Toyota Sequoia steering problems

STEERING

Turned into a laundromat parking lot and my balljoint snapped and my truck was sitting on the ground on the driver side front. Bent my fender and door also.

NHTSA complaint #11707612 — an unverified report by a vehicle owner.

STEERING

I was driving my 2002 Toyota Sequoia on the freeway at approximately 65 mph on the [XXX] when suddenly the vehicle made a beeping noise and the VSC Light and TRAC Light came on. The vehicle suddenly lost control in the wheels and tires and suddenly decelerated out-of-nowhere. Due to the sudden, abrupt movement and loss of control, the vehicle nearly flipped over. It was an extremely dangerous, possibly life-threatening situation. Thankfully, I was attentive and alert and had both hands on the wheel and was able to get the vehicle in control. This happened before two times and this would be the third time. I have taken the vehicle to several different auto repair shops and they have been unable to pin point and fix the problem. Because this issue continues to happen and puts me into dangerous situations repeatedly, I firmly believe that this is a bigger malfunctioning/defect problem that Toyota needs to address and fix. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11684034 — an unverified report by a vehicle owner.

STEERING

Power steering rack assembly malfunctioned and started shaking violently. Upon inspection, a fluid leak was found from the passenger side of the steering rack.

NHTSA complaint #11609103 — an unverified report by a vehicle owner.

STEERING:RACK AND PINION

The contact owns a 2018 Toyota Sequoia. The contact stated that while having routine maintenance at the local dealer, he was informed that the outer seals were leaking and full of fluid. The vehicle was diagnosed, and it was determined that the rack and pinion seals had failed. The outer seals were leaking and full of fluid. The vehicle was repaired. The contact stated that the failure was related to NHTSA Campaign Number: 21E103000 (Steering). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 100,000.

NHTSA complaint #11592886 — an unverified report by a vehicle owner.

STEERING

On [XXX] while driving our 2011 Toyota Sequoia 4x4 Limited (5.7 iforce non flex fuel) my wife was preparing to stop at a traffic light. Completely unexpected and with no warning, the vehicle started bucking, the engine began making a knocking noise and numerous dashboard lights started flashing. It immediately stalled while attempting to stop, thus, causing a very dangerous situation, losing total control of the brakes and steering, nearly causing a collision with the vehicle in front of her. The vehicle had to be towed from the middle of the road, while in heavy traffic. Eventually it was diagnosed (at my mechanics shop) and determined to be a broken valve spring in cylinder #7. This caused the valve to drop into the cylinder bore, making contact with the piston, known as "catastrophic failure on an 'interference' engine"..I later learned that these DEFECTIVE ($5) valve springs, are used in my meticulously maintained 5.7 Toyota motor,...THE SAME PART NUMBER UNDER RECALL IN SEVERAL LEXUS VEHICLES!! Being that I constantly maintained this vehicle and it being in overall excellent condition, I determined it was less expensive to have the engine replaced over repaired. I spent over $4600 in a used motor with 88k miles, and $5400 in labor for the replacement.. total cost of over $10,000 for a $5 defective part that was only recalled on the Lexus vehicles. I kept the original engine in case I can (eventually) have Toyota Corp do an inspection on it and get some kind of compensation on this dangerous, avoidable, selective vehicle recall. No luck thus far but have pictures, invoices and all documents on this situation that I can provide when requested. I am having difficulty downloading these documents to this site. Thank you very much. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11578821 — an unverified report by a vehicle owner.

STEERING

Front end in rolled shacking. Tires wearing extremely fast and uneven image. Unable to drive

NHTSA complaint #11576522 — an unverified report by a vehicle owner.

STEERING

Traction control warning lights, VSC warning lights. These lights have been on for 2 years, resulting in check engine light on. I have replaced every sensor possible, fuses, gas cap, and reset the system multiple times but can not get these lights to stay off. Since lights have been on, when driving on a muddy, wet, icy or slippery road way, my steering locks up, the brakes stop working and there is complete loss of vehicle control. All without warning. This is an extreme hazard and very dangerous. This has been on going since 2017 and is still a major problem . It started at around 200,000 miles.

NHTSA complaint #11566695 — an unverified report by a vehicle owner.

STEERING

While driving on a curved road, the vehicle made a grinding sound with flashing VSC off and Trac off lights, as it pulled violently to the right and almost ran off the road with my two children in the back seat. This was an extremely scary incident. I 1. While driving on a curved road, the vehicle made a grinding sound with flashing VSC off and Trac off lights, as it pulled violently to the right and almost ran off the road with my two children in the back seat. This was an extremely scary incident. I do understand that many first generation Sequoia owners have reported similar incidents and that there were no recalls, however, I think this is a serious enough issue that will cost innocent people their lives. I was able to pull a reading from the OBD2 and it says there is a fault with the Yaw Rate Sensor. Please help before this causes someone's death. Thank you!do understand that many first generation Sequoia owners have reported similar incidents and that there were no recalls, however, I think this is a serious enough issue that will cost innocent people their lives. I was able to pull a reading from the OBD2 and it says there is a fault with the Yaw Rate Sensor. Please help before this causes someone's death. Thank you!

NHTSA complaint #11548841 — an unverified report by a vehicle owner.

STEERING

I took my 2019 Sequoia to Toyota of Knoxville for scheduled maintenance and was told the boots on my rack of my power steering has a leak and needs to be repaired for the cost of $2000. My Sequoia has 84,308 miles and I was told this was caused by "normal wear and tear." When I started looking into it I found a recall for 2008-2022 Sequoias with the exact same issue as mine (Toyota Recall 21TB10 or 21TA10) issued on November 22, 2021, but was told that despite my car having the same issue that it was not covered by the recall and I would have to pay for repairs to-of-pocket. Upon further research, the number one cause for leaks in power steering is age and use, again, my Sequoia is a 2019 with 84,308 miles, so neither would apply.

NHTSA complaint #11542145 — an unverified report by a vehicle owner.

STEERING

While driving my 2001 Sequoia SR5 with only 74,750 miles on freeways at speeds between 55 and 65 mph, the SUV's braking system activates unexpectedly and without cause. The VSC check engine lighting and warning sound illuminate. My SUV veered to the right, the steering wheel vibrated, and it went into a skid when the brakes were abruptly engaged, causing it to skid. My SUV abruptly decelerated as if it had lost power. This situation was hazardous for other vehicles who could not tell if they were applying the brakes due to the absence of visible brake lights to prevent a collision. Fortunately, I responded defensively and avoided collisions with other vehicles and roadside obstacles. This issue is a safety concern; if it occurs at the wrong moment, a tragedy can be avoided. I've seen more than a hundred complaints from other proprietors and a completed NHTSA investigation. Sequoia models from 2001 and subsequent years were recalled for the same issue. Before a life is lost, Toyota must address this issue in all model years.

NHTSA complaint #11537179 — an unverified report by a vehicle owner.

STEERING

Frame deterioration has rendered the rear torque arm incapable resulting in dynamic misalignment of the rear axle. Under acceleration the vehicle veers into oncoming traffic and under deceleration it veers towards the road ditch as the axle shifts about beneath the vehicle.

NHTSA complaint #11488948 — an unverified report by a vehicle owner.

STEERING

While driving on a highway at about 60 mph, my vehicle made a loud grinding noise while the steering felt very difficult to control and then the VSC TRAC and TRAC OFF lights both came on. I got off the highway and pulled over to a parking lot to inspect the vehicle, but I did not see anything that would cause the vehicle to do that. After a few minutes, I restarted the vehicle and while driving on local roads to get home, the same thing happened again. I was extremely worried for the safety of my wife and children in the vehicle. After reading a few Toyota owners threads online, this seems to be a very familiar pattern with these Toyota Sequoias, and I strongly believe that this will result in very serious injuries or possible deaths if Toyota does not issue a recall to fix the problem causing such dangers for drivers. Please investigate the matter to save lives. Thank you!

NHTSA complaint #11484462 — an unverified report by a vehicle owner.

STEERING

I was coming off the highway goi g down the off ramp at a rate of speed in line with the speed limit, and the vsc/abs/brake lights all came on. The truck started making a grinding noise and was difficult to control. I pulled over and checked underneath. Everything was fine and there was no sign of an issue. I turned the truck off and on, and all the lights cleared; however, the lights turn on again when the vehicle is cold. Once it warms up, and you turn the car on and off, the clear. No codes on the scanner. Forums say this happens regularly with this make, model and year, but no one is sure what it is. Everything from emissions, to the brake sensor to the yaw rate sensor.

NHTSA complaint #11483918 — an unverified report by a vehicle owner.

STEERING

Rack and pinion rusted out and had to be replaced. It cracked in the middle of the highway and left me inching to safety. Never fully recovered 186k, frame is fully rusted and will not pass inspection due to faulty oxygen sensors and excessive rust and corrosion. Will need to replace exhaust to input a new sensor at 4k Vechicle is fully operable and functional but cannot pass inspection without the safety of rust treatment or replacement It’s a great vechicle but unfortunate that the 2002 series is left out of the recall . There are a lot of early generations that have these issues and although the trucks are reliable and have a long life , are undriveable because they can’t pass inspection. Please consider extended the rust recall to 2001-2003 Sequoias. This was my grandfathers truck and really would like to keep his memory in the family and drive my grandfathers truck as it still runs perfectly but has on going issues with rust and frame issues . There was an extended warranty for 2002 Sequoias that expired in 2014. This is a point where most Sequioas weren’t experiencing this issue. Dealership or recall will not honor and denied any claim for rust It is unfortunate because I am now disabled and love my Sequoia so much and was hoping to drive to appointments and gain my health back. It has become more than I am able to afford to fix an entire frame of the vehicle. It’s evident that early generations all that his issue but has not been honored for repair. I’ve repaired things over the years with hopes to pass inspection and now have insight as to what the real issue is. The excessive rust and damage to the frame.

NHTSA complaint #11474941 — an unverified report by a vehicle owner.

STEERING

Abnormal rust all over underside of vehicle including frame, structural components, brake lines, steering components … etc. FRAME and steering/suspension components rusting out. Rear differential rusting out. Cab mounts rusting out. Spare tire hardware rusting out. Transmission cooler lines about to burst from corrosion. Rear tow assembly rusting out. Entire underside is rotting out. Known issue which has plagued hundreds of owners, but Toyota has not recalled this model year. Extremely dangerous; one brake line has already gone out resulting in a loss of braking. Toyota applied an undercoating circa 2013 but they just sprayed over an already rusted frame and other components without proper preparation which actually accelerated the corrosion and rot. Deceptive and unethical business practices. Vehicle cost over $50,000 new in 2003 and only has just over 120,000 miles on it. This should NOT be happening. Please help. Please investigate.

NHTSA complaint #11471811 — an unverified report by a vehicle owner.

STEERING

Lower ball joint on drivers side sheared off.

NHTSA complaint #11459943 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2022 Toyota Sequoia. The contact received a recall notification for NHTSA Campaign Number: 21V920000 (Steering). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The part was not available for repair. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11449736 — an unverified report by a vehicle owner.

STEERING

The frame of the vehicle has severe rust and now has holes in the frame, making it unsafe to drive and possibly causing an accident. Meticulous care has been taken of this vehicle and it is never taken off road or abused. I’ve had several other vehicles and have never had this frame rust safety issue.

NHTSA complaint #11441396 — an unverified report by a vehicle owner.

STEERING

My front end sounds weird and when I turn my trac lights come on and it tries to turn off but never does I was told my fuel pump was bad I paid 650 for it to be fixed was the issue I believe it is a recall on similar vehicles

NHTSA complaint #11433930 — an unverified report by a vehicle owner.