1997 Plymouth Voyager brake problems

SERVICE BRAKES, HYDRAULIC

AFTER STARTING VEHICLE, STEPPED ON BRAKE PEDAL, PEDAL WENT TO FLOOR. LEAK WAS AT CORRODED PORTION OF REAR STEEL BRAKE LINE. FORTUNATELY, FAILURE OCCURRED BEFORE SHIFTING INTO GEAR. THIS WAS SECOND OCCURRENCE OF CORRODED STEEL BRAKE LINE. FIRST OCCURRENCE WAS 1 YEAR AGO. BOTH FAILURES OCCURRED WHILE IN DRIVEWAY BEFORE SHIFTING INTO GEAR. PRETTY LUCKY!

NHTSA complaint #10435209 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

AFTER STARTING VEHICLE, STEPPED ON BRAKE PEDAL, PEDAL WENT TO FLOOR. LEAK WAS AT CORRODED PORTION OF FRONT STEEL BRAKE LINE. FORTUNATELY, FAILURE OCCURRED BEFORE SHIFTING INTO GEAR.

NHTSA complaint #10435206 — an unverified report by a vehicle owner.

SERVICE BRAKES, ELECTRIC

CONSUMER STATES OF HAVING PROBLEMS WITH AIR BAG LIGHT ON AND THE HORN AND THE CRUISE CONTROL DON'T WORK. DEALER WAS NOT CONTACTED. TS

NHTSA complaint #8021808 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

CONSUMER STATES THAT WHILE DRIVING AND NO WARNING IF BRAKES ARE APPLIED THE SEAT BELT WILL NOT LOCK UP AND THIS CAN CAUSE INJURIES TO THE CONSUMER TO THE IF IN A VEHICLE ACCIDENT. DEALER NOTIFIED. MR

NHTSA complaint #8021139 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

WHILE DRIVING ABOUT ANY MPH COULD STEP ON BRAKE PEDAL TO REDUCE SPEED OR TO STOP VEHICLE, BUT THE PEDAL WILL GO ALWAYS TO THE FLOOR, AND BRAKES WILL NOT WORK SOMETIMES. PLEASE PROVIDE MORE INFORMATION.

NHTSA complaint #8001719 — an unverified report by a vehicle owner.

SERVICE BRAKES, AIR:ANTILOCK

THE BRAKES ON MY VEHICLE HAVE GONE OUT 6 TIMES. THE INITIAL TIME WAS AT 30,000 MILES AND EVERY 10,000 MILES SINCE THEN. EACH TIME THE MECHANICS HAVE LOOKED FUTHER AND FURTHER INTO THE PROBLEM AND HAVE NOW DISCOVERED IT IS THE STEERIING KNUCKLE THAT LOCKS THE CALIPER AND BRAKE PAD INTO THE KNUCKLE. IT BRAKE PAD GRINDS INTO THE KNUCKLE CAUSING PITS INTO THE MEDAL OF THE KNUCKLE AND BRAKE PADS WORN OUT EVERY 10,000 MILES. THESE ARE WARRANTY COVERED PARTS THAT WILL BE REPLACED BY THE WARRANTY COMPANY IF THEY ARE GIVE A REASON FOR THIS DEFECT AND DEFECT IS CAUSED BY A COVERED PART. THE DEALER CANNOT EXPLAIN WHAT IS CAUSING THE PROBLEM. CHRYSLER CORPORATION HAS BEEN INFORMED AND THEY WILL NOT GET INVOLVED BECAUSE THE CAR WAS NOT FIXED AT THE CHRYSLER DEALER EVERY TIME. THE WARRANTY COMPANY ADVISED ME THAT THIS COULD BE A DESIGN FLAW WITH MY PARTICULAR VECHICLE AND THAT CHRYSLER SHOULD GET OUT THER TO LOOK AT THE VEHICLE.

NHTSA complaint #753651 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

THE BRAKES ON MY VEHICLE HAVE GONE OUT 6 TIMES. THE INITIAL TIME WAS AT 30,000 MILES AND EVERY 10,000 MILES SINCE THEN. EACH TIME THE MECHANICS HAVE LOOKED FUTHER AND FURTHER INTO THE PROBLEM AND HAVE NOW DISCOVERED IT IS THE STEERIING KNUCKLE THAT LOCKS THE CALIPER AND BRAKE PAD INTO THE KNUCKLE. IT BRAKE PAD GRINDS INTO THE KNUCKLE CAUSING PITS INTO THE MEDAL OF THE KNUCKLE AND BRAKE PADS WORN OUT EVERY 10,000 MILES. THESE ARE WARRANTY COVERED PARTS THAT WILL BE REPLACED BY THE WARRANTY COMPANY IF THEY ARE GIVE A REASON FOR THIS DEFECT AND DEFECT IS CAUSED BY A COVERED PART. THE DEALER CANNOT EXPLAIN WHAT IS CAUSING THE PROBLEM. CHRYSLER CORPORATION HAS BEEN INFORMED AND THEY WILL NOT GET INVOLVED BECAUSE THE CAR WAS NOT FIXED AT THE CHRYSLER DEALER EVERY TIME. THE WARRANTY COMPANY ADVISED ME THAT THIS COULD BE A DESIGN FLAW WITH MY PARTICULAR VECHICLE AND THAT CHRYSLER SHOULD GET OUT THER TO LOOK AT THE VEHICLE.

NHTSA complaint #753651 — an unverified report by a vehicle owner.

PARKING BRAKE:CONVENTIONAL

VEHICLE EXPERIENCING PROBLEM WITH PARKING BRAKE NOT HOLDING OR JUMPING OUT OF GEAR WHEN ENGAGED. DEALER/MANUFACTURER WERE NOT NOTIFIED AT THIS TIME.

NHTSA complaint #878347 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

WHILE DRIVING 60 MPH THROTTLE CABLE BROKE. BRAKES FAILED TO STOP VEHICLE. VEHICLE WAS PUT INTO NEUTRAL, AND THE EMERGENCY BRAKE WAS APPLIED TO GAIN CONTROL OF VEHICLE. PLEASE GAVE ANY FURTHER DETAILS.

NHTSA complaint #876221 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

WHILE VEHICLE WAS BEING DRIVEN AIR BAGS DEPLOYED WITHOUT A COLLISION OCCURRING, CAUSE UNKNOWN. ALSO, IN RAINY WEATHER CONDITIONS WATER ENTERS VEHICLE FROM DASH AREA, CAUSING ELECTRICAL SHORTAGE. *AK THE WINDSHIELD WIPER HAD NO GASKET ALONG BOTTON. TIRE TREAD SEPARATED WHILE TRAVELING. FOUR SETS OF BRAKE PADS AND TWO SETS OF ROTORS FAILE IN TWO YEARS PERIOD.

NHTSA complaint #874637 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

WHILE VEHICLE WAS BEING DRIVEN AIR BAGS DEPLOYED WITHOUT A COLLISION OCCURRING, CAUSE UNKNOWN. ALSO, IN RAINY WEATHER CONDITIONS WATER ENTERS VEHICLE FROM DASH AREA, CAUSING ELECTRICAL SHORTAGE. *AK THE WINDSHIELD WIPER HAD NO GASKET ALONG BOTTON. TIRE TREAD SEPARATED WHILE TRAVELING. FOUR SETS OF BRAKE PADS AND TWO SETS OF ROTORS FAILE IN TWO YEARS PERIOD.

NHTSA complaint #874637 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:SHOES/LININGS

HEARD A NOISE WHILE DRIVING. TOOK VEHICLE TO LOCAL MECHANIC AND WAS TOLD THAT REAR BRAKE SHOES HAD WORN OUT COMPLETELY AND GOUGED INTO THE DRUMS. HAD IT REPAIRED.

NHTSA complaint #865532 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

CONSUMER TOOK CAR INTO DEALER FOR A SQUEAK. MECHANIC NOTICED THAT THE ROTORS WERE HEAT STRUCK AND PITTED. THEY WERE NOT ABLE TO FIX THE ROTORS, THEY HAD TO REPLACE THEM. ROTORS ON JEEPS FROM 96-99 HAD BEEN RECALLED, POSSIBLE THAT THESE CHRYSLER ROTORS MIGHT BE DEFECTIVE ALSO. *AK

NHTSA complaint #863705 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

DEALER STATED THAT ROTORS WERE RUSTY AND PITTED. YET THE BRAKE PADS WERE ONLY 25% WORN OUT.

NHTSA complaint #721865 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

WHILE DRIVING AT APPROX. 65 MPH, A VIBRATION WAS NOTED FROM UNDER THE VEHICLE. SHORTLY THEREAFTER, WHEN ATTEMPTING TO STOP THE VEHICLE, THE BRAKE PEDAL WENT TO THE FLOOR, AND THE BRAKES FAILED TO STOP THE VEHICLE. DRIVER PULLED INTO THE MEDIAN ON US 15, AND THE GRASS AND MUD SLOWED THE WEHICLE TO A STOP. DEALER WAS UNABLE TO REPLICATE THE PROBLEM, AND DENIED ANY HISTORY OF SIMILAR PROBLEMS.

NHTSA complaint #720993 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

ON BRAKING IT IS HARD TO BE SURE THE BRAKES ARE WORKING BUT IT STOPS THE VEHICLE WITHOUT ANY PROBLEM. YH

NHTSA complaint #605684 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

THE LEAK IN WHEEL CYLINDER CAUSED BRAKES TO MAKE GRINDING SOUND. YH

NHTSA complaint #609379 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM

VEHICLE WAS SITTING IN THE YARD. WHEN MOVING THE RIGHT WHEEL WAS LOCKED UP. CALLED BONIFACE-HIERS CHRYSLER-DODGE, MERRIT ISLAND CSWY, MERRIT ISLAND, FL 32952 AND HAD THE VEHICLE TOWED TO THEM. NEXT DAY THEY CALLED AND SAID THE BRAKE SHOE WAS RUSTED TO THE DRUM. COST OF REPAIR $90.00. CLEAN BREAK AND TURN DRUMB. PICKED VEHICLE UP AND BREAK WAS DRAGING. MADE ANOTHER APPT. AND TOOK VEHICLE BACK. WAS TOLD BREAK DRUM WAS OUT OF ROUND. THEY TURNED THE DRUMB AGAIN AND PUT IT BACK TOGETHER. THE BREAK IS STILL DRAGING. WAS TOLD NOT TO DRIVE THE VEHICLE THROUGH WATER PUDDLES BY THE SERVICE ADVISOR..HAVE HEARD THAT THERE IS A DIRECTIVE OUT ON THE REAR BREAK CYLINDERS BUT NOT SURE????( DOT NUMBER: )

NHTSA complaint #713842 — an unverified report by a vehicle owner.

SERVICE BRAKES, AIR:ANTILOCK

THIS VAN, SLIGHTLY OVER 1 YEAR OLD, HAS A HISTORY OF STALLING, WINDSHIELD WIPERS GOING ON WITHOUT REASON AND OFF, RADIO BREAKING, TAPE PLAYER MAKING NOISE WHEN NOT USED AND THE BRAKES WENT OUT THE FIRST TIME, I WAS TOLD IT WAS FIXED, AND THE VERY NEXT DAY THEY WENT OUT AGAIN ALMOST CAUSING A SERIOUS ACCIDENT AND DEATHS. THIS IS SERIOUS AND I WOULD LIKE TO KNOW ACTIONS TAKEN BY NHTSA CONCERNING THIS AS I HAVE SEEN MANY OTHER INSTANCES/COMPLAINTS OF STALLING, WINDSHIELD WIPER PROBLEMS AND SERIOUS BRAKE DEFECTS AND BREAKDOWNS ON NHTSA'S CUSTOMER COMPLAINTS ON THE INTERNET. I BELIEVE THAT NHTSA SHOULD GIVE MORE SERIOUS INVESTIGATIVE ATTENTION AGAINST DAIMLER CHRYSLER CONCERNING THE STALLING AND BRAKE PROBLEMS AS THIS IS PUTTING PEOPLE'S LIVES IN DANGER IT SEEMS ON A CONSTANT AND RE-OCCURING BASIS!

NHTSA complaint #710989 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

DRIVER SIDE DISC BRAKE PADS ARE PREMATURELY WORN OUT.ALSO, PASSENGER'S SIDE DISC ROTORS BRAKE ROTORS ARE RUSTED AND PITTED. CAUSE UNKNOWN. PLEASE GIVE ANY FURTHEER DETAILS.

NHTSA complaint #843054 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

BOTH FRONT ROTORS ARE DEFECTIVE DUE TO RUST AND CORROSION AT 20,000 MILE OF WEAR. DEFECTIVE PARTS ARE AVAILABLE FOR INSPECTION IF NEEDED. DEALER/ MANUFACTURER NOTIFIED.

NHTSA complaint #838449 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM

NO SUMMARY

NHTSA complaint #704481 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

ENGINE OIL LEAK DUE TO BLOWN ENGINE HEAD GASKET. THUMPING FROM REAR OF VEHICLE. SILENCER PADS AND STRAPS REPLACED ON GAS TANK. STILL THUMPS. BRAKES: HOWLING FROM REAR BRAKES. PADS/MASTERCYLINDER AND SPRINGS REPLACED.

NHTSA complaint #702836 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

ENGINE OIL LEAK DUE TO BLOWN ENGINE HEAD GASKET. THUMPING FROM REAR OF VEHICLE. SILENCER PADS AND STRAPS REPLACED ON GAS TANK. STILL THUMPS. BRAKES: HOWLING FROM REAR BRAKES. PADS/MASTERCYLINDER AND SPRINGS REPLACED.

NHTSA complaint #702836 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:POWER ASSIST

IN ICY CONDITIONS WITH TEMPERATURES APPROXIMATELY 10 DEGREES F, BRAKES DID NOT ACTIVATE WITHOUT EXCESSIVE PEDAL PRESSURE APPARENTLY DUE TO FAILURE OF POWER ASSIST. THIS HAPPENED TWICE WITHIN 24 HOURS DURING A TRIP TO FLINT, MI. UPON RETURNING TO VIRGINIA, THE VEHICLE WAS TAKEN TO GREENBRIER CHRYSLER-PLYMOUTH, WHO INSPECTED AND ADVISED THAT THEY WERE UNABLE TO DUPLICATE THE FAILURE.

NHTSA complaint #702506 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

IN ICY CONDITIONS WITH TEMPERATURES APPROXIMATELY 10 DEGREES F, BRAKES DID NOT ACTIVATE WITHOUT EXCESSIVE PEDAL PRESSURE APPARENTLY DUE TO FAILURE OF POWER ASSIST. THIS HAPPENED TWICE WITHIN 24 HOURS DURING A TRIP TO FLINT, MI. UPON RETURNING TO VIRGINIA, THE VEHICLE WAS TAKEN TO GREENBRIER CHRYSLER-PLYMOUTH, WHO INSPECTED AND ADVISED THAT THEY WERE UNABLE TO DUPLICATE THE FAILURE.

NHTSA complaint #702506 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

BRAKES WILL NOT STOP VEHICLE. WHEN APPLYING PRESSURE TO THE PEDAL, VEHICLE WILL NOT GIVE DRIVER FULL CAPACITY TO STOP. HE HAS NOTIFIED THE DEALERSHIP, NOT MANUFACTURER.

NHTSA complaint #828468 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ABS BRAKES; WHEN APPLYING BRAKES IN NORMAL CONDITIONS, PEDAL WENT TO THE FLOOR AND BRAKES FAILED TO STOP VEHICLE, CAUSING A EXTENDED STOPPING DISTANCE BEFORE VEHICLE CAME TO STOP. WINDSHIELD WIPERS OPERATE SPORATICALLY

NHTSA complaint #825502 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

BRAKES REPLACED SEVERAL TIMES.

NHTSA complaint #536993 — an unverified report by a vehicle owner.