Owners have filed 13 complaints
about the 2020 Toyota Avalon with NHTSA between 2021 and 2025.
The largest single group is the fuel & propulsion.
Across this model's run it ranks 26 of 28 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 4
Against the median year of the Toyota Avalon. 50 means typical for this
model; 100 means roughly double.
Severity — 100
30.8% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — not reported
Too few complaints recorded a mileage to measure this.
Complaints filed with NHTSA, by model year. Bar colour is the FaultScore grade:
A
B
C
D
F
ungraded
What breaks on a 2020 Toyota Avalon
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
Fuel & Propulsion
538.5%
Median failure at 2,950 miles
Driver Assist & Collision Avoidance
323.1%
1 crashes, 0 fires
Windows, Mirrors & Wipers
17.7%
Median failure at 8,937 miles
Acceleration & Cruise Control
17.7%
Brakes
17.7%
1 crashes, 0 fires
Steering
17.7%
Airbags
17.7%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
Frontal crash test
Side barrier crash test
Side pole crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2020 Toyota AVALON 4 DR FWD
10.5% risk
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Feb 2021peak 3Dec 2025
Recalls on the 2020 Toyota Avalon
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202368499,965 units in Canada
Airbag
Issue: On certain vehicles, a sensor for the occupant classification system (OCS) may not have been manufactured properly. As a result, the sensor could short circuit and cause the airbag system to turn off the passenger-front airbag even when a passenger is seated. Note: This problem would cause a warning message to display on the instrument panel and the airbag indicator light would display "passenger airbag off". Safety Risk: An airbag that is turned off could increase the risk of injury to a passenger in a crash. Corrective Actions: Toyota will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the OCS sensor.
Recall 2020514126,597 units in Canada
Fuel System
Issue: On certain vehicles, the low-pressure fuel pump could fail. If this happens, then engine may run rough or may not start and the check engine light may turn on. This could also result in a sudden loss of engine power while driving. Note: This recall is an expansion of recalls SRC R95/SRC R96 and SRC RA2/SRC RA3 (Transport Canada Recall Numbers 2020-005 and 2020-088). Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct you to take your vehicle to a dealer to replace the fuel pump.
Reports where the owner recorded a crash, a fire, an injury or a death.
Freehold, NJCrash1 killed
SERVICE BRAKES
I represent the family of a fatally injured rollaway victim. It is on their behalf I am reporting the circumstances of this incident and to strongly urge that NHTSA update the rollaway requirements specified in Federal Motor Vehicle Safety Standard 114. On August 22, 2020, It is believed that while attempting to retrieve the key fob, the driver inadvertently bumped the gear selector forward into Neutral, releasing the torque to the wheels that had kept it stationary on their sloped driveway. (Unlike shifting out of the Park position, which requires application of the brake pedal and depressing the lock button on the shift selector, the shift selector can be moved from Drive forward into the Neutral position, without a secondary interlocking action.) The drivers wife, who was behind the vehicle. was pinned by the car and dragged under to her death. The position of the transmission gear selector was not documented by any witnesses or first responders when the vehicle eventually came to rest on the opposite side of the road, not is it documented in the extensive data stored within the vehicle. However, the data retrieved from the subject vehicle during a subsequent inspection revealed that the Vehicle Control History (VCH) included a field for “Driver Exited Vehicle When Shift Position Wasn’t P” which showed that at the time of the incident that is exactly what happened. Finally, there is ample evidence to support the need for an upgrade of the rollaway provisions within FMVSS 114 – as the facts above show. It’s not enough for a safety agency to simply allow manufacturers to do so voluntarily. . Instead, the Toyota was content to collect the data and blame the driver for an event that it clearly knows occurs and has extensive information about, but fails to prevent. The public needs to rely on NHTSA to promulgate updated regulations that meet the safety needs presented to drivers of modern vehicles.
NHTSA complaint #11426884 — an unverified report by a vehicle owner.
I represent the family of a fatally injured rollaway victim. It is on their behalf I am reporting the circumstances of this incident and to strongly urge that NHTSA update the rollaway requirements specified in Federal Motor Vehicle Safety Standard 114. On August 22, 2020, It is believed that while attempting to retrieve the key fob, the driver inadvertently bumped the gear selector forward into Neutral, releasing the torque to the wheels that had kept it stationary on their sloped driveway. (Unlike shifting out of the Park position, which requires application of the brake pedal and depressing the lock button on the shift selector, the shift selector can be moved from Drive forward into the Neutral position, without a secondary interlocking action.) The drivers wife, who was behind the vehicle. was pinned by the car and dragged under to her death. The position of the transmission gear selector was not documented by any witnesses or first responders when the vehicle eventually came to rest on the opposite side of the road, not is it documented in the extensive data stored within the vehicle. However, the data retrieved from the subject vehicle during a subsequent inspection revealed that the Vehicle Control History (VCH) included a field for “Driver Exited Vehicle When Shift Position Wasn’t P” which showed that at the time of the incident that is exactly what happened. Finally, there is ample evidence to support the need for an upgrade of the rollaway provisions within FMVSS 114 – as the facts above show. It’s not enough for a safety agency to simply allow manufacturers to do so voluntarily. . Instead, the Toyota was content to collect the data and blame the driver for an event that it clearly knows occurs and has extensive information about, but fails to prevent. The public needs to rely on NHTSA to promulgate updated regulations that meet the safety needs presented to drivers of modern vehicles.
NHTSA complaint #11426884 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Buda, TX
FUEL/PROPULSION SYSTEM
A couple of months ago, my car started running a little rough as it would sit in idle mode. When suddenly my check engine light came on. I checked the codes and they seemed to be P0445 Evaporitive emission system leak detected (large leak). And P0441 Evaporative emission system. Incorrect Purge Flow. P0505 Idle control system. And P0171 System to Lean Bank 1 and P0174 System to Lean. Bank 2 and P0172 System Too Rich and P1170 and P117B Manufacture Control. But other then just running a little rough at idle that was about all that I had noticed until I went to go fuel up back in October. My fuel was low so I went to fuel up and after wards, my car struggled really hard to start. And every time since that days it’s progressively gotten worse. Last week I kept my car running while I fueled up and as I drove away from the gas station, my car just stalled out completely. It took me about an hour and a half before my car would start again. I was waiting for the tow truck to come get me and thank God inc checked it one more time and it started. Now just recently, when I put my car in park the engine immediately Reva up super high. It started to wine really loud and rpm go through the roof. Until I shut the car off. So I am unable to sit in idle at all anymore. I decided to Google what could be going on with my car and then I seen this recall on the fuel pump off some Toyota Avalon 2019 & 2020 models. But much to my surprise, my Vin/Vehicle is not listed. Will Toyota still replace the fuel pump for free? Please contact me as soon as possible. I really need to address this issue. Thank You!
NHTSA complaint #11703613 — an unverified report by a vehicle owner.
Keaau, HI
AIR BAGS
To Whom It May Concern, I am filing this complaint to report Right Toyota in Scottsdale, Arizona, and Toyota Motor Corporation for their mishandling of a critical airbag safety recall (23TA15) on my 2020 Toyota Avalon Hybrid. The lack of transparency, misleading information, and failure to provide a remedy has left me with a vehicle that is unsafe to drive and has caused significant financial hardship. 1. Right Toyota never informed me of the recall, despite multiple service visits throughout the year. I only discovered this issue through my insurance company in August 2024. 2. I scheduled service appointments with Right Toyota on August 23rd and October 15th, 2023, after learning about the recall. Each time, I was told that there was no remedy available, and I was not offered any alternative solutions or a loaner vehicle. Toyota’s Brand Engagement Team later confirmed that a remedy for my specific vehicle is not expected until March 2026. 3. I called Right Toyota back after the manufacturer told me the dealership was meant to solve this issue by offering me a loaner vehicle or buying my car off me. I spoke to Jason Murdoch who informed it was preposterous to think they would offer me a loaner vehicle until 2026 and that the only option he could offer is buying my car off me 8K negative on what I still owe on my car loan. He told me the dealerships hands were tied unless NHTSA or the manufacturer gave specific instructions for me. 4. I have since relocated to Hawaii, where I cannot use the vehicle due to safety concerns. I am still making loan payments on a car that I cannot drive, and Right Toyota’s refusal to offer any assistance has placed me in a difficult situation. I request that Toyota and Right Toyota either: Repurchase the Vehicle: Take back the vehicle and pay off the remaining loan balance. Provide an Immediate Solution: If repurchasing is not possible, arrange for a free airbag repair or provide a rental vehicle until the remedy is available.
NHTSA complaint #11625964 — an unverified report by a vehicle owner.
Garden Grove, CA
STEERING
TIE ROD LOOSE I heard a clunking noise while turning the steering wheel to the left at very low speeds. Took car in for service Service Mechanic found left outer tie rod end "with play, loose" Safety issue: potential loss of steering ability while driving Vehicle has been inspected and repaired - (my cost $1308.94) - images attached No warning messages / appeared about a month before I went in... it became progressively worse with time
NHTSA complaint #11602383 — an unverified report by a vehicle owner.
Myakka City, FL
FUEL/PROPULSION SYSTEM
When refueling vehicle, gasoline backs up immediately, doesn't shut off gas hose and pours out all over vehicle and feet of person refueling. Today is the 4th time it's happened. It's been to Gettle Toyota of Lakewood in Bradenton FL for this exact complaint and was told there's nothing wrong with the vehicle.
NHTSA complaint #11556756 — an unverified report by a vehicle owner.
King OF Prussia, PA
VEHICLE SPEED CONTROL
on 3 lane expressway (US422)about 1/4 mile from where the lanes split( see attached). No cars in front of me but cars in the lane to my left slowed. My car suddenly braked causing the car behind me to swerve to my right to avoid a collision. The adaptive breaking (incorrectly) determined that there was a collision hazard, thus creating an actual collision hazard
NHTSA complaint #11476773 — an unverified report by a vehicle owner.
King OF Prussia, PA
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
on 3 lane expressway (US422)about 1/4 mile from where the lanes split( see attached). No cars in front of me but cars in the lane to my left slowed. My car suddenly braked causing the car behind me to swerve to my right to avoid a collision. The adaptive breaking (incorrectly) determined that there was a collision hazard, thus creating an actual collision hazard
NHTSA complaint #11476773 — an unverified report by a vehicle owner.
on 3 lane expressway (US422)about 1/4 mile from where the lanes split( see attached). No cars in front of me but cars in the lane to my left slowed. My car suddenly braked causing the car behind me to swerve to my right to avoid a collision. The adaptive breaking (incorrectly) determined that there was a collision hazard, thus creating an actual collision hazard
NHTSA complaint #11476773 — an unverified report by a vehicle owner.
Dupo, IL
FUEL/PROPULSION SYSTEM
This has happened 3 times now. When putting gas in and the pump kicks off fuel gushes out of the tank. I only had a quarter of a tank at the time. Only got $1 worth in the last time this happened. If you try to put more fuel in pump will kick off then it just pushes fuel out all over the ground, which could easily cause a fire. Took to the dealer today to get this on record, had a full tank so they did not not try to gas it up. Get no warning that this is going to happen. On all 3 occasions I was able to gas up without an issue the next day.
NHTSA complaint #11444624 — an unverified report by a vehicle owner.
Freehold, NJCrash1 killed
SERVICE BRAKES
I represent the family of a fatally injured rollaway victim. It is on their behalf I am reporting the circumstances of this incident and to strongly urge that NHTSA update the rollaway requirements specified in Federal Motor Vehicle Safety Standard 114. On August 22, 2020, It is believed that while attempting to retrieve the key fob, the driver inadvertently bumped the gear selector forward into Neutral, releasing the torque to the wheels that had kept it stationary on their sloped driveway. (Unlike shifting out of the Park position, which requires application of the brake pedal and depressing the lock button on the shift selector, the shift selector can be moved from Drive forward into the Neutral position, without a secondary interlocking action.) The drivers wife, who was behind the vehicle. was pinned by the car and dragged under to her death. The position of the transmission gear selector was not documented by any witnesses or first responders when the vehicle eventually came to rest on the opposite side of the road, not is it documented in the extensive data stored within the vehicle. However, the data retrieved from the subject vehicle during a subsequent inspection revealed that the Vehicle Control History (VCH) included a field for “Driver Exited Vehicle When Shift Position Wasn’t P” which showed that at the time of the incident that is exactly what happened. Finally, there is ample evidence to support the need for an upgrade of the rollaway provisions within FMVSS 114 – as the facts above show. It’s not enough for a safety agency to simply allow manufacturers to do so voluntarily. . Instead, the Toyota was content to collect the data and blame the driver for an event that it clearly knows occurs and has extensive information about, but fails to prevent. The public needs to rely on NHTSA to promulgate updated regulations that meet the safety needs presented to drivers of modern vehicles.
NHTSA complaint #11426884 — an unverified report by a vehicle owner.
I represent the family of a fatally injured rollaway victim. It is on their behalf I am reporting the circumstances of this incident and to strongly urge that NHTSA update the rollaway requirements specified in Federal Motor Vehicle Safety Standard 114. On August 22, 2020, It is believed that while attempting to retrieve the key fob, the driver inadvertently bumped the gear selector forward into Neutral, releasing the torque to the wheels that had kept it stationary on their sloped driveway. (Unlike shifting out of the Park position, which requires application of the brake pedal and depressing the lock button on the shift selector, the shift selector can be moved from Drive forward into the Neutral position, without a secondary interlocking action.) The drivers wife, who was behind the vehicle. was pinned by the car and dragged under to her death. The position of the transmission gear selector was not documented by any witnesses or first responders when the vehicle eventually came to rest on the opposite side of the road, not is it documented in the extensive data stored within the vehicle. However, the data retrieved from the subject vehicle during a subsequent inspection revealed that the Vehicle Control History (VCH) included a field for “Driver Exited Vehicle When Shift Position Wasn’t P” which showed that at the time of the incident that is exactly what happened. Finally, there is ample evidence to support the need for an upgrade of the rollaway provisions within FMVSS 114 – as the facts above show. It’s not enough for a safety agency to simply allow manufacturers to do so voluntarily. . Instead, the Toyota was content to collect the data and blame the driver for an event that it clearly knows occurs and has extensive information about, but fails to prevent. The public needs to rely on NHTSA to promulgate updated regulations that meet the safety needs presented to drivers of modern vehicles.
NHTSA complaint #11426884 — an unverified report by a vehicle owner.
at 8,937 milesOwings Mills, MD
VISIBILITY:SUN/MOON ROOF ASSEMBLY
TL* THE CONTACT OWNS A 2020 TOYOTA AVALON. THE CONTACT STATED WHILE DRIVING AT 60 MPH, WHEN THE SUNROOF SHATTERED WITHOUT ANY OBJECT CAUSING THE IMPACT. THE VEHICLE WAS TAKEN TO LOCAL DEALER HERITAGE TOYOTA OWINGS MILLS (9801 REISTERSTOWN RD, OWINGS MILLS, MD 21117: (844) 202-9429), WHERE IT WAS DIAGNOSED THAT THE SUNROOF NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 8,937.
NHTSA complaint #11416402 — an unverified report by a vehicle owner.
at 4,000 milesHenderson, NV
FUEL/PROPULSION SYSTEM
ON OCTOBER 28, 2020, TOYOTA ANNOUNCED IT WAS CONDUCTING A SAFETY RECALL INVOLVING CERTAIN TOYOTA AND LEXUS VEHICLES PRODUCED BETWEEN JULY 2017 THROUGH DECEMBER 2019 DUE TO THE SAME FUEL PUMP ISSUE FOR WHICH THEY ANNOUNCED A SAFETY RECALL IN JANUARY 2020. THE REFERENCED VEHICLE DOOR STICKER SHOWS A PRODUCTION DATE OF 12/19, WHICH IS WITHIN THE PRODUCTION PERIOD ANNOUNCED ON 10/28/2020. HOWEVER, THE VIN ON THIS VEHICLE DOES NOT APPEAR ON ANY RECALL LIST AND THE DEALER TELLS ME THERE ARE NO RECALLS FOR MY VEHICLE. NONETHELESS, I HAVE EXPERIENCED SEVERAL INSTANCES WHERE THE VEHICLE FEELS LIKE IT IS ABOUT TO STALL: WHEN MAKING A TURN OR DRIVING ON CITY STREETS; IN SOME INSTANCES (INCLUDING TODAY) IT IS WHEN STARTING FROM A STOP SIGN OR TRAFFIC LIGHT; OTHER TIMES IT IS WHEN ACCELERATING. THERE HAVE BEEN TWO INSTANCES WHERE THIS HAPPENED WHILE MAKING A LEFT TURN AT AN INTERSECTION. IN ONE SUCH INSTANCE, A YELLOW TRIANGLE WARNING LIGHT FLASHED MOMENTARILY ON THE VEHICLE'S DISPLAY. THIS ISSUE WAS REPORTED TO THE SELLING DEALER DURING THE LAST ROUTINE MAINTENANCE VISIT ON MAY 4, 2021. IN REFERENCE TO THIS COMPLAINT, THE DEALER WORK ORDER REPORTED TECHNICIAN "WAS UNABLE TO DUPLICATE CUSTOMERS CONCERN AT THIS TIME VEHICLE IS CURRENTLY OPERATING WITHIN ALL MANUFACTURERS SPECIFICATIONS".
NHTSA complaint #11416511 — an unverified report by a vehicle owner.
at 1,900 milesClayton, NC
FUEL/PROPULSION SYSTEM
RECALL# 20V-682,IF A VEHICLE STALLS WHILE DRIVING,THIS COULD INCREASE THE RISK OF A CRASH.TOYOTA IS TALKING ABOUT THE RECALL FOR A LOW PRESSURE FUEL PUMP WHICH MAY STOP OPERATING.THIS IS A SERIOUS SAFETY CONDITION WHICH COULD ENDANGER THE LIVES OF MY FAMILY AND MYSELF.THIS CONDITION HAS BEEN REPORTED TO ME IN NOVEMBER 2020 WITH NO REMEDY IN SIGHT.ALL I WANT IS FOR TOYOTA TO FIX MY PROBLEM ASAP,OR TELL ME TO PARK MY VEHICLE AND USE A LOANER FROM TOYOTA TILL SERIOUS CONDITION IS FIXED.THERE ARE SEVERAL CLASS ACTION SUITS DUE TO THIS PROBLEM WITH THE FUEL PUMPS MADE IN CHINA FOR SEVERAL YEARS.
NHTSA complaint #11395907 — an unverified report by a vehicle owner.
