NTB20-89, that a Nissan initiated "stop sale" was put into effect in December of 2020. However, Bates Nissan failed to complete this recall prior to selling it to me and did not inform me that there was an open recall on this vehicle. On July 22, 2022 I had a Nissan dealer (LeBrun Nissan, 396 Grant Ave, Auburn NY 13021, 315-253-7700) attempt to perform this recall. The technician did not find any evidence of visible damage on or near the transmission power wires OEM splice, however step 25's "continuity test" of the transmission power wire failed. I am a highly skilled engineer and have reviewed NTB20-89, and find that the transmission power wire continuity test to battery ground is flawed for the following reasons. 1) The process does not isolate (disconnect all ends) the transmission power wire. Therefore, it quite likely that some DVOM's will show continuity to battery ground causing a false positive. 2) Since the recall is to determine if this wires insulation has failed, a continuity test is not appropriate since it cannot measure the integrity of the wire insulation. Therefore, this test could also test as a false negative and allow vehicles to return to service with insulation that is still compromised/weak. Instead, an insulation dielectric test should be performed on this wire. Issue #2 is concerning, since vehicle safety may be at risk and is the primary reason I am informing NHTSA. My hope is that NHTSA has technical people that can review NTB20-89 and discuss with Nissan. I have no confidence that Nissan can fix this issue.

NHTSA complaint #11489979 — an unverified report by a vehicle owner.

ENGINE

The problem I am writing about concerns this vehicle and recall #PC773 EGI HARNESS. Reference must also be made to Nissan #NTB20-89 dated December 8, 2020. I purchased this vehicle from Bates Nissan (5501 East Central Texas Expressway, Killeen TX 76543, 254-781-3837) on February 18, 2021 used with 5448 miles. I was told that it had been owned by an employee at the dealership. It is my understanding, as described in NTB20-89, that a Nissan initiated "stop sale" was put into effect in December of 2020. However, Bates Nissan failed to complete this recall prior to selling it to me and did not inform me that there was an open recall on this vehicle. On July 22, 2022 I had a Nissan dealer (LeBrun Nissan, 396 Grant Ave, Auburn NY 13021, 315-253-7700) attempt to perform this recall. The technician did not find any evidence of visible damage on or near the transmission power wires OEM splice, however step 25's "continuity test" of the transmission power wire failed. I am a highly skilled engineer and have reviewed NTB20-89, and find that the transmission power wire continuity test to battery ground is flawed for the following reasons. 1) The process does not isolate (disconnect all ends) the transmission power wire. Therefore, it quite likely that some DVOM's will show continuity to battery ground causing a false positive. 2) Since the recall is to determine if this wires insulation has failed, a continuity test is not appropriate since it cannot measure the integrity of the wire insulation. Therefore, this test could also test as a false negative and allow vehicles to return to service with insulation that is still compromised/weak. Instead, an insulation dielectric test should be performed on this wire. Issue #2 is concerning, since vehicle safety may be at risk and is the primary reason I am informing NHTSA. My hope is that NHTSA has technical people that can review NTB20-89 and discuss with Nissan. I have no confidence that Nissan can fix this issue.

NHTSA complaint #11489979 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Please also reference NTB21-028, NTB21-073. The failed system appears to be the engine/transmission power control. My safety and passenger safety was at risk. A dealer did inspect in May of 2021 and was not able to duplicate and did not perform any corrective action. The problem is twofold. First the vehicle can fail to accelerate during a rolling stop (i.e. entrance into a traffic circle) and because there is no power can roll slowly into oncoming traffic. Second, the vehicle can shift erratically and is slow to shift into the next gear (high RPM before shifting) and can sometimes flair during shifting. I am now aware that Nissan is and has been aware of this issue however this issue is not currently identified as a recall. Bottom line, I think the hesitation/delayed acceleration is a safety issue and wanted to be sure the NHTSA is informed. Thank you

NHTSA complaint #11490010 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

The EVAP Canister and Control Valve clogs with road dust/dirt. Fuel vapors have nowhere to exits the system and fuel will overflow when fueling the vehicle. Fuel vapors have no way to exit the tank when the fuel cap is in place, creating an over pressure. This condition exist on previous year models and Nissan has made recalls and fixes available.

NHTSA complaint #11487836 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I the last 6 months the truck has the TCM replaced after leaving me stranded on the side of the road. prior to completely going out the two dealers that looked at the truck said there was nothing wrong. the truck has had to be towed in three times to clear the transmission because it thinks it in park. This does not include the multilabel times of having to pulling off the road to shut the truck to reset the transmission. The high pressure fuel pump has gone out then five weeks later the low pressure fuel pump went out. Now a week later the IPDM went out.

NHTSA complaint #11478094 — an unverified report by a vehicle owner.