Owners have filed 194 complaints
about the 2007 Toyota Sequoia with NHTSA between 2007 and 2026.
The largest single group is the airbags.
Across this model's run it ranks 6 of 16 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 32
Against the median year of the Toyota Sequoia. 50 means typical for this
model; 100 means roughly double.
Severity — 56
10.8% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 21
12% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
1040.0%
Frame AND Members
728.0%
Underbody Shields
28.0%
Exhaust System
28.0%
Seat Heater/Cooler
14.0%
Accelerator Pedal
14.0%
Sidewall
14.0%
Lower Ball Joint
14.0%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
32.3%
1,000 – 9,999 miles
32.3%
10,000 – 24,999 miles
53.8%
25,000 – 49,999 miles
2015.4%
50,000 – 74,999 miles
3224.6%
75,000 – 99,999 miles
1813.8%
100,000 – 149,999 miles
2720.8%
150,000+ miles
2216.9%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Feb 2007peak 8Jan 2026
NHTSA investigations into the 2007 Toyota Sequoia
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C...
EA06014Opened 2 Aug 2006Closed 28 Feb 2007SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
LOWER BALL JOINT FAILURE
IN A LETTER DATED JANUARY 18, 2007, TOYOTA NOTIFIED NHTSA OF A SAFETY DEFECT IN MODEL YEAR (MY) 2004 THROUGH 2006 TOYOTA TUNDRA AND MY 2004 THROUGH 2007 TOYOTA SEQUOIA VEHICLES PRODUCED BETWEEN SEPTEMBER 15, 2003 AND NOVEMBER 17, 2006 (NHTSA RECALL NO. 07V-013). ACCORDING TO TOYOTA, ?IN THE FRONT SUSPENSION LOWER BALL JOINT ON THE SUBJECT VEHICLES, DUE TO POSSIBLE IMPROPER FINISHING OF THE BALL JOINT, SUCH AS THE ASPECT OF THE BALL STUD SURFACE, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN PREMATURELY,...
Recalls on the 2007 Toyota Sequoia
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
22E002000
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Tenneco Automotive (DRiV) is recalling certain aftermarket ball joints for 2004-2007 Toyota Sequoia and 2004-2006 Toyota Tundra vehicles, MOOG part number K80521, K80522, NAPA part number NCP2601633, NCP2601634, ACDelco part number 45D2344, and 45D2345. The ball joint housing may have inadequate hardness, causing premature failure.
Risk: A ball joint failure may cause a loss of control, increasing the risk of a crash.
19V741000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
16V396000
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
15V286000
AIR BAGS
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.
Risk: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
15V285000
AIR BAGS
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.
Risk: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
14V743000
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
10V036000
EQUIPMENT:OTHER:LABELS
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Risk: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
07E023000
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Risk: LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 201952337,591 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the passenger-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Action: Owners will be notified by mail and instructed to take their vehicle to a dealer to have the passenger-front airbag inflator or airbag module replaced. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected. Additional Note: Vehicles may have had the original front passenger airbag inflator replaced as a "like-for-like" replacement under recall 2016-103 (Toyota Recall #'s SRC 241 & SRC 242) as a temporary remedy while evaluating a permanent remedy. These vehicles will receive the permanent remedy passenger airbag assembly under this recall.
Recall 2016103400,124 units in Canada
Airbag
On certain vehicles, the passenger (frontal) airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the passenger airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Note: This recall supersedes recalls 2013113, 2014224, 2015197 and 2015269. Correction: All vehicles having not received a replacement inflator as part of the previous recall will now have a replacement inflator installed by dealers. For Matrix model vehicles, dealers may replace the front passenger airbag assembly with one equipped with a newly specified inflator.
Recall 2015269366,860 units in Canada
Airbag
On certain vehicles, the passenger (frontal) airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the passenger airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Note: This recall is superseded by recall 2016103. Please see recall 2016103 for more information. <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2016103">Click here for more information</a>
Recall 200701411,298 units in Canada
Steering
On certain vehicles, a manufacturing issue with the front lower ball joint could result in premature wear. If the vehicle is operated for an extended period of time in this condition, the ball joint may eventually experience excessive wear and looseness, resulting in increased steering effort, reduced vehicle self-centering and noise in the front suspension. In extreme cases, when the driver continues to operate the vehicle in this condition, the lower ball joint may separate from the knuckle causing a loss of vehicle steering control. Correction: Dealers will inspect and, if necessary, replace the front lower ball joints.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 157,400 milesIowa City, IACrash1 injured
AIR BAGS
ON WEDNESDAY, FEBRUARY 7, I WAS DRIVING OUR 2007 TOYOTA SEQUOIA 4X4 ON A RURAL ROAD THAT HAD HAD FRESH SNOW THE NIGHT BEFORE, BUT NO SAND OR OTHER ROAD SALT WAS LAID DOWN. IT IS A CURVY AND HILLY ROAD. I HAD DRIVEN ON THE ROAD AN HOUR EARLIER WITH NO PROBLEMS. AT APPROXIMATELY 9AM, I ENCOUNTERED A PATCH OF ICE WHERE THERE WAS A CURVE IN THE ROAD AND MY SUV THAT HAD BRAND NEW MICHELIN TIRES ON COLLIDED WITH A TREE THAT WAS PART OF AN ISLAND IN THE MIDDLE OF THE ROAD. THE TREE WAS APPROXIMATELY 15 INCHES IN DIAMETER. THE COLLISION STRUCK DIRECTLY ON LEFT SIDE OF ENGINE BY HEADLIGHT'PLOWING IN APPROXIMATELY 9 INCHES AND DEFLATED FRONT TIRE. FRONT SUSPENSION WAS BROKEN AS IS HOOD ( SEE PICTURE). NO AIRBAGS DEPLOYED?? I WAS GOING APPROXIMATELY 25-30 MPH AT IMPACT. MY AIRBAG ON DRIVERS SIDE WAS RECALLED WITH TAKATA RECALL AND REPLACED , BUT I WONDER IF IT WAS INSTALLED PROPERLY OR WRONG? I SUFFERED A CONCUSSION AND OTHER TRAUMA TOYOTA DEALER BODY SHOP INDICATES THAT ALL SENSORS FOR AIRBAGS ON FRAME ONLY AND SINCE FRAME NOT HIT NO DEPLOYMENT??
NHTSA complaint #11073193 — an unverified report by a vehicle owner.
at 157,400 milesIowa City, IACrash1 injured
SUSPENSION
ON WEDNESDAY, FEBRUARY 7, I WAS DRIVING OUR 2007 TOYOTA SEQUOIA 4X4 ON A RURAL ROAD THAT HAD HAD FRESH SNOW THE NIGHT BEFORE, BUT NO SAND OR OTHER ROAD SALT WAS LAID DOWN. IT IS A CURVY AND HILLY ROAD. I HAD DRIVEN ON THE ROAD AN HOUR EARLIER WITH NO PROBLEMS. AT APPROXIMATELY 9AM, I ENCOUNTERED A PATCH OF ICE WHERE THERE WAS A CURVE IN THE ROAD AND MY SUV THAT HAD BRAND NEW MICHELIN TIRES ON COLLIDED WITH A TREE THAT WAS PART OF AN ISLAND IN THE MIDDLE OF THE ROAD. THE TREE WAS APPROXIMATELY 15 INCHES IN DIAMETER. THE COLLISION STRUCK DIRECTLY ON LEFT SIDE OF ENGINE BY HEADLIGHT'PLOWING IN APPROXIMATELY 9 INCHES AND DEFLATED FRONT TIRE. FRONT SUSPENSION WAS BROKEN AS IS HOOD ( SEE PICTURE). NO AIRBAGS DEPLOYED?? I WAS GOING APPROXIMATELY 25-30 MPH AT IMPACT. MY AIRBAG ON DRIVERS SIDE WAS RECALLED WITH TAKATA RECALL AND REPLACED , BUT I WONDER IF IT WAS INSTALLED PROPERLY OR WRONG? I SUFFERED A CONCUSSION AND OTHER TRAUMA TOYOTA DEALER BODY SHOP INDICATES THAT ALL SENSORS FOR AIRBAGS ON FRAME ONLY AND SINCE FRAME NOT HIT NO DEPLOYMENT??
NHTSA complaint #11073193 — an unverified report by a vehicle owner.
at 157,400 milesIowa City, IACrash1 injured
STRUCTURE:BODY
ON WEDNESDAY, FEBRUARY 7, I WAS DRIVING OUR 2007 TOYOTA SEQUOIA 4X4 ON A RURAL ROAD THAT HAD HAD FRESH SNOW THE NIGHT BEFORE, BUT NO SAND OR OTHER ROAD SALT WAS LAID DOWN. IT IS A CURVY AND HILLY ROAD. I HAD DRIVEN ON THE ROAD AN HOUR EARLIER WITH NO PROBLEMS. AT APPROXIMATELY 9AM, I ENCOUNTERED A PATCH OF ICE WHERE THERE WAS A CURVE IN THE ROAD AND MY SUV THAT HAD BRAND NEW MICHELIN TIRES ON COLLIDED WITH A TREE THAT WAS PART OF AN ISLAND IN THE MIDDLE OF THE ROAD. THE TREE WAS APPROXIMATELY 15 INCHES IN DIAMETER. THE COLLISION STRUCK DIRECTLY ON LEFT SIDE OF ENGINE BY HEADLIGHT'PLOWING IN APPROXIMATELY 9 INCHES AND DEFLATED FRONT TIRE. FRONT SUSPENSION WAS BROKEN AS IS HOOD ( SEE PICTURE). NO AIRBAGS DEPLOYED?? I WAS GOING APPROXIMATELY 25-30 MPH AT IMPACT. MY AIRBAG ON DRIVERS SIDE WAS RECALLED WITH TAKATA RECALL AND REPLACED , BUT I WONDER IF IT WAS INSTALLED PROPERLY OR WRONG? I SUFFERED A CONCUSSION AND OTHER TRAUMA TOYOTA DEALER BODY SHOP INDICATES THAT ALL SENSORS FOR AIRBAGS ON FRAME ONLY AND SINCE FRAME NOT HIT NO DEPLOYMENT??
NHTSA complaint #11073193 — an unverified report by a vehicle owner.
Lagrange, GACrash1 injured
FUEL/PROPULSION SYSTEM
ACCELERATOR STUCK WHEN PARKING (<5 MPH) CAUSING VEHICLE TO STRIKE A CURB AND 1 FT RETAINER WALL RESULTING IN GOING AIRBORNE UP A 3' BANK, OVER A 6' SIDEWALK AND 8' GRASS AREA TO STRIKE AN OFFICE BUILDING. LOCATION WAS KIA DRIVE LAGRANGE, GA. MY WIFE WAS DRIVING AND INJURED HER RIGHT FOREARM. NO BROKEN BONE, JUST BUMPED AND REMAINS SORE. VEHICLE WAS MFG IN AUGUST 07. WE TOOK DELIVERY IN SEPT AFTER PLACING AN ORDER. I SAW RECALL ON 08 THRU 12 BUT NOT 07. WONDERING IF LATE 07 HAD A 08 ACCELERATOR INSTALLED? PHOTO FILES WERE RESIZED TO SMALLLER IMAGES FOR SENDING.
NHTSA complaint #10960029 — an unverified report by a vehicle owner.
at 159,647 milesHanover, MDFire
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
TL* THE CONTACT OWNS A 2007 TOYOTA SEQUOIA. THE CONTACT NOTICED AN ABNORMAL ODOR AND OBSERVED BURN HOLES IN THE PASSENGER SEAT. THE CONTACT DISCONNECTED THE SEAT HEATER. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 159,647.
NHTSA complaint #10853633 — an unverified report by a vehicle owner.
at 155,170 milesFlorence, OR1 injured
SEATS
THE REAR LATCH WOULD NOT WORK DURING A CAMPING TRIP IN A REMOTE AREA. THE REAR SEATS HAD BEEN REMOVED AS PER THE OWNERS MANUAL PRIOR TO THE TRIP. THE REAR PORTION OF THE VEHICLE WAS FULL OF CAMPING GEAR, FOOD, WATER, AND OUR FIRST AIDE KIT . I SPRAINED MY HAND AND BACK WHILE FIRST ATTEMPTING REPEATED TIMES TO OPEN THE TAILGATE AND THEN HAVING TO RESORT TO LIFTING HEAVY EQUIPMENT THROUGH THE BACK WINDOW AND ALSO OVER THE PASSENGER SEATS. WE TOOK THE VEHICLE TO A TOYOTA DEALER AT OUT FIRST OPPORTUNITY. WE WERE TOLD THAT TOYOTA WAS AWARE OF THE PROBLEM WHICH WAS DESCRIBED TO MY WIFE AND I AS WEAK ENGINEERING AND A PLASTIC PART ALSO KNOW TO FAIL. WE WERE TOLD THAT THE FAILURE COULD HAVE BEEN RAISED BY DRIVING THE VEHICLE ON DUSTY ROADS, BECAUSE THE LATCH WAS NOT PROTECTED FROM DUST AND IT WAS POORLY DESIGNED AND WAS LIKELY TO FAIL IF IT GOT DIRTY. WE LEARNED FROM THIS DEALER THAT WE HAD ALREADY HAD THE LATCH REPLACED A YEAR PRIOR. WE WERE TOLD THAT TOYOTA WOULD NO LONGER STAND BEHIND REPAIRS TO THIS VEHICLES TAILGATE LATCH BECAUSE THE PROBLEM WAS CHRONIC AND THE REPLACEMENT PARTS HAVE NOT BEEN IMPROVE TO PREVENT EXPECTED FAILURES. THE DEALER REPLACED, CLEANED AND LUBRICATE THE LATCH PARTS AND THEN ATTEMPTED TO PROTECT THEM USING A SURPLUS PLASTIC BAG. I AM CONCERNED THAT WHEN THE LATCH FAILS AGAIN IT MAY BE DURING AN EMERGENCY, OR CAUSE ANOTHER INJURY, OR ENTRAPMENT...
NHTSA complaint #10714286 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Edmond, OK
STRUCTURE:BODY
Tail gate handle broke (second time). dealer fixed the first time. If I have a flat tire, I can't get to the spare tire.
NHTSA complaint #11710293 — an unverified report by a vehicle owner.
Cape Girardeau, MO
STEERING
Turned into a laundromat parking lot and my balljoint snapped and my truck was sitting on the ground on the driver side front. Bent my fender and door also.
NHTSA complaint #11707612 — an unverified report by a vehicle owner.
Cape Girardeau, MO
SUSPENSION
Turned into a laundromat parking lot and my balljoint snapped and my truck was sitting on the ground on the driver side front. Bent my fender and door also.
NHTSA complaint #11707612 — an unverified report by a vehicle owner.
Litchfield, MN
UNKNOWN OR OTHER
The frame of the vehicle is rusting away despite being sprayed with rust inhibitor during the frame recall. The vehicle was considered unsafe to drive due to large holes in the frame just 3 years after being sprayed by Toyota.
NHTSA complaint #11664860 — an unverified report by a vehicle owner.
Chicago, IL
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The rear gate door or Deck lid will not open. with either key, or any other method. Every time this occurs, I have to take to the body shop to open and pay $200 for them to open it. They have to climb to the back, dismantle the rear door panels from the inside and undo some mechanisms to open it finally. The shop stated that they have had this problem with these Sequoias many times.
NHTSA complaint #11640629 — an unverified report by a vehicle owner.
Wasilla, AK
UNKNOWN OR OTHER
Rear hatch/latch. I purchased my 2007 Sequoia lightly used in 2013. Luckily I purchased a 3 year extended warranty also. Within a year my rear hatch broke for the 1st time, I was unable to open the rear gate, my warranty covered the parts & Labor, within a year it broke again, this time the door would not latch closed, it freely opened & would or could not be secured. This happened while out of town (Fairbanks, AK. In Feb. -40 degrees) luckily the dealership had the parts & was able to fix it quickly. Still covered by my extended warranty. That dealership told me about the consistent problem & I was told about the cheap parts, but also a poor design as far as weather & grime able to reach the components & cause corrosion quickly. It broke one more time before my warranty expired (#3) again unable to open the rear gate. That repair didn’t even last 3 months, But the warranty was expired & I had a very reliable mechanic replace it this time (#4). Much cheaper than what Toyota wanted to charge me. He did a little weather preventative repair and I actually got nearly 2 years on that repair. He also said it was a terrible design flaw on the rear hatch, & there was significant corrosion on many other parts in the rear gate. He cleaned it up as well as possible. When it broke the 5th time, I was furious, & couldn’t see the point of the $750.00+ repair (Alaska is more $$), again was broken in the unable to open position. So I used the window & crawling over the seats method for over a year, until my window started making horrible noise when opening. I made an appointment with Toyota in Anchorage, AK to repair it this time as I had a recall taken care of at the same time. The only visible corrosion on the vehicle was around the latch, the window does not work properly, & you hear parts rattling when you open & close the gate now. I realize the open gate break is not common, But that was a horribly dangerous situation, recall is needed immediately for safety & reputation
NHTSA complaint #11634769 — an unverified report by a vehicle owner.
at 138,000 milesGreenfield, WI
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2007 Toyota Sequoia. The contact stated while the vehicle was parked, the contact noticed that the rear subframe was fractured. The vehicle was taken to an independent mechanic where it was determined that the rear subframe needed to be replaced. The vehicle was not repaired. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 138,000.
NHTSA complaint #11633912 — an unverified report by a vehicle owner.
Pelham, NH
SUSPENSION
2007 Toyota Sequoia frame completely deteriorated and rusted through. I discovered this when brining my vehicle in for the Toyota Airbag Recall when the technician brought this safety issue to my attention. Previous driving had been extremely unstable and buckled when I was on the highway. Since discovering the frame issue, I stopped driving the vehicle. I believe this is a safety issue caused by a defective frame that Toyota is aware of and had issue a past recall for. The Toyota dealer has made a video of the deteriorated frame and has commented that the vehicle is a safety issue.
NHTSA complaint #11597103 — an unverified report by a vehicle owner.
Grand Prairie, TX
ELECTRICAL SYSTEM
Doors not locking with key fob. Have to manually lock all doors by hand. Sometimes the key fob arms the security and sometimes it doesn’t. I’ve replaced the key fob and tried to program new fob but cannot program, hooked up a scanner to run for codes and 1 showed a (B1242 - wireless door lock tuner circuit)
NHTSA complaint #11565897 — an unverified report by a vehicle owner.
Pinehurst, NC
STRUCTURE:BODY
Purchased this vehicle with a clear title and then noticed it has frame rot.
NHTSA complaint #11556595 — an unverified report by a vehicle owner.
Eaglelake, ME
UNKNOWN OR OTHER
Plan road trip Had Vehicle thoroughly. Inspected only to find that the frame was cracked on goth side and all brake lines are corroded. Called several places to get help with this matter, only to have no help at all. Spoke to many people final communication was with [XXX] in Tennessee who admitted the prior owner was notified as to the issue I have owned this vehicle for 6 yrs and could not understand why the Prior owner was notified and not I. I find that due to not notifying the correct owner they should allow me to have this issue taken care of, but they are not cooperating with me I would like to take this matter further and have them accountable for this safety issue and neglect as to contacting the existing owner. reaching out for help Sincerely [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11548140 — an unverified report by a vehicle owner.
Eaglelake, ME
SERVICE BRAKES
Plan road trip Had Vehicle thoroughly. Inspected only to find that the frame was cracked on goth side and all brake lines are corroded. Called several places to get help with this matter, only to have no help at all. Spoke to many people final communication was with [XXX] in Tennessee who admitted the prior owner was notified as to the issue I have owned this vehicle for 6 yrs and could not understand why the Prior owner was notified and not I. I find that due to not notifying the correct owner they should allow me to have this issue taken care of, but they are not cooperating with me I would like to take this matter further and have them accountable for this safety issue and neglect as to contacting the existing owner. reaching out for help Sincerely [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11548140 — an unverified report by a vehicle owner.
Vero Beach, FL
TIRES:SIDEWALL
Selling Old tires as if they were new On May 1st 2023, I took my 2007 Toyota Sequoia to Toyota of Vero Beach to be serviced. They advised me that my 2 Goodyear tires were dry rotting and cracking. The tires were purchased in 5/14/2019. The odometer read 181923 the mileage when they were inspected by Toyota was 205140 a difference of 23,217 miles and show no wear. I called the mechanic stated I purchased the tires in 2010, how could they be dry rotting and cracking. The mechanic looked up the serial number and determined they were made in 2015 and were 8 years old. The tires are P265/65R17 110S S2 WRL SR-A TL MFG. No. M7AHEXWR2316 and M7AHEXWR2315. I can’t understand how you can sell me tires that are 5 years old and pass them off as new. That is not what I bargained for! This is unconscionable and dangerous since this vehicle is used to tow a heavy boat.
NHTSA complaint #11523979 — an unverified report by a vehicle owner.
Westfield, MA
POWER TRAIN
the transmission seems to be slipping cs when taking off rpms goes up then vehicle takes off cs when going uphill around 40 vehicle struggles and does not shifts down..need replace transmission...
NHTSA complaint #11522725 — an unverified report by a vehicle owner.
Westfield, MA
VEHICLE SPEED CONTROL
the transmission seems to be slipping cs when taking off rpms goes up then vehicle takes off cs when going uphill around 40 vehicle struggles and does not shifts down..need replace transmission...
NHTSA complaint #11522725 — an unverified report by a vehicle owner.
Westfield, MA
UNKNOWN OR OTHER
the transmission seems to be slipping cs when taking off rpms goes up then vehicle takes off cs when going uphill around 40 vehicle struggles and does not shifts down..need replace transmission...
NHTSA complaint #11522725 — an unverified report by a vehicle owner.
at 48,000 milesOakdale, CT
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2007 Toyota Sequoia. The contact stated that while driving at an undisclosed speed, the vehicle made abnormal sounds. The vehicle was taken to an independent mechanic, who diagnosed that there were holes in the subframe and that the subframe needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but confirmed that an unknown recall had expired. The failure mileage was approximately 48,000.
NHTSA complaint #11522206 — an unverified report by a vehicle owner.
at 187,000 milesWestfield, MA
POWER TRAIN:MANUAL TRANSMISSION
The contact owns a 2007 Toyota Sequoia. The contact stated while at a stop light and attempting to accelerate, the vehicle hesitated with the traction control warning light illuminated. The contact stated that after several seconds, the vehicle accelerated normally. The vehicle was taken to the dealer and the dealer stated that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but provided no assistance. The approximate failure mileage was 187,000.
NHTSA complaint #11519436 — an unverified report by a vehicle owner.
at 320,000 milesFront Royal, VA
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2007 Toyota Sequoia. The contact stated that while the vehicle was in for inspection, it was discovered that the rear subframe had multiple holes due to rusting and corrosion. The vehicle was taken to an independent mechanic who repaired and welded the rear subframe of the vehicle. The contact indicated that in 2017 the vehicle was serviced under the Manufacturer Extended Warranty Service Campaign regarding rusting and corrosion of the subframe. The contact indicated that the failure occurred. The manufacturer and local dealer were notified of the failure. The failure mileage was 320,000.
NHTSA complaint #11495285 — an unverified report by a vehicle owner.
old Greenwich, CT
SUSPENSION
car is not recalled yet the same model year is recalled from 2007, this problem effects my car as well as cars made earlier in the year. The suspension is unstable and joints are worn in many places ball joints and other steering effecting joints. The car makes sudden side movements like the wheel is about to fall off or the tire fell off the time but the tires are properly inflated. Repair estimated are atleast $600 possibly $1200 as it is worn in 2 places The problem is on the passenger side front. The car has 114000 miles. There is no recall on this car but other Sequoias made the same year are recalled This is pretty obvious the problem was in the design and not the date of manufacture.
NHTSA complaint #11494966 — an unverified report by a vehicle owner.
Induanapolis, IN
UNKNOWN OR OTHER
Frame is completely rusted. Almost the body is about to detach from the frame. A very safety issue. This vehicle was never taken to Toyota for rusted frame at the time of the recall. Toyota must resolve this issue because it's safety matter as the frame can separate from the body at any time.
NHTSA complaint #11493574 — an unverified report by a vehicle owner.
Etobicoke, NY
UNKNOWN OR OTHER
Hi I have this 2007 Toyota sequoia. It has a rusty rotten frame with holes. I called Toyota in the past about but they didn't do any thing and I never received any recall notice form Toyota about frame. What should I do ?. Thanks [XXX] Sorry I put wrong address. I live in Canada and Vehicle is also registered in Canada. My address is [XXX]. [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11487521 — an unverified report by a vehicle owner.
Etobicoke, NY
STRUCTURE:BODY
Hi I have this 2007 Toyota sequoia. It has a rusty rotten frame with holes. I called Toyota in the past about but they didn't do any thing and I never received any recall notice form Toyota about frame. What should I do ?. Thanks [XXX] Sorry I put wrong address. I live in Canada and Vehicle is also registered in Canada. My address is [XXX]. [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11487521 — an unverified report by a vehicle owner.
Brownsville, TX
UNKNOWN OR OTHER
I noticed under my SUV frame is alot of rust on several areas.and I read about the recall on sequoias frames and I would like you to help me to resolve this problem thanks. Note que de Abajo de mi sequoia en El chassis hay Mucha picadura en diferente areas y no me siento Agusto con Este detalle de Toyota no SE si se pueda hacer Algo por seguridad Mia Al manejarla no me gustaria un dia venderla y venderla asi si me puede ayudar con esto se los agradrseria escuche que habia un recall en Esto de Los frames muchas gracias.
NHTSA complaint #11447814 — an unverified report by a vehicle owner.
Brownsville, TX
STRUCTURE:BODY
I noticed under my SUV frame is alot of rust on several areas.and I read about the recall on sequoias frames and I would like you to help me to resolve this problem thanks. Note que de Abajo de mi sequoia en El chassis hay Mucha picadura en diferente areas y no me siento Agusto con Este detalle de Toyota no SE si se pueda hacer Algo por seguridad Mia Al manejarla no me gustaria un dia venderla y venderla asi si me puede ayudar con esto se los agradrseria escuche que habia un recall en Esto de Los frames muchas gracias.
NHTSA complaint #11447814 — an unverified report by a vehicle owner.