Owners have filed 156 complaints
about the 2016 Toyota Tundra with NHTSA between 2015 and 2026.
The largest single group is the brakes.
Across this model's run it ranks 19 of 27 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 22
Against the median year of the Toyota Tundra. 50 means typical for this
model; 100 means roughly double.
Severity — 23
4.5% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
76% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
1770.8%
Speedometer/Odometer
14.2%
Integrated Trailer Brake Control
14.2%
HUB
14.2%
Front
14.2%
Bumpers
14.2%
Wheel Bearing
14.2%
Tread/Belt
14.2%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
1513.8%
1,000 – 9,999 miles
3532.1%
10,000 – 24,999 miles
2422.0%
25,000 – 49,999 miles
1311.9%
50,000 – 74,999 miles
1311.9%
75,000 – 99,999 miles
54.6%
100,000 – 149,999 miles
32.8%
150,000+ miles
10.9%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
Frontal crash test
Side barrier crash test
Side pole crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2016 Toyota Tundra PU/CC 2WD
21.9% risk
2016 Toyota Tundra PU/CC 4WD
19.8% risk
2016 Toyota Tundra PU/RC 2WD
21.9% risk
2016 Toyota Tundra PU/RC 4WD
19.8% risk
2016 Toyota Tundra PU/EC 4WD
19.8% risk
2016 Toyota Tundra PU/EC 2WD
21.9% risk
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2015peak 11Jul 2026
NHTSA investigations into the 2016 Toyota Tundra
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA19001Opened 19 Apr 2019Closed 19 Sep 2024AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE
Electrical overstress
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mount...
Recalls on the 2016 Toyota Tundra
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
21E103000
STEERING:HYDRAULIC POWER ASSIST SYSTEM
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain JTEKT power steering gear assembly service parts for 2007-2021 Tundra and 2008-2022 Sequoia, part numbers 44250-0C160, 44250-0C131, 44250-0C170, and 11250-0C121. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Risk: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
21V920000
STEERING:HYDRAULIC POWER ASSIST SYSTEM
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.
Risk: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
17V416000
AIR BAGS:KNEE BOLSTER
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016 Tundra vehicles. The affected vehicles have a passenger knee air bag module that was attached to the instrument panel mounting brackets with incorrect bolts.
Risk: The incorrect bolts may cause the air bag module to loosen over time, affecting the performance of the knee airbag, increasing the risk of injury during a crash.
17V311000
WHEELS:LUGS/NUTS/BOLTS/STUDS
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2017 Toyota Tundra and Sequoia vehicles accessorized with Southeast Toyota accessory 20-inch Rockstar wheels installed by Southeast Toyota or a Southeast Toyota dealer. The Rockstar wheels were installed with lugnuts that may crack and detach.
Risk: Lugnuts that crack and detach may cause the wheels to separate from the vehicle, increasing the risk of a crash.
17V051000
STRUCTURE:BODY:BUMPERS
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2017 Tundra vehicles equipped with a resin rear step bumper and resin reinforcement brackets (vehicles with chrome step bumpers are not affected). In the event of an impact to the corner of the bumper, the resin bracket may be damaged but not be noticed.
Risk: If a person steps on the corner of the bumper that is damaged, a portion of the bumper may break away, increasing the risk of injury.
16V420000
EQUIPMENT:OTHER:LABELS
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2016 Toyota Camry and Highlander, 2015-2016 Toyota Tundra, Scion FR-S, and tC vehicles. The Load Carrying Capacity Modification Label may not reflect the correct added weight of the installed accessories. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims for Passenger Cars."
Risk: An incorrect label may lead an owner to overload the vehicle, increasing the risk of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202172355,683 units in Canada
Electrical
Issue: This recall is for certain block heater kits installed on certain vehicles or sold as accessories at Toyota or Lexus dealerships. On certain vehicles, the engine block heater cable may not have enough heat protection and could be damaged by high temperatures. If this happens, the cable could short circuit while plugged in, and cause the wiring to overheat or melt. Note: This recall only affects the following block heater/cord part numbers: C014003034 PK5A408J09 PU14000904 C014003151 PK5A408J13 PU14000905 C014000885 PK5A489J11 PU14000907 C014000888 PK5A489J22 PU14000909 C014000907 PK5A410H00 PU14000911 C014100904 PU14000900 PU14000913 C014100907 PU14000901 PU14003571 C014100911 PU14000902 PK5A489J14 PK5A408J05 PU14000903 Safety Risk: Engine block heater wiring that overheats or melts could create the risk of a fire. Corrective Actions: Toyota recommends that you should stop using the engine block heater immediately. Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to disable the engine block heater. For some vehicles, the corrective actions for this recall are under development. For others, a new engine block heater cannot be installed, and the owner will receive a refund of the purchase price of the engine block heater.
Recall 201736339,189 units in Canada
Electrical
On certain vehicles, the electrical power cords of some dealer installed block heaters may have been improperly manufactured, causing the wires to contact each other, resulting in a short circuit. A short circuit could lead to a fire which would increase the risk of injury and/or damage to property. Correction: For vehicles where the subject block heater was approved for installation, the dealer will replace the block heater assembly with a new one of an improved design. For vehicles where the subject block heater was not approved for installation, dealers will remove the block heater assembly. In the interim, until the remedy can be performed, dealers will cut the plug end from the block heater cord to disable the block heater's operation.
Recall 20170366,157 units in Canada
Structure
On certain vehicles equipped with the plastic rear step bumper, the resin reinforcement brackets that secure the step corners of the bumper could become damaged after a rear impact. If a person were to use the rear bumper steps with damaged resin reinforcement brackets, part of the bumper could break off which could cause the person to fall, increasing the risk of injury. Correction: Dealers will replace the resin reinforcement brackets with steel reinforcement brackets. In addition, the rear bumper tread covers will also be replaced.
Reports where the owner recorded a crash, a fire, an injury or a death.
Dillon, SCCrash
AIR BAGS
2016 TOYOTA TUNDRA. CONSUMER STATES THAT AIR BAGS DID NOT DEPLOY AND SEAT BELTS DID NOT LOCK DURING COLLISION. *LD
NHTSA complaint #11290515 — an unverified report by a vehicle owner.
Dillon, SCCrash
SEAT BELTS:FRONT
2016 TOYOTA TUNDRA. CONSUMER STATES THAT AIR BAGS DID NOT DEPLOY AND SEAT BELTS DID NOT LOCK DURING COLLISION. *LD
NHTSA complaint #11290515 — an unverified report by a vehicle owner.
at 8,000 milesLakeland, FLCrash
ELECTRICAL SYSTEM
I PURCHASED A NEW TRAILER TO PICK UP MY NEW TRACTOR. I TESTED THE TRAILER BRAKES KNOWING I WAS PULLING A LARGE LOAD AND DIDN'T WANT AN ACCIDENT. THE BRAKES APPEARED TO APPLY BUT DUE TO IT NOT BEING LOADED WHEN TESTING I HAD IT SET TO 5(OUT OF 10). WHILE PULLING IT BACK HOME ON THE INTERSTATE TOWING MY TRACTOR BEHIND ME THERE WAS TRAFFIC STOPPING AHEAD. I ALWAYS DRIVE IN THE RIGHT LANE TO NOT SLOW OTHERS...THANK GOD I DID. I HAD TO DRIVE OFF THE ROAD ONTO THE SHOULDER TO MISS HITTING OR DRIVING OVER CARS AHEAD OF ME! THE BRAKES TURNED UP TO 10 DID NOTHING TO EVEN SLOW ME DOWN. I WAS TOWING 4 TONS AND 3 TONS FOR THE TRUCK TOTALING 7 TONS, SOMEONE WOULD'VE BEEN KILLED! TOYOTA NEEDS TO FIX THESE TRAILER BRAKES! I CAN'T TOW MY TRACTOR ANYWHERE FOR WORK DUE TO THE BRAKES BEING UNSAFE!
NHTSA complaint #11062085 — an unverified report by a vehicle owner.
at 8,000 milesLakeland, FLCrash
SERVICE BRAKES
I PURCHASED A NEW TRAILER TO PICK UP MY NEW TRACTOR. I TESTED THE TRAILER BRAKES KNOWING I WAS PULLING A LARGE LOAD AND DIDN'T WANT AN ACCIDENT. THE BRAKES APPEARED TO APPLY BUT DUE TO IT NOT BEING LOADED WHEN TESTING I HAD IT SET TO 5(OUT OF 10). WHILE PULLING IT BACK HOME ON THE INTERSTATE TOWING MY TRACTOR BEHIND ME THERE WAS TRAFFIC STOPPING AHEAD. I ALWAYS DRIVE IN THE RIGHT LANE TO NOT SLOW OTHERS...THANK GOD I DID. I HAD TO DRIVE OFF THE ROAD ONTO THE SHOULDER TO MISS HITTING OR DRIVING OVER CARS AHEAD OF ME! THE BRAKES TURNED UP TO 10 DID NOTHING TO EVEN SLOW ME DOWN. I WAS TOWING 4 TONS AND 3 TONS FOR THE TRUCK TOTALING 7 TONS, SOMEONE WOULD'VE BEEN KILLED! TOYOTA NEEDS TO FIX THESE TRAILER BRAKES! I CAN'T TOW MY TRACTOR ANYWHERE FOR WORK DUE TO THE BRAKES BEING UNSAFE!
NHTSA complaint #11062085 — an unverified report by a vehicle owner.
at 500 milesPost Falls, ID1 injured
STRUCTURE:BODY
I PURCHASED A BRAND NEW TOYOTA TRUCK. I STEP ON THE REAR BUMPER WHEN THE TRUCK WAS STATIONARY AND NEARLY BROKE MY LEG, I NOTICED THAT THE REAR BUMPER APPEARED TO HAVE BEEN ALREADY BROKEN. WHEN I TOOK THE NEW TOYOTA TRUCK TO THE PARKER TOYOTA COEUR D'ALENE IDAHO DEALERSHIP THEY SAID THAT THE REAR BUMPER WAS UNDER RECALL. A "...EQUIPPED WITH RESIN REAR STEP BUMPERS AND RESIN REINFORCEMENT BRACKETS AT EACH CORNER." YET THEY DID NOT HAVE THE PARTS. THIS I HAD TO DRIVE AROUND WITH THIS CRACKED BUMPER. THE BUMPER EVENTUALLY CAME OFF ON THE FREE WAY AND BROKE APART. I RETURNED AFTER PARKER TOYOTA IN COEUR D'ALENE, IDAHO HAD THE PARTS AND I HAD THE TIME. BOB TOLD ME THAT TOYOTA WOULD NOT PAY FOR THE BUMPER. THEY TOLD ME THAT IT WAS MY FAULT THAT I STEPPED ON THE PICKUP TRUCK'S BUMPER. I CALLED TOYOTA AND MY CASE NUMBER IS CASE NUMBER: 170-906-0652 JEREMY. THEY SAID PARKER TOYOTA REPORTED THAT THERE WAS SOME DAMAGE TO THE BODY OF THE TRUCK, AND ALSO SINCE I STEPPED ON THE BUMPER THEY WOULD NOT REPLACE THE BUMPER. IF THERE IS ANY DAMAGE TO THE TRUCK, IT IS TINY AND IT HAD TO HAPPEN AFTER THE BUMPER WAS OFF THE TRUCK. TO HAVE ANY DAMAGE TO THE BODY AN ACCIDENT WOULD HAVE HAD TO GO "THROUGH" THE BUMPER. I HAVE DRIVEN AROUND WITH THE CAR FOR NEARLY 1 YEAR AFTER THE BUMPER FELL OFF A NEW TOYOTA TRUCK. STEPPING ON A BUMPER, WHICH IS A VERY NORMAL THING TO DO WITH A PICKUP TRUCK SHOULD NOT VOID THE RECALL. IT IS NOT MY FAULT THAT A BRAND NEW TRUCK HAD A RESIN BRACKET THAT GAVE WAY, INJURING ME, AND BECOMING A ROAD HAZARD. TOYOTA DOES NOT WANT TO PAY TO FIX THEIR PROBLEMS.
NHTSA complaint #11022304 — an unverified report by a vehicle owner.
at 16,000 milesGalepon, PA1 injured
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2016 TOYOTA TUNDRA. WHEN THE CONTACT STEPPED ON THE VEHICLE'S REAR BUMPER, THE BUMPER DETACHED. AS A RESULT, THE CONTACT SUSTAINED A KNEE INJURY THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE BUMPER WAS REPLACED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V051000 (STRUCTURE). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 16,000. ..UPDATED 06/27/17 *BF
NHTSA complaint #10967770 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Caballo, NM
ENGINE
2016 flex fuel toyota tundra with 118,00 miles was towed to toyota dealer in Las cruces with a no fuel issue. After the analysis it was determined the fuel pump over heated burning out conector and wiring ,but the pump was still working. According to toyota TSB 0166-19 this is a problem the can arise if the alcohol fuel density ID is not updated. I told the dealer to due repairs on vehicle even though a fuel pump was installed and reflashed at 114,000 miles. Viva toyota of las cruses advicate stated that a reflash is all the vehiles needs and does not desire to change the alchol fuel density to updated ID as per TSB-0166-19, so I am worried I will be operating a vehicle with a fuel pump that will over heat and burn out connectors again. I called Toyota complaints and they told me they cannot make a dealer do any repairs.
NHTSA complaint #11752420 — an unverified report by a vehicle owner.
Caballo, NM
FUEL/PROPULSION SYSTEM
2016 flex fuel toyota tundra with 118,00 miles was towed to toyota dealer in Las cruces with a no fuel issue. After the analysis it was determined the fuel pump over heated burning out conector and wiring ,but the pump was still working. According to toyota TSB 0166-19 this is a problem the can arise if the alcohol fuel density ID is not updated. I told the dealer to due repairs on vehicle even though a fuel pump was installed and reflashed at 114,000 miles. Viva toyota of las cruses advicate stated that a reflash is all the vehiles needs and does not desire to change the alchol fuel density to updated ID as per TSB-0166-19, so I am worried I will be operating a vehicle with a fuel pump that will over heat and burn out connectors again. I called Toyota complaints and they told me they cannot make a dealer do any repairs.
NHTSA complaint #11752420 — an unverified report by a vehicle owner.
Missoula, MT
STRUCTURE:BODY
Bed is rusting out from the bottom in a fashion that looks very similar to a previous Tundra bed rusting issue that had a TSB and remedy from Toyota. On the driver's side bed bolt closest to the cab, the sheet metal tack welded to the bed has separated and is rusting out. Approximately 7 inches to the drivers side from that bolt. The seam sealer is also cracking. Additionally, the drivers side bed bolt closes to the tailgate has rust bubbling up from underneath approximately 1 inch to the passenger side from the bolt and also along where that sheet metal is tack welded onto the bed.
NHTSA complaint #11744041 — an unverified report by a vehicle owner.
Cleveland, GA
FUEL/PROPULSION SYSTEM
The fuel pump component or system failed or malfunctioned the engine tried cranking but would not start. The problem has been reproduced to an independent service center, where I was notified of a safety recall on Toyota Tundra. No other inspections have been performed. There are no warning lamps messages visible on the vehicle in question. The vehicle will not start until repeated starts are performed. Vehicle idles roughly before regaining normal idle. One other past similar incident of this type has occurred. No other
NHTSA complaint #11739464 — an unverified report by a vehicle owner.
at 67,000 milesWest Palm Beach, FL
FUEL SYSTEM, GASOLINE
The contact owns a 2016 Toyota Tundra. The contact stated that while driving at slower speeds, the vehicle stalled while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was towed to a local dealer to be diagnosed. The contact was informed that the fuel pump and other fuel pump-related parts needed to be replaced. The vehicle was not repaired because the parts were on back order. The manufacturer was made aware of the failure. The failure mileage was approximately 67,000.
NHTSA complaint #11732710 — an unverified report by a vehicle owner.
at 67,000 milesWest Palm Beach, FL
ENGINE
The contact owns a 2016 Toyota Tundra. The contact stated that while driving at slower speeds, the vehicle stalled while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was towed to a local dealer to be diagnosed. The contact was informed that the fuel pump and other fuel pump-related parts needed to be replaced. The vehicle was not repaired because the parts were on back order. The manufacturer was made aware of the failure. The failure mileage was approximately 67,000.
NHTSA complaint #11732710 — an unverified report by a vehicle owner.
Oregon City, OR
STEERING
The steering rack internal seal inside the steering rack failed/ "blew" per mechanic and is leaking. I could lose my ability to steer at any time while driving my vehicle and wreck. It is currently at the Toyota services center in Gladstone, OR and has been diagnosed. No other representatives have inspected the vehicle. There were no warnings or signs of failure. I had originally taken my truck in to have an oil change and have it checked for a "slow" start up.
NHTSA complaint #11719220 — an unverified report by a vehicle owner.
Boise, ID
STEERING
The power steering went out during routine around-town driving. One moment it was steering fine, the next moment it became extremely difficult and sluggish. There were no warning lights or warning of any sort until the steering wheel started jerking unevenly as I tried to turn. I was able to get control of the vehicle and pull it to the side of the road. There was no difference in the engine noise, and I couldn't see any noticeable fluid leak. I was able to drive the vehicle home, make an appointment with the Toyota dealer, and get the vehicle to the dealership for inspection. The dealership told me after inspection, that the rack and pinion steering was binding internally, and that there was seepage from the right boot. Initially, they told me that the pump should be fine. I authorized them to replace the rack and pinion steering. After which, they told me that the problem seemed to still persist some, and that the pump would have to be replaced also. My total bill came to $3,200, which seemed not unfair. But this whole issue seemed like something that should be noticed as part of a recall. I found the NHTSA recall number. 21V-920, and my truck seemed to match exactly the symptoms spelled out is this recall , but Toyota refused to acknowledge it. My VIN number did not fall within the specified VIN for this recall. I've driven several Toyotas, including another Tundra, a Tacoma, 2 Highlanders and a Sienna, and have been pleased with each vehicle. This Tundra is 10 years old with 95,000 miles, and I've only done expected maintenance and a couple of occasional minor repairs. Those being: - Having the brakes resurfaced - Changing out the alternator In the end, it wasn't a devastating amount of money, but it was an issue that I felt Toyota should have taken care of. I did reach out to them, but because I had already paid for the repairs on the vehicle I needed to drive for work, they refused to talk to me any further. I have the estimate and final bill.
NHTSA complaint #11705412 — an unverified report by a vehicle owner.
Crosby, ND
EXTERIOR LIGHTING
My right front headlamp is getting moisture inside the headlamp assembly. It can be inspected any time. Chance that headlamp will not work. Did not take to a dealer.
NHTSA complaint #11662959 — an unverified report by a vehicle owner.
Odometer Fraud. The contact purchased a 2016 Toyota Tundra. The contact stated while going through prior service paperwork found in the vehicle, he discovered that there was a mileage discrepancy. The vehicle was a private sale. The contact also stated that the vehicle was once sold at a private auction. At the time of purchase, the vehicle mileage was 158,000; however, upon discovery of the service paperwork, the contact discovered that the vehicle mileage was once 250,000.
NHTSA complaint #11659434 — an unverified report by a vehicle owner.
Ashville, AL
STRUCTURE:BODY:HOOD
I have had multiple incidents where the front hood bulge has blown off going down the interstate and nearly hit other cars. It’s not been worth buying a new one with the risk of them flying off. It’s definitely a saftey concern and a hazard.
NHTSA complaint #11649615 — an unverified report by a vehicle owner.
Mckees Rocks, PA
SERVICE BRAKES
The trailer brake controller went out. It does not supply electronic braking and the truck no longer recognizes the controller on the dashboard. Multiple on line chats and forums, along with my trailer provider, show awareness of this defect. Online individuals learned of the issue during emergency stopping. This appears to be known and wide spread.
NHTSA complaint #11643867 — an unverified report by a vehicle owner.
Mandeville, LA
UNKNOWN OR OTHER
The frame of the truck is extremely rusted. I am unsure if it can be fixed. It is available for inspection. This 2016 Tundra has 71,000 miles and is used as a third car. It has been serviced at the same dealership (Northshore Toyota, Covington, LA) and we were never informed of the damage by the dealership. My safety is at risk because the extensive rust could cause the frame to fail. Previous Tundra models have been recalled because of the same issues. No warnings were issued even after the dealership serviced the truck on a lift numerous times (approximately 9 years). The only previous warning by the dealership was on 1/29/2025 when the dealership informed us of a rusty trailer hitch. The truck was brought to 4 body shops in the local area after the owner went to work on the trailer hitch and saw the damage. All 4 shops confirmed that the rust was extensive. 3 shops would not fix the damage because it would be an expensive/extensive fix. We are waiting on what shop #4 says.
NHTSA complaint #11643127 — an unverified report by a vehicle owner.
Mandeville, LA
STRUCTURE:BODY
The frame of the truck is extremely rusted. I am unsure if it can be fixed. It is available for inspection. This 2016 Tundra has 71,000 miles and is used as a third car. It has been serviced at the same dealership (Northshore Toyota, Covington, LA) and we were never informed of the damage by the dealership. My safety is at risk because the extensive rust could cause the frame to fail. Previous Tundra models have been recalled because of the same issues. No warnings were issued even after the dealership serviced the truck on a lift numerous times (approximately 9 years). The only previous warning by the dealership was on 1/29/2025 when the dealership informed us of a rusty trailer hitch. The truck was brought to 4 body shops in the local area after the owner went to work on the trailer hitch and saw the damage. All 4 shops confirmed that the rust was extensive. 3 shops would not fix the damage because it would be an expensive/extensive fix. We are waiting on what shop #4 says.
NHTSA complaint #11643127 — an unverified report by a vehicle owner.
Prescott, AZ
ENGINE
Problem Parts?? At around 70,000 miles I was told that there was an engine oil leak ... camshaft area... and the engine needs to pulled out with a repair cost of about $5,000 dollars. (Reseal both cam towers, replace gaskets, etc.) A bit ridiculous. Is there now a possible engine fire risk? At 70,000 miles there was obviously a manufacturing mistake or a defective part used during assembly.
NHTSA complaint #11625264 — an unverified report by a vehicle owner.
Chesapeake, VA
STRUCTURE:BODY
Peeling paint. White paint is separating from primer on hood, and adjacent to windshield on a pillars and the leading edge if the roof.
NHTSA complaint #11623575 — an unverified report by a vehicle owner.
East Greenville, PA
STEERING
1)Over 60 MPH with new tires the vehicle pulses & shakes on front end, checked alignment everything OK per Mechanic. Just started to occur 2)Bluetooth when on iPhone will at any time cut out guaranteed to occur when using at any time been occurring for 2 + years. 3)Trailer brake warning light (Idiot light) comes on dashboard does not recommend trailering due to electrical issue. occurring for 2+ years Bought vehicle used in 2017 with 13k on Truck now 2024 has 91K on truck love the truck but zero recalls for any of the above?
NHTSA complaint #11592560 — an unverified report by a vehicle owner.
East Greenville, PA
ELECTRICAL SYSTEM
1)Over 60 MPH with new tires the vehicle pulses & shakes on front end, checked alignment everything OK per Mechanic. Just started to occur 2)Bluetooth when on iPhone will at any time cut out guaranteed to occur when using at any time been occurring for 2 + years. 3)Trailer brake warning light (Idiot light) comes on dashboard does not recommend trailering due to electrical issue. occurring for 2+ years Bought vehicle used in 2017 with 13k on Truck now 2024 has 91K on truck love the truck but zero recalls for any of the above?
NHTSA complaint #11592560 — an unverified report by a vehicle owner.
East Greenville, PA
SERVICE BRAKES
1)Over 60 MPH with new tires the vehicle pulses & shakes on front end, checked alignment everything OK per Mechanic. Just started to occur 2)Bluetooth when on iPhone will at any time cut out guaranteed to occur when using at any time been occurring for 2 + years. 3)Trailer brake warning light (Idiot light) comes on dashboard does not recommend trailering due to electrical issue. occurring for 2+ years Bought vehicle used in 2017 with 13k on Truck now 2024 has 91K on truck love the truck but zero recalls for any of the above?
NHTSA complaint #11592560 — an unverified report by a vehicle owner.
at 99,000 milesDanbury, NH
STRUCTURE
The contact owns a 2016 Toyota Tundra. The contact stated that while driving at an undisclosed speed, the vehicle ran off the road during a thunderstorm, causing the driver's and passenger's side curtain air bags to deploy. The vehicle was towed to the dealer, who informed the contact that the headliner needed to be replaced; however, the part to complete the repair was not available. The manufacturer was made aware of the failure and confirmed that parts were not yet available. The failure mileage was approximately 99,000.
NHTSA complaint #11543094 — an unverified report by a vehicle owner.
South Jordan, UT
ELECTRICAL SYSTEM
Seat heater stopped working. Turns out there is a burnt connector leading to part number 87501-0C020, which appears to be a seat heater amp. One pin of the connector is completely melted. I've purchased this truck brand new from Toyota. Nobody has ever touched this part. Scared that it could have caught fire.
NHTSA complaint #11543017 — an unverified report by a vehicle owner.
Chico, CA
STEERING
I was stopped at a turn light to merge left onto freeway and the truck steering went out when trying to turn, it led me into oncoming traffic that was just coming to a stop light, I was able to crank my wheel with all my strength to get to the side of the uphill freeway merge ramp. There were no warning signs. It was so scary and thank goodness I hadn't merged onto the freeway. The component that failed was the power steering assembly, rack and pinion with inner and outer tie rods. I don't believe the parts will be available for inspection since the truck was towed to repair shop. Overall, I was lucky to be alive. My safety was put at risk being unable to properly steer, if I had been going any faster, or even on the freeway there would be no way to control the vehicle. Initially, I was put into oncoming traffic that was coming to a stop. It put myself and everyone around me in danger. The problem has been confirmed by an independent repair shop that truck was towed to. They immediately saw the problem and took several days to fix. Even questioned what I was doing at the time of this event, because something like this just doesn't typically happen. It concerned them so much, that United Wheels and Tires suggested I reach out to Toyota. The vehicle has not been inspected by anyone but the dealer and the tow truck services. Insurance was notified of situation and services dispatched, since the truck was not drivable. There were NO warming lamps, messages or anything on truck. Truck is in perfect condition and drove only on roads (no off-roading or towing, etc.).
NHTSA complaint #11537568 — an unverified report by a vehicle owner.
Creswell, OR
SERVICE BRAKES
The integrated brake controller does not apply enough power to the trailer brakes.
NHTSA complaint #11530257 — an unverified report by a vehicle owner.
Aurora, CO
FUEL/PROPULSION SYSTEM
Gas tank no longer fills completely in a single squeeze. Each squeeze of the pump only fills up maybe a .25 gallon at a squeeze if I am lucky, but typically less. This results in a complete fill up taking close to a half hour. There are numerous posts on forums such as https://www.tundras.com/threads/gas-filling-problem.38449/, https://www.tundras.com/threads/gas-tank-roll-over-valve-stuck-causes-hard-fuelling-anyone-else.42535/, and many others regarding this issue, with no response from dealers other than sorry. This sounds like a pure manufacturing issue if so many people have issues with their tanks, in a similar fashion.
NHTSA complaint #11528967 — an unverified report by a vehicle owner.
Gilroy, CA
FUEL/PROPULSION SYSTEM
Fuel gauge provides false inaccurate reading, resulting in stranded situation when fuel runs out. Toyota is aware is issue and has only issued a TSB for limited years when the problem is more wide spread. My daughter has been stranded several times.
NHTSA complaint #11509356 — an unverified report by a vehicle owner.
