2007 Volvo XC70 problems

AIR BAGS

Description of Safety Problem:This complaint is a formal report of an open safety recall remedy failure under NHTSA Campaign 21V800 (Volvo Recall R10136). On 7/8/2026, an authorized manufacturer dealership (Volvo Cars Palo Alto) replaced the driver's airbag module on my 2007 Volvo XC70. Prior to this mandatory safety service, the vehicle's Supplemental Restraint System (SRS) network functioned flawlessly with no dashboard warning lights. Shortly after picking up the vehicle, the "SRS Service Urgent" hard fault was active. Dealership diagnostics confirmed that Controller Area Network (CAN) bus codes SRS-00E5 and SRS-00E7 are present, noting that the Upper Electrical Module (UEM) mirror has proper power and ground but is actively "interrupting the CAN signal." This technical diagnosis confirms a severe internal semiconductor short circuit within the mirror's data transceiver chip, likely induced by a voltage surge during the recall's battery handling or live-component swapping process. Because the driver's airbag and the UEM mirror communicate directly over the same high-speed CAN bus data highway, a technician's failure to electrically isolate the system could send an electrical surge that fried the peripheral mirror network link. The manufacturer is currently refusing to cover the damage, demanding over $2,000 for repairs, and forcing me to operate a vehicle with limited functioning airbags as a direct consequence of a federal safety recall.Crash/Injury/Fire: No.Speed at failure: 0 mph (occurred during dealership service).

NHTSA complaint #11750222 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Description of Safety Problem:This complaint is a formal report of an open safety recall remedy failure under NHTSA Campaign 21V800 (Volvo Recall R10136). On 7/8/2026, an authorized manufacturer dealership (Volvo Cars Palo Alto) replaced the driver's airbag module on my 2007 Volvo XC70. Prior to this mandatory safety service, the vehicle's Supplemental Restraint System (SRS) network functioned flawlessly with no dashboard warning lights. Shortly after picking up the vehicle, the "SRS Service Urgent" hard fault was active. Dealership diagnostics confirmed that Controller Area Network (CAN) bus codes SRS-00E5 and SRS-00E7 are present, noting that the Upper Electrical Module (UEM) mirror has proper power and ground but is actively "interrupting the CAN signal." This technical diagnosis confirms a severe internal semiconductor short circuit within the mirror's data transceiver chip, likely induced by a voltage surge during the recall's battery handling or live-component swapping process. Because the driver's airbag and the UEM mirror communicate directly over the same high-speed CAN bus data highway, a technician's failure to electrically isolate the system could send an electrical surge that fried the peripheral mirror network link. The manufacturer is currently refusing to cover the damage, demanding over $2,000 for repairs, and forcing me to operate a vehicle with limited functioning airbags as a direct consequence of a federal safety recall.Crash/Injury/Fire: No.Speed at failure: 0 mph (occurred during dealership service).

NHTSA complaint #11750222 — an unverified report by a vehicle owner.

AIR BAGS

The driver airbag has been under recall per letter dated 12/14/21, NHTSA RECALL #21V-800 We scheduled initial repair with dealer upon receipt of notice last December, however, this has not been accomplished and as of 9/23/22 as we are continually told the part needed remains on backorder. We had contacted Volvo directly on 3/31/22 and they stated the dealer would have to order the part. The "incident" or complaint filed here is due to the inability of being able to have this recalled part replaced in over 9 months and belief that manufacturer is delaying required replacement part due to the age of the vehicle.

NHTSA complaint #11486006 — an unverified report by a vehicle owner.

SEAT BELTS

Transmission issues, shifting, stop bump. Headlight issues wiring and hid ballast. Engine Evap work done. Back drivers side seat belt locking mechanism faulty. Knocking clinging under carriage in suspension areas.

NHTSA complaint #11471592 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

Transmission issues, shifting, stop bump. Headlight issues wiring and hid ballast. Engine Evap work done. Back drivers side seat belt locking mechanism faulty. Knocking clinging under carriage in suspension areas.

NHTSA complaint #11471592 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Transmission issues, shifting, stop bump. Headlight issues wiring and hid ballast. Engine Evap work done. Back drivers side seat belt locking mechanism faulty. Knocking clinging under carriage in suspension areas.

NHTSA complaint #11471592 — an unverified report by a vehicle owner.

AIR BAGS

The contact owns a 2007 Volvo XC70. The contact received notification of NHTSA Campaign Number: 21V800000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA complaint #11461268 — an unverified report by a vehicle owner.

AIR BAGS

2007 VOLVO XC-70. CONSUMER WRITES IN REGARDS TO NHTSA SAFETY RECALL 21V-800. THE CONSUMER STATED THERE WERE NO VOLVO DEALERSHIPS WITHIN A REASONABLE DISTANCE TO PERFORM THE REPAIR. THE CONSUMER REQUESTED TO HAVE THE NECESSARY PARTS SENT TO A LOCAL AUTOMOTIVE SHOP.

NHTSA complaint #11458709 — an unverified report by a vehicle owner.

SEAT BELTS

FRONT SEATBELT STUCK IN THE RETRACTED POSITION AND THEREFORE THE SEATBELT CANNOT BE USED. THE VEHICLE WAS PARKED WHEN THE DEFECT WAS DISCOVERED.

NHTSA complaint #11377783 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

STARTED MY CAR IN THE MORNING AND IT SOUNDED NORMAL (IT HAD DRIVEN PERFECTLY NORMAL THE DAY BEFORE). WHEN I TRIED TO BACK OUT OF THE DRIVEWAY, IT HAD NO POWER IN REVERSE AND BARELY CREPT ONTO THE ROAD. WHEN I PUT IT INTO DRIVE, IT HAD NO POWER EITHER-ONLY CRAWLED VERY SLOWLY. WHEN I PUT IT INTO MANUAL DRIVE, IT WENT NORMALLY. BACK INTO AUTOMATIC AND IT WAS CREEPING AGAIN. HAVEN'T TAKEN IT TO A GARAGE YET BECAUSE I DON'T TRUST IT ON THE ROAD NOW.

NHTSA complaint #11173301 — an unverified report by a vehicle owner.

SUSPENSION

TL* THE CONTACT OWNS A 2007 VOLVO XC70. WHILE SITTING IN THE IDLE VEHICLE, THE CONTACT STATED THAT THE VEHICLE FELT LOW. UPON DRIVING A HALF MILE DOWN THE ROAD, THE BODY OF THE VEHICLE COLLAPSED ON TOP OF THE WHEELS. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR COIL SPRING FAILED AND ALL THE COIL SPRINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 118,945.

NHTSA complaint #11120709 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2007 VOLVO XC70. THE CONTACT STATED THAT THE ALL WHEEL DRIVE FAILED TO FUNCTION. THE CONTACT WAS CONCERNED THAT THE FAILURE COULD CAUSE A CRASH DURING INCLEMENT WEATHER. IN ADDITION, WHILE IN A DITCH, THE VEHICLE WAS DIFFICULT TO EXIT AND WAS DAMAGED WHILE ATTEMPTING TO GET THE VEHICLE OUT. THE VEHICLE WAS TAKEN TO AN UNKNOWN LOCAL DEALER LOCATED IN SANTA FE, NEW MEXICO WHERE THE CAUSE OF THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000. UPDATED 11/06/17*LJ *JS CONSUMER STATED WEIGHT SENSOR IN SEAT TURNS ON AIR BAG LIGHT THAT FLARES OUR OF ELCTRONIC REAR VIEW MIRROR THAT DIDN'T WORK EITHER. UPDATED 7/18/18

NHTSA complaint #11024233 — an unverified report by a vehicle owner.

STRUCTURE:BODY:BUMPERS

TL* THE CONTACT OWNS A 2007 VOLVO XC70. THE CONTACT STATED THAT THE ALL WHEEL DRIVE FAILED TO FUNCTION. THE CONTACT WAS CONCERNED THAT THE FAILURE COULD CAUSE A CRASH DURING INCLEMENT WEATHER. IN ADDITION, WHILE IN A DITCH, THE VEHICLE WAS DIFFICULT TO EXIT AND WAS DAMAGED WHILE ATTEMPTING TO GET THE VEHICLE OUT. THE VEHICLE WAS TAKEN TO AN UNKNOWN LOCAL DEALER LOCATED IN SANTA FE, NEW MEXICO WHERE THE CAUSE OF THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000. UPDATED 11/06/17*LJ *JS CONSUMER STATED WEIGHT SENSOR IN SEAT TURNS ON AIR BAG LIGHT THAT FLARES OUR OF ELCTRONIC REAR VIEW MIRROR THAT DIDN'T WORK EITHER. UPDATED 7/18/18

NHTSA complaint #11024233 — an unverified report by a vehicle owner.

SERVICE BRAKES

TL* THE CONTACT OWNS A 2007 VOLVO XC70. THE CONTACT STATED THAT THE ALL WHEEL DRIVE FAILED TO FUNCTION. THE CONTACT WAS CONCERNED THAT THE FAILURE COULD CAUSE A CRASH DURING INCLEMENT WEATHER. IN ADDITION, WHILE IN A DITCH, THE VEHICLE WAS DIFFICULT TO EXIT AND WAS DAMAGED WHILE ATTEMPTING TO GET THE VEHICLE OUT. THE VEHICLE WAS TAKEN TO AN UNKNOWN LOCAL DEALER LOCATED IN SANTA FE, NEW MEXICO WHERE THE CAUSE OF THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000. UPDATED 11/06/17*LJ *JS CONSUMER STATED WEIGHT SENSOR IN SEAT TURNS ON AIR BAG LIGHT THAT FLARES OUR OF ELCTRONIC REAR VIEW MIRROR THAT DIDN'T WORK EITHER. UPDATED 7/18/18

NHTSA complaint #11024233 — an unverified report by a vehicle owner.

BACK OVER PREVENTION: CAMERA SYSTEM

TL* THE CONTACT OWNS A 2007 VOLVO XC70. THE CONTACT STATED THAT THE ALL WHEEL DRIVE FAILED TO FUNCTION. THE CONTACT WAS CONCERNED THAT THE FAILURE COULD CAUSE A CRASH DURING INCLEMENT WEATHER. IN ADDITION, WHILE IN A DITCH, THE VEHICLE WAS DIFFICULT TO EXIT AND WAS DAMAGED WHILE ATTEMPTING TO GET THE VEHICLE OUT. THE VEHICLE WAS TAKEN TO AN UNKNOWN LOCAL DEALER LOCATED IN SANTA FE, NEW MEXICO WHERE THE CAUSE OF THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000. UPDATED 11/06/17*LJ *JS CONSUMER STATED WEIGHT SENSOR IN SEAT TURNS ON AIR BAG LIGHT THAT FLARES OUR OF ELCTRONIC REAR VIEW MIRROR THAT DIDN'T WORK EITHER. UPDATED 7/18/18

NHTSA complaint #11024233 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

SERIOUS ENGINE SPEED SURGING. JUMPS TO OVER 8000 RPM. HAPPENS WHEN STOPPING ON OCTANE, NOT ALWAYS. I COULD HAVE GOT KILLED WHILE BACKING INTO MY DRIVEWAY ON A HILL. I HAVE SEEN THIS AT LEAST 4 TIMES AND WILL NOT DRIVE IT. I INFORMED MY INSURER. AT DEALER NOW, THEY SAY THEY HAVE NEVER HEARD OF THIS AND CANNOT DUPLICATE. LOTS OF INFO ON WEB FROM OTHERS WHO HAVE SAME PROBLEM. IT SEEMS TO BE A THROTTLE CONTROL ISSUE AND CLASS ACTION SUIT HAS BEEN DONE ON YEARS JUST UP TO 2016. VOLVO HAVE EXTENDED WARRANTY FOR THE THROTTLE MODULE AND ECM. I ASKED THE DEALER TO RESEARCH ON THIS AND IF THEY CANNOT DUPLICATE THAN REPLACE THE LIKELY SUSPECT AND SOFTWARE AS WELL AS CONTACT VOLVO FOR HELP. IF THIS IS A KNOWN ISSUE, VOLVO NEEDS GET INFO OUT AS SOMEONE IS GOING TO GET HURT OR DIE DUE TO THIS KNOWN DEFECT AND SHOULD PAY FOR THE REPAIRS. I LOVE THE CARE BUT WILL NOT DRIVE IT AS IT IS. 63K MILES ON IT. PLEASE FEEL FREE TO CALL OR EMAIL. THANKS [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #10984994 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2007 VOLVO XC70. WHILE DRIVING AT NIGHT, THE LENS COVER ON THE HEADLAMPS WAS FAULTY. THE CONTACT WAS UNABLE TO SEE THE ROAD CLEARLY BECAUSE THE LENS COVER WAS BLURRY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE HEADLAMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. THE CONSUMER MADE SEVERAL ATTEMPTS T CLEAR THE SURFACE OF THE DEFECTIVE HEADLIGHT LENSES BY GOING TO AN AUTO BODY SHOP WHO ATTEMPTED TO BUFF OUT THE DEFECTS WITHOUT SUCCESS. THE CONSUMER THEN TRIED RAIN-X WITH NO SUCCESS. HE FINALLY TRIED A COMPOUNDING ROUGH, ALSO WITH NO SUCCESS. THE CONSUMER WAS INFORMED THE LENSES ALONE COULD NOT BE REPLACED. THE ENTIRE ASSEMBLY WOULD NEED TO BE REPLACED AT A COST OF $1200. UPDATED 06/13/16.*JB...UPDATED 06/30/16 *BF UPDATED 07/14/16.

NHTSA complaint #10865329 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

ON INTERSTATE HIGHWAY THE ENGINE SUDDENLY LOST POWER WITHOUT WARNING. A "REDUCED ENGINE PERFORMANCE" LIGHT WAS LIT ON THE DASH. I WAS ABLE TO GET OFF THE INTERSTATE HIGHWAY AND STOP ON THE BERM. I TURNED OFF THE ENGINE AND RESTARTED. THE WARNING LIGHT WAS STILL ON BUT IT HAD ENOUGH POWER TO GET ME HOME (30 MILES). THIS IS A VERY SERIOUS PROBLEM. THE WARNING LIGHT IS STILL ON AND I AM AFRAID TO USE THE WAGON.

NHTSA complaint #10787780 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

AFTER DRIVING FOR ABOUT 20 MINUTES IN 77F, SUNNY, DRY CONDITIONS, I'D COME OFF THE FREEWAY AND STOPPED FOR ABOUT 15 SECONDS AT A LIGHT TO MAKE A LEFT TURN. WHEN I STARTED MAKING THE LEFT, SOMEONE BLEW THROUGH THE RED LIGHT TO TURN RIGHT COMING FROM THE OPPOSITE DIRECTION RIGHT IN FRONT OF ME. I LET OFF THE THROTTLE BUT THE THROTTLE DID NOT RELEASE. I WAS GOING ABOUT 15-20MPH WITH THE ENGINE AROUND 2,000RPM IN, MOST LIKELY, THIRD GEAR. SINCE I WAS AT LOW SPEED, I PROMPTLY TRIED GENTLY TIPPING IN THE THROTTLE TO SEE IF I COULD CLOSE BUT IT DID NOT SO I IMMEDIATELY PUT THE TRANSMISSION IN NEUTRAL. THE MOTOR REVVED UP TO ABOUT 4,000RPM WHICH IS A NATURAL IDLE FOR THIS MOTOR IF THE TRANSMISSION IS IN GEAR AND THE MOTOR IS UNDER LOAD AT 2,000RPM. AFTER SEEING IT REV UP, I PUT IT BACK IN DRIVE AND IT JERKED INTO GEAR BECAUSE THE VEHICLE WAS STILL ON THROTTLE. SUDDENLY THE THROTTLE CUT AND IT RETURNED TO THE NORMAL PEDAL TRAVEL VS. ACCELERATION RESPONSE RELATION. IT FELT AS THOUGH THE CAR HAD CRUISE CONTROL ON. I COULD MAKE IT GO FASTER BUT THE MOTOR WOULDN'T ROTATE ANY SLOWER THAN ABOUT 2,000RPM.

NHTSA complaint #10714553 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

AFTER DRIVING FOR ABOUT 20 MINUTES IN 77F, SUNNY, DRY CONDITIONS, I'D COME OFF THE FREEWAY AND STOPPED FOR ABOUT 15 SECONDS AT A LIGHT TO MAKE A LEFT TURN. WHEN I STARTED MAKING THE LEFT, SOMEONE BLEW THROUGH THE RED LIGHT TO TURN RIGHT COMING FROM THE OPPOSITE DIRECTION RIGHT IN FRONT OF ME. I LET OFF THE THROTTLE BUT THE THROTTLE DID NOT RELEASE. I WAS GOING ABOUT 15-20MPH WITH THE ENGINE AROUND 2,000RPM IN, MOST LIKELY, THIRD GEAR. SINCE I WAS AT LOW SPEED, I PROMPTLY TRIED GENTLY TIPPING IN THE THROTTLE TO SEE IF I COULD CLOSE BUT IT DID NOT SO I IMMEDIATELY PUT THE TRANSMISSION IN NEUTRAL. THE MOTOR REVVED UP TO ABOUT 4,000RPM WHICH IS A NATURAL IDLE FOR THIS MOTOR IF THE TRANSMISSION IS IN GEAR AND THE MOTOR IS UNDER LOAD AT 2,000RPM. AFTER SEEING IT REV UP, I PUT IT BACK IN DRIVE AND IT JERKED INTO GEAR BECAUSE THE VEHICLE WAS STILL ON THROTTLE. SUDDENLY THE THROTTLE CUT AND IT RETURNED TO THE NORMAL PEDAL TRAVEL VS. ACCELERATION RESPONSE RELATION. IT FELT AS THOUGH THE CAR HAD CRUISE CONTROL ON. I COULD MAKE IT GO FASTER BUT THE MOTOR WOULDN'T ROTATE ANY SLOWER THAN ABOUT 2,000RPM.

NHTSA complaint #10714553 — an unverified report by a vehicle owner.

ENGINE

AFTER DRIVING FOR ABOUT 20 MINUTES IN 77F, SUNNY, DRY CONDITIONS, I'D COME OFF THE FREEWAY AND STOPPED FOR ABOUT 15 SECONDS AT A LIGHT TO MAKE A LEFT TURN. WHEN I STARTED MAKING THE LEFT, SOMEONE BLEW THROUGH THE RED LIGHT TO TURN RIGHT COMING FROM THE OPPOSITE DIRECTION RIGHT IN FRONT OF ME. I LET OFF THE THROTTLE BUT THE THROTTLE DID NOT RELEASE. I WAS GOING ABOUT 15-20MPH WITH THE ENGINE AROUND 2,000RPM IN, MOST LIKELY, THIRD GEAR. SINCE I WAS AT LOW SPEED, I PROMPTLY TRIED GENTLY TIPPING IN THE THROTTLE TO SEE IF I COULD CLOSE BUT IT DID NOT SO I IMMEDIATELY PUT THE TRANSMISSION IN NEUTRAL. THE MOTOR REVVED UP TO ABOUT 4,000RPM WHICH IS A NATURAL IDLE FOR THIS MOTOR IF THE TRANSMISSION IS IN GEAR AND THE MOTOR IS UNDER LOAD AT 2,000RPM. AFTER SEEING IT REV UP, I PUT IT BACK IN DRIVE AND IT JERKED INTO GEAR BECAUSE THE VEHICLE WAS STILL ON THROTTLE. SUDDENLY THE THROTTLE CUT AND IT RETURNED TO THE NORMAL PEDAL TRAVEL VS. ACCELERATION RESPONSE RELATION. IT FELT AS THOUGH THE CAR HAD CRUISE CONTROL ON. I COULD MAKE IT GO FASTER BUT THE MOTOR WOULDN'T ROTATE ANY SLOWER THAN ABOUT 2,000RPM.

NHTSA complaint #10714553 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

VEHICLE IGNITION ASSEMBLY FAILED, IMMOBILIZING CAR. KEY WOULDN'T MOVE PAST "I" POSITION, PREVENTING IT FROM STARTING. THE STEERING WHEEL WAS LOCKED AND THE TRANSMISSION COULDN'T BE MOVED FROM THE PARK POSITION. VEHICLE HAD TO BE TOWED TO VOLVO DEALER FOR REPAIR.

NHTSA complaint #10678929 — an unverified report by a vehicle owner.

ENGINE

VEHICLE IGNITION ASSEMBLY FAILED, IMMOBILIZING CAR. KEY WOULDN'T MOVE PAST "I" POSITION, PREVENTING IT FROM STARTING. THE STEERING WHEEL WAS LOCKED AND THE TRANSMISSION COULDN'T BE MOVED FROM THE PARK POSITION. VEHICLE HAD TO BE TOWED TO VOLVO DEALER FOR REPAIR.

NHTSA complaint #10678929 — an unverified report by a vehicle owner.

POWER TRAIN

WHEN DRIVING THROUGH PUDDLES OF WATER, SLUSH OR SNOW, THE EXHAUST MAY COOL DOWN FAST ENOUGH TO CHANGE SHAPE AND TOUCH THE PROPELLER SHAFT, CAUSING A HIGH PITCHED SQUEALING NOISE. THIS NOISE WILL BE NOTICED BY THE DRIVER FOR ONLY A SHORT TIME; ONCE THE EXHAUST TEMPERATURE EQUALIZES THE NOISE WILL DISAPPEAR. THIS CREATES A HIGH-PITCHED, SIREN LIKE NOISE, WHICH CAN SCARE THE DRIVER CAUSING HIS/HER TO SWERVE OR LOSE CONTROL OF THE VEHICLE. THE IS A DESIGN DEFECT RECOGNIZED BY VOLVO WITH REPAIR KIT AVAILABLE PN# 30742265. AS THIS IS A DESIGN DEFECT AND A SERIOUS SAFETY ISSUE, THIS SHOULD BE RECALLED BY VOLVO AND NOT A $250.00 REPAIR BY THE CUSTOMER.

NHTSA complaint #10605182 — an unverified report by a vehicle owner.

STRUCTURE:BODY

WHEN DRIVING THROUGH PUDDLES OF WATER, SLUSH OR SNOW, THE EXHAUST MAY COOL DOWN FAST ENOUGH TO CHANGE SHAPE AND TOUCH THE PROPELLER SHAFT, CAUSING A HIGH PITCHED SQUEALING NOISE. THIS NOISE WILL BE NOTICED BY THE DRIVER FOR ONLY A SHORT TIME; ONCE THE EXHAUST TEMPERATURE EQUALIZES THE NOISE WILL DISAPPEAR. THIS CREATES A HIGH-PITCHED, SIREN LIKE NOISE, WHICH CAN SCARE THE DRIVER CAUSING HIS/HER TO SWERVE OR LOSE CONTROL OF THE VEHICLE. THE IS A DESIGN DEFECT RECOGNIZED BY VOLVO WITH REPAIR KIT AVAILABLE PN# 30742265. AS THIS IS A DESIGN DEFECT AND A SERIOUS SAFETY ISSUE, THIS SHOULD BE RECALLED BY VOLVO AND NOT A $250.00 REPAIR BY THE CUSTOMER.

NHTSA complaint #10605182 — an unverified report by a vehicle owner.