2016 Toyota Tundra other reported problems

UNKNOWN OR OTHER

The frame of the truck is extremely rusted. I am unsure if it can be fixed. It is available for inspection. This 2016 Tundra has 71,000 miles and is used as a third car. It has been serviced at the same dealership (Northshore Toyota, Covington, LA) and we were never informed of the damage by the dealership. My safety is at risk because the extensive rust could cause the frame to fail. Previous Tundra models have been recalled because of the same issues. No warnings were issued even after the dealership serviced the truck on a lift numerous times (approximately 9 years). The only previous warning by the dealership was on 1/29/2025 when the dealership informed us of a rusty trailer hitch. The truck was brought to 4 body shops in the local area after the owner went to work on the trailer hitch and saw the damage. All 4 shops confirmed that the rust was extensive. 3 shops would not fix the damage because it would be an expensive/extensive fix. We are waiting on what shop #4 says.

NHTSA complaint #11643127 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

THE POWER LOCKS FOR THE FRONT DRIVER SIDE AND PASSENGER SIDE FAIL TO WORK AS EXPECTED. IT IS NOT CONSISTENT. WHEN DRIVING, IT IS SUPPOSED TO LOCK AUTOMATICALLY FOR SAFETY BUT DOES NOT ALWAYS LOCK (OR UNLOCK WITH THE KEY FOB WHEN NEEDING TO GET INTO THE VEHICLE. PROBLEM OCCURS WHEN VEHICLE IS STATIONARY OR MOVING.

NHTSA complaint #11316264 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

REAR WHEEL OR AXLE BEARINGS MAKE A NOTICEABLE LOUD HUMMING SOUND WHEN DRIVING AT ROAD SPEED LIMIT, ESPECIALLY WHEN MOVING SLIGHTLY LEFT INTO A CURVE OR RIGHT INTO A CURVE.

NHTSA complaint #11242929 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

INTEGRATED TRAILER BRAKE CONTROLLER INTERMITENT FAILURE. TRAILER BRAKES WORK FOR A FEW BRAKING CYCLES THEN FAIL COMPLETELY WITH AN ERROR MESSAGE ON THE TRUCK OF "TRAILER WIRING TYPE, OR CONNECTION FAULT". TURNING THE VEHICLE OFF AND ON RESETS THE CONTROLLER AND "FIXES" THE PROBLEM UNTIL ANOTHER FEW BRAKING CYCLES, THEN REPEATS.

NHTSA complaint #11230497 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

TODAY 01/31/2019 I WAS DRIVING MY 2016 TOYOTA TUNDRA 1794 CREW MAX TRUCK ON THE FREEWAY IN OAKLAND, CA AROUND 1:30 PM. I HAD BEEN DRIVING WITH THE REAR (FACING) WINDOW DOWN APPROXIMATELY 8 " I WAS IN THE PROCESS OF CLOSING THE REAR ELECTRIC WINDOW AND JUST AS IT CLOSED I DROVE OVER A STEEL TRENCH PLATE THAT HAD BEEN PLACED ON THE FREEWAY BY CAL TRANS ALL 3 THINGS HAPPENED AT ONCE, THE WINDOW CLOSED, I DROVE OVER THE PLATE AND THE SUNROOF EXPLODED OUTWARD WITH A SHOTGUN LIKE BANG, I HAD THE SUN SHADE CLOSED SO NO GLASS FELL ON ME. I BELIEVE THAT THE CHANGE IN CABIN AIR PRESSURE COUPLED WITH THE IMPACT OF THE TRENCH PLATE WAS ALL IT TOOK TO CAUSE THIS FLAWED SUNROOF TO EXPLODE UNDER NORMAL OPERATING CONDITIONS. THE WEATHER WAS SLIGHTLY OVERCAST AND APPROXIMATELY 64 DEGREES AT THE TIME. I HAVE PHOTOS BUT CAN NOT UPLOAD THEM AT THIS TIME. THE VEHICLE IS NOW AT THE LOCAL TOYOTA DEALERSHIP.

NHTSA complaint #11173398 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

IBC DOES NOT FUNCTION

NHTSA complaint #11004984 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

ABOUT 3 MONTHS AFTER PURCHASING MY VEHICLE, I'VE NOTICED THE FRONT SENSORS (INTERMITTENTLY) KEEP GOING OFF. THIS HAPPENS ONCE OR TWICE EVERY OTHER WEEK. TAKEN TO DEALERSHIP, AT THIS TIME CAN'T DETERMINE WHAT'S CAUSING THE PROBLEM. ALSO, THE RADIO SHUTS OFF FOR SEVERAL MINUTES, THEN COMES BACK ON.

NHTSA complaint #10991588 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

HAVE HAD BRAKING ISSUES WITH INTEGRATED BRAKE CONTROLLER, NO MATTER WHAT POWER LEVEL I USE THERE SEEMS TO BE VERY LITTLE IF NO EFFECT ON THE TRAILER BRAKING. I CAN SWITCH THE INTEGRATED BRAKE CONTROLLER TO ELECTRIC OVER HYDRAULIC AND THEY APPLY THE BRAKES AND THEY GRAB IMMEDIATELY, IT SEEMS THAT THE INTEGRATED BRAKE CONTROLLER IN ELECTRIC BRAKE MODE DOES NOT PRODUCE ENOUGH ELECTRICAL POWER TO ACTIVATE THE TRAILER BRAKES.

NHTSA complaint #10985431 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

CPSC:I PURCHASED A 2016 TOYOTA TUNDRA PICKUP TRUCK. THE TRUCK COMES WITH AN INTEGRATED BRAKE CONTROLLER FOR TOWING TRAILERS, BOATS, ETC. THE IBC HAS TWO MODES OF BRAKING, FOR TRAILERS WITH ELECTRIC BRAKES OR FOR TRAILERS WITH HYDRAULIC BRAKES. *BF THE CONSUMER STATED THE AUTOMATIC BRAKING DID NOT WORK FOR THE ELECTRICS BRAKES MODE. UPDATED 04/21/2017

NHTSA complaint #10979512 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

INTEGRATED BRAKE CONTROLLER DOES NOT OPERATE TRAILER BRAKES, AT ANY TIME. MOVING OR STANDING STILL.

NHTSA complaint #10970626 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

INTEGRATED TRAILER BRAKE CONTROLLER NOT WORKING. SET AT ITS HIGHEST RATING IT STILL DID NOT WORK. CHECKED TRAILER BRAKES WITH ANOTHER TRUCK AND THEY WORK. APPLIED THE BRAKES WITH THE MANUAL ACTIVATOR AND NO BRAKES. CAME CLOSE TO HAVING AN ACCIDENT. WILL BE MEETING WITH DEALER ON THIS ISSUE. RESEARCH ON THE INTERNET SHOWS THAT THIS MIGHT BE A COMMON PROBLEM

NHTSA complaint #10957206 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

THE INTEGRATED ELECRIC BRAKE CONTROLLER INCLUDED IN MY PLATINUM EDITION OPTIONS FOR TOWING A TRAILER DOES NOT WORK. ACCORDING TO DEALER, THERE IS NO FIX FROM TOYOTA ALTHOUGH THEY ARE AWARE OF THE ISSUE.

NHTSA complaint #10916440 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

RE: INTEGRATED BREAK CONTROLLER I WANTED TO EXPRESS A SERIOUS SAFETY CONCERN I HAVE WITH AN ITEM THAT NOW SHIPS WITH THE 2016 TOYOTA 5.7L TUNDRA'S - THE BUILT IN / INTEGRATED BREAK CONTROLLER FOR USE WHEN PULLING TRAILERS/CAMPERS/ETC. IT SEEMS THAT REGARDLESS OF THE POWER SETTING, NO NOTICEABLE POWER IS SUPPLIED TO THE TRAILER BRAKES, EVEN AT IT'S HIGHEST SETTING. IT FEELS LIKE THE TRAILER/CAMPER IS PUSHING THE TRUCK, WHICH CAN BE A SERIOUS ISSUE WHEN STOPPING. THIS WOULD HAPPEN EVERY TIME I WOULD TOW AND I WAS ALWAYS VERY WORRIED ABOUT CAUSING AN ACCIDENT IF I NEEDED TO STOP QUICKLY OR IF THE ROAD CONDITIONS WERE NOT IDEA. I'VE NEVER FELT THIS WITH OTHER BREAK CONTROLLERS. IT'S MY UNDERSTANDING TOYOTA HAS NOT ACKNOWLEDGED THIS AS BEING AN ISSUE YET. AFTER TALKING TO MANY OTHER TUNDRA OWNERS EVERYONE HAS THE SAME ISSUE, I'VE NOT TALKED TO ANYONE THAT HAS A WORKING INTEGRATED BREAK CONTROLLER IN THEIR 2016. I'VE TAKEN OUT MY INTEGRATED BREAK CONTROLLER THAT CAME IN MY 2016 TOYOTA TUNDRA AND REPLACED IT WITH AN AFTER MARKET BRAKE CONTROLLER OUT SO I CAN PROPERTY BRAKE WITH MY CAMPER ATTACHED. FOR NOW MY ISSUE IS RESOLVED, HOWEVER, I AM HOWEVER VERY WORRIED ABOUT OTHERS THAT MIGHT BE USING THE INTEGRATED BREAK CONTROLLER AND THE HUGE POTENTIAL FOR A SERIOUS ACCIDENT BECAUSE THEIR TRAILER OR CAMPER BRAKES ARE NOT WORKING. PLEASE LOOK INTO THIS BEFORE ANY SERIOUS ACCIDENTS HAPPEN. THANKS!

NHTSA complaint #10874031 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

FACTORY INTEGRATED BRAKE CONTROLLER DOES NOT WORK EFFICIENTLY. WITH THE IBC GAIN UP TO 10, THE TRAILER BRAKES ARE NOT ACTIVATED ENOUGH TO SLOW THE VEHICLE IN A NORMAL OR EMERGENCY SITUATION. THE MANUAL OVERRIDE SLIDE BAR BARELY ENGAGES THE TRAILER BRAKES, IT WILL NOT LOCK THE TRAILER BRAKES AS DESIGNED. VEHICLE BRAKES BEGIN TO GET TO HOT TO SLOW BOTH THE TRUCK AND TRAILER COMING DOWN HILLS, EXTREMELY DANGEROUS!

NHTSA complaint #10873637 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

2016 TUNDRA CREW MAX XPSX PACKAGE, 4X4. VIBRATION IN STEERING WHEEL AT ALL SPEEDS. SOUTHEAST TOYOTA STATES THAT THE PROBLEM IS JUST A OPERATIONAL CHARACTERISTIC OF THE TRUCK.

NHTSA complaint #10820760 — an unverified report by a vehicle owner.