1997 Plymouth Voyager fuel system problems

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 1997 PLYMOUTH VOYAGER. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT WAS ABLE TO SAFELY STOP THE VEHICLE AND UPON EXAMINING THE VEHICLE, THE CONTACT NOTICED THAT ONE OF THE FUEL TANK STRAPS HAD FRACTURED DUE TO CORROSION. THE CONTACT APPLIED A TEMPORARY STRAP AS A REMEDY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 175,000.

NHTSA complaint #10452772 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

DT: THE CONTACT STATED VEHICLE STALLS WHEN IDLING FOLLOWED BY THE ENGINE DYING. THE VEHICLE RESTARTS AFTER SEVERAL ATTEMPTS. HE TOOK THE VEHICLE TO AN INDEPENDENT REPAIR SHOP. THE REPAIR SHOP CLEANED THE THROTTLE BODY AND THE FUEL INJECTION SYSTEM. THIS DID NOT CORRECT THE PROBLEM. NO FURTHER REPAIRS HAVE BEEN MADE AT THIS TIME.

NHTSA complaint #10143329 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

SAFETY RECALL CLOCK SPRING ASSEMBLY NAR 1/22/2003 THE AIR BAG LIGHT ILLUMINATED AND THE CONSUMER TOOK THE VEHICLE TO THE DEALER WHERE THE PROBLEM WAS DIAGNOSED AS A SHORT IN CLOCK SPRING. THE POWER DOOR LOCKS WERE NOT UNLOCKING, BUT THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. ANOTHER RECALL REGARDING THE FUEL RAIL WAS REPAIRED, HOWEVER THE CONSUMER WAS CHARGED A $50.00 DEDUCTIBLE.

NHTSA complaint #10004728 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL

CONSUMER NOTICED EVIDENCE OF FUEL LEAKAGE. DEALER DIAGNOSED THAT FUEL WAS LEAKING FROM FUEL RAIL AND REPLACED IT.

NHTSA complaint #10031515 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

THE FUEL TANK WOULD NOT TAKE MORE THAN A HALF A TANK OF FUEL. THE DEALER HAS BEEN NOTIFIED. *NLM

NHTSA complaint #10019393 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

THE VEHICLE EXPERIENCED A FUEL LEAK. *JB THE ELECTRICAL SYSTEM HAS NOT WORKED WHILE VEHICLE WAS RUNNING. (WINDOW, BLINKERS, AND THE RADIO) RESTARTING THE VEHICLE SOLVES THE PROBLEM EACH TIME. SCC

NHTSA complaint #10014704 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

THE CONSUMER HAS EXPERIENCE THE FOLLOWING: NOISE COMING FROM THE REAR BRAKES, NOISE WHEN STARTING THE ENGINE/UNEVEN IDLE, THE CHECK ENGINE LIGHT HAD COME ON/BURNED #5 EXHAUST VALVE-REMOVED HEAD/REPLACED VALVE/REASSEMBLED ENGINE, THE ENGINE IS KNOCKING/INTERNAL ROD KNOCKING-ENGINE HAD AN OIL LEAK/REPLACED GASKET & THE REAR MAIN SEAL IS LEAKING (THE VEHICLE IS GOING THRU 2-3 QUARTS PER MONTH), AND WHEN ENGAGING IN GEAR, THE ENGINE MOVES HARD. SCC

NHTSA complaint #10001959 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

FUEL RAIL HAS A HAIR LINE CRACK ,AND IT LEAKS GAS INTO VEHICLE, CAUSING VEHICLE TO SMELL LIKE GAS. PH.

NHTSA complaint #10004271 — an unverified report by a vehicle owner.

FUEL SYSTEM, OTHER

CONSUMER NOTICE WHILE TRAVELING FUEL GAUGE MOVING UP AND DOWN GIVING WRONG READING IN RESULT OF FUEL INDICATOR RING WHILE VEHICLE IS FUEL LEVEL IS FULL. MANUFACTURE HAS BEEN CONTACTED. PLEASE PROVIDE FURTHER INFORMATION. TS

NHTSA complaint #10003912 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

THE FUEL LINE FROM THE GAS TANK TO THE FUEL INJECTION PASSED OVER THE MANIFOLD AND DEVELOPED A HOLE DUE TO THE EXPANSION AND CONTRACTION OF THE HEAT AND COLD, WHICH CAUSED THE FUEL TO LEAK ON THE MANIFOLD WHICH WAS HOT AND THE FUMES WAS PUSHED BACK INTO THE VEHICLE.TS

NHTSA complaint #8023692 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

HEADLIGHTS ARE DIM, CAN'T SEE VERY FAR DOWN THE ROAD, UNSAFE TO DRIVE AT NIGHT. PREMATURE FAILURE OF FUEL GAUGE SENDING UNIT. DT

NHTSA complaint #769436 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

THIS AUTO HAS A NUMEROUS/EXPENSIVE REPAIRS, WE HAVE NOT BEEN NOTIFIED OF RECALLS FOR THIS CAR. HELP WHAT DO WE DO? DT

NHTSA complaint #769444 — an unverified report by a vehicle owner.

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY

CONSUMER STATES WHILE ENTERING THE VEHICLE COULD SMELL GAS FUMES CONSUMER STATES GAS IS LEAKING UNDER VEHICLE. TOOK TO DEALER AND THEY REPLACED GAS TANK AND STRAPS. PLEASE PROVIDE ANY FURTHER INFORMATION. MR

NHTSA complaint #8021335 — an unverified report by a vehicle owner.

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY

CONSUMER STATES THAT THERE IS A FUEL ODOR IN THE VEHCLE SOMETIMES STRONG SOMETIMES FADE.CONSUMER STATES THERE HAS BEEN A RECALL BUT CONSUMERS VIN NUMBER WAS NOT INCLUDED.

NHTSA complaint #8019557 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

CONSUMER RECIEVED RECALL NOTICE 00V-268 FOR THE FAULTY O-RINGS BUT IS UNABLE TO HAVE THE RECALL REPAIRS MADE BECAUSE THE DEALER CANNOT GET THE PARTS AND IS NOT SURE WHEN THEY WILL BECOME AVAILABLE. NLM

NHTSA complaint #564821 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

CONSUMER STATES THERE IS A SMELL OF GAS IN THE VEHICLE AT TIMES, CONSUMER SAW A REPORT ABOUT A RECALL FOR 1996 THRU 2000 MODELS, REGARDING A GAS LEAK IN THE ENGINE AREA, HOWEVER CONSUMER WAS NOT SPECIFIC ABOUT THE RECALL.

NHTSA complaint #566483 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

NHTSA RECALL 00 V 268 000/MANUFACTURER'S RECALL 895 CONCERNING FUEL LEAKAGE: DEALER: MAROONE DODGE IN DELRAY BEACH, FL; PHONE# 561/278-6362. INDICATED ON WORK INVOICE THAT BOTH CLAMPS AND TUBE WERE REPLACED. CONSUMER STATES THAT BOTH CLAMPS WAS REPLACED, BUT NOT THE TUBE. *AK JLG

NHTSA complaint #8011209 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY

STRONG ODOR OF GASOLINE THAT SEEMS TO COME FROM THE ENGINE COMPARTMENT IS PRESENT, BUT NOT CONSISTENTLY. I HAVE TAKEN THE VEHICLE TO A LOCAL GARAGE AND THEY COULD SMELL THE GAS ALSO, BUT COULD NOT LOCATE THE PROBLEM. I THEN BROUGHT THE VAN TO THE DEALER. AFTER HEARING ABOUT A RECALL ON THESES VANS BECAUSE OF A FUEL LINE SEAL PROBLEM, I TOOK THE VEHICLE TO THE DEALER AND CONTACTED CHRYSLER. THE DEALER ALSO COULD NOT FIND THE PROBLEM, HOWEVER THE GASOLINE ODOR WAS NOT PRESENT THAT DAY. CHRYSLER WOULD NOT AUTHORIZE THE RECALL REPAIR SINCE THE DEALER DID NOT DETECT A PROBLEM AND THE RECALL DID NOT INVOLVE 3.0 LITER ENGINES. SINCE I HAVE NOT BEEN ABLE TO FIND THE PROBLEM, I CONTINUE TO DRIVE THE VEHICLE. I WOULD LIKE TO KNOW IF ANYONE IS HAVING THIS TYPE OF PROBLEM WITH THIS PARTICULAR VEHICLE.

NHTSA complaint #761132 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

VEHICLE LOCKED UP AND SHUT DOWN WITHOUT PRIOR WARNING. FUEL GAUGE ACKNOWLEDGED A FUEL TANK. BUT THERE WAS NO GASOLINE, AND VEHICLE SHUT DOWN.

NHTSA complaint #8006081 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

VEHICLE LOCKED UP AND SHUT DOWN WITHOUT PRIOR WARNING. FUEL GAUGE ACKNOWLEDGED A FUEL TANK. BUT THERE WAS NO GASOLINE, AND VEHICLE SHUT DOWN.

NHTSA complaint #8006081 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

SEVERE FUEL ODOR/FUMES WERE GETTING INTO THE VEHICLE WHILE RUNNING OR DRIVING. VEHICLE HAS BEEN TO THE DEALER ON TWO OCCASIONS, AND THE PROBLEM IS STILL OCCURRING. *AK

NHTSA complaint #8005276 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS

WHEN TURNING ON VEHICLE CAN SMELL FUEL IN AND ON OUTSIDE OF VEHICLE. THERE'S A RECALL FOR SAME PROBLEM, BUT VIN NUMBER WAS NOT INCLUIDED. CONSUMER PLEASE PROVIDE RECALL NUMBER FOR THE RECALL YOUR VIN NUMBER WAS NOT INCLUDED IN.

NHTSA complaint #894201 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

RECALL 00V268000/ MANUFACTURER'S RECALL 895.CONSUMER CONTACTED DEALER MONTHS BEFORE RECEIVING RECALL NOTICE. DEALER STATED THEY HAVE TO WAIT FOR MANUFACTURER, THERE WAS NOTHING THEY COULD DO. RECALL SHOWED A REMEDY, BUT DEALER, PUCKETT DODGE CHRYSLER JEEP, 3625 OLD HALIFAX ROAD, PO BOX 818 SOTH BOSTON, VA 24592, PHONE# 804-575-5050 DID NOT SEEM TO KNOW WHAT TO DO. *AK CONSUMER STATES THE FUEL RAIL COULD BE REPLACED NOW, HOWEVER CONSUMER BELIEVES THAT DEALER THINKS IT IS TOO EXPENSIVE AND ARE TRYING TO COME UP WITH A CHEAP WAY TO FIX PROBLEM.

NHTSA complaint #893351 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY

OUR VAN FUEL PUMP / FUEL LINE FAILED AT OR NEAR THE GAS TANK. WHILE DRIVING, MY WIFE NOTICED A SMELL (WHICH TURNED OUT TO BE FUEL). I MET HER, AND TO MY SHOCK, THE VEHICLE WAS ENVELOPED IN GASOLINE FUMES !! WE ABANDONED THE VEHICLE IMMEDIATELY, DUE TO OBVIOUS CONCERNS OF FUMES COMBUSTION. WE CONTACTED A TOW TRUCK, HAD THE VAN TOWED TO A REPAIR SHOP WHICH HAPPENED TO BE WITHIN 2 MILES, AND HAD REPAIRS MADE. AT THE SHOP, THEY WOULD NOT PULL THE VEHICLE INTO THE GARAGE BECAUSE THE UNDERSIDE WAS SOAKED IN GASOLINE ! THEY REPLACED THE FUEL PUMP / LINE ASSEMBLY. I AM CONTACTING NHTSA AT THIS POINT DUE TO AN ARTICLE IN THE DETROIT NEWS (JULY 18, 2001)WHICH INDICATES THIS FAILURE MIGHT BE A KNOWN/RECURRING PROBLEM. SINCE I SAW MY WIFE SITTING ON THE SIDE OF THE ROAD IN A VAN ENGULFED IN GASOLINE VAPORS, I AM NOT AT ALL HAPPY OR IMPRESSED WITH THE THOUGHT THAT SOMEONE KNEW THIS MIGHT HAPPEN TO HER. THANK YOU FOR YOUR SUPPORT.

NHTSA complaint #748673 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

FUEL GAUGE SENSOR FAILED. FAILING TO SHOW EMPY FUEL TANK. VEHICLE STALLED AND WAS TOWED.

NHTSA complaint #742640 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

CHRYSLER TOLD US THEY KNEW NOTHING OF THE PROBLEM AND NOW WE HEAR THERE WILL BE A RECALL.. THE FUMES ARE BAD AND WE ARE AFRAID OF FIRE.

NHTSA complaint #738351 — an unverified report by a vehicle owner.