Owners have filed 293 complaints
about the 2006 Toyota Sequoia with NHTSA between 2006 and 2025.
The largest single group is the airbags.
Across this model's run it ranks 8 of 16 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 49
Against the median year of the Toyota Sequoia. 50 means typical for this
model; 100 means roughly double.
Severity — 23
4.4% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 17
10% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
3570.0%
Underbody Shields
36.0%
Frame AND Members
36.0%
Automatic Transmission
36.0%
Rear Window Wiper/Washer
24.0%
Driveline
24.0%
Software
12.0%
Buckle Assembly
12.0%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
31.5%
1,000 – 9,999 miles
10.5%
10,000 – 24,999 miles
84.1%
25,000 – 49,999 miles
199.8%
50,000 – 74,999 miles
3819.6%
75,000 – 99,999 miles
3920.1%
100,000 – 149,999 miles
5126.3%
150,000+ miles
3518.0%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Configuration
Overall
Front
Side
Rollover
2006 Toyota Sequoia 4-DR
—
—
—
—
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Mar 2006peak 15Jan 2025
NHTSA investigations into the 2006 Toyota Sequoia
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C...
EA06014Opened 2 Aug 2006Closed 28 Feb 2007SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
LOWER BALL JOINT FAILURE
IN A LETTER DATED JANUARY 18, 2007, TOYOTA NOTIFIED NHTSA OF A SAFETY DEFECT IN MODEL YEAR (MY) 2004 THROUGH 2006 TOYOTA TUNDRA AND MY 2004 THROUGH 2007 TOYOTA SEQUOIA VEHICLES PRODUCED BETWEEN SEPTEMBER 15, 2003 AND NOVEMBER 17, 2006 (NHTSA RECALL NO. 07V-013). ACCORDING TO TOYOTA, ?IN THE FRONT SUSPENSION LOWER BALL JOINT ON THE SUBJECT VEHICLES, DUE TO POSSIBLE IMPROPER FINISHING OF THE BALL JOINT, SUCH AS THE ASPECT OF THE BALL STUD SURFACE, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN PREMATURELY,...
Recalls on the 2006 Toyota Sequoia
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
22E002000
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Tenneco Automotive (DRiV) is recalling certain aftermarket ball joints for 2004-2007 Toyota Sequoia and 2004-2006 Toyota Tundra vehicles, MOOG part number K80521, K80522, NAPA part number NCP2601633, NCP2601634, ACDelco part number 45D2344, and 45D2345. The ball joint housing may have inadequate hardness, causing premature failure.
Risk: A ball joint failure may cause a loss of control, increasing the risk of a crash.
19V741000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
16V396000
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
16V065000
AIR BAGS:SIDE/WINDOW
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags. The affected vehicles have an air bag control module that may be improperly programmed, causing the side curtain-shield-air bags to deploy inadvertently.
Risk: If the side curtain-shield-air bags deploy unexpectedly, it can increase the risk of occupant injury.
15V286000
AIR BAGS
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.
Risk: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
15V285000
AIR BAGS
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.
Risk: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
14V743000
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
10V036000
EQUIPMENT:OTHER:LABELS
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Risk: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 201952337,591 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the passenger-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Action: Owners will be notified by mail and instructed to take their vehicle to a dealer to have the passenger-front airbag inflator or airbag module replaced. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected. Additional Note: Vehicles may have had the original front passenger airbag inflator replaced as a "like-for-like" replacement under recall 2016-103 (Toyota Recall #'s SRC 241 & SRC 242) as a temporary remedy while evaluating a permanent remedy. These vehicles will receive the permanent remedy passenger airbag assembly under this recall.
Recall 2016103400,124 units in Canada
Airbag
On certain vehicles, the passenger (frontal) airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the passenger airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Note: This recall supersedes recalls 2013113, 2014224, 2015197 and 2015269. Correction: All vehicles having not received a replacement inflator as part of the previous recall will now have a replacement inflator installed by dealers. For Matrix model vehicles, dealers may replace the front passenger airbag assembly with one equipped with a newly specified inflator.
Recall 20160516,962 units in Canada
Airbag
On certain vehicles, the roll rate sensors in the airbag control module may improperly calibrate if the vehicle experiences a body roll motion approximately four seconds after the ignition is turned to the ‘ON’ position. If the vehicle experiences another subsequent body roll motion, the system may erroneously detect a rollover, causing both of the side curtain airbags to deploy and the seat belt pre-tensioners to be activated. Unintended airbag and/or seat belt pre-tensioner deployment, in a non-warranted (non-impact) situation, could result in injury and increase the risk of a vehicle crash causing injury and/or property damage. Correction: Dealers will replace the airbag control module with one which has improved programming.
Recall 2015269366,860 units in Canada
Airbag
On certain vehicles, the passenger (frontal) airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the passenger airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Note: This recall is superseded by recall 2016103. Please see recall 2016103 for more information. <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2016103">Click here for more information</a>
Recall 200701411,298 units in Canada
Steering
On certain vehicles, a manufacturing issue with the front lower ball joint could result in premature wear. If the vehicle is operated for an extended period of time in this condition, the ball joint may eventually experience excessive wear and looseness, resulting in increased steering effort, reduced vehicle self-centering and noise in the front suspension. In extreme cases, when the driver continues to operate the vehicle in this condition, the lower ball joint may separate from the knuckle causing a loss of vehicle steering control. Correction: Dealers will inspect and, if necessary, replace the front lower ball joints.
Reports where the owner recorded a crash, a fire, an injury or a death.
Chicago, ILCrash1 injured
AIR BAGS
2006 TOYOTA SEQUOIA. CONSUMER STATED THAT THE AIRBAG DID NOT DEPLOY DURING AUTO ACCIDENT. THE CONSUMER STATED THE MANUFACTURER DENIED ANY RESPONSIBILITY, STATING THAT THE VEHICLE OPERATED AS DESIGNED. THE MANUFACTURER ADVISED THE VEHICLE'S IMPACT DID NOT REQUIRE THE AIRBAGS TO DEPLOY. THE CONSUMER WAS UNSATISFIED WITH THIS RESPONSE. THE VEHICLE WAS TOTALED. THE CONSUMER REQUESTED A NEWLY REPAIRED VEHICLE AND TO BE COMPENSATED FOR FUTURE ACCIDENTS THAT MAY AFFECT THE DRIVER.
NHTSA complaint #11485635 — an unverified report by a vehicle owner.
at 250,000 milesHeber City, UTCrash1 injured
AIR BAGS
TL* THE CONSUMER OWNS A 2006 TOYOTA SEQUOIA. WHILE DRIVING 15 MPH, THE CONSUMER SLID ON BLACK ICE, LOST CONTROL OF THE VEHICLE, AND CRASHED INTO A METAL BARRIER DIVIDING THE ROAD. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE AIR BAGS DID NOT DEPLOY. THE CONSUMER SUSTAINED NECK AND LEFT ARM INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONSUMER'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 250,000. *LN POLICE REPORT CASE NUMBER: XXXXXXX 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB
NHTSA complaint #11270187 — an unverified report by a vehicle owner.
at 230,000 milesAlbany, MNCrash
SUSPENSION
TL* THE CONTACT OWNED A 2006 TOYOTA SEQUOIA. WHILE DRIVING 5 MPH AND MAKING A LEFT TURN, THE DRIVER'S SIDE BALL JOINT FAILED WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE THE BALL JOINT WAS REPLACED. A YEAR LATER, WHILE THE CONTACT'S WIFE WAS DRIVING 70 MPH, THE PASSENGER SIDE BALL JOINT FAILED WITHOUT WARNING. THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED INTO A MEDIAN. THERE WERE NO INJURIES AND POLICE REPORT NUMBER: P190541059 WAS FILED. THE VEHICLE WAS TOTALED AND TOWED TO A TOW YARD. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THERE WERE NO RECALLS ON THE VEHICLE. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 230,000. THE VIN WAS UNKNOWN.
NHTSA complaint #11258626 — an unverified report by a vehicle owner.
at 204,000 milesTomball, TXCrash1 injured
AIR BAGS
"TAKATA RECALL" WHILE ENTERING THE RAMP TO GET ON THE EASTEX FWY. (IH 59) NORTH BOUND, I OBSERVED THAT UP AHEAD OF ME A VEHICLE WAS IN A COMPLETE STOP WHILE ON THE FREEWAY. I TRIED TO SWITCH LANES BUT I HAD ANOTHER VEHICLE TO MY LEFT WHICH MADE IT IMPOSSIBLE FOR ME TO SWITCH LANES. I THEN RAN INTO THE BACK OF THE OTHER CAR WHICH CAUSED THE ACCIDENT. AFTER COLLIDING WITH THE STOPPED VEHICLE, I WAS THRUST FORWARD INTO THE STEERING WHEEL OF MY CAR. THE DRIVER'S SIDE AIRBAG DID NOT DEPLOY AND THERE WAS NOTHING TO PREVENT MY FACE, HEAD, AND UPPER BODY FROM CRASHING INTO THE STEERING WHEEL AND FRONT WINDSHIELD OF MY CAR.
NHTSA complaint #11123246 — an unverified report by a vehicle owner.
Tucson, AZCrash1 injured
AIR BAGS
TAKATA RECALL ACCIDENT AIRBAG DID NOT DEPLOY , AUTO AIRBAG SETTLEMENT PORTLAND SETTLEMENT , ACCIDENT , DID NOT DEPLOY WHEN HIT !
NHTSA complaint #11019807 — an unverified report by a vehicle owner.
at 159,000 milesWoodland, CACrash
VEHICLE SPEED CONTROL
TOYOTA SEQUOIA (BALL JOINTS RECALL) WAS DRIVING ON HIGHWAY I-5 NORTHBOUND JUST AFTER THE BRIDGE THAT GOES OVER THE SACRAMENTO RIVER I WAS ON THE BYPASS/COSWAY BRIDGE DRIVING IN THE #1 (OF 2) LANE GOING 65 MPH WHEN SUDDENLY MY FRONT END DRIVER'S SIDE OF MY VEHICLE DROPPED COMPLETELY AND I WAS SKIDDING ON COMPLETE METAL, I HAD NO BREAKS AND CONTINUED TO SKID FOR WHAT SEEMED LIKE FOREVER, AND STEERED TO MY TO MY RIGHT PASSING THE #2 LANE GOING UP AGAINST THE EDGE OF THE RIGHT SIDE ON THE BRIDGE. I WAS COMPLETELY SHOCKED. I COULDN'T OPEN MY DRIVER'S SIDE DOOR DUE THE TRAFFIC RIGHT UP AGAINST ME. I IMMEDIATELY CALLED MY INSURANCE ROAD-SIDE ASSISTANCE WHO DISPATCHED A TOW TRUCK. DUE TO THE NATURE OF THE LOCATION, THE TOW TRUCK REQUIRED THE ASSISTANCE OF HIGHWAY PATROL. THE TOW TRUCK DRIVER IMMEDIATELY KNEW ABOUT THIS ISSUE AND SAID TOYOTAS WERE KNOWN FROM THE UPPER/LOWER BALL JOINTS BREAKING ON THEM. THE VEHICLE WAS TAKEN TO VALLEY TIRE SERVICE SHOP. THE SERVICE GUY THERE ALSO KNEW IMMEDIATELY WHAT WAS WRONG WITH IT. THE NEXT DAY I CALLED THE TOYOTA MANUFACTURER TO REPORT THE INCIDENT. I WAS INFORMED THAT THE DEFECTIVE PART WAS IN FACT A RECALL. HOWEVER, THE PART HAD ALREADY BEEN REPLACED IN 2009. AFTER HAVING REVIEWED MANY BLOGS ON LINE ABOUT THIS BEING A COMMON ISSUE WITH TOYOTA SEQUOIAS (SOME MORE THAN ONCE), I WAS EXTREMELY CONCERNED. I AM EXTREMELY CONCERNED AND FEAR DRIVING THIS VEHICLE KNOWING THAT THE DEFECTIVE PART HAVING ALREADY BEEN REPLACED IS STILL DEFECTIVE. I WILL NOT TRUST ANOTHER PART BEING REPLACED ON THIS VEHICLE AND WOULD LIKE TO KNOW WHAT I SHOULD DO. THE CONSUMER NO LONGER OWNS THE VEHICLE. UPDATED 10/04/2017
NHTSA complaint #10970333 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Navarre, FL
UNKNOWN OR OTHER
This Toyota has several large rust holes directly on the frame. i hit a pot hole and more structure damage was revealed on the frame from rust. The truck drives rough now. The vehicle only has 150,000 miles. The rust holes are so severe that they're directly under my suspension. I feel very unsafe driving this vehicle. Their was once a recall for the frame. It doesn't seem that it was satisfied. I'm very worried about this issue. Toyota should have to replace frame or make it safe to drive.
NHTSA complaint #11639427 — an unverified report by a vehicle owner.
Navarre, FL
SUSPENSION
This Toyota has several large rust holes directly on the frame. i hit a pot hole and more structure damage was revealed on the frame from rust. The truck drives rough now. The vehicle only has 150,000 miles. The rust holes are so severe that they're directly under my suspension. I feel very unsafe driving this vehicle. Their was once a recall for the frame. It doesn't seem that it was satisfied. I'm very worried about this issue. Toyota should have to replace frame or make it safe to drive.
NHTSA complaint #11639427 — an unverified report by a vehicle owner.
Navarre, FL
STRUCTURE:BODY
This Toyota has several large rust holes directly on the frame. i hit a pot hole and more structure damage was revealed on the frame from rust. The truck drives rough now. The vehicle only has 150,000 miles. The rust holes are so severe that they're directly under my suspension. I feel very unsafe driving this vehicle. Their was once a recall for the frame. It doesn't seem that it was satisfied. I'm very worried about this issue. Toyota should have to replace frame or make it safe to drive.
NHTSA complaint #11639427 — an unverified report by a vehicle owner.
Tinley Park, IL
STRUCTURE:BODY
Back in 2018 toyota did the undercoat to my 2006 Toyota sequoia frame to prevent rust. Now my frame is completely rotted out to the point i can’t drive my vehicle.
NHTSA complaint #11629218 — an unverified report by a vehicle owner.
Alexandria, VA
STRUCTURE:BODY
Frame of this vehicle has lot of rust damage, is it still under manufacture recall? How can I ensure safety of my vehicle along with rusty frame? I’ll be glad to receive more information how to contact manufacturer in order to get this resolved. I drove this vehicle on Nov 19, 2023 last time just hear some knocking sounds while driving
NHTSA complaint #11556820 — an unverified report by a vehicle owner.
Sheboygan Falls, WI
STRUCTURE:BODY
Frame rusted so badly the the brackets attached to it are coming off
NHTSA complaint #11546216 — an unverified report by a vehicle owner.
Chicago, ILCrash1 injured
AIR BAGS
2006 TOYOTA SEQUOIA. CONSUMER STATED THAT THE AIRBAG DID NOT DEPLOY DURING AUTO ACCIDENT. THE CONSUMER STATED THE MANUFACTURER DENIED ANY RESPONSIBILITY, STATING THAT THE VEHICLE OPERATED AS DESIGNED. THE MANUFACTURER ADVISED THE VEHICLE'S IMPACT DID NOT REQUIRE THE AIRBAGS TO DEPLOY. THE CONSUMER WAS UNSATISFIED WITH THIS RESPONSE. THE VEHICLE WAS TOTALED. THE CONSUMER REQUESTED A NEWLY REPAIRED VEHICLE AND TO BE COMPENSATED FOR FUTURE ACCIDENTS THAT MAY AFFECT THE DRIVER.
NHTSA complaint #11485635 — an unverified report by a vehicle owner.
ADA, MI
UNKNOWN OR OTHER
My vehicle was in dealer shop for various maintenance 3 times (Nov 202 - May 2021 - Jan 2022). Frame rear passenger side rusting to the point I was told not to drive my vehicle on bad roads. Toyota dealer said to replace the frame thru them would cost me $14,000. I cried all the way home because I take exceptional care since I purchased her 2006 new. She is a Cream Puff. This should have been identified sooner. I have not driven her since Jan 3, 2022 because not only me+ (husband & dogs), but also my fellow motorists are at risk. Both my husband & an employee of the dealer shop asked Toyota directly in attempt to get them to replace frame at their expense. Toyota said No.
NHTSA complaint #11462229 — an unverified report by a vehicle owner.
Priest River, ID
STRUCTURE:BODY
The driver side, rear, trailing arm broke away from the vehicles frame due to “frame rot” while driving. The vehicle became extremely dangerous to drive. Toyota has since declined to help. They said they notified us via mail of a customer service campaign addressing the premature rust issue, but we never learned of the program and lawsuit until after the frame broke and I almost crashed. Later I saw the broken arm/frame under the vehicle. This frame failure can potentially be a catastrophic and deadly event. I opened an insurance claim and it was denied and I was referred back to Toyota. Our vehicle has been factory maintained it’s entire life. No service advisors ever mentioned a possible problem to my family and I. I recently spoke to the Toyota service manager at Parker Toyota in Couer d Alene Idaho and his master technicians have seen the same failure that occurred on our vehicle. This is extremely dangerous.
NHTSA complaint #11441232 — an unverified report by a vehicle owner.
at 298,000 milesJanesville, WI
SUSPENSION
The contact owns a 2006 Toyota Sequoia. The contact stated while driving 65 mph, the vehicle experienced the death wobble. The contact stated that the VSC OFF, and the VSC traction and brake warning lights were illuminated. The contact was able to park on the side of the road before deciding to continue to drive. The contact stated while driving to his residence, he heard an abnormal noise. The contact stated while inspecting the vehicle, the rear driver suspension link was detached from the vehicle. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 298,000.
NHTSA complaint #11439099 — an unverified report by a vehicle owner.
Metairie, LA
POWER TRAIN
My front end sounds weird and when I turn my trac lights come on and it tries to turn off but never does I was told my fuel pump was bad I paid 650 for it to be fixed was the issue I believe it is a recall on similar vehicles
NHTSA complaint #11433930 — an unverified report by a vehicle owner.
Metairie, LA
STEERING
My front end sounds weird and when I turn my trac lights come on and it tries to turn off but never does I was told my fuel pump was bad I paid 650 for it to be fixed was the issue I believe it is a recall on similar vehicles
NHTSA complaint #11433930 — an unverified report by a vehicle owner.
Metairie, LA
SUSPENSION
My front end sounds weird and when I turn my trac lights come on and it tries to turn off but never does I was told my fuel pump was bad I paid 650 for it to be fixed was the issue I believe it is a recall on similar vehicles
NHTSA complaint #11433930 — an unverified report by a vehicle owner.
at 198,000 milesMpls, MN
STRUCTURE:BODY
I was on the freeway driving and out of nowhere the body started swaying and bobbing with no control. Was informed by the tow truck driver that i could have rolled the vehicle easily and the consequences would have been serious. The frame is so rusted out that the tie rod and sway bar assembly are completely detached from the frame and hanging loose. Upon further inspection at the auto repair garage there are rusting issues throughout the frame. The frame needs complete replacement.
NHTSA complaint #11433624 — an unverified report by a vehicle owner.
Round Lake, IL
UNKNOWN OR OTHER
Bought the vehicle not knowing it has a rotting frame
NHTSA complaint #11431551 — an unverified report by a vehicle owner.
Finksburg, MD
STRUCTURE:BODY
Frame rusted out and parts dropping off frame with no early warning. Toyota completed corrosion resistant compound 2 years ago following inspection per limited service campaign H0F, saying issue resolved to extent of warranty with known rust issue for this year and model. Now another independent garage saying we never should have been driving, much less hauling 5000 lb. trailer. Only warning was odd sound from under carriage.
NHTSA complaint #11426571 — an unverified report by a vehicle owner.
at 226,000 milesTremont, IL
STRUCTURE:BODY
THE FRAME IS VERY RUSTED
NHTSA complaint #11398038 — an unverified report by a vehicle owner.
at 127,000 milesEscondido, CA
UNKNOWN OR OTHER
I HAVE PURCHASED THE VEHICLE A YEAR AGO. I HAPPEN TO LOOK AT THE CARFAX TODAY AND REALIZE THE CARFAX HAS MORE MILEAGE THEN WHAT IS ON THE ODOMETER.
NHTSA complaint #11326248 — an unverified report by a vehicle owner.
at 127,000 milesEscondido, CA
ELECTRICAL SYSTEM:SOFTWARE
I HAVE PURCHASED THE VEHICLE A YEAR AGO. I HAPPEN TO LOOK AT THE CARFAX TODAY AND REALIZE THE CARFAX HAS MORE MILEAGE THEN WHAT IS ON THE ODOMETER.
NHTSA complaint #11326248 — an unverified report by a vehicle owner.
at 134,000 milesTallahassee, FL
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT WARNING. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE CLEANED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 134,000. TH VIN WAS INVALID.
NHTSA complaint #11320484 — an unverified report by a vehicle owner.
at 110,000 milesCalifornia City, CA
UNKNOWN OR OTHER
I ALMOST KILL MYSELF, THE TRACK OFF GOES WHEN I WAS DRIVING AND MY CAR SLIDE TO THE RIGHT AFTER THAT ALL LIGHTS ON THE CAR WENT ON AND THE CODE READER DO NOT WORK SAYS I CAN'T READ THE CODES NO CODES ON THE COMPUTER
NHTSA complaint #11318279 — an unverified report by a vehicle owner.
at 110,000 milesCalifornia City, CA
SERVICE BRAKES
I ALMOST KILL MYSELF, THE TRACK OFF GOES WHEN I WAS DRIVING AND MY CAR SLIDE TO THE RIGHT AFTER THAT ALL LIGHTS ON THE CAR WENT ON AND THE CODE READER DO NOT WORK SAYS I CAN'T READ THE CODES NO CODES ON THE COMPUTER
NHTSA complaint #11318279 — an unverified report by a vehicle owner.
at 110,000 milesCalifornia City, CA
ELECTRONIC STABILITY CONTROL (ESC)
I ALMOST KILL MYSELF, THE TRACK OFF GOES WHEN I WAS DRIVING AND MY CAR SLIDE TO THE RIGHT AFTER THAT ALL LIGHTS ON THE CAR WENT ON AND THE CODE READER DO NOT WORK SAYS I CAN'T READ THE CODES NO CODES ON THE COMPUTER
NHTSA complaint #11318279 — an unverified report by a vehicle owner.
at 160,000 milesWaynesville, NC
ELECTRONIC STABILITY CONTROL (ESC)
TRACTION CONTROL INTERMITTENTLY KICKS IN WHEN TAKING OFF FROM A STOP. PAVEMENT IS LEVEL AND DRY AT THE TIME. LOSES ACCELERATION FOR A SECOND OR TWO. IT HAS HAPPENED SEVERAL TIMES SINCE 01/03/2020. PROBLEM SEEMS TO BE INCREASING.
NHTSA complaint #11299309 — an unverified report by a vehicle owner.
Celeveland Heights, OH
SUSPENSION
PULLED OUT OF DRIVEWAY AND DROVE 30 FEET TOWARDS A STOP SIGN GOING 15 MPH AND BALL JOINT BROKE AND CAR FELL TO DRIVER SIDE.
NHTSA complaint #11288295 — an unverified report by a vehicle owner.