FaultScore

FaultScore report

2012 Volvo S60 problems

Owners have filed 167 complaints about the 2012 Volvo S60 with NHTSA between 2011 and 2026. The largest single group is the engine & cooling. Across this model's run it ranks 1 of 19 worst.

F

FaultScore 86/100

Higher is worse. Measured against the other years of the Volvo S60.

How this is worked out

The numbers

167

Complaints

17

Crashes reported

0

Fires reported

15

Injuries reported

75,000 mi

Median mileage at failure

Half of reported failures happened before this

23%

Failed under 36,000 miles

Inside a typical bumper-to-bumper warranty

What kind of bad

The letter says how bad. This says what kind — whether this year drew an unusual number of complaints, unusually dangerous ones, or failures that arrived unusually early.

Complaint volume 96 vs 50 Severity 99 vs 50 Early failure 39 vs 50
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 96
Against the median year of the Volvo S60. 50 means typical for this model; 100 means roughly double.
Severity — 99
19.2% of these complaints involved a crash, fire, injury or death, against a national rate of 9.7%.
Early failure — 39
23% of failures with a mileage on record happened under 36,000 miles, against a national rate of 29%.

How 2012 compares with every other Volvo S60

Click any bar to open that year's report.

Complaints filed with NHTSA, by model year. Bar colour is the FaultScore grade: A B C D F ungraded

What breaks on a 2012 Volvo S60

Every complaint is filed against a part. Follow any row for the complaints about that part alone.

Engine & Cooling 62 37.1%

1 crashes, 0 fires · median 86,000 mi

1 crashes, 0 fires · median 66,000 mi

1 crashes, 0 fires · median 75,000 mi

Seat Belts 9 5.4%

2 crashes, 0 fires · median 71,430 mi

Fuel & Propulsion 8 4.8%

1 crashes, 0 fires · median 79,000 mi

Steering 8 4.8%

1 crashes, 0 fires · median 21,700 mi

Body & Structure 7 4.2%

2 crashes, 0 fires · median 71,430 mi

Acceleration & Cruise Control 6 3.6%

2 crashes, 0 fires · median 7,000 mi

Brakes 6 3.6%

1 crashes, 0 fires · median 7,000 mi

Airbags 6 3.6%

3 crashes, 0 fires · median 22,000 mi

Driver Assist & Collision Avoidance 4 2.4%

1 crashes, 0 fires · median 126,436 mi

Windows, Mirrors & Wipers 4 2.4%

Median failure at 126,436 miles

Transmission & Drivetrain 4 2.4%

1 crashes, 0 fires · median 57,392 mi

Doors, Latches & Locks 3 1.8%

Median failure at 150,000 miles

Lights 3 1.8%
Equipment & Accessories 2 1.2%

Median failure at 20,502 miles

Stability & Traction Control 2 1.2%

Median failure at 47,593 miles

Seats 1 0.6%

When it fails

Odometer readings owners gave when they filed. About half of all complaints include one.

Under 1,000 miles 4 3.5%
1,000 – 9,999 miles 8 7.0%
10,000 – 24,999 miles 9 7.8%
25,000 – 49,999 miles 14 12.2%
50,000 – 74,999 miles 22 19.1%
75,000 – 99,999 miles 27 23.5%
100,000 – 149,999 miles 25 21.7%
150,000+ miles 6 5.2%

When owners complained

A spike years after the car went on sale usually means a part wearing out on schedule across the whole fleet — the kind of pattern no single owner can see from inside their own car.

Jul 2011 peak 6 Jun 2026

Recalls on the 2012 Volvo S60

A complaint is one owner's allegation. A recall is the point at which the manufacturer or a regulator agreed the defect is real and dangerous enough to fix for free — however old the car is.

Canada — Transport Canada

Canada runs its own recall programme, and its campaigns do not always mirror the American ones.

Recall 2020298 24,089 units in Canada

Seats And Restraints

Issue: On certain vehicles, the flexible steel cable that attaches the seat belt to the outside of the front seats may weaken over time. As a result, the seat belt could detach. Safety Risk: A seat belt that detaches in a crash could create an increased risk of injury. Corrective Action: Volvo will notify owners by mail and instruct you to take your vehicle to a dealer to replace the front-outboard seat belt anchors.

Recall 2013419 1,402 units in Canada

Lights And Instruments

Certain vehicles may not comply with the requirements of Canada Motor Vehicle Safety Standard 101 - Controls and Displays. The oil pressure sensor is not activated in the original factory downloaded software. As a result, no oil pressure information would be indicated to the driver in the instrument cluster. Correction: Dealers will update software.

Recall 2012101 136 units in Canada

Fuel System

On certain vehicles, the underbody coating may have been incorrectly formulated and excessively applied during the vehicle assembly process. This can result in rigid, icicle-like formations of underbody coating hanging from the undercarriage of the vehicle, which could damage the fuel lines and cause a leak. Fuel leakage, in the presence of an ignition source, could result in a fire causing property damage and/or personal injury. Correction: Dealers will inspect and, if necessary, remove excessive underbody coating near the fuel lines.

Recall 2012082 3,424 units in Canada

Airbag

On certain vehicles, the wire harness under the driver and/or passenger seat may not have been properly affixed to the seat frame during vehicle assembly. As such, the harness may get caught by the amplifier (mounted under the seat) when seating position is adjusted. If this occurs, the harness connector may detach from the socket and, as a result, the corresponding airbag may not function as intended, causing the instrument panel SRS warning lamp to illuminate. Failure of a frontal airbag to deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Correction: Dealers will inspect and, if necessary, secure the wire harness to the driver and/or passenger seat frame.

Recall 2011388 11 units in Canada

Label

On certain vehicles equipped with a dealer-installed optional accessory spare tire and wheel kit, the Tire and Loading Information label may not contain correct information. Since the vehicle was originally fitted (by the factory) with a tire inflation kit, the label indicates “none” as the spare tire designation, instead of spare tire size and inflation pressure information. Correction: Dealers will replace the Tire and Loading Information label.

Recall 2011218 27 units in Canada

Fuel System

On certain vehicles, a fuel line quick connector may have been incorrectly manufactured and could fail. Should the connector detach, it could cause engine stalling and a fuel leak. Engine stalling would result in lost propulsion which, in conjunction with traffic and road conditions, and the driver's reactions, could increase the risk of a crash. Fuel leakage, in the presence of an ignition source, could result in a fire. These issues could result in property damage and/or personal injury. Correction: Dealers will replace the high-pressure fuel line assembly.

Recall 2011211 402 units in Canada

Fuel System

On certain vehicles, the fuel system software may not be compatible with the fuel pump assembly. Insufficient fuel transfer could cause engine hesitation or stalling. Engine stalling would result in loss of propulsion which, in conjunction with traffic and road conditions, and the driver's reactions, could increase the risk of a crash causing property damage and/or personal injury. Correction: Dealers will update the engine control module software.

Recalls cover specific build ranges, so check your own vehicle by VIN at nhtsa.gov/recalls or, in Canada, Transport Canada.

Complaints that involved harm

Reports where the owner recorded a crash, a fire, an injury or a death.

Woodbridge, VA Crash 1 injured

VEHICLE SPEED CONTROL

Brakes , and vacuum booster, speed control I experienced a sudden acceleration phenomenon and reached speeds of 100+ mph I manipulated the brakes and the gas in order to safe my life I eventually got my speeds down but it was too late I was ejected from the vehicle and nearly died my brakes scrubbed and I pressed my brakes as hard as I could and my car continued to acceleration. The police has the vehicle and there were no warnings signs . I had just bought the vehicle and was on my way home from the dealership never made it home

NHTSA complaint #11746049 — an unverified report by a vehicle owner.

Woodbridge, VA Crash 1 injured

UNKNOWN OR OTHER

Brakes , and vacuum booster, speed control I experienced a sudden acceleration phenomenon and reached speeds of 100+ mph I manipulated the brakes and the gas in order to safe my life I eventually got my speeds down but it was too late I was ejected from the vehicle and nearly died my brakes scrubbed and I pressed my brakes as hard as I could and my car continued to acceleration. The police has the vehicle and there were no warnings signs . I had just bought the vehicle and was on my way home from the dealership never made it home

NHTSA complaint #11746049 — an unverified report by a vehicle owner.

Woodbridge, VA Crash 1 injured

SERVICE BRAKES

Brakes , and vacuum booster, speed control I experienced a sudden acceleration phenomenon and reached speeds of 100+ mph I manipulated the brakes and the gas in order to safe my life I eventually got my speeds down but it was too late I was ejected from the vehicle and nearly died my brakes scrubbed and I pressed my brakes as hard as I could and my car continued to acceleration. The police has the vehicle and there were no warnings signs . I had just bought the vehicle and was on my way home from the dealership never made it home

NHTSA complaint #11746049 — an unverified report by a vehicle owner.

Wayne, NJ 1 injured

STEERING

The steering wheel trim peeled and created a razor sharp surface at the bottom which sliced through my finger and caused pain and bleeding. It is difficult to avoid touching the sharp part of the steering wheel especially at highway speeds. This startled me while driving and distracted me while I attempted to stop the bleeding. Volvo has agreed to replace the trim but will charge for labor if I choose to go into a dealer.

NHTSA complaint #11483292 — an unverified report by a vehicle owner.

Foster City, CA Crash

VEHICLE SPEED CONTROL

Volvo arrived at the hiking trailhead parking lot at approximately 10 miles an hour, slowed down more to select parking space then turn right into space in front of a cement outhouse. Space had a cement parking block. As the car was about to come to a complete stop in the space, it suddenly accelerated on its own as if the accelerator was press all the way overcoming the cement block and crashing into the outhouse. Both driver and passenger airbags were deployed. The driver never took the foot off the brake when the car accelerated. The automated braking system never deployed. Prior to the accident, the low battery warning light was on but the battery was checked out by a professional to be fully charged. We walk away from the accident bruised with back and chest pains from the seat belt but considered ourselves lucky. Had we not parked with a cement outhouse five feet in front of us two spaces over, we would have accelerated into an open field and into a forest of trees.

NHTSA complaint #11423030 — an unverified report by a vehicle owner.

Foster City, CA Crash

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Volvo arrived at the hiking trailhead parking lot at approximately 10 miles an hour, slowed down more to select parking space then turn right into space in front of a cement outhouse. Space had a cement parking block. As the car was about to come to a complete stop in the space, it suddenly accelerated on its own as if the accelerator was press all the way overcoming the cement block and crashing into the outhouse. Both driver and passenger airbags were deployed. The driver never took the foot off the brake when the car accelerated. The automated braking system never deployed. Prior to the accident, the low battery warning light was on but the battery was checked out by a professional to be fully charged. We walk away from the accident bruised with back and chest pains from the seat belt but considered ourselves lucky. Had we not parked with a cement outhouse five feet in front of us two spaces over, we would have accelerated into an open field and into a forest of trees.

NHTSA complaint #11423030 — an unverified report by a vehicle owner.

The most recent complaints

In the owners' own words, exactly as filed with NHTSA.

Woodbridge, VA Crash 1 injured

VEHICLE SPEED CONTROL

Brakes , and vacuum booster, speed control I experienced a sudden acceleration phenomenon and reached speeds of 100+ mph I manipulated the brakes and the gas in order to safe my life I eventually got my speeds down but it was too late I was ejected from the vehicle and nearly died my brakes scrubbed and I pressed my brakes as hard as I could and my car continued to acceleration. The police has the vehicle and there were no warnings signs . I had just bought the vehicle and was on my way home from the dealership never made it home

NHTSA complaint #11746049 — an unverified report by a vehicle owner.

Woodbridge, VA Crash 1 injured

UNKNOWN OR OTHER

Brakes , and vacuum booster, speed control I experienced a sudden acceleration phenomenon and reached speeds of 100+ mph I manipulated the brakes and the gas in order to safe my life I eventually got my speeds down but it was too late I was ejected from the vehicle and nearly died my brakes scrubbed and I pressed my brakes as hard as I could and my car continued to acceleration. The police has the vehicle and there were no warnings signs . I had just bought the vehicle and was on my way home from the dealership never made it home

NHTSA complaint #11746049 — an unverified report by a vehicle owner.

Woodbridge, VA Crash 1 injured

SERVICE BRAKES

Brakes , and vacuum booster, speed control I experienced a sudden acceleration phenomenon and reached speeds of 100+ mph I manipulated the brakes and the gas in order to safe my life I eventually got my speeds down but it was too late I was ejected from the vehicle and nearly died my brakes scrubbed and I pressed my brakes as hard as I could and my car continued to acceleration. The police has the vehicle and there were no warnings signs . I had just bought the vehicle and was on my way home from the dealership never made it home

NHTSA complaint #11746049 — an unverified report by a vehicle owner.

Kent, WA

AIR BAGS

The driver's side seat airbag system failed. Specifically, diagnostic trouble code SRS-B002011 was retrieved, indicating a circuit short to ground in the left side airbag deployment control system. The technician found a broken clip on the airbag connector housing, causing an intermittent connection failure between the connector and the seat airbag itself. The airbag cannot be relied upon to deploy in a crash. The vehicle is available for inspection upon request. I purchased this vehicle on May 10, 2026, and drove it as my primary means of transportation. During that time, the driver's side seat airbag was non-functional due to a circuit short to ground and a broken connector housing. Had I been involved in a collision during that period, the driver's side airbag may not have deployed, significantly increasing the risk of serious injury or death. I was not informed of this defect at the time of purchase and had no knowledge that the airbag system was compromised. I drove the vehicle believing it to be equipped with functioning safety systems. The defect was confirmed by Volvo Cars Tacoma (O'Brien Auto Group), a franchised manufacturer-certified Volvo dealership in Tacoma. Technician #2101608 performed a comprehensive inspection using Volvo's proprietary VIDA diagnostic system dated May 16–30, 2026. The inspection retrieved diagnostic trouble code SRS-B002011 confirming a circuit short to ground in the left side airbag deployment control system, and physically identified a broken clip on the airbag connector housing. The technician documented: "There is likely an intermittent failure at the connection between the airbag connector and the seat airbag itself. Need to start with replacement of airbag and repin connector." The check engine light illuminated within days of my purchase. This prompted me to bring the vehicle to Volvo Cars Tacoma on May 16, 2026 — six days after purchase. I personally did not observe an SRS warning light.

NHTSA complaint #11742523 — an unverified report by a vehicle owner.

Kent, WA

UNKNOWN OR OTHER

The driver's side seat airbag system failed. Specifically, diagnostic trouble code SRS-B002011 was retrieved, indicating a circuit short to ground in the left side airbag deployment control system. The technician found a broken clip on the airbag connector housing, causing an intermittent connection failure between the connector and the seat airbag itself. The airbag cannot be relied upon to deploy in a crash. The vehicle is available for inspection upon request. I purchased this vehicle on May 10, 2026, and drove it as my primary means of transportation. During that time, the driver's side seat airbag was non-functional due to a circuit short to ground and a broken connector housing. Had I been involved in a collision during that period, the driver's side airbag may not have deployed, significantly increasing the risk of serious injury or death. I was not informed of this defect at the time of purchase and had no knowledge that the airbag system was compromised. I drove the vehicle believing it to be equipped with functioning safety systems. The defect was confirmed by Volvo Cars Tacoma (O'Brien Auto Group), a franchised manufacturer-certified Volvo dealership in Tacoma. Technician #2101608 performed a comprehensive inspection using Volvo's proprietary VIDA diagnostic system dated May 16–30, 2026. The inspection retrieved diagnostic trouble code SRS-B002011 confirming a circuit short to ground in the left side airbag deployment control system, and physically identified a broken clip on the airbag connector housing. The technician documented: "There is likely an intermittent failure at the connection between the airbag connector and the seat airbag itself. Need to start with replacement of airbag and repin connector." The check engine light illuminated within days of my purchase. This prompted me to bring the vehicle to Volvo Cars Tacoma on May 16, 2026 — six days after purchase. I personally did not observe an SRS warning light.

NHTSA complaint #11742523 — an unverified report by a vehicle owner.

Marietta, GA

ENGINE

I experienced an engine issue that I believe is related to excessive oil consumption and the lack of an oil pressure light warning. The car was driven out of town when a noise was heard coming from the engine. A visual inspection of the engine revealed smoke coming from the engine department when the oil cap was removed. The dipstick was checked and showed no visible oil on the stick. Later in that evening, 3 additional quarts of oil were added to the engine but the addition of oil did not remedy the noise from the engine. The final result was that the car was towed to a Volvo dealership in Florida for repair. I checked the status of the recalls (oil comsumption and no oil pressure light) and the status is closed. From what I can tell, this issue appears to be directly related to previous recalls for the vehicle.

NHTSA complaint #11732954 — an unverified report by a vehicle owner.

San Diego, CA

ENGINE

Engine has failed and is unrepairable. The car has been maintained well according to the manufacturer’s guidelines with regular oil changes. It has only 94,875 miles. The mechanic said that there is probably a piston gasket failure leading to oil leak into the engine. This appears to have been reported with this year/model vehicles. I would like Volvo to take ownership of poor manufacturing and fix the problem to my satisfaction.

NHTSA complaint #11644323 — an unverified report by a vehicle owner.

Basking Ridge, NJ

BACK OVER PREVENTION: WARNINGS

At temperatures around 90* and higher the rear camera flickers and is unusable. This happens without any warning and when vehicle attempting to reverse.

NHTSA complaint #11608588 — an unverified report by a vehicle owner.

Basking Ridge, NJ

BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING

At temperatures around 90* and higher the rear camera flickers and is unusable. This happens without any warning and when vehicle attempting to reverse.

NHTSA complaint #11608588 — an unverified report by a vehicle owner.

Edmonton, AL

ENGINE

Discovered that my engine is burning oil. There was no warning from my vehicle or from Volvo (during regular maintenance) that this was happening. It was just sudden that the check engine light went on and I checked the oil and found that it was basically empty. Volvo confirmed that the engine is burning oil and that this model and make was discovered to have this engine issue. Volvo did not offer a solution other than to buy a new vehicle to replace this one. In my research online, this problem is common for this model and make 2012 S60 T5, may other have reported the same issue and it seems that there is a recall for this problem but my vehicle (VIN) does not report this to be a problem for my car. I’m not sure what to do.

NHTSA complaint #11599825 — an unverified report by a vehicle owner.

at 80,000 miles Jersey City, NJ

ENGINE

The contact owns a 2012 Volvo S60. The contact stated that upon starting the vehicle, an unknown belt fractured, and the vehicle failed to start. There were no warning lights illuminated. The contact called the local dealer, who informed the contact about diagnostic testing, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 80,000.

NHTSA complaint #11589833 — an unverified report by a vehicle owner.

Alexandria, VA

VISIBILITY:WINDSHIELD

While driving or parked water is dripping down my window shield. This obstructs my view and distracts me from driving. It further distracts my driving if I have to wipe away the water which usually leads to smearing which causes further obstruction to my field of vision.

NHTSA complaint #11574442 — an unverified report by a vehicle owner.

OAK Lawn, IL

VISIBILITY:WINDSHIELD

original windshield never replaced unglueing to the point where you can push the glass and have it move and minor seepage of water

NHTSA complaint #11573156 — an unverified report by a vehicle owner.

at 137,000 miles Kernersville, NC

ENGINE AND ENGINE COOLING

The contact owns a 2012 Volvo S60. The contact stated that while driving at an undisclosed speed, she smelled a burning odor in the interior of the vehicle, after which the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle failed to restart. After a visual inspection of the engine compartment, the contact became aware that the engine was without oil; however, the low oil warning light was not illuminated. The check engine warning light was illuminated. The vehicle was not taken to the dealer nor an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 13V592000 (Engine and Engine Cooling) but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 137,000.

NHTSA complaint #11570537 — an unverified report by a vehicle owner.

Richmond, CA

ELECTRICAL SYSTEM

On June 2, 2023 I went to start my car and the engine would not turn over. The dashboard displayed a number of warning lights and messages (DSTC Service Required, SRS Airbag Service Urgent, Transmission Service Required, Coolant System Service Required). When the tow truck driver arrived later that day, they tried to jumpstart my car but reported the battery was completely dead. I had the car taken to a local shop that specialized in Volvo cars. A few days later the shop called to tell me that not only was the battery dead, but my car key was no longer responding, and that the Engine Control Module "exploded." None of the mechanics at the shop had seen such a thing before. The shop also told me that they could not figure out what had been draining the battery. I was advised to reach out to the dealership. I did and happened to meet with the general manager and a lead technician who happened to be on site. I was told that while rare, the Engine Control Module can "explode." I was willing to drop the matter until I started seeing "Low Battery" warnings in early Sept. of 2023. I was finally able to get the car into the dealership on 1/2/24. After talking with the mechanic, he suggested that the satellite radio in my car was continuously draining my battery and to resolve the problem all they would need to do is download new software. A few hours later the mechanic confirmed that my car needed an RDAR upgrade to stop the battery drainage. I do not understand how the dealership could sell me the car without checking to make sure the software had been upgraded in the first place. RDAR failure is not something that pops up as a recall or major safety concern. If the car had lost power while in motion, there could have been serious consequences.

NHTSA complaint #11564522 — an unverified report by a vehicle owner.

Richmond, CA

ENGINE

On June 2, 2023 I went to start my car and the engine would not turn over. The dashboard displayed a number of warning lights and messages (DSTC Service Required, SRS Airbag Service Urgent, Transmission Service Required, Coolant System Service Required). When the tow truck driver arrived later that day, they tried to jumpstart my car but reported the battery was completely dead. I had the car taken to a local shop that specialized in Volvo cars. A few days later the shop called to tell me that not only was the battery dead, but my car key was no longer responding, and that the Engine Control Module "exploded." None of the mechanics at the shop had seen such a thing before. The shop also told me that they could not figure out what had been draining the battery. I was advised to reach out to the dealership. I did and happened to meet with the general manager and a lead technician who happened to be on site. I was told that while rare, the Engine Control Module can "explode." I was willing to drop the matter until I started seeing "Low Battery" warnings in early Sept. of 2023. I was finally able to get the car into the dealership on 1/2/24. After talking with the mechanic, he suggested that the satellite radio in my car was continuously draining my battery and to resolve the problem all they would need to do is download new software. A few hours later the mechanic confirmed that my car needed an RDAR upgrade to stop the battery drainage. I do not understand how the dealership could sell me the car without checking to make sure the software had been upgraded in the first place. RDAR failure is not something that pops up as a recall or major safety concern. If the car had lost power while in motion, there could have been serious consequences.

NHTSA complaint #11564522 — an unverified report by a vehicle owner.

Elizabeth CTY, NC

ENGINE

Surpintine belt shredded due to faulty belt tensioner. Shreds of belt wedged between crankshaft timing sprocket on engine causing engine to jump timing while driving down highway and vehicle lost all power and very hard to steer due to all valves in motor bent because of poor design. Definitely a safety concern. Volvo is aware but does nothing. 11,000 dollars to replace engine.

NHTSA complaint #11560890 — an unverified report by a vehicle owner.

at 62,000 miles Buena Park, CA

ENGINE

The contact owns a 2012 Volvo S60. The contact stated while driving approximately 40 MPH, the vehicle lost motive power and stalled. The vehicle was later towed to the local dealer who diagnosed the vehicle and determined that the drive belt had failed, causing damage to the timing cover and other drive belts. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 62,000.

NHTSA complaint #11558481 — an unverified report by a vehicle owner.

Houston, TX

UNKNOWN OR OTHER

I bought used s60 and sent car to auto shop due to engine seize . I was told The engine needed to be replaced. I has replacement done. Car ran good and I was pleased. Months later, the vehicle made a clicking noise when I arrived home. When I checked the oil the following morning, there was no oil in car. I was never given a low oil level indication or warning. Now car is making crazy tapping sounds. i

NHTSA complaint #11548673 — an unverified report by a vehicle owner.

Houston, TX

ENGINE

I bought used s60 and sent car to auto shop due to engine seize . I was told The engine needed to be replaced. I has replacement done. Car ran good and I was pleased. Months later, the vehicle made a clicking noise when I arrived home. When I checked the oil the following morning, there was no oil in car. I was never given a low oil level indication or warning. Now car is making crazy tapping sounds. i

NHTSA complaint #11548673 — an unverified report by a vehicle owner.

Colorado Springs, CO

EXTERIOR LIGHTING

These headlight assemblies commonly develop significant water ingress problems as they age. Owners report issues in wet climates even when these cars were relatively new, resulting in bulb ignition problems as water finds it way into the ballasts, resulting in high-voltage shorting. The water in the headlight housings also "fogs" up the forward lens, resulting in a poor distribution of light out the front, both poor for the driver and dazzling for oncoming traffic. The headlights can work fine for weeks or months, and then a wet week comes along and 1 or both headlights fail to operate or work but poorly and blind oncoming traffic. If caught after dark in the rain the headlights often fail to function. If this could be solved with new headlight assemblies for a reasonable price, I would not consider this a major safety issue, unfortunately, they are difficult to source, astronomically priced (~$1100 per assembly), and replacing them doesn't seem to fix this problem for many owners of these cars. The way these assemblies are vented from the factory seems to be problematic for water ingress and the position of the ballasts ensures that any significant water ingress causes the ballast to short internally. I believe that the atmospheric vent on these must be positioned in such a way that they suck water in as they cool if its raining. The all-halogen assemblies for these cars work better, likely because there's no ballast for the water to leak into and more heat from the bulb to quickly evaporate the water out of the same assembly design. The poorly designed housing is "saved" by the simpler electronics and thermal output of the bulbs. Unfortunately, different factory programming is required to run the all-halogen assemblies. A recall should be issued to replace all of these gimmicky (and distracting) "steerable" xenon headlights with the halogen versions, with the reprogramming effort included in the recall.

NHTSA complaint #11543976 — an unverified report by a vehicle owner.

at 150,000 miles Dallas, TX

SEAT BELTS

The contact owns a 2012 Volvo S60. The contact stated that while driving approximately 10 MPH, the driver’s side rear door opened unintendedly without the driver touching the door handle. The contact pulled over to the side of the road and inspected the vehicle. Additionally, the contact stated that on several occasions when the seat belt tongue was inserted inside the buckle, the seat belt failed to latch properly. The contact stated that the latch plate latched securely after several attempts. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 150,000.

NHTSA complaint #11537428 — an unverified report by a vehicle owner.

at 150,000 miles Dallas, TX

LATCHES/LOCKS/LINKAGES

The contact owns a 2012 Volvo S60. The contact stated that while driving approximately 10 MPH, the driver’s side rear door opened unintendedly without the driver touching the door handle. The contact pulled over to the side of the road and inspected the vehicle. Additionally, the contact stated that on several occasions when the seat belt tongue was inserted inside the buckle, the seat belt failed to latch properly. The contact stated that the latch plate latched securely after several attempts. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 150,000.

NHTSA complaint #11537428 — an unverified report by a vehicle owner.

Allenstown, NH

STEERING

I have experienced the steering in my car to become looser over time. I have found the culprit to be a plastic tension cap on the steering rack itself. The cap appears to have stripped and backed out completely and is now resting against the subframe. There is no warning of this happening and very hard to pinpoint the cause. The effect is that there is about 10 degrees of play in the steering wheel. It appears that it only affects the left wheel as that one is loose and the right wheel is tight. I will be taking it to the dealer to see if there is a replacement or an upgraded version of this cap but feel this should be addressed further as this could happen without warning.

NHTSA complaint #11526710 — an unverified report by a vehicle owner.

Blaine, WA

SEAT BELTS

Our seat belts have been problematic because the passenger side is sticky and has to be moved around before it will disengage. When I took it to a dealer they said it was fine and just needed a little lubrication. Lubrication did not help the problem

NHTSA complaint #11506751 — an unverified report by a vehicle owner.